Monocomponent industrial coating - Industrial use. Carboline Company 2150 Schuetz Road St. Louis, MO USA 63146

Transcription

1 Safety Data Sheet prepared to UN GHS Revision 3 1. Identification of the Substance/Mixture and the Company/Undertaking 1.1 Product Identifier 0025S5NL Product Name: BITUMASTIC Relevant identified uses of the substance or mixture and uses advised against Monocomponent industrial coating - Industrial use. Revision Date: 07/13/2015 Supercedes Date: 06/11/ Details of the supplier of the safety data sheet Manufacturer: Carboline Company 2150 Schuetz Road St. Louis, MO USA Regulatory / Technical Information: Contact Carboline Technical Services at Datasheet Produced by: Emergency telephone number: Schlereth, Ken - ehs@stoncor.com CHEMTREC (Inside US) CHEMTREC (Outside US) HEALTH - Pittsburgh Poison Control Hazard Identification 2.1 Classification of the substance or mixture Acute Toxicity, Inhalation, category 4 Carcinogenicity, category 1A Flammable Liquid, category 3 Germ Cell Mutagenicity, category 1A Reproductive Toxicity, category 1A STOT, repeated exposure, category 1 STOT, single exposure, category 3, RTI Skin Irritation, category 2 Page 1 / 9

2 2.2 Label elements Symbol(s) of Product Signal Word Danger Named Chemicals on Label ORTHO-XYLENE, ETHYL BENZENE, PARA-XYLENE, META-XYLENE, COAL TAR PITCH GHS HAZARD STATEMENTS Flammable Liquid, category 3 Skin Irritation, category 2 Acute Toxicity, Inhalation, category 4 STOT, single exposure, category 3, RTI Germ Cell Mutagenicity, category 1A Carcinogenicity, category 1A Reproductive Toxicity, category 1A STOT, repeated exposure, category 1 GHS PRECAUTION PHRASES H226 H315 H332 H335 H340-1A H350-1A H360-1A H372 Flammable liquid and vapour. Causes skin irritation. Harmful if inhaled. May cause respiratory irritation. May cause genetic defects. May cause cancer. May damage fertility or the unborn child. Causes damage to organs through prolonged or repeated exposure. 2.3 Other hazards Not applicable P201 Obtain special instructions before use. P202 Do not handle until all safety precautions have been read and understood. P210 Keep away from heat/sparks/open flames/hot surfaces. No smoking. P260 Do not breathe dust/fume/gas/mist/vapours/spray. P264 Wash hands thoroughly after handling. P280 Wear protective gloves/protective clothing/eye protection/ face protection. P284 Wear respiratory protection. P IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P IF exposed or concerned: Get medical advice/attention P308+P313 IF exposed or concerned: Get medical advice/attention P314 Get medical advice/attention if you feel unwell. P If skin irritation occurs: Get medical advice/attention. P Store in a well-ventilated place. Keep container tightly closed. Results of PBT and vpvb assessment: 3. Composition/Information On Ingredients 3.2 Mixtures Hazardous Ingredients % COAL TAR PITCH Page 2 / 9

3 TALC META-XYLENE PARA-XYLENE ETHYL BENZENE ORTHO-XYLENE SURFACTANT GHS Symbols GHS Hazard Statements M-Factors GHS07-GHS08 H GHS02-GHS07 H GHS02-GHS07-GHS08 H GHS02-GHS07 H GHS02-GHS07 H Additional Information: The text for GHS Hazard Statements shown above (if any) is given in Section First-aid Measures 4.1 Description of First Aid Measures AFTER INHALATION: Give oxygen or artificial respiration if needed. Remove person to fresh air. If signs/symptoms continue, get medical attention. AFTER SKIN CONTACT: In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. If skin irritation persists, call a physician. AFTER EYE CONTACT: Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician. AFTER INGESTION: Do NOT induce vomiting. Never give anything by mouth to an unconscious person. If swallowed, call a poison control centre or doctor immediately. 4.2 Most important symptoms and effects, both acute and delayed Harmful if swallowed. Irritating to eyes and skin. Risk of serious damage to the lungs (by aspiration). Vapours may cause drowsiness and dizziness. 4.3 Indication of any immediate medical attention and special treatment needed No information available on clinical testing and medical monitoring. Specific toxicological information on substances, if available, can be found in section Fire-fighting Measures 5.1 Extinguishing Media: Carbon Dioxide, Dry Chemical, Foam, Water Fog UNUSUAL FIRE AND EXPLOSION HAZARDS: Flammable liquid. Vapours are heavier than air and may spread along floors. Vapours may form explosive mixtures with air. Vapors may travel to areas away from work site before igniting/flashing back to vapor source. Provide adequate ventilation. Prevent the creation of flammable or explosive concentrations of vapour in air and avoid vapour concentration higher than the occupational exposure limits. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Electrical installations / working materials must comply with the technological safety standards. Wear shoes with conductive soles. 5.2 Special hazards arising from the substance or mixture No Information 5.3 Advice for firefighters In the event of fire, wear self-contained breathing apparatus. Cool containers / tanks with water spray. Flammable. 6. Accidental Release Measures 6.1 Personal precautions, protective equipment and emergency procedures For personal protection see section 8. Ensure adequate ventilation. Ensure adequate ventilation. Evacuate personnel to safe areas. Evacuate personnel to safe areas. Remove all sources of ignition. Remove all sources of ignition. To avoid ignition of Page 3 / 9

