Safety Data Sheet according to 1907/2006/EC, Article 31

Transcription

1 Page 1/6 * 1 Identification of substance: Product details: Application of the substance / the preparation Priming Manufacturer/Supplier: Hermann Otto GmbH Krankenhausstraße 14 D Fridolfing Tel.: 0049/(0)8684/908-0 Fax.: 0049/(0)8684/ Further information obtainable from: Tel.: (0) ( -460 ) alois.parzinger@otto-chemie.de Information in case of emergency: Tel.: (0) (emergency telephone no.) * 2 Hazards identification Hazard description: Xn Harmful F Highly flammable N Dangerous for the environment Information concerning to particular hazards to man and environment The product has to be labelled due to the calculation procedure of the "General Classification guideline for preparations of the EU" in the latest valid version. R 11 Highly flammable. R 36/38 Irritating to eyes and skin. R 51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment. R 65 Harmful: may cause lung damage if swallowed. R 67 Vapours may cause drowsiness and dizziness. Classification system The classification is according to the latest editions of the EU-lists, and extended by company and literature data. 3 Composition/information on ingredients Chemical characterization Description: Solvent mixture with additives. Dangerous components: CAS: Isoalkane C7 -C10 EINECS: Xn, Xi, F, N; R / CAS: titanium tetrabutanolate EINECS: Xi; R CAS: toluene EINECS: Xn, Xi, F; R / CAS: tetraethyl silicate EINECS: Xn, Xi; R /37 Additional information For the wording of the listed risk phrases refer to section % < 10% < 5% < 5% 4 First aid measures General information Immediately remove any clothing soiled by the product. Symptoms of poisoning may even occur after several hours; therefore medical observation for at least 48 hours after the accident. (Contd. on page 2)

2 Page 2/6 (Contd. of page 1) After inhalation Supply fresh air. If required, provide artificial respiration. Keep patient warm. Consult doctor if symptoms persist. After skin contact Immediately wash with water and soap and rinse thoroughly. If skin irritation continues, consult a doctor. After eye contact Rinse opened eye for several minutes under running water. Then consult a doctor. After swallowing Do not induce vomiting; call for medical help immediately. Show container or label. 5 Fire fighting measures Suitable extinguishing agents CO2, powder or water spray. Fight larger fires with water spray or alcohol resistant foam. For safety reasons unsuitable extinguishing agents Water with full jet. Special hazards caused by the substance, its products of combustion or resulting gases: Formation of toxic gases is possible during heating or in case of fire. Protective equipment: Mount respiratory protective device. Do not inhale explosion gases or combustion gases. Additional information Cool endangered receptacles with water spray. Collect contaminated fire fighting water separately. It must not enter the sewage system. * 6 Accidental release measures Person-related safety precautions: Ensure adequate ventilation Keep away from ignition sources Measures for environmental protection: Do not allow to enter sewers/ surface or ground water. Measures for cleaning/collecting: Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Dispose contaminated material as waste according to item 13. Additional information: See Section 8 for information on personal protection equipment. 7 Handling and storage Handling Information for safe handling: Ensure good ventilation/exhaustion at the workplace. see item 8: Personal protective equipment Information about fire - and explosion protection: Keep ignition sources away - Do not smoke. Protect against electrostatic charges. Traces of flammable substances may collect in the steam chamber of enclosed systems. Keep clear ofignition sources. Flammable gas-air mixtures may form in empty receptacles. Storage Requirements to be met by storerooms and receptacles: Provide solvent resistant, sealed floor. Prevent any seepage into the ground. Information about storage in one common storage facility: Store away from foodstuffs. Further information about storage conditions: Store receptacle in a well ventilated area. Store in cool, dry conditions in well sealed receptacles. (Contd. on page 3)

3 Page 3/6 Protect from heat and direct sunlight. (Contd. of page 2) * 8 Exposure controls and personal protection gear Additional information about design of technical facilities: No further data; see item 7. Ingredients with limit values that require monitoring at the workplace: toluene OES Short-term value: 574 mg/m³, 150 ppm Long-term value: 191 mg/m³, 50 ppm Sk tetraethyl silicate OES Short-term value: 260 mg/m³, 30 ppm Long-term value: 87 mg/m³, 10 ppm Additional information: The lists valid during the making were used as basis. Personal protective equipment General protective and hygienic measures The usual precautionary measures are to be adhered to when handling chemicals. Wash hands before breaks and at the end of work. Avoid contact with the eyes and skin. Pregnant women should strictly avoid inhalation or skin contact. Respiratory protection: Use suitable respiratory protective device when high concentrations are present. Protection of hands: Protective gloves. Material of gloves The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. Butyl rubber, BR Fluorocarbon rubber (Viton) Penetration time of glove material The exact break trough time has to be found out by the manufacturer of the protective gloves and has to be observed. Eye protection: Tightly sealed goggles. Body protection: Protective work clothing. * 9 Physical and chemical properties: General Information Form: Colour: Odour: Fluid Yellowish Characteristic Change in condition Melting point/melting range: undetermined Boiling point/boiling range: 116 C Flash point: 9 C Ignition temperature: 420 C Self-igniting: Product is not selfigniting. Danger of explosion: Product is not explosive. However, formation of explosive air/ vapour mixtures are possible. Explosion limits: Lower: 0.9 Vol % Upper: 7 Vol % Density at 20 C: 0.76 g/cm³ (Contd. on page 4)

