GHS Classification: Signal word NONE

Transcription

1 MEGA LOOK SEALER MATERIAL SAFETY DATA SHEET Code PC765 5L Jerrycan Issue date: 1 st May IDENTIFICATION OF CHEMICAL PRODUCT AND COMPANY SUPPLIER: Pan Chemicals Pty Ltd ABN Address: 22 Prince William Drive Seven Hills NSW 2147 Phone: (02) Fax: (02) EMERGENCY PHONE No. Poisons Information Centre Phone anywhere in Australia. PRODUCT USE: Floor Sealer/Polish. See label for details of methods of use. 2. HEALTH HAZARDS IDENTIFICATION STATEMENT OF HAZARDOUS NATURE Not classified as Hazardous according to criteria of NOHSC Australia. Not classified as Dangerous Goods Class 3 according to the ADG Code. GHS Classification: Signal word NONE APPROVED CRITERIA CLASSIFICATION: Not Classified as a Workplace Hazardous Substance. SUSDP CLASSIFICATION: Not scheduled ADG CODE CLASSIFICATION: Not Classified UN No. None HAZCHEM Code: None Initial Emergency Procedure Guide: None HAZARD STATEMENTS: None PRECAUTINARY STATEMENTS: None RESPONSE STATEMENTS: None STORAGE STATEMENTS: None DISPOSAL STATEMENTS: None POTENTIAL HEALTH EFFECTS Acute Swallowed: Ingestion is not expected to cause acute toxic effects. Ingestion of large quantities may result in nausea, stomach pain and vomiting. DO NOT INDUCE vomiting. For advice contact Poisons Information Centre by telephoning from anywhere in Australia or contact a doctor Eye: Skin: Inhaled: Contact with the eyes may cause irritation if not washed out immediately. Hold eyelids apart and flush the eye continuously with running water. Continue flushing until advised to stop by the Poisons Information Centre or for at least 15 minutes Contact with the skin is not expected to cause irritation, however remove clothing and flush skin and hair with running water. Apply artificial respiration if not breathing. Inhalation of mist, spray or gas may cause minor irritation to airways. Page 1 of 6

2 3. COMPOSITION INFORMATION AND INGREDIENTS CAS No. CONCENTRATION Ingredients deemed non-hazardous according to NOHSC criteria not applicable <to 100% 4. FIRST AID MEASURES For advice, contact a Poisons Information Centre Phone anywhere in Australia, or a doctor. Eye (Contact): Hold eyelids apart and flush the eye continuously with running water. Skin (Contact): Remove contaminated clothing and flush skin and hair with running water. Inhalation (Breathing): Remove victim from exposure. Allow patient to assume most comfortable position and keep warm. Oxygen may be administered by qualified personnel if breathing is difficult. Seek medical attention if effects persist. Ingestion (Swallowing): DO NOT induce vomiting. Give water to drink if conscious. For advice, contact a Poisons Information Centre (Phone ) or a doctor. Advice to Doctor: Treat symptomatically. First Aid Facilities: Ensure an eye wash is available and ready for use. Additional Information: No aggravated medical conditions are known to be caused by exposure to this product. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media: Use water fog (or if unavailable fine water spray), dry chemical, carbon dioxide or alcohol stable foam suitable for materials that are burning. Hazards From Combustion Products: Carbon dioxide and carbon monoxide may be produced in the case of fire or during thermal decomposition. Precautions For Fire Fighters and Special Protective Equipment: Keep containers cool by spraying with water. Additional Information: None available. Hazchem Code: Not applicable. 6. ACCIDENTAL RELEASE MEASURES EMERGENCY PROCEDURES: SAA/SNZ HB76: Dangerous Goods initial Emergency Response Guide Not applicable. Accidental Release: Clean up personnel should wear full protective clothing. Restrict access until completion of clean up. Then ensure adequate ventilation. Stop leak if safe to do so. Contain spill with absorbent material, such as towelling, sand, vermiculite or other inert material. Prevent spill entering stormwater drains or waterways. Collect and dispose of clean up material according to local regulations. Wash away remnants with copious amounts of cold water to sewer. Clean area by working from the periphery to the centre of spill or from the edge of the room to the centre. Clear area of all unprotected personnel. Wear Personal Protective Equipment shown in Section 8. Seal leak. Place leaking containers in overbin, label for disposal. Contain spill with absorbent material such as dry sand. Do not allow to enter drains or sewer. Sweep up used absorbent and place in labelled container. Damp down contaminated area with water, cover with absorbent and sweep up and place in labelled container. Negotiate disposal with Waste authority for jurisdiction. OCCUPATIONAL RELEASE: As for accidental release. Page 2 of 6

