1. Chemical Product and Company Identification 1.1 Product name: LP-Cleaner 1.2 Manufacturer / distributor identification company: Egger Otoplastik+Labortechnik GmbH Aybühlweg 59 D-87439 Kempten Phone: +49-8 31-5 81 13 60 Fax: +49-8 31-5 81 13 14 Internet: www.-labor.com e-mail: sales@-labor.de Poison emergency: Munich (Germany) (Toxicological department of the II. Med. Hospital) Phone: 00 49 89 1 92 40 2. Composition / Information on Ingredients 2.1 Chemical characterization (preparation): Glycerol (chemical name: 1, 2, 3-propane-triol), Water (H2O) 2.2 Hazardous ingredients: CAS-No.: 56-81-5 EINECS-No.: 2002895 CTFA-Name: Glycerin INCI-Name: Glycerin 2.3 Additional advice: 3. Possible Hazards Critical hazards to man and environment: No specific hazards under normal use conditions. 4. First-Aid Measures General information: In all cases of doubt, or when symptoms persist, seek mediacl attention. After inhalation: Move to fresh air, rest, half upright position, loosen clothing. Seek medical advice after significant exposure or if feeling unwell. After skin contact: Wash immediately with soap and plenty of water. Remove contaminated clothing. After eye contact: Rinse immediately with plenty of water. Eyelids should be held away from the eyeball to ensure thorough rising. After swallowing: Drink plenty of water. Consult doctor if feeling unwell. Advice to doctor: Page 1 of 5
5. Fire-Fighting Measures Suitable extinguishing material: Foam, dry chemical powder, carbon dioxide Extinguishing material which must not be used for safety reasons: water jet Special exposure hazards arising from the substance or preparation itself, combustion products, resulting gases: Combustible. Vapours heavier than air and cause coughing. Forms explosive mixtures with air on intense heating. At elevated temperatures there is a risk of exothermic polymerisation (> 200 C (392 F)). At a temperature > 280 C (536 F), acrolein may be formed. Special protective equipment for fire fighting: Chemical protection clothing, self-contained breathing aparatus. Additional information: Avoid contact with oxidising agents. Cool closed container with water. 6. Accidental Release Measures Personal precautions: The usual precautions for handling chemicals should be observed. Do not inhale vapours/aerolsols. Environmental precautions: Do not allow to enter sewerage system. Methods for cleaning up: Absorb or contain liquid with sand, earth or spill control material. Shovel into a suitable, clearly marked container for disposal. Other information: No dangerous substances will be released. 7. Handling and Storage 7.1 Handling: Precautions for safe handling: The usual precautions for handling chemicals should be observed. Precautions against fire and explosion: No specific recommendations. Avoid contact with oxidising agents. 7.2 Storage: Conditions for storage rooms and vessels: Keep container tightly closed. Avoid direct sunlight, heat sources and strong oxidising agents. Store at ambient temperatures. Advice for storage of incompatible materials: --- Further information for storage: --- Page 2 of 5
8. Exposure Controls / Personal Protection 8.1 Additional advice on system design: The usual precautions for handling chemicals should be observed. 8.2 Ingredients with occupational exposure limits to be monitored: --- 8.3 Personal protection equipment General protection and hygiene measures: Respiratory protection: none Hand and skin protection: none Eye protection: Safety spectacles Hygiene measures: none 9. Physical and Chemical Properties 9.1 Appearance: Form: Colour: Odour: liquid colourless odourless 9.2 Data relevant for safety Method ph-value: Melting point: approx. -10 C (14 F) Boiling point: approx. 130 C (266 F) Flash point: approx. 190 C (374 F) Ignition point: approx. 400 C (752 F) Explosion properties: unknown Vapour pressure: approx. 8 hpa at 20 C (68 F) Viscosity: approx. 150 mpa.s at 20 C (68 F) Density: approx. 1.227 g/cm³ at 20 C (68 F) 9.3 Further information Solubility in water: soluble at 20 C (68 F) Solubility in organic solvent: 10. Stability and Reactivity General information: Thermal decomposition: > 200 C (392 F) -> thermal destruction (polymerisationm decomposition) Conditions to avoid: --- Materials to avoid: Avoid contact with oxidising agents. Hazardous decomposition: Acrolein (> 280 C (536 F)) Page 3 of 5
11. Toxicological Information Acute oral toxicity LD50: species rat 12600 mg/kg pure substance Irritation of skin: unknown Irritation of eye: mildly irritating Specific effects: Additional information: Not classified as hazardous conform EEC Dangerous Substance Directive and Dangerous Preparation Directives. If the product is used properly it will not cause any injuries to health. 12. Ecological Information 12.1 Data on elimination (persistence and degradability): Readily biodegradable. 12.2 Behaviour in environmental compartments: --- Effects in sewage treatment plants (bacteria toxicity: respiration-/reproduction inhibition): --- 12.3. Ecotoxicological effects: fish: 24 h LC50 > 5000 mg/l (Lit., pure substance) algae: 7 d IC5 > 10000mg/l (Lit., pure substance bacteria: 16 h EC5 > 10000 mg/l /Lit., pure substance 12.4 Further information / ecology: 13. Disposal Considerations Material: According to local regulations (most probably controlled incineration). Contaminated packaging: According to local regulations. Recommended detergent: water 14. Transport Information 14.1 Regulations for land (ADR/RID/GGVS/GGVE) ADR/RID-GGVS/E class: No./letter: Express: 14.2 Regulations for inland waterways (ADN/ADNR) ADR/ADNR class: No./letter: category: 14.3 Regulations for see (IMDG/GGV See) IMDG/GGVSee-class: EmS: MFAG: Marine pollutant: 14.4 Regulations for air (ICAO/IATA) ICAO/IATA-class: UN-number: Air mail transportation: Proper name: 14.5 Transport / further information: not dangerous for conveyance Page 4 of 5
15. Regulatory Information 15.1 Labelling according to EC-regulations: not classified as dangerous under EC criteria. Labelling: Symbols and hazard classification: EEC/R: EEC/S: Special labelling for certain preparations: 15.2 National regulations (German) Restriction of occupation: TA-Luft/classification, compount, remarks: Water hazard class (German only): WGK 1 15.3 Other regulations, restrictions and prohibition regulations 16. Other information n. a. = not applicable n. s. = not subject to These data are given here according to our current knowledge on experience. The data does not signify any warranty with regard to the product's properties. Page 5 of 5