4 Page 4/6 Solubility in / Miscibility with Water: ph-value at 20 C: 7 Not miscible or difficult to mix (Contd. of page 3) * 10 Stability and reactivity Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications. Avoid strong heating. Dangerous reactions Danger of receptacles bursting because of high vapour pressure when heated Can form explosive mixtures in air if heated above flash point and/or when sprayed or atomised Dangerous decomposition products: see item Toxicological information Acute toxicity: Primary irritant effect: on the skin: Irritating effects to skin and mucous membranes possible on the eye: Irritating effect possible Additional toxicological information: Inhalation of concentrated vapours as well as oral intake will lead to anaesthesia-like conditions and headache, dizziness, etc. * 12 Ecological information: General notes: Water hazard class 2 (German Regulation) (Self-assessment): hazardous for water. Do not allow product to reach ground water, water course or sewage system. Also poisonous for fish and plankton in water bodies. The material is harmful to the environment. 13 Disposal considerations Product: Recommendation Liquid residues must be specially treated adhering to official regulations. Uncleaned packaging: Recommendation: Empty contaminated packagings thoroughly. They may be recycled after thorough and proper cleaning. Packagings that may not be cleansed are to be disposed of in the same manner as the product. * 14 Transport information Land transport ADR/RID (cross-border) ADR/RID class: 3 (F1) Flammable liquids. Danger code (Kemler): 33 UN-Number: 1993 (Contd. on page 5)

5 Page 5/6 (Contd. of page 4) Packaging group: II Hazard label 3 Special marking: Symbol (fish and tree) Description of goods: 1993 FLAMMABLE LIQUID, N.O.S. (Isoalkane C7 -C10, TOLUENE) Tunnel restriction code D/E Maritime transport IMDG: IMDG Class: 3 UN Number: 1993 Label 3 Packaging group: II EMS Number: F-E,S-E Marine pollutant: Yes Symbol (fish and tree) Proper shipping name: FLAMMABLE LIQUID, N.O.S. (Isoalkane C7 -C10, TOLUENE) Air transport ICAO-TI and IATA-DGR: ICAO/IATA Class: 3 UN/ID Number: 1993 Label 3 Packaging group: II Proper shipping name: FLAMMABLE LIQUID, N.O.S. (Isoalkane C7 -C10, TOLUENE) * 15 Regulations Labelling according to EU guidelines: The product has been classified and marked in accordance with EU Directives / Ordinance on Hazardous Materials Code letter and hazard designation of product: Xn Harmful F Highly flammable N Dangerous for the environment Hazard-determining components of labelling: Isoalkane C7 -C10 Risk phrases: 11 Highly flammable. 36/38 Irritating to eyes and skin. 51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment. 65 Harmful: may cause lung damage if swallowed. 67 Vapours may cause drowsiness and dizziness. Safety phrases: 2 Keep out of the reach of children. 16 Keep away from sources of ignition - No smoking. 37/39 Wear suitable gloves and eye/face protection. 51 Use only in well-ventilated areas. 62 If swallowed, do not induce vomiting: seek medical advice immediately and show this container or label. (Contd. on page 6)

6 Page 6/6 National regulations Information about limitation of use: Employment restrictions concerning juveniles must be observed. Employment restrictions concerning pregnant and lactating women must be observed. Waterhazard class: Water hazard class 2 (Self-assessment): hazardous for water. (Contd. of page 5) 16 Other information: This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Relevant R-phrases 10 Flammable. 11 Highly flammable. 20 Harmful by inhalation. 36/37 Irritating to eyes and respiratory system. 38 Irritating to skin. 41 Risk of serious damage to eyes. 48/20 Harmful: danger of serious damage to health by prolonged exposure through inhalation. 51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment. 63 Possible risk of harm to the unborn child. 65 Harmful: may cause lung damage if swallowed. 67 Vapours may cause drowsiness and dizziness. Department issuing MSDS: Tel.: (0) Contact: Tel.: (0) ( -460 ) * Data compared to the previous version altered.