SAFETY DATA SHEET Version 6 1. IDENTIFICATION Product identifier Product Name ULTRA GREY RIGID HIGH TORQUE RTV 13 Other means of identification Product Code 82195 Recommended use of the chemical and restrictions on use Recommended Use Sealant Uses advised against Details of the supplier of the safety data sheet Manufacturer Address ITW Permatex 6875 Parkland Blvd. Solon, OH 44139 USA 24-hour emergency phone number Chem-Tel: 800-255-3924 International Emergency: 00+1+ 813-248-0585 Contract Number: MIS0003453 May Also Be Distributed by: ITW Permatex Canada 101-2360 Bristol Circle Oakville, ON Canada L6H 6M5 Telephone: (800) 924-6994 E-mail address: mail@permatex.com 2. HAZARDS IDENTIFICATION Classification OSHA Regulatory Status This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) Serious eye damage/eye irritation Category 2A Skin sensitization Category 1 Carcinogenicity Category 2 Label elements Signal word Warning Emergency Overview Causes serious eye irritation May cause an allergic skin reaction Suspected of causing cancer Page 1 / 8
Appearance Gray Physical state Paste Odor Mild Precautionary Statements - Prevention Obtain special instructions before use Do not handle until all safety precautions have been read and understood Use personal protective equipment as required Wash face, hands and any exposed skin thoroughly after handling Avoid breathing dust/fume/gas/mist/vapors/spray Contaminated work clothing should not be allowed out of the workplace Precautionary Statements - Response IF exposed or concerned: Get medical advice/attention Specific treatment (see supplemental first aid instructions on this label) IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention IF ON SKIN: Wash with plenty of soap and water If skin irritation or rash occurs: Get medical advice/attention Wash contaminated clothing before reuse Precautionary Statements - Storage Store locked up Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) Not applicable Other Information - Not applicable Unknown acute toxicity 32.7506 % of the mixture consists of ingredient(s) of unknown toxicity 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance(s) Chemical Name CAS No Weight-% 2-BUTANONE OXIME 96-29-7 1-5 Description of first aid measures 4. FIRST AID MEASURES General advice Eye contact Get medical advice/attention if you feel unwell. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Skin contact IF ON SKIN:. Wash skin with soap and water. If skin irritation or rash occurs: Get medical Page 2 / 8
advice/attention. Wash contaminated clothing before reuse. Inhalation Ingestion Self-protection of the first aider IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. If symptoms persist, call a physician. IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Call a physician. Use personal protective equipment as required. Most important symptoms and effects, both acute and delayed Symptoms May cause allergic skin reaction. Indication of any immediate medical attention and special treatment needed Note to physicians Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Carbon dioxide (CO2), Dry chemical, Foam Unsuitable extinguishing media None Specific hazards arising from the chemical None in particular. Explosion data Sensitivity to Mechanical Impact Sensitivity to Static Discharge None. None. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal precautions Ensure adequate ventilation, especially in confined areas. Avoid contact with eyes and skin. Use personal protective equipment as required. Environmental precautions Environmental precautions See Section 12 for additional Ecological Information. Methods and material for containment and cleaning up Methods for containment Methods for cleaning up Prevention of secondary hazards Prevent further leakage or spillage if safe to do so. Ensure adequate ventilation. Flood with water to complete polymerization and scrape off floor. Sweep up and shovel into suitable containers for disposal. Slippery, can cause falls if walked on. Clean contaminated objects and areas thoroughly observing environmental regulations. 7. HANDLING AND STORAGE Precautions for safe handling Page 3 / 8
Advice on safe handling Handle in accordance with good industrial hygiene and safety practice. Avoid breathing vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling. Wash contaminated clothing before reuse. Use personal protective equipment as required. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible materials Keep containers tightly closed in a cool, well-ventilated place. Protect from moisture. Strong oxidizing agents, Acids, Water 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Exposure Guidelines. NIOSH IDLH Immediately Dangerous to Life or Health Other Information Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Controls Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/face protection Skin and body protection Respiratory protection General Hygiene Considerations Tight sealing safety goggles. Wearprotectivenaturalrubber,nitrilerubber,Neoprene orpvcgloves. Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as appropriate. Handle in accordance with good industrial hygiene and safety practice. Regular cleaning of equipment, work area and clothing is recommended. Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state Appearance Odor Odor threshold Paste Gray Mild Property Values Remarks Method ph Melting point / freezing point Boiling point / boiling range Polymerization Flash point > 93 C / > 199 F Tag Closed Cup Evaporation rate < 1 Butyl acetate = 1 Flammability (solid, gas) Flammability Limit in Air Upper flammability limit: Lower flammability limit: Vapor pressure <5 mm Hg @ 70 F Vapor density >1 Air = 1 Relative density 1.47 Page 4 / 8
Water solubility Solubility in other solvents Partition coefficient Autoignition temperature Decomposition temperature Kinematic viscosity Dynamic viscosity Explosive properties Oxidizing properties Other Information Softening point Molecular weight VOC Content (%) <2% Density Bulk density Reactivity Stable under normal conditions Chemical stability Stable under recommended storage conditions Possibility of Hazardous Reactions None under normal processing. Conditions to avoid Excessive heat. Incompatible materials Strong oxidizing agents, Acids, Water 10. STABILITY AND REACTIVITY Hazardous Decomposition Products Carbon oxides Nitrogen oxides (NOx) Formaldehyde May release 2-butanone oxime (ethyl methyl ketoxime) at elevated temperature Information on likely routes of exposure 11. TOXICOLOGICAL INFORMATION Inhalation Eye contact Skin contact Ingestion May cause irritation of respiratory tract. Contact with eyes may cause irritation. May cause redness and tearing of the eyes. May cause sensitization by skin contact. May cause skin irritation and/or dermatitis. Ingestion may cause irritation to mucous membranes. Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 2-BUTANONE OXIME = 930 mg/kg ( Rat ) 1000-1800 mg/kg ( Rabbit ) > 4800 mg/m 3 ( Rat ) 4 h 96-29-7 Information on toxicological effects Symptoms. Page 5 / 8
Delayed and immediate effects as well as chronic effects from short and long-term exposure Sensitization Germ cell mutagenicity Carcinogenicity Target Organ Effects May cause sensitization by skin contact... Eyes, Respiratory system, Skin. The following values are calculated based on chapter 3.1 of the GHS document. ATEmix (oral) 14587 ATEmix (dermal) 17649 Ecotoxicity 12. ECOLOGICAL INFORMATION 99.8106 % of the mixture consists of component(s) of unknown hazards to the aquatic environment Persistence and degradability. Bioaccumulation. Mobility. Chemical Name 2-BUTANONE OXIME 96-29-7 Partition coefficient 0.65 Other adverse effects 13. DISPOSAL CONSIDERATIONS Waste treatment methods Disposal of wastes Contaminated packaging US EPA Waste Number Disposal should be in accordance with applicable regional, national and local laws and regulations. Do not reuse container. Not applicable 14. TRANSPORT INFORMATION DOT Proper shipping name: IATA Proper shipping name: IMDG Proper shipping name: Not regulated Not regulated Not regulated Page 6 / 8
15. REGULATORY INFORMATION International Inventories TSCA DSL/NDSL EINECS/ELINCS Not determined ENCS Not determined IECSC KECL PICCS AICS Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372 SARA 311/312 Hazard Categories Acute health hazard Chronic Health Hazard Fire hazard Sudden release of pressure hazard Reactive Hazard Yes No No No No CWA (Clean Water Act) This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40 CFR 122.42) CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level pertaining to releases of this material US State Regulations California Proposition 65 This product does not intentionally contain any chemicals known by the State of California to cause cancer and/or birth defects U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania ALUMINIUM POWDER X X X 7429-90-5 U.S. EPA Label Information EPA Pesticide Registration Number Not applicable WHMIS Hazard Class D2B - Toxic materials 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION OF THE LAST REVISION Page 7 / 8
NFPA Health hazards 2 Flammability 1 Instability 0 - HMIS Health hazards 2 Flammability 1 Physical hazards 0 Personal protection B NFPA (National Fire Protection Association) HMIS (Hazardous Material Information System) Revision Date 17-Jul-2018 Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 8 / 8