SAFETY DATA SHEET Issue Date 25-Mar-2016 Version 1 1. IDENTIFICATION Product identifier Product Name Other means of identification Product Code Synonyms Air-Bloc 17MR HE017 None Recommended use of the chemical and restrictions on use Recommended Use Coatings Uses advised against Details of the supplier of the safety data sheet Manufacturer Address HENRY COMPANY 999 N. Sepulveda Blvd., Suite 800 El Segundo, CA 90245-2716 Web Site: www.henry.com www.ca.henry.com Emergency telephone number Company Phone Number 800-486-1278 Emergency Telephone CHEMTREC: 800-424-9300 CHEMTREC: 703-527-3887 CANUTEC: 613-966-6666 Classification 2. HAZARDS IDENTIFICATION OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 2A Specific target organ toxicity (single exposure) Category 3 Label elements Warning Emergency Overview Hazard statements Causes skin irritation Causes serious eye irritation May cause respiratory irritation Page 1 / 8
Appearance viscous cream Physical state liquid Odor Slight Precautionary Statements - Prevention Wash face, hands and any exposed skin thoroughly after handling Wear protective gloves/protective clothing/eye protection/face protection Avoid breathing dust/fume/gas/mist/vapors/spray Use only outdoors or in a well-ventilated area Precautionary Statements - Response IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention IF ON SKIN: Wash with plenty of soap and water If skin irritation occurs: Get medical advice/attention Take off contaminated clothing and wash before reuse IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing Call a POISON CENTER or doctor/physician if you feel unwell Precautionary Statements - Storage Store in a well-ventilated place. Keep container tightly closed Store locked up Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information Toxic to aquatic life with long lasting effects. Toxic to aquatic life. Unknown acute toxicity 28.19223275% of the mixture consists of ingredient(s) of unknown toxicity Substance Not applicable Mixture 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% Water * 7732-18-5 15-40 Limestone * 1317-65-3 15-40 Acrylic polymer * Proprietary 10-30 * 1-5 * 1-5 Non-phthalate Plasticizer * Proprietary 1-5 Titanium dioxide * 13463-67-7 1-5 Diethylene glycol monobutyl ether * 112-34-5 1-5 *The exact percentage (concentration) of composition has been withheld as a trade secret. Description of first aid measures 4. FIRST AID MEASURES General advice In case of accident or unwellness, seek medical advice immediately (show directions for use or safety data sheet if possible). If symptoms persist, call a physician. Eye contact Keep eye wide open while rinsing. Immediately flush with plenty of water. After initial Page 2 / 8
flushing, remove any contact lenses and continue flushing for at least 15 minutes. If symptoms persist, call a physician. Skin contact Inhalation Ingestion Self-protection of the first aider Wash off immediately with soap and plenty of water while removing all contaminated clothes and shoes. If symptoms persist, call a physician. Wash contaminated clothing before reuse. Remove to fresh air. If breathing is irregular or stopped, administer artificial respiration. Avoid direct contact with skin. Use barrier to give mouth-to-mouth resuscitation. If symptoms persist, call a physician. Call a physician or poison control center immediately. Do not induce vomiting without medical advice. Rinse mouth. Never give anything by mouth to an unconscious person. Use personal protective equipment as required. Most important symptoms and effects, both acute and delayed Symptoms May cause redness and tearing of the eyes. Coughing and/ or wheezing. May cause skin irritation. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Dry chemical, CO2, sand, earth, water spray or regular foam. Unsuitable extinguishing media. Specific hazards arising from the chemical Thermal decomposition can lead to release of irritating and toxic gases and vapors. Explosion data Sensitivity to Mechanical Impact None. Sensitivity to Static Discharge None. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Use personal protective equipment as required. Avoid contact with skin, eyes or clothing. Environmental precautions Environmental precautions Prevent entry into waterways, sewers, basements or confined areas. Do not flush into surface water or sanitary sewer system. Methods and material for containment and cleaning up Methods for containment Methods for cleaning up Prevent further leakage or spillage if safe to do so. Use personal protective equipment as required. Cover liquid spill with sand, earth or other non-combustible absorbent material. Dam up. Take up mechanically, placing in appropriate Page 3 / 8
containers for disposal. Clean contaminated surface thoroughly. 7. HANDLING AND STORAGE Precautions for safe handling Advice on safe handling Avoid contact with skin, eyes or clothing. Use personal protective equipment as required. Wash contaminated clothing before reuse. Do not breathe dust/fume/gas/mist/vapors/spray. Do not eat, drink or smoke when using this product. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible materials Keep container tightly closed in a dry and well-ventilated place. Keep out of the reach of children. Strong oxidizing agents. Strong acids. Strong bases. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Exposure Guidelines. Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Limestone 1317-65-3 - TWA: 15 mg/m 3 total dust TWA: 5 mg/m 3 respirable fraction TWA: 10 mg/m 3 total dust TWA: 5 mg/m 3 respirable dust TWA: 0.5 mg/m 3 benzene soluble - Ceiling: 5 mg/m 3 fume 15 min aerosol fume, inhalable fraction Ceiling: 100 mg/m 3 aerosol only - - Titanium dioxide TWA: 10 mg/m 3 TWA: 15 mg/m 3 total dust IDLH: 5000 mg/m 3 13463-67-7 Diethylene glycol monobutyl ether 112-34-5 TWA: 10 ppm inhalable fraction and vapor - - NIOSH IDLH Immediately Dangerous to Life or Health Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems. Individual protection measures, such as personal protective equipment Eye/face protection Skin and body protection Respiratory protection General Hygiene Considerations Wear safety glasses with side shields (or goggles). Wear protective gloves and protective clothing. If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. Positive-pressure supplied air respirators may be required for high airborne contaminant concentrations. Respiratory protection must be provided in accordance with current local regulations. Handle in accordance with good industrial hygiene and safety practice. 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Physical state liquid Appearance viscous cream Odor Slight Color Light gray Odor threshold Page 4 / 8
