1. IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING

Transcription

1 Flavonin Food LC2 CLEAN NATURE SOLUTIONS GmbH 1. IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING Product Information Trade name: Use: Producer/Supplier: Flavonin Food LC2 Food additive acidity regulator Flavonin Food LC2 is a unique, non-toxic, natural acidity regulator based on lactic acid and other food grade components which delay the degradation of the lactic acid. It conforms to EC Directive 1333/2008 and 834/2007 for use in organic produce. Clean Nature Solutions GmbH Mariahilfer Straße 34/5 A-1070 Wien Österreich office@cns-world.com Emergency number: Clean Nature Solutions GmbH: POISON CENTER Austria: HAZARDS IDENTIFICATION Classification of the mixture according to Regulation (EG) Nr.1272/2008 GHS 05 Corrosion GHS 07 Eye Dam. 1 H318 Causes serious eye damage. Skin Irrit. 2 H315 Causes skin irritation. Labelling according to Regulation (EG) Nr. 1272/2008 The Product is classified and labelled according to the CLP regulation. Hazard pictograms: GHS05 Signal word: Danger Hazard-determining components of labelling: Lactic acid 80% Hazard statements: H315 Causes skin irritation. H318 Causes serious eye damage. Precautionary statements: P280 Wear protective gloves/clothing/eye protection/ face protection. P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310 Immediately call a POISON CENTER or doctor/physician. P321 Specific treatment (see on the label). P362 Take off contaminated clothing and wash before reuse. P If skin irritation occurs: Get medical advice/attention. Other hazards: Results of PBT and vpvb assessment: PBT and vpvb not applicable. Seite 1 von 6

2 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical characterization: Mixtures Description: Mixture of substances listed below with nonhazardous additions. Dangerous components: CAS: L-(+) -lactic acid % EINECS: Eye Da. 1, H318; Skin Irrit. 2, H315 Additional information: For the wording of the listed risk phrases refer to section FIRST AID MEASURES Description of first aid measures: After inhalation: In case of unconsciousness place patient stably in side position for transportation. After skin contact: Immediately wash with water and soap and rinse thoroughly. After eye contact: Rinse opened eye for several minutes under running water. Then consult a doctor. After swallowing: If symptoms persist consult doctor. Most important symptoms and effects, both acute and delayed: Indication of any immediate medical attention and special treatment needed: No further relevant information available. 5. FIREFIGHTING MEASURES Suitable extinguishing agents: Special hazards arising from the mixture: Protective equipment: CO2, powder or water spray. Fight larger fires with water spray or alcohol resistant foam. No special measures required. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures: Not required. Environmental precautions: Dilute with plenty of water. Do not allow to enter sewers/ surface or ground water. Methods and material for containment and cleaning up: Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Ensure adequate ventilation. Reference to other sections: See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information. 7. HANDLING AND STORAGE Handling: Seite 2 von 6

3 Precautions for safe handling: Protection against explosions and fires: Conditions for safe storage, including any incompatibilities Storage: Requirements to be met by storerooms and containers: Storage in one common storage facility: Further information about storage conditions: Specific end use(s): 8. EXPOSURE CONTROLS/ PERSONAL PROTECTION CLEAN NATURE SOLUTIONS GmbH Keep receptacles tightly sealed. Ensure good ventilation/ exhaustion at the workplace. Prevent formation of aerosols. No special measures required. No special requirements. Allowed. None. No further information available. Additional information about design of technical systems: No further data; see item 7. Control parameters Components with critical values that require monitoring at the workplace: The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace. Additional information: The lists valid during the making were used as basis. Exposure controls Personal protective equipment: General protective and hygienic measures: Keep away from foodstuffs, beverages and feed. Immediately remove all soiled and contaminated clothing. Wash hands before breaks and at the end of work. Avoid contact with the eyes and skin. Breathing equipment: In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure use self-contained respiratory protective device. Protection of hands: Protective gloves. The glove material has to be impermeable and resistant to the product/ the substance/ the preparation. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation. Material of gloves The selection of the suitable gloves does not only depend on the material, but also on the further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the application. Penetration time of glove material: The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed. For the permanent contact gloves made of the following materials are suitable: Nitrile rubber, NBR Natural rubber, NR Protection of eyes: Tightly sealed goggles 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties General Information Appearance: Form: Colour: Odor: Odor threshold: Fluid Brown Characteristic Seite 3 von 6

