Mopar MasterShield Undercoat. Relevant identified uses of the substance or mixture and uses advised against

Transcription

1 Mopar MasterShield Undercoat Safety Data Sheet Section 1: Identification Product identifier Product Name Mopar MasterShield Undercoat Synonyms 0MS01002; 0MS01002AB; 0MS01006; 0MS01006AB; AA (*Kit Containing AA*); AB (*Kit Containing AB*); AA; AB; ; AB; ; AB Relevant identified uses of the substance or mixture and uses advised against Recommended use Solvent based undercoating, Protective coating and sound deadener Restrictions on use No information available Details of the supplier of the safety data sheet Manufacturer Mopar (FCA US LLC Service & Customer Care Division) Lawrence Ave. Center Line, MI United States Telephone (General) Mopar Emergency telephone number Manufacturer Section 2: Hazard Identification United States (US) According to: OSHA 29 CFR HCS Classification of the substance or mixture OSHA HCS 2012 H227: Combustible liquid, Category 4 H315: Skin corrosion/irritation Category 2 H319: Serious Eye Damage/Eye Irritation, Category 2 H373: Target organ toxicity, repeat exposure Category 2 Label elements OSHA HCS 2012 DANGER Page 1 of 8

2 Hazard statements H227: Combustible liquid H315: Causes skin irritation. H319: Causes serious eye irritation H373: May cause damage to organs through prolonged or repeated exposure. Precautionary statements Prevention P270: Do Not Eat, Drink or Smoke When Using This Product P210: Keep away from heat, sparks, open flames, hot surfaces and other ignition sources. No smoking. P261: Avoid breathing mist, vapours, spray. P264: Wash thoroughly after handling. P280: Wear protective gloves, protective clothing, eye protection, face protection. Response P303 +P361+P364+P352: IF ON SKIN (or hair): Take off immediately all contaminated clothing and wash it before reuse. Wash with plenty of soap and water. P305 + P351 + P338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P370+P378: In case of fire; Use water spray, carbon dioxide, dry chemical or alcohol foam to extinguish. P332+P313: If skin irritation occures: get medical attretion. P337+P313: If Eye Irritation Persists: Get Medical Advice/Attention P308+P311: If exposed or concerned: Call POISON Center/Doctor/physician. Storage/Disposal P402 + P404: Store in a dry place. Store in a closed container. P501: Dispose of contents and/or container in accordance with local/regional/national/international regulation Other hazards OSHA HCS 2012 Canada According to: WHMIS Classification of the substance or mixture WHMIS Combustible Liquids B3 Label elements WHMIS Other hazards WHMIS Combustible Liquids B3 Section 3 Composition/Information on Ingredients Substances Mixtures Composition Chemical Name Identifiers % Classifications According to LD50/LC50 Regulation/Directive Page 2 of 8 Comments

3 Petroleum Distillates Petroleum hydrocarbon CAS: EINECS: CAS: EINECS: % TO 55% 30% TO 60% WHMIS: OSHA HCS 2012: OSHA HCS 2012: Common Name: Stoddard Solvent Common Name: Asphalt Section 4: First Aid Measures Description of first aid measures Inhalation Skin Eye Ingestion Remove person to fresh air and keep comfortable for breathing. Get Medical attention if you feel unwell. Take off immediately all contaminated clothing and wash it before reuse. Wash with plenty of soap and water. If skin irritation or a rash occurs: Get medical advice/attention. Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do and continue rinsing. If eye irritation persists: Get medical attention. IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. Get Medical advice/attention if you feel unwell. Most important symptoms and effects, both acute and delayed Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling and blurred vision. Indication of any immediate medical attention and special treatment needed Notes to Physician Provide general supportive measures and treat symptomatically. Section 5: Fire Fighting Measures Extinguishing media Suitable Extinguishing Media Carbon dioxide (CO2), foam, water fog or dry chemical. Unsuitable Extinguishing Media Do not use stream/jet of water as this will spread fire. Special hazards arising from the substance or mixture Unusual Fire and Explosion Hazards Hazardous Combustion Products Advice for firefighters Vaporized material may form explosive mixture with air.. Thermal decomposition (burning) will produce oxides of carbon including carbon monoxide and may also produce irritating, corrosive and/or toxic gases, vapors and fumes. Self contained breathing apparatus and full protective gear must be worn in case of fire. Section 6 Accidental Release Measures Personal precautions, protective equipment and emergency procedures Personal Precautions Emergency Procedures Leak or spill procedures: Remove all sources of ignition. Provide adequate ventilation. Environmental precautions Avoid discharge into drains, water courses and the ground. Page 3 of 8

