FOREST DISINFECTANT CLEANER Date of Issue 1/ 12 / 16 Code PC471 for 25L drum Version No. 3 Code PC475 for 5L jerrycan

Transcription

1 SAFETY DATA SHEET FOREST DISINFECTANT CLEANER Date of Issue 1/ 12 / 16 Code PC471 for 25L drum Version No. 3 Code PC475 for 5L jerrycan 1: IDENTIFICATION OF CHEMICAL PRODUCT AND COMPANY Chemical Nature: Water solution of surfactants and other minor ingredients. SUPPLIER: General Sanitation Pty Ltd ABN Prince William Drive Seven Hills NSW 2147 Telephone Fax: (02) MANUFACTURER: PAN CHEMICALS PTY LTD ABN ADDRESS: 22 Prince William Drive Seven Hills NSW 2147 TELEPHONE NUMBER: (02) FACSIMILE NUMBER: (02) EMERGENYCY TELEPHONE NUMBER: (02) during office hours only OR ANYWHERE IN AUSTRALIA PRODUCT USE: A quaternary ammonium formulation for use as a disinfectant for non-porous surfaces or similar. Thoroughly rinse surfaces after disinfecting. 2: HAZARDS IDENTIFICATION STATEMENT OF HAZARDOUS NATURE This product is classified as: Not classified as hazardous according to the criteria of SWA Australia. Not a Dangerous Good according to Australian Dangerous Goods (ADG) Code, IATA and IMDG/IMSBC criteria. Risk Phrases: Not Hazardous - No criteria found. Safety Phrases: S25. Avoid contact with eyes. SUSMP Classification: allocated. ADG Classification: allocated. Not a Dangerous Good under the ADG Code. UN Number: allocated GHS Signal word: NONE. Not hazardous. PREVENTION P102: Keep out of reach of children. P262: Do not get in eyes, on skin, or on clothing. P281: Use personal protective equipment as required. RESPONSE P337: If eye irritation persists: seek medical attention. P353: Rinse skin or shower with water. P301+P330+P331: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P370+P378: Not combustible. Use extinguishing media suited to burning materials. STORAGE P402+P404: Store in a dry place. Store in a closed container. DISPOSAL P501: If product cannot be recycled or reclaimed, contact a specialist waste disposal company (see Section 13 of this SDS). Page 1 of 7

2 EMERGENCY OVERVIEW Physical Description & Colour: Red coloured liquid. Odour: Eucalyptus Aroma. Major Health Hazards: no significant risk factors have been found for this product. POTENTIAL HEALTH EFFECTS No adverse health effects are likely to occur from any exposure during normal use of the product, providing the precautions for use are followed. Acute May be irritant to mouth, throat and gastro-intestinal system. Significant quantities can cause nausea, vomiting. Inhaled: Chronic: Some Irritation may result. Not sufficiently irritant to be classified as hazardous, however, first aid should be applied promptly. Not expected to be irritant. Repeated contact may cause mild de-fatting of skin and lead to contact dermatitis. Vapours not an inhalation hazard. Mists may be irritant. No data was found indicating any chronic effects of ingredients. CHRONIC (LONG TERM) EFFECTS: CARCINOGEN STATUS: Repeated contact with skin may lead to dermatitis. No ingredient reported as sensitising or carcinogenic in animal tests. Not classified by NOHSC, NTP or IARC 3: COMPOSITION INFORMATION AND INGREDIENTS Ingredients leading to hazardous characteristic: Chemical Name: CAS Number: Proportion: TWA (mg/m3) STEL (mg/m3) Alkylbenzyldimethyl ammonium chloride not set not set Other non hazardous ingredients secret 1-5 not set not set Water to 100 not set not set This is a commercial product whose exact ratio of components may vary slightly. Minor quantities of other non hazardous ingredients are also possible No ingredients are present which cause the product to be classified as hazardous. Contains 30 g/l quaternary ammonium compound. The TWA exposure value is the average airborne concentration of a particular substance when calculated over a normal 8 hour working day for a 5 day working week. The STEL (Short Term Exposure Limit) is an exposure value that should not be exceeded for more than 15 minutes and should not be repeated for more than 4 times per day. There should be at least 60 minutes between successive exposures at the STEL. The term "peak "is used when the TWA limit, because of the rapid action of the substance, should never be exceeded, even briefly. Page 2 of 7