3 7. HANDLING AND STORAGE Not Classified as Dangerous Goods (DG). Precautions for safe handling: Any non intended or non-authorised use of this product may result in personal injury or damage to equipment. Store product in original container. Wash hands and face thoroughly after handling and before work breaks, eating, smoking and using toilet facilities. STORAGE: SHELF LIFE: Store away from heat and below 30º and out of direct sunlight. Store in a cool, dry, well ventilated area away from incompatible materials. Keep container tightly sealed. Check regularly for spills and leaks. Protect against physical damage. 2 years from manufactured date. 8. EXPOSURE CONTROL & PERSONAL PROTECTION National Exposure Standards Source: National Exposure Standards for Atmospheric Contaminants in the Occupational Environment [NOHSC:1003] & New Zealand Workplace Exposure Standards EXPOSURE LIMITS: NOHSC TWA = None established NOHSC STEL= None established The Time Weighted Average (TWA) is the concentration of the substance in the worker s breathing zone, exposure to which over 8-hour days, 5-day weeks over a working lifetime, should not cause any undue discomfort or health impairment to nearly all workers. The Short Term Exposure Limit (STEL), means a 15 minute TWA exposure which should not be exceeded and should not be repeated within 60 minutes or more than four times per day. Biological limit values: Engineering Controls: Not available. Ensure adequate ventilation to keep airborne concentrations below exposure levels Ingredient CAS No ES-TWA ES-STEL Not Applicable Personal Protection: VENTILATION: RESPIRATOR: EYE PROTECTION: SKIN PROTECTION: Flammability: Mechanical ventilation is not required in normal use where there is good natural ventilation. Avoid breathing spray or mist. Not required for normal use in a well ventilated area. If product is being used in a confined area where mist is a problem, use a respirator suitable for organic vapours. Avoid contact with eyes. Wear eye protection complying with AS 1337 of type: safety glasses or chemical resistant goggles to prevent eye contact. When decanting/handling concentrate from original container, avoid contact with skin. Wear impervious gloves complying with AS 2161 of type: PVC-coated cotton or nitrile rubber gloves. Not flammable or combustible. Page 3 of 6

4 9. PHYSICAL & CHEMICAL PROPERTIES Appearance Milky white liquid Odour Mild Odour Threshold ph 9.00 Freezing Point Approx. 0⁰C Initial Boiling Point Approx. 100⁰C Boiling Range Flash point Evaporation Rate Flammability Upper flammability limit Lower flammability limit Vapour Pressure Vapour Density Relative Density Solubility Completely miscible with water Partition Coefficient: n-octanol/water Autoignition temperature Decomposition temperature Viscosity Approx. 10 cps 10. STABILITY & REACTIVITY REACTIVITY: CONDITIONS TO AVOID: SHELF LIFE: INCOMPATIBILITIES: HAZARDOUS DECOMPOSITION: HADZARDOUS REACTIONS: Chemically stable under normal ambient conditions and will not undergo any hazardous reactions under normal conditions of use and storage. Store in cool place, preferably below 30 C. Do not add water to drum. If storage space regularly has large temperature changes condensation may occur inside the drum and hence cause the preservative to deteriorate and hence the product will smell and will no longer be usable. Protect against physical damage. 2 years from manufactured date None identified. Do not mix with other chemicals. No decomposition expected at normal temperatures. None known. 11. TOXICOLOGICAL INFORMATION HEALTH EFFECTS ACUTE Swallowed: Eyes: Considered an unlikely route of entry in commercial/industrial environments. May cause tissue irritation or damage in the mouth, throat and stomach. Pain, irritation and reddening may occur. Skin: Inhaled: CHRONIC Swallowed: Eye: Skin: Inhalation: May cause irritation. No effects known. No data on the product mixture is available. Hazard estimated from consideration of hazardous ingredient concentration. No effects known No effects known No effects known No effect known Page 4 of 6