4 Methods and material for containment and cleaning up Containment/Clean up Measures Section 7 Handling and Storage Contain and absorb with inert material. (e.g. oil dry, sand). Dispose in accordance with all local, state and federal regulations. In the event of a large spill, contain material and recover for use if possible. Precautions for safe handling Handling Avoid prolonged or repeated skin contact and avoid breathing vapors. Conditions for safe storage, including any incompatibilities Storage Incompatible Materials or Ignition Sources Keep away from ignition sources. Keep containers tightly closed. Store in a cool, dry and well ventilated area. Avoid exposure to oxidizing agents. Section 8 Exposure Controls/Personal Protection Control parameters Petroleum Distillates ( ) Exposure Limits/Guidelines Result ACGIH NIOSH OSHA OSHA Vacated TWAs 100 ppm TWA 350 mg/m3 TWA Ceilings Not established 1800 mg/m3 Ceiling (15 min) 500 ppm TWA; 2900 mg/m3 TWA Not established 100 ppm TWA; 525 mg/m3 TWA Not established Exposure controls Engineering Use with adequate ventilation. Measures/Controls Personal Protective Equipment Respiratory Level of exposure needs to be determined. If required, use a particulate filter, a NIOSH approved air purifying respirator with organic vapor cartridge or a supplied air respirator. Eye/Face Face shield, goggles. Skin/Body Chemical protective gloves. Environmental Exposure Controls Section 9 Physical and Chemical Properties Information on Physical and Chemical Properties Material Description Physical Form Liquid Appearance/Description No data available Color Black Odor Mild Petroleum Odor. Taste No data available Odor Threshold Physical and Chemical Properties No data available General Properties Boiling Point > 350 F(> C) Melting Point/Freezing Point Not Determined Not Determined Page 4 of 8

5 Decomposition Temperature Not Determined ph Not applicable Specific Gravity/Relative Density > 16 C(60.8 F) Water=1 Water Solubility very slight Viscosity Time/shear dependent Oxidizing Properties: No data available Volatility Vapor Pressure < 3 mmhg 20 C(68 F) based on solvent Explosive Properties Vapor Density No data available > 1 Air=1 Evaporation Rate Flammability Not Determined Flash Point 142 F( C) UEL (Mineral Spirits): ~6% LEL Flammability (solid, gas) Class 4. Environmental (Mineral Spirits): ~0.8% Autoignition > 410 F(> 210 C) Octanol/Water Partition coefficient Not Determined Section 10: Stability and Reactivity Reactivity Chemical stability Stable Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous reactions: Combustion. Polymerization: Will not occur. Strong oxidizing agents: sources of ignition. Strong oxidizing agents. Hazardous decomposition products Combustion products: Oxides of carbon, nitrogen, and sulfur and potentially irritating and/or toxic fumes. Section 11 Toxicological Information Information on toxicological effects Components Petroleum Distillates (40% TO 55%) Acute Toxicity: Ingestion/Oral Rat LD50 >5 g/kg; Unreported Route Rat >5500 mg/m³ 4 Hour(s) Comments: LC50 GHS Properties Acute toxicity Classification Page 5 of 8

6 Aspiration Hazard Carcinogenicity Germ Cell Mutagenicity Skin corrosion/irritation Skin sensitization STOT RE STOT SE Toxicity for Reproduction Respiratory sensitization Serious eye damage/irritation Route(s) of entry/exposure Potential Health Effects Inhalation Acute (Immediate) Chronic (Delayed) Skin Acute (Immediate) Chronic (Delayed) Eye Acute (Immediate) Chronic (Delayed) Ingestion Acute (Immediate) Chronic (Delayed) Carcinogenic Effects Inhalation Ingestion Skin Contact Eye Contact. May cause damage to organs. Prolonged or repeated inhalation of petroleum distillates may cause damage to organs. Causes skin irritation. Causes severe eye irritation. Unlikely: Expect low ingestion hazard. Do NOT induce vomiting. None of the components of this mixture are considered to be a carcinogen by IARC, ACGIH, NTP, OR OSHA. Section 12 Ecological Information Toxicity Eco toxicity: This mixture contains components that are potentially toxic to freshwater and saltwater ecosystems. Persistence and degradability Bioaccumulative potential