3 4: FIRST AID MEASURES First Aid Inhaled: First Aid facilities: Advice to doctor: If poisoning occurs contact a doctor or poisons information centre. If swallowed, DO NOT INDUCE VOMITING. Give water or milk then a raw egg. If vomiting or nausea occurs, give more water and seek medical advice. Immediately wash out with plenty of water or eye-wash solution. Continue to wash out, holding the eye open, for at least 15 minutes and then seek medical advice. Wash with water followed by soap and water. Launder contaminated clothing before re-use. Not applicable No specific facilities. Treat as exposure to cationic surfactant. For further advice contact the Poisons Information Centre Telephone anywhere in Australia, contact a doctor. 5: FIRE-FIGHTING MEASURES FIRE/EXPLOSION HAZARD: SUITABLE EXTINGUISHING MEDIA: ; will not burn (based on water). Water jets (fine spray) or fog, dry chemical or carbon dioxide. HAZARDS FROM COMBUSTION PRODUCTS: Burning can produce carbon monoxide and/or carbon dioxide PRECAUTIONS FOR FIRE FIGHTERS AND SPECIAL PROTECTIVE EQUIPMENT: ADDITIONAL INFORMATION: Use water to cool containers. If safe to do so, remove containers from path of fire. Fire fighters must wear self-contained breathing apparatus with full face-mask and protective clothing. available. 6: ACCIDENTAL RELEASE MEASURE EMERGENCY PROCEDURES METHODS AND MATERIALS FOR CONTAINMENT AND CLEAN UP SAA/SNZ HB76: Dangerous Goods Initial Response Guide Not applicable. Clear area of all unprotected personnel. Wear full protective equipment to prevent skin and eye contact. Collect in an appropriate container or absorb with an inert material (eg vermiculite, dry sand, earth), and place in a chemical waste container. 7: HANDLING AND STORAGE PRECAUTIONS FOR SAFE HANDLING: CONDITIONS FOR SAFE STORAGE INCLUDING AND INCOMPATABILITIES: Any non authorised use or non intended use of this product may result in personal injury or damage to equipment. Always store product in original container. Always wash hands and face thoroughly with clean portable water after handling and before eating, drinking, smoking, using the toilet.. Store in a cool, dry and well ventilated area away from incompatible materials. Keep container tightly sealed. Check regularly for leaks and spills. Protect container from physical damage. Page 3 of 7

4 8: EXPOSURE CONTROL & PERSONAL PROTECTION Exposure standards: TWA = mg/m³ Worksafe Australia = established STEL = mg/m³ Worksafe Australia = established The Time Weighted Average (TWA) is the concentration of the substance in the worker s breathing zone, exposure to which over 8-hour days, 5-day weeks over a working lifetime, should not cause any undue discomfort or health impairment to nearly all workers. The Short Term Exposure Limit (STEL), means a 15 minute TWA exposure which should not be exceeded and should not be repeated within 60 minutes or more than four times per day. No standard set by Worksafe Australia. Engineering Controls: required. Natural ventilation expected to be adequate Personal Protection: Flammability: Normal room ventilation is adequate Safety glasses preferred. Always wear suitable gloves on hands. Respiratory protection needed where mist is a problem or if used in a confined area. Use a respirator suitable for organic vapours. Not flammable and not combustible 9: PHYSICAL & CHEMICAL PROPERTIES Appearance: Pale green liquid Boiling Point: 100 C (water) Vapour Pressure: approx mm 20 C Closed Flash Point: N/A C Fire Point: N/A ºC Initial Boiling Point: 100 (water) ºC Solubility in water: All proportions ph of 1% solution: 7 Odour: Pine Corrosiveness: Not corrosive Oxidising properties: Not an oxidising agent Reactivity: Stable, may accelerate stress cracking of some plastics. Incompatible with anionic surfactants and nitric acid. May corrode mild steel, copper, zinc or aluminium. Autoignition Temperature: Not applicable UN No. Dangerous Goods Class: Subsidiary Risk: HAZCHEM Code: Emergency Procedure Guide: Poisons Schedule: Classification according to SWA: FREE Not Scheduled Not hazardous Page 4 of 7

