Revision Date: 6 September IPS SatWipes with Citrus Cleaner

Transcription

1 Revision Date: 6 September 2017 Trade Name: IPS SatWipes with Citrus Cleaner 1. Identification of the substance and of the company undertaking 1.1 Product identifier Product Name: IPS SatWipes with Citrus Cleaner Product Number: 7015HA 1.2 Relevant identified uses of the substance or mixture and uses advised against Identified use(s): General cleaning / degreaser Uses advised against: Follow supplier s recommendations on correct use of the product. Uses other than those covered by the exposure scenarios included in this safety data sheet are not supported. 1.3 Details of the supplier of the safety data sheet Manufacturer/Supplier: IPS-Group A/S Hejreskovvej 22a DK Kvistgaard Danmark Telephone: : Emergency telephone number In case of emergency call: (24hrs) 2. HAZARDS IDENTIFICATION: Classification according to Regulation (EC) No 1272/2008 (CLP) Eye Irrit.2 Other hazards 2.2 Label Elements 2.2.1Label according to Regulation (EC) No 1272/2008 (CLP) Signal word: Hazard Statement(s): Warning H319: Causes serious eye irritation Precautionary Statement(s) P264: Wash hands thoroughly after handling P305+P351: IF IN EYES rinse continuously with water for several minutes. Remove contact lenses if present and safe to do so continue rinsing. Call a poison centre or doctor/physician P : If skin irritation occurs. Get medical advice/attention 1

2 Other Hazards The mixture does not contain any vpvb or PBT substances. Section 3 Composition/Information on Ingredients 3.1 Substances 3.2 Mixtures Composition: Identification CAS No. EC No. Hazard Pict/ Statements % (Mixture) (mixture) Flam liq 2 H STOT SE H371 Eye irritant2 H319 Acute tox4- H302/312/332 TDSA (contains Ethanol /Methanol) Sodium Laureth sulphate Eye Dam. 1 H Cocodiethanolamide Eye damage 1 H Skin Irrit 2 H FIRST AID MEASURES 4.1 Description of first aid measures Inhalation: Eyes: Remove contact lenses. Rinse with water immediately for at least 10 minutes. Obtain medical attention if any discomfort occurs. Skin: Ingestion: May cause irritation. Wash with soap and water and rinse off If swallowed, drink plenty of water. Do not induce vomiting. Obtain immediate medical attention. 4.2 Most important symptoms and effects, both acute and delayed: No important symptoms or effects 5. FIRE-FIGHTING MEASURES 5.1 Extinguishing Media Suitable extinguishing media: Carbon dioxide, foam, water fog and dry chemical Unsuitable extinguishing Water stream media: 5.2 Special hazards arising from the substance or mixture Decomposition products may include toxic and irritant fumes 5.3 Advice for firefighters A self-contained breathing apparatus and suitable protective clothing should be worn in fire conditions. Move undamaged containers from fire area if this can be done safely. Keep fire containers cool by spraying with water. 6. ACCIDENTAL RELEASE MEASURES 6.1 Personal precautions, protective equipment and emergency procedures For non-emergency personnel Consult the safety measures listed under headings 7 and For emergency responders 6.2 Environmental precautions Avoid release to the environment 6.3 Methods and materials for cleaning up Clean preferably with a detergent, do not use solvents 6.4 Reference to other sections 2

3 Wear protective clothing as per section 8 7. HANDLING AND STORAGE The regulations relating to storage premises apply to workshops where the product is handled 7.1 Precautions for safe handling: Keep container closed when not in use Fire prevention: Recommended equipment and procedures For personal safety see section 8 Prohibited equipment and procedures Smoking, eating and drinking are prohibited in premises where the preparation is used. 7.2 Conditions for safe storage, including any incompatibilities Store tightly closed, in a cool, dry, ventilated area. Prevent exposure to high temperatures. 7.3 Specific end use(s) None specified 8. EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1 Control Parameters Occupational exposure limit - UK/WEL (Workplace exposure limits, EH40/2005, 2007): Ingredients LTEL 8Hr STEL 15 Mins Note TDSA (Ethanol) 1000ppm - WEL TSDA (Methanol) 200mg/m 3 (skin) 250mg/m 3 (skin) WEL 8.2 Exposure Controls Appropriate engineering controls Personal protection Eye protection: Skin protection: Hand protection: Respiratory protection: Safety goggles/glasses if there is a risk of eye contact. For frequent contact -nitrile gloves (EN 374). See glove manufacturer data for glove selection and breakthrough time for use conditions. If engineering controls do not maintain safe level, then filter/respirator. Type A filter material Environmental exposure controls Environmental exposure controls See sects 6,12, PHYSICAL AND CHEMICAL PROPERTIES 9.1 Information on basic physical and chemical properties Appearance: Odour: Odour threshold: ph: Melting/freezing point: Initial boiling point and range: Flash point: Evaporation rate: Flammability (solid, gas): Solid Characteristic, citrus 61 0 C 3

4 Upper/lower flammability or explosive limits: Vapour pressure: Vapour density: Relative density: 0.99 Solubility(ies): Miscible with water Partition coefficient: n- octanol/water Auto ignition temperature: Not self-igniting Decomposition temperature: Viscosity: Explosive properties: Oxidising properties: 10. STABILITY AND REACTIVITY 10.1 Reactivity: No dangerous reactions known under normal conditions of use Chemical stability: The mixture is stable under the recommended handling and storage conditions in section Possibility of hazardous reactions: None known 10.4 Conditions to avoid: Heat, flame and other ignition sources 10.5 Incompatible materials: Strong oxidising agents 10.6 Hazardous Carbon dioxide, carbon monoxide decomposition products: 11. TOXICOLOGICAL INFORMATION 11.1 Information on toxicological effects Mixture Irritation: Corrosivity: Sensitisation: Repeated dose toxicity: Carcinogenicity: Mutagenicity: Toxicity for reproduction: Information on likely routes of exposure Inhalation: Skin contact: Eye contact: Ingestion Symptoms related to the physical, chemical and toxicological characteristics: Mixture versus substance information: Other information:. None 4

5 12. ECOLOGICAL INFORMATION 12.1 Toxicity Substances Substances classified as category 1 acute toxicity: Fish toxicity: Algae toxicity: Mixtures No aquatic toxicity data available for the mixture Persistence and degradability: Bioaccumulative potential: Mobility in soil: Results of PBT and vpvb: Other adverse effects: 13. DISPOSAL CONSIDERATION 13.1 Waste Treatment Methods Dispose of in accordance with local authority guidelines. 14. TRANSPORT INFORMATION IATA/ICAO ADR 5

6 ADN RID IMDG 15. REGULATORY INFORMATION 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture This Safety Data Sheet was prepared in accordance with 1272/2008 (CLP) 15.2 Chemical safety assessment A chemical safety assessment has not been carried out 6

7 16. Other Information Full text of relevant R-phrases and/or H-statements: H225 Highly flammable liquid and vapour H302+H312+H332 Harmful if swallowed, in contact with skin and if inhaled H315 Causes skin irritation H318: Causes serious eye damage H412: Harmful to aquatic life Supplemental Hazard information (EU): Disclaimer: This safety data sheet contains important information to ensure the safe storage, handling and use of this product, it does not however constitute an assessment of workplace risks. Users are advised to refer to relevant legislation, approved codes of practice and guidance available from the Health & Safety Executive (website: ). Further information: The above information is based on our current knowledge of the product. The purpose of this data sheet is to describe the product in terms of its safety and environmental requirements. It is the user s responsibility to satisfy themselves as to the application of this information and/or recommendations for their own use. 7