4 vapours by static electricity discharge, all metal parts of the equipment must be grounded. Wear personal protective equipment. 6.2 Environmental precautions Do not allow material to contaminate ground water system. Prevent product from entering drains. 6.3 Methods and material for containment and cleaning up 6.4 Contain spillage, soak up with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and transfer to a container for disposal according to local / national regulations (see section 13). Contain spillage, soak up with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and transfer to a container for disposal according to local / national regulations (see section 13). Reference to other sections Please refer to disposal requirements or country specific disposal requirements for this material. See Section 13 for further information. 7. Handling and Storage 7.1 Precautions for safe handling INSTRUCTIONS FOR SAFE HANDLING : Keep containers dry and tightly closed to avoid moisture absorption and contamination. Prepare the working solution as given on the label(s) and/or the user instructions. Do not breathe vapours or spray mist. Ensure all equipment is electrically grounded before beginning transfer operations. Do not use sparking tools. Wash thoroughly after handling. Do not get in eyes, on skin, or on clothing. Use only with adequate ventilation/personal protection. PROTECTION AND HYGIENE MEASURES : Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday. When using, do not eat, drink or smoke. 7.2 Conditions for safe storage, including any incompatibilities CONDITIONS TO AVOID: Heat, flames and sparks. STORAGE CONDITIONS: Keep container closed when not in use. Store in a dry, well ventilated place away from sources of heat, ignition and direct sunlight. 7.3 Specific end use(s) No specific advice for end use available. 8. Exposure Controls/Personal Protection 8.1 Control parameters Ingredients with Occupational Exposure Limits (US) Name % ACGIH TLV- ACGIH TLV- OSHA PEL- OSHA PEL- TWA STEL TWA CEILING COAL TAR PITCH MG/M3 N/E 0.2 MG/M3 N/E TALC N/E N/E N/E N/E META-XYLENE PPM 150 PPM 435 MG/M3 N/E PARA-XYLENE PPM 150 PPM 435 MGM3 N/E ETHYL BENZENE PPM N/E 435 MGM3 N/E ORTHO-XYLENE PPM 150 PPM 435 MG/M3 N/E SURFACTANT N/E N/E N/E N/E FURTHER INFORMATION: Refer to the regulatory exposure limits for the workforce enforced in each country. OEL Note 8.2 Exposure controls Personal Protection RESPIRATORY PROTECTION: In order to avoid inhalation of spray-mist and sanding dust, all spraying and sanding must Page 4 / 9

5 be done wearing adequate respirator. Use only with ventilation to keep levels below exposure guidelines reported in this document. User should test and monitor exposure levels to ensure all personnel are below guidelines. If not sure, or not able to monitor, use State or federally approved supplied air respirator. For silica containing coatings in a liquid state, and/or if no exposure limits are established above, air-supplied respirators are generally not required. EYE PROTECTION: Safety glasses with side-shields. HAND PROTECTION: Gloves should be discarded and replaced if there is any indication of degradation or chemical breakthrough. Impervious glovesrequest information on glove permeation properties from the glove supplier. OTHER PROTECTIVE EQUIPMENT: Ensure that eyewash stations and safety showers are close to the workstation location. Lightweight protective clothing ENGINEERING CONTROLS: Avoid contact with skin, eyes and clothing. Ensure adequate ventilation, especially in confined areas. 9. Physical and Chemical Properties 9.1 Information on basic physical and chemical properties Appearance: Physical State Odor Odor threshold ph Viscous, Black Liquid Liquid Tar Odor Melting point / freezing point ( C) Boiling point/range ( C) 176 F (80 C) F (138 C) Flash Point, ( C) 27 Evaporation rate Flammability (solid, gas) Upper/lower flammability or explosive limits Vapour Pressure, mmhg Vapour density Relative density Solubility in / Miscibility with water Partition coefficient: n-octanol/water Auto-ignition temperature ( C) Decomposition temperature ( C) Viscosity Explosive properties Oxidising properties Slower Than Ether Heavier than Air 9.2 Other information VOC Content g/l: 276 Specific Gravity (g/cm3) 1.33 Page 5 / 9

