LHB INDUSTRIES Material Safety Data Sheet

Size: px

Start display at page:

Download "LHB INDUSTRIES Material Safety Data Sheet"

Gavin Gregory
5 years ago
Views:

1 Section 1 Chemical Product And Company Identification Manufacturer: LHB Industries Emergency Telephone Number (800) (Chemtrec) Trenton Ave. Information Telephone Number (314) St. Louis, Mo Date of Preparation April 15, 2010 Product ID: Calamine Lotion USP LHB Part Number: Section 2 Composition / Information On Ingredients There are no components that are considered a health hazardous. Section 3 Hazards Identification EMERGENCY OVERVIEW: Keep out of reach of children. Symptoms of Exposure: Inhalation: May cause irritation of the respiratory tract. Ingestion: May cause nausea, vomiting and diarrhea. Eyes: May cause irritation to the eyes. Skin: None expected. This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. This material does not contain any components considered hazardous by the OSHA Hazard Communication Standard (29 CFR ). Section 4 First Aid Measures Emergency first aid procedures by route of exposure: Inhalation: If symptoms are experience, remove source of contamination or move victim to fresh air. If affected person is not breathing, apply artificial respiration. If breathing is difficult, give oxygen. Get medical attention. Ingestion: Do not induce vomiting. If material is swallowed, get medical attention or advice. Skin: If irritation occurs, wash with soap and water. If irritation persists, get medical attention. Eyes: Immediately flush eyes with water for at least 15 minutes while holding eyelids open. If symptoms persist, get medical attention. Section 5 Fire Fighting Measures Flash Point: Not available Auto Ignition: Not available Extinguishing Media: Use methods appropriate for the surrounding fire. Consider water spray or fog, carbon dioxide, dry chemical powder, or alcohol resistant foam. Products of Combustion: Upon combustion this product may emit carbon dioxide, carbon monoxide and/or low molecular weight hydrocarbons. Fire Fighting Equipment and Procedures: Wear protective clothing and equipment suitable for the surrounding fire, including helmet, facemask, and self contained breathing apparatus. Section 6 Accidental Release Measures Personal Precautions: Read entire label before using and follow all label directions. Environmental Precautions: Prevent discharge to open waters. Method of Containment: Absorb spilled liquids in suitable inert material such as clay, vermiculite or diatomaceous earth. Method for Clean-Up: Ventilate area of spill or leak. Sweep or scrap up and containerize in approved chemical waste container. Wash spill area with water. Section 7 Handling and Storage Handling: Do not take internally. Do not consume food, drink or smoke while handling this product. Storage: Keep from freezing. Keep container tightly closed and in a cool, well ventilated place. Section 8 Exposure Controls/Personal Protection Engineering Controls: Normal room ventilation is usually adequate under normal use. Personal Protective Equipment (PPE) Eye/Face Protection: None needed under normal use. Skin Protection: None needed under normal use. Respiratory Protection: None needed under normal use. General Hygiene Considerations: Wash hands after use. Page 1 of 2 Calamine Lotion USP

2 Section 9 Physical and Chemical Properties Appearance/Color: Pink Liquid Odor: None ph: 9.5 Solubility in Water: Soluble Section 10 Stability and Reactivity Chemical Stability: Stable under normal ambient temperatures (70 F) Hazardous Polymerization: Will not occur Conditions to Avoid: Freezing and extreme heat Hazardous Decomposition Products: upon decomposition, this product evolves carbon monoxide, carbon dioxide, and/or weight hydrocarbons. Section 11 Toxicological Information Section 16 Other Information Revision Number: 01 Additional Information: This MSDS meets the requirements of 29 CFR IMPORTANT NOTE: This information is furnished without warranty, expressed or implied, as to accuracy or completeness. The information is obtained from various sources including the manufacturer and other third party sources. The information may not be valid under all conditions nor if this material is used in combination with other materials or any process. Final determination of suitability of any material is the sole responsibility of the user. Prepared by: Mark Epstein, R&D Manager *** END OF MSDS*** Acute Effects: Not expected to cause irritation when used according to label instructions. Chronic Effects: Component Ethyl Alcohol ( ) Carcinogenicity: Not classified as a human carcinogen. Section 12 Ecological Information Ecotoxicity: No information is available for this product. Section 13 Disposal Considerations Dispose of in accordance with Federal, State, and Local regulations. Section 14 Transport Information U.S. DOT 49 CFR Hazardous Material Table Not regulated IATA: List of Dangerous Goods Not regulated Section 15 Regulatory Information No information is available for this product. Page 2 of 2 Calamine Lotion USP