5 TOXICITY DATA Generally none available Carcinogenicity No components of this product at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcigen by IARC Reproductive toxicity Specific Target Organ Toxicity singe exposure Specific Target Organ Toxicity repeated exposure Aspiration Hazard 12. ECOLOGICAL INFORMATION Does not contain heavy metals. NOT expected to be exotoxic as no data is available Persistence and degradability no data is available Bioaccumulative potential no data available Mobility in soil no data available other adverse effects no data available TOXICITY TO FISH: TOXICITY TO DAPHNIA: TOXICITY TO ALGA: TOXICITY TO BACTERIA: READY BIODEGRADABILITY: No data on mixture No data on product No data on product No data on product Data not yet available 13. DISPOSAL CONSIDERATIONS PREFERRED METHOD OF DISPOSAL: Disposal method Disposal to sewer is normally recommended with copious amounts of water. Refer to State/Territory Land Waste Management Authorities if applicable. Containers are recyclable and can be disposed of by a licensed waste contractor. Containers can be disposed of to general waste or rinsed thoroughly and recycled. Special precautions Suitable for incineration by approved agent. Triple rinse containers into the cleaning liquid and recycle container, if recycling system is available. 14. TRANSPORT INFORMATION & STORAGE CLASS Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG Code). UN Number Not applicable. UN Proper Shipping Name Not applicable. Class and subsidiary risk Not applicable. Packing Group Not applicable. Special precautions for user Not applicable. : STORAGE: Store in cool place, preferably below 30 C. Do not add water to drum. If storage space regularly has large temperature changes condensation may occur inside the drum and hence cause the preservative to deteriorate and hence the product will smell and will no longer be usable. Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG code). Page 5 of 6

6 15. REGULATORY INFORMATION Poisons Schedule (SUSDP): Not applicable. All ingredients are listed in the Australia Inventory of Chemical Substances (AICS). This document has been produced in accordance with the requirements of the Globally Harmonised System of Classification and Labelling. 16. OTHER INFORMATION. As the product is not classified as a Workplace Hazardous Substance, the product does not need WHS labelling. R-PHRASES: None S-PHRASES: Precautionary AVOID CONTACT WITH SKIN AND EYES (S24/25) IN CASE OF CONTACT WITH EYES, RINSE IMMEDIATLEY WITH PLENTY OF WATER AND CONTACT A DOCTOR OR POISONS INFORMATION CENTRE. (S26) POISONS REGULATION REQUIREMENTS: None Contact A. Sakalidis Telephone during business hours (02) NEXT REVISION DATE: Not later than 30 th April 2021 but may require revision when new or better information becomes available. Data and information on these Safety Data Sheets was compiled and copied from Aimix Chemicals Pty Ltd SUPPLIER STATEMENT and IMPORTANT DISCLAIMER All information given in this data sheet and by the company s technical staff is compiled from the best information currently available to the company. The company accepts no responsibility whatsoever for its accuracy or for any results which may be obtained by customers. Any customer who relies upon any advice or information given in this data sheet by the company or by its directors and staff does so entirely at their own risk and the company will not be liable for any loss or damage thereby suffered not withstanding any want of care on the part of the company, its directors or its staff in compiling or giving the advice or information. This SDS is based on information known to the company at this time by its directors and staff. Pan Chemicals Pty Ltd, its directors and staff as well as General Sanitation Pty Ltd have taken all reasonable precautions in preparing this SDS, however, Pan Chemicals Pty Ltd, its directors and staff and the authors and consultants as well as General Sanitation Pty Ltd involved in preparing the report are not responsible for the results of any actions taken on the basis of information provided nor for any error therein or omission therefrom. Pan Chemicals Pty Ltd, its directors and staff and the authors as well as General Sanitation Pty Ltd of the SDS expressly disclaim all and any liability and responsibility to any person in respect of anything and of the consequences of anything done or omitted to be done by any such person in reliance, whether wholly or partially, upon the whole or any part of the contents of the SDS. Pan Chemicals Pty Ltd, its directors and staff as well as General Sanitation Pty Ltd cannot anticipate or control conditions under which the product may be used, hence each user must prior to usage, review and rely on their own best judgements after reviewing all the information on this SDS in context of how the user intends to handle and use the product in the workplace. This product s use is intended for use in a commercial establishment. Health or safety data given may indicate a risk to a purchaser. It is the responsibility of the purchaser to pass onto staff and others the information needed, to ensure adequate safety procedures are used including good hygiene. Page 6 of 6