Product Code: Product Name: Company Name: Web site address: 5310 SUNBELT LABORATORIES P.O. BOX 1563 STAFFORD, TX 77497 1. Product and Company Identification www.sunbelt-labs.com Phone Number: (281)261-4747 Emergency Contact: CHEM-TEL (800)255-3924 Flammable Liquids, Category 3 2. Hazards Identification Page: 1 GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: OSHA Regulatory Status: Potential Health Effects (Acute and Chronic): Inhalation: Skin Contact: Eye Contact: Ingestion: Warning Flammable liquid and vapor. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Keep container tightly closed. Use explosion-proof electrical/ventilating/lighting/.../ equipment. Use only non-sparking tools. Take precautionary measures against static discharge. Wear protective gloves/protective clothing/eye protection/face protection. IF ON SKIN (or hair): Remove/take off immediately all contaminated clothing. Rinse skin with water/shower. Store in cool/well-ventilated place. Dispose of contents/container to... This material is classified as hazardous under OSHA regulations. Chronic: Inhalation of vapors or contact with substance will result in contamination and potential harmful effects. May cause skin irritation. Dermatitis. May cause eye irritation. May cause coughing, difficult breathing and nausea. May cause dizziness, incoordination, and unconsciousness. May cause drowsiness or dizziness. 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) 64742-52-5 Mineral oil, petroleum distillates, hydrotreated Concentration 1.0-5.0 % 64741-44-2 Petroleum Distillates 65.0-95.0 % 8028-38-4 Oils, lemon < 0.5 %
Page: 2 Emergency and First Aid Procedures: In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: Indication of any immediate medical attention and special treatment needed: Note to Physician: Flash Pt: > 190.00 F (87.8 C) Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: 4. First Aid Measures IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell. Immediately wash skin with soap and plenty of water. Remove contaminated clothing. Get medical attention if symptoms occur. Wash clothing before reuse. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. IF ON SKIN (or hair): Remove/take off immediately all contaminated clothing. Rinse skin with water/shower. IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs, get medical advice/attention. Flush eye with water for 15 minutes. Get medical attention. IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell. If swallowed, do NOT induce vomiting. Nausea, vomiting, diarrhea. Shortness of breath, May cause mild skin and eye irritation. Dermatitis. IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell. Show this safety data sheet to the doctor in attendance. 5. Fire Fighting Measures Explosive Limits: LEL: UEL: Suitable Extinguishing Media:Dry chemical or CO2. DO NOT USE WATER! Unsuitable Extinguishing DO NOT USE WATER! Media: Hazardous Combustion Products: Protective Equipment: Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and eyes. None. 6. Accidental Release Measures Steps To Be Taken In Case Material Is Released Or Spilled: Do not flush to sewer. Do not let product enter drains. Cover liquid spill with sand, earth or other non-combustible absorbent material. 7. Handling and Storage Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Other Precautions: Suitable: Store in a cool dry place. Not available. 8. Exposure Controls/Personal Protection
Page: 3 CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits 64742-52-5 Mineral oil, petroleum distillates, hydrotreated 64741-44-2 Petroleum Distillates 8028-38-4 Oils, lemon Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Environmental Exposure Controls: Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced. Splash proof safety goggles. It should not be construed as offering an approval for any specific use scenario. No special ventilation requirements. 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: ph: Melting Point: Boiling Point: > 300.00 F (148.9 C) Flash Pt: > 190.00 F (87.8 C) Evaporation Rate: Flammability (solid, gas): Clear. Lemon-type. Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): 4.7 Specific Gravity (Water = 1):.810 at 77.0 F (25.0 C) Solubility in Water: Insoluble Percent Volatile: Autoignition Pt: Corrosion Rate: Reactivity: Stability: Conditions To Avoid - Instability: Incompatibility - Materials To Avoid: Hazardous Decomposition or Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: 100.0 % by volume. Excess heat. 10. Stability and Reactivity Strong oxidizing agents. Unstable [ ] Stable [ X ] Strong oxidizing agents. Heat. Will occur [ ] Will not occur [ X ] Product will not undergo polymerization.
Toxicological Information: Carcinogenicity: 11. Toxicological Information NTP? No IARC Monographs? No OSHA Regulated? No Page: 4 CAS # Hazardous Components (Chemical Name) NTP 64742-52-5 Mineral oil, petroleum distillates, hydrotreated heavy naphthenic IARC ACGIH OSHA n.a. n.a. n.a. n.a. 64741-44-2 Petroleum Distillates n.a. n.a. n.a. n.a. 8028-38-4 Oils, lemon n.a. n.a. n.a. n.a. Waste Disposal Method: LAND TRANSPORT (US DOT): 12. Ecological Information 13. Disposal Considerations 14. Transport Information DOT Proper Shipping Name: DOT Hazard Class: 3 FLAMMABLE LIQUID UN/NA Number: 1202 Packing Group: III CAS # Hazardous Components (Chemical Name) 15. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists 64742-52-5 Mineral oil, petroleum distillates, hydrotreated S. 302 (EHS) S. 304 RQ S. 313 (TRI) No No No 64741-44-2 Petroleum Distillates No No No 8028-38-4 Oils, lemon No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated: [X] Yes [ ] No Acute (immediate) Health Hazard [X] Yes [ ] No Chronic (delayed) Health Hazard [X] Yes [ ] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard CAS # Hazardous Components (Chemical Name) Other US EPA or State Lists 64742-52-5 Mineral oil, petroleum distillates, hydrotreated TSCA: Inventory 64741-44-2 Petroleum Distillates TSCA: Inventory 8028-38-4 Oils, lemon
Revision Date: Hazard Rating System: HMIS: 06/10/2015 HEALTH FLAMMABILITY REACTIVITY PPE 16. Other Information 1 2 0 Flammability Health NFPA: 1 2 Instability Special Hazard Page: 5 Additional Information About This Product: Company Policy or Disclaimer: DISCLAIMER: To the best of our knowledge, the information contained herin is accurate. There is no assumption of liability for accuracy contained within this information. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.