3 Industries Material Safety Data Sheet Section 1 Chemical Product And Company Identification Manufacturer: LHB Industries Emergency Telephone Number (800) (Chemtrec) Trenton Ave. Information Telephone Number (314) St. Louis, Mo Date of Preparation August 2, 2005 Product ID: 10% Povidone-Iodine U.S.P. LHB Part Number: A, B CAGE Code: 1A864 Section 2 Composition / Information On Ingredients Wt% ACGIH Ingredient OSHA PEL (Max) TLV Povidone Iodine 10.0 NE NE Section 3 Hazards Identification Health Hazards (Acute and Chronic) Ingestions: Fatal in large quantities. Rat LD ml/kg increase in serum iodine levels. Eye Contact: May cause irritation. Skin: severe hypernatremia and acidosis have been noted along with increased serum iodine levels Signs and Symptoms of Exposure NA Section 4 First Aid Measures Ingestion: Get medical attention immediately. Eye Contact: Flush thoroughly with water for 15 minutes. If irritation persists, contact doctor. Skin: Flush skin with soapy water. If symptoms persist or recur, seek medical attention. Section 5 Fire Fighting Measures Flash Point: None Explosive Limits: LEL: N/A UEL: N/A Extinguishing Media: Will not burn. Special Protective Procedures: None. NFPA Rating: HEALTH 1, FLAMMABILITY 0, REACTIVITY 0 HMIS Classification: HEALTH 1, FLAMMABILITY 0, REACTIVITY 0 Section 6 Accidental Release Measures Personal Precautionary Measures Read entire label before using and follow all label directions. Waste Disposal Method: Do not wash large spills into sewers without prior local regulatory consent. Spills may be absorbed and then disposed in accordance with local, state, and federal regulations. Section 7 Handling and Storage Handling: Keep out of reach of children. Do not take internally. Do not consume food, drink or smoke while handling this product. Storage: Keep from freezing. Section 8 Exposure Controls/Personal Protection Engineering Controls: None required for normal use. Respiratory Protection: None required for normal use. Gloves: None required for normal use. Protective glove should be worn for prolonged direct contact. Skin Protection: None required for normal use. Other Personal Protection Data: Good hygienic work practice. Section 9 Physical and Chemical Properties Physical State: Liquid Color: Reddish Brown Odor: Iodine Specific Gravity: Density: 8.55 lb/gal Vapor Pressure: NE Evaporation Rate: >1 (Butyl Acetate = 1) Solubility in Water: Soluble Section 10 Stability and Reactivity Chemical Stability: Stable Hazardous Polymerization: Will not occur Conditions to Avoid: Freezing and extreme heat Material to Avoid: None Hazardous Decomposition Products: None known Section 11 Toxicological Information No data available. Section 12 Ecological Information No data available. MSDS Part No Page 1 of 2 Povodine Iodine 10%

4 Industries Material Safety Data Sheet Section 13 Disposal Considerations Disposal of Waste Method: Dispose of in accordance with Federal, State, and Local regulations regarding pollution. Section 14 Transport Information U.S. DOT 49 CFR Hazardous Material Table Not regulated Section 15 Regulatory Information All components are listed on the TSCA Inventory. No components are subject to California Proposition 65 labeling. Section 16 Other Information Revision : 02 Additional Information: This MSDS has been prepared in accordance with FED-STD-313D and meets the requirements of 29 CFR Important Note: This information is furnished without warranty, expressed or implied, as to accuracy or completeness. The information is obtained from various sources including the manufacturer and other third party sources. The information may not be valid under all conditions nor if this material is used in combination with other materials or any process. Final determination of suitability of any material is the sole responsibility of the user. Prepared by: Mark Epstein, R&D Manager *** END OF MSDS*** MSDS Part No Page 2 of 2 Povodine Iodine 10%