5 10: STABILITY & REACTIVITY Chemical stability Reactivity: Incompatible materials: Autoignition Temperature: Corrosiveness: Oxidising properties: Hazardous decomposition products: Hazardous reactions: Shelf Life: Stable under normal storage conditions. Avoid high temperatures, store below 30º C. Protect from physical damage. Stable, may accelerate stress cracking of some plastics. Incompatible with anionic surfactants and nitric acid. May corrode mild steel, copper, zinc or aluminium. Not applicable Not corrosive Not an oxidising agent. known known 2 years from manufactured date 11: TOXICOLOGOCAL INFORMATION HEALTH EFFECTS ACUTE Inhaled: CHRONIC Inhalation: TOXICITY DATA: May cause tissue irritation especially in mouth, throat and stomach. Pain, irritation and reddening. May cause irritation.. Not available 12: ECOLOGICAL INFORMATION TOXICITY TO FISH: TOXICITY TO DAPHNIA: TOXICITY TO ALGA: TOXICITY TO BACTERIA: BIOGRADIBILITY: 13: DISPOSAL CONSIDERATIONS Spills can be slippery; clean up promptly. Do not allow into storm water drains or natural watercourses. Toxic to fish in high concentrations. Precipitated by anionic surfactants in sewerage systems or absorbed on sludge. Spills and Disposal: Dike and cover with dry absorbent. Dispose of absorbent in ordinary domestic or commercial waste. Disposal of used absorbent to ordinary landfill is acceptable. Page 5 of 7

6 14: TRANSPORT INFORMATION Storage and Transport: Not Dangerous Goods according to Australia Dangerous goods Code. Ordinary Storage conditions are adequate. STORAGE: Store in cool place, preferably below 25 C. Do not add water to drum. If storage space regularly has large temperature changes condensation may occur inside the drum and hence cause the preservative to deteriorate and hence the product will smell and will no longer be usable. 15: REGULATORY INFORMATION Poisons Schedule (SUSMP): allocated All ingredients listed in the Australian Inventory of Chemical Substances (AICS). Version No. 3 16: OTHER INFORMATION As the product is not classified as a Workplace Hazardous Substance, the product does not need SWA Acronyms: labelling. R-PHRASES: S-PHRASES: Precautionary AVOID CONTACT WITH SKIN AND EYES (S24/25) IN CASE OF CONTACT WITH EYES, RINSE IMMEDIATLEY WITH PLENTY OF WATER AND CONTACT A DOCTOR OR POISONS INFORMATION CENTRE. (S26) POISONS REGULATION REQUIREMENTS: ADG Code AICS CAS Number Hazchem Code SWA IARC NOS NTP R-Phrase SUSMP UN Number This SDS contains only safety-related information. For other data see product literature. Australian Code for the Transport of Dangerous Goods by Road and Rail Australian Inventory of Chemical Substances Chemical Abstracts Service Registry Number Emergency action code of numbers and letters that provide information to emergency services specially firefighters Safe Work Australia, formerly ASCC and NOHSC International Agency for Research on Cancer Not otherwise specified National Toxicology Program (USA) Risk Phrase Standard for the Uniform Scheduling of Medicines & Poisons United Nations Number Page 6 of 7

7 CONTACT: Anastasios Sakalidis Telephone: (02) Facsimile: (02) NEXT REVISION DATE: Not later than 30 th November, 2021 but may require revision when new or better information becomes available. VERSION AUTHORISED BY: Anastasios Sakalidis Position: Consultant Date: 1 st December 2016 SUPPLIER STATEMENT and IMPORTANT DISCLAIMER All information given in this data sheet and by the company s technical staff is compiled from the best information currently available to the company. The company accepts no responsibility whatsoever for its accuracy or for any results which may be obtained by customers. Any customer who relies upon any advice or information given in this data sheet by the company or by its directors and staff does so entirely at their own risk and the company will not be liable for any loss or damage thereby suffered not withstanding any want of care on the part of the company, its directors or its staff in compiling or giving the advice or information. This SDS is based on information known to the company at this time by its directors and staff. Pan Chemicals Pty Ltd and General Sanitation Pty Ltd, their directors and staff have taken all reasonable precautions in preparing this SDS, however Pan Chemicals Pty Ltd and General Sanitation Pty Ltd, their directors and staff and the authors and consultants involved in preparing the report are not responsible for the results of any actions taken on the basis of information provided nor for any error therein or omission therefrom. Pan Chemicals Pty Ltd and General Sanitation Pty Ltd, their directors and staff and the authors of the SDS expressly disclaim all and any liability and responsibility to any person in respect of anything and of the consequences of anything done or omitted to be done by any such person in reliance, whether wholly or partially, upon the whole or any part of the contents of the SDS. Pan Chemicals Pty Ltd and General Sanitation Pty Ltd, their directors and staff cannot anticipate or control conditions under which the product may be used, hence each user must prior to usage, review and rely on their own best judgements after reviewing all the information on this SDS in context of how the user intends to handle and use the product in the workplace. This product s use is intended for use in a commercial establishment. Health or safety data given may indicate a risk to a purchaser. It is the responsibility of the purchaser to pass onto staff and others the information needed, to ensure adequate safety procedures are used including good hygiene. Page 7 of 7