6 10. Stability and Reactivity 10.1 Reactivity No reactivity hazards known under normal storage and use conditions Chemical stability Stable under normal conditions Possibility of hazardous reactions Hazardous polymerisation does not occur Conditions to avoid Heat, flames and sparks Incompatible materials Strong oxidizing agents Hazardous decomposition products Carbon dioxide (CO2), carbon monoxide (CO), oxides of nitrogen (NOx), dense black smoke. 11. Toxicological Information 11.1 Information on toxicological effects Acute Toxicity: Oral LD50: Inhalation LC50: Irritation: Corrosivity: Sensitization: Repeated dose toxicity: Carcinogenicity: Mutagenicity: Toxicity for reproduction: If no information is available above under Acute Toxicity then the acute effects of this product have not been tested. Data on individual components are tabulated below: Oral LD50 Dermal LD50 Vapor LC COAL TAR PITCH 4300 mg/kg, oral, rat 5000 ppm/4 hr, inh, rat TALC Not Available Not Available META-XYLENE Not Available Not Available PARA-XYLENE Not Available Not Available ETHYL BENZENE 3500 mg/kg rat, oral >5000 mg/l, dermal rabbit 17.2 mg/l Inh, Rat, 4Hr ORTHO-XYLENE Not Available Not Available Page 6 / 9

7 SURFACTANT Not Available Not Available Additional Information: Harmful if swallowed. Irritating to eyes and skin. Risk of serious damage to the lungs (by aspiration). Vapours may cause drowsiness and dizziness. 12. Ecological Information 12.1 Toxicity: EC50 48hr (Daphnia): IC50 72hr (Algae): LC50 96hr (fish): 12.2 Persistence and degradability: 12.3 Bioaccumulative potential: 12.4 Mobility in soil: 12.5 Results of PBT and vpvb assessment: 12.6 Other adverse effects: EC50 48hr IC50 72hr LC50 96hr COAL TAR PITCH No information No information No information TALC No information No information No information META-XYLENE No information No information No information PARA-XYLENE No information No information No information ETHYL BENZENE No information No information No information ORTHO-XYLENE No information No information No information SURFACTANT No information No information No information 13. Disposal Considerations 13.1 WASTE TREATMENT METHODS: Do not burn, or use a cutting torch on, the empty drum. If recycling is not practicable, dispose of in compliance with local regulations. Dispose of in accordance with local regulations. Empty containers should be taken to an approved waste handling site for recycling or disposal. Page 7 / 9

8 14. Transport Information 14.1 UN number UN 1263 UN proper shipping name 14.2 Paint Technical name Transport hazard class(es) Subsidiary shipping hazard Packing group 14.4 III 14.5 Marine Pollutant: Yes Environmental hazards 14.6 Special precautions for user EmS-No.: N/A N/A F-E, S-E 14.7 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC code 15. Regulatory Information 15.1 Safety, health and environmental regulations/legislation for the substance or mixture: U.S. Federal Regulations: As follows - CERCLA - Sara Hazard Category This product has been reviewed according to the EPA Hazard Categories promulgated under Sections 311 and 312 of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to meet the following categories: Fire Hazard, Acute Health Hazard, Chronic Health Hazard Sara Section 313: This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372: META-XYLENE PARA-XYLENE ETHYL BENZENE ORTHO-XYLENE Toxic Substances Control Act: All components of this product are either listed on the TSCA Inventory or are exempt. This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from the United States: No TSCA 12(b) components exist in this product. U.S. State Regulations: As follows - New Jersey Right-to-Know: The following materials are non-hazardous, but are among the top five components in this product. FULLERS EARTH Pennsylvania Right-To-Know The following non-hazardous ingredients are present in the product at greater than 3%. Page 8 / 9

9 FULLERS EARTH California Proposition 65: Warning: The following ingredients present in the product are known to the state of California to cause Cancer: ETHYL BENZENE BENZENE Warning: The following ingredients present in the product are known to the state of California to cause birth defects, or other reproductive hazards. TOLUENE BENZENE International Regulations: As follows - * Canadian DSL: No Information 15.2 Chemical Safety Assessment: No Chemical Safety Assessment has been carried out for this substance/mixture by the supplier. 16. Other Information Text for GHS Hazard Statements shown in Section 3 describing each ingredient: H225 Highly flammable liquid and vapour. H226 Flammable liquid and vapour. H312 Harmful in contact with skin. H315 Causes skin irritation. H332 Harmful if inhaled. H335 May cause respiratory irritation. H340 May cause genetic defects. H350 May cause cancer. H360 May damage fertility or the unborn child. H371 May cause damage to organs. H372 Causes damage to organs through prolonged or repeated exposure. Reasons for revision No Information No Information Page 9 / 9