4 ph-value: Change in physical state: Melting point/ melting range: Undetermined. Boiling point/ boiling range: Undetermined. Fashpoint: > 65 C Inflammability (solid, gaseous): Not applicable. Ignition temperature: Decomposition temperature: Autoflammability: Product is not selfignating. Danger of explosion: Product does not present an explosion hazard. Explosion limits: Density at 20 C: g/cm 3 Relative density: Vapour density: Evapouration rate: Solubility in/ Miscibility with water: Fully miscible. Distribution coefficient (n-octanol/water): Viscosity: dynamic: kinematic: Other information: 10. STABILITY AND REACTIVITY Reactivity Chemical Stability: Thermal decomposition/ conditions to be avoided: No decomposition if used according to specifications. Possibility of hazardous reactions: No dangerous reactions known. Conditions to avoid: Incompatible materials: Hazardous decomposition products: No dangerous decomposition products known. 11. TOXICOLOGICAL INFORMATION Information on toxicological effects Acute toxicity: Relevant LD /LC50-Values for classification: l-(+)-lactic acid Oral LD mg/kg (rat) Primary irritant effects: On the skin: Irritant to skin and mucous membranes. On the eye: Strong irritant with the danger of severe eye injury. Sensitization: No sensitizing effects known. Additional toxicological effects: The product shows the following dangers according to the calculation method of the General EU Classification Guidelines for Preparations as issued in the latest version: Irritant 12. ECOLOGICAL INFORMATION Toxicity Seite 4 von 6

5 Aquatic toxicity: Persistence and degradibility: Behaviour in environmental compartments: Bioaccumulative potential: Mobility in soil: Further ecological advices: General advices: Water hazard class 1 (German Regulation) (Self-assessment): Slightly hazardous for water Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system. Results of PB- and vpvb assessment: Not applicable Other adverse effects: 13. DISPOSAL CONSIDERATIONS Waste treatment methods Recommendation: Uncleaned packagings: Recommendation: Recommended detergent: Must not be disposed together with household garbage. Do not allow product to reach sewage system. Disposal must be made according to official regulations. Water, if necessary together with cleansing agents. 14. TRANSPORT INFORMATION Transport hazard classes: ADR: ADN: IMDG: IATA: Environmental hazards: No Special precautions for user: Not applicable. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code: Not applicable. Transport/ additional information: Not dangerous according to the above specifications. UN Model Regulation : REGULATORY INFORMATION Safety; health and environmental regulations/ legislation specific for the substance or mixture Labelling according to Regulation (EG) Nr. 1272/2008 The product is classified and labelled according to the CLP regulation. Hazard pictograms: GHS05 Signal word: Danger Hazard-determining components of labelling: l-(+)-lactic acid Hazard statements: H315 Causes skin irritation. H318 Causes serious eye damage. Seite 5 von 6

6 Precautionary statements: P280 Wear protective gloves/ protective clothing/ eye protection/ face protection. P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310 Immediately call a POISON CENTER or doctor/physician. P321 Specific treatment (see on the label). P362 Take off contaminated clothing and wash before reuse. P If skin irritation occurs: Get medical advice/attention. National regulations: Chemikaliengesetz 1996 und Chemikalien VO, ASchG und Durchführungs VO Water hazard class 1 (Self-assessment): Slightly hazardous for water Chemical safety assessment: A Chemical Safety Assessment has not been carried out. 16. OTHER INFORMATION This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Relevant phrases: H315 Causes skin irritation. H318 Causes serious eye damage. H319 Causes serious eye irritation. R36 Irritating to eyes. R36/37 Irritating to eyes and respiratory system. R38 Irritating to skin. R41 Risk of serious damage to eyes. Recommended restriction of use: Only for industrial purposes suitable! Further information: The information provided in this Safety Data Sheet is correct to our knowledge at the date of its revision. The information given only describes the products with regard to safety arrangements and is not to be considered as a warranty or quality specification and does not constitute a legal relationship. The information contained in this Safety Data Sheet relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text This safety datasheet only contains information relating to safety and does not replace any product information or product specification. The attention of the user is drawn to the possible risks that incur by using the product for any other purpose than that for which it was intended. State of information: See revision date of MSDS. END OF MSDS Seite 6 von 6