Property Values ph 6-9 Melting point / freezing point <= 0 C / 32 F Boiling point / boiling range > 100 C / 212 F Flash point > 100 C / 212 F Evaporation rate >= 1 Flammability (solid, gas) Flammability Limit in Air Upper flammability limit: Lower flammability limit: Vapor pressure 18 mmhg Vapor density Relative density 1.1-1.3 Water solubility dispersible Solubility in other solvents Partition coefficient Autoignition temperature Decomposition temperature Kinematic viscosity > 100 mm2/s Dynamic viscosity Explosive properties Not an explosive Oxidizing properties Not applicable Remarks Method Pensky-Martens Closed Cup (PMCC) @ 25 C @ 40 C Other Information Softening point Molecular weight VOC Content (%) Density Bulk density 10. STABILITY AND REACTIVITY Reactivity No data available Chemical stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. Conditions to avoid Elevated Temperature. Keep from freezing. Incompatible materials. Incompatible materials Strong oxidizing agents. Strong acids. Strong bases. Hazardous Decomposition Products Thermal decomposition can lead to release of irritating and toxic gases and vapors. Information on likely routes of exposure Product Information 11. TOXICOLOGICAL INFORMATION Inhalation Eye contact Skin contact Ingestion May cause irritation of respiratory tract. Irritating to eyes. Irritating to skin. No data available. Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 Page 5 / 8
Water 7732-18-5 Titanium dioxide 13463-67-7 Diethylene glycol monobutyl ether 112-34-5 > 90 ml/kg ( Rat ) - - > 5000 mg/kg ( Rat ) > 2000 mg/kg ( Rabbit ) - = 4700 mg/kg ( Rat ) = 10600 mg/kg ( Rat ) = 9530 µl/kg - ( Rabbit ) > 10000 mg/kg ( Rat ) - - = 5660 mg/kg ( Rat ) = 2700 mg/kg ( Rabbit ) - Information on toxicological effects Symptoms May cause redness and tearing of the eyes. Coughing and/ or wheezing. May cause skin irritation. Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization. Germ cell mutagenicity. Carcinogenicity This product contains titanium dioxide which is classified as a possible carcinogen when present as respirable dust. This is not relevant for this product since it is a liquid. The table below indicates whether each agency has listed any ingredient as a carcinogen. Chemical Name ACGIH IARC NTP OSHA - Group 2B - X Titanium dioxide 13463-67-7 - Group 2B - X IARC (International Agency for Research on Cancer) Group 2B - Possibly Carcinogenic to Humans OSHA (Occupational Safety and Health Administration of the US Department of Labor) X - Present Reproductive toxicity. STOT - single exposure Target Organs. Respiratory system. Eyes. STOT - repeated exposure. Target Organ Effects Eyes, lungs, Respiratory system, Skin, Central nervous system. Aspiration hazard. Numerical measures of toxicity - Product Information The following values are calculated based on chapter 3.1 of the GHS document. ATEmix (oral) 10,348.00 mg/kg Ecotoxicity Very toxic to aquatic life with long lasting effects None known 12. ECOLOGICAL INFORMATION 99.58198 % of the mixture consists of components(s) of unknown hazards to the aquatic environment Persistence and degradability. Bioaccumulation Chemical Name Partition coefficient 6-1.93 Other adverse effects Page 6 / 8
13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Contaminated packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. Do not reuse container. 14. TRANSPORT INFORMATION DOT TDG IATA IMDG Not regulated Not regulated Not regulated Not regulated International Inventories TSCA DSL/NDSL EINECS/ELINCS IECSC KECL PICCS AICS 15. REGULATORY INFORMATION Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 Chemical Name SARA 313 - Threshold Values % - 1.0 Diethylene glycol monobutyl ether - 112-34-5 1.0 SARA 311/312 Hazard Categories Acute health hazard Yes Chronic Health Hazard No Fire hazard No Sudden release of pressure hazard No Reactive Hazard No CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 Page 7 / 8
CFR 122.42) CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) 5000 lb - RQ 5000 lb final RQ RQ 2270 kg final RQ US State Regulations California Proposition 65 This product contains the following Proposition 65 chemicals Chemical Name California Proposition 65 - Developmental Titanium dioxide - 13463-67-7 Carcinogen Quartz - 14808-60-7 Carcinogen U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania Limestone 1317-65-3 Titanium dioxide 13463-67-7 Diethylene glycol monobutyl ether X - X 112-34-5 Sulfur 7704-34-9 Quartz 14808-60-7 U.S. EPA Label Information EPA Pesticide Registration Number Not applicable 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION OF THE LAST REVISION NFPA HMIS Health hazards 2 Flammability 0 Health hazards 2 Flammability 0 Instability 0 Physical hazards 0 Physical and Chemical Properties - Personal protection X Issue Date 25-Mar-2016 Revision Date 25-Mar-2016 Revision Note Disclaimer The information provided in this Material Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 8 / 8