5 Section 1 Chemical Product And Company Identification Manufacturer: LHB Industries Emergency Telephone Number (800) (Chemtrec) Trenton Ave. Information Telephone Number (314) St. Louis, Mo Date of Preparation April 15, 2010 Product ID: Tincture Green Soap LHB Part Number: Section 2 Composition / Information On Ingredients Ingredients CAS# OSHA Pel ACGIH TLV v/v % ethanol ppm (TWA) 1000 ppm (TWA) 30 glycerin mg/m 3 (TWA) 10 mg/m 3 (TLV) 3.3 Section 3 Hazards Identification EMERGENCY OVERVIEW: Keep out of Reach of Children. NFPA RATING: HEALTH 1, FLAMMABILITY 3, REACTIVITY 0 HMIS CLASSIFICATION: HEALTH 1, FLAMMABILITY 3, REACTIVITY 0 Potential Health Effects: The toxicity of this product has not been completely examined. It is presumed that the toxicity of this item is similar to other aliphatic alcohols. Inhalation: Alcohols are absorbed through the mucous membranes and produce irritation as well as the same effects as ingestion. Ingestion: Ingestion will produce CNS disturbance, dizziness, photophobia, headache, stupor, come and death. Skin Contact: Alcohols are absorbed through the skin. Repeated contact causes defatting of the skin with resultant irritation and flaking. Eye Contact: May be irritating. Chronic Exposure: Unknown Aggravation of Preexisting Conditions: Impaired kidney and liver function may be aggravated by exposure to alcohols. Preexisting eye, skin, and respiratory conditions may also be aggravated. Section 4 First Aid Measures Inhalation: If symptoms are experience, remove source of contamination or move victim to fresh air. If affected person is not breathing, apply artificial respiration. If breathing is difficult, give oxygen. Get medical attention. Ingestion: Do not induce vomiting if patient is unconscious or extremely drowsy. Otherwise administer 2 glasses of water and induce vomiting. Get immediate medical attention even if symptoms improve. Skin: In case of skin contact, remove contaminated clothing and flush with water. Wash affected area with soap and water. Get medical advice if irritation develops. Eyes: Immediately flush eyes with water for at least 15 minutes while holding eyelids open. If symptoms persist, get medical attention. Section 5 Fire Fighting Measures Flash Point: 28 C (82 F) TCC Flammability Limits(for ethanol): LEL: 3% UEL: 19% Extinguishing Media: Alcohol type foam, carbon dioxide or dry chemical. Water is ineffective against alcohol fires but may be used to cool adjacent containers. Products of Combustion: Upon combustion this product may emit carbon dioxide and carbon monoxide. Fire Fighting Equipment and Procedures: Wear protective clothing and equipment including helmet, facemask, and self contained breathing apparatus. Section 6 Accidental Release Measures Personal Precautions: Read entire label before using and follow all label directions. Environmental Precautions: Prevent discharge to open waters. Method of Containment: Absorb spilled liquids in suitable inert material such as clay, vermiculite or diatomaceous earth. Method for Clean-Up: Remove all sources of ignition. Ventilate area of spill or leak. Sweep or scrap up and containerize in approved chemical waste container. Wash spill area with water. Section 7 Handling and Storage Handling: Do not take internally. Do not consume food, drink or smoke while handling this product. Storage: Keep container tightly closed and in a cool, well ventilated place. ] Page 1 of 2 Tincture Green Soap

6 Section 8 Exposure Controls/Personal Protection Airborne Exposure Limits: See Section 2 Ventilation System: Usually not required. When required, refer to the ACGIH document, Industrial Ventilation a Manual for Recommended Practices for detail about ventilation. Personal Respirator: Usually not required. In case of emergency, or when exposure levels are unknown, use a positive pressure, full face piece, air supplied respirator. Skin Protection: Protective gloves are not required for normal use. Eye Protection: Laboratory safety goggles or similar products are not required for normal use. Section 9 Physical and Chemical Properties Appearance/Color: Clear brown solution Odor: Lavender Boiling Point: 84 C (183 F) Density: 0.97 g/ml Solubility in Water: Soluble Section 10 Stability and Reactivity Chemical Stability: Freezes at low temperatures Hazardous Polymerization: Will not occur Conditions to Avoid: Freezing, heat, flame and sources of ignition Incompatibilities: Oxidizers Hazardous Decomposition Products: Nothing unusual Section 11 Toxicological Information Section 14 Transport Information U.S. DOT 49 CFR Hazardous Material Table Bottles smaller than 23 fl. oz. are eligible to be shipped under ORM-D or limited quantity exemptions. Section 15 Regulatory Information SARA 302: SARA 313: SARA 313/312: No No Acute: Yes Chronic: Yes Section 16 Other Information Revision Number: 01 Additional Information: This MSDS meets the requirements of 29 CFR IMPORTANT NOTE: This information is furnished without warranty, expressed or implied, as to accuracy or completeness. The information is obtained from various sources including the manufacturer and other third party sources. The information may not be valid under all conditions nor if this material is used in combination with other materials or any process. Final determination of suitability of any material is the sole responsibility of the user. Prepared by: Mark Epstein, R&D Manager *** END OF MSDS*** Chronic consumption of ethanol is believed to be linked to liver disease, cancer and birth defects. This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. Section 12 Ecological Information Environmental Fate: Biodegradable Environmental Toxicity: None expected Section 13 Disposal Considerations Dispose of in accordance with Federal, State, and Local regulations. Page 2 of 2 Tincture Green Soap

Material Safety Data Sheet

Page 1 Material Safety Data Sheet Section 1: PRODUCT AND COMPANY IDENTIFICATION Vi-Jon Incorporated Phone: 314-427-1000 8515 Page Avenue In Case of Spill Emergency Contact: Saint Louis, MO 63114 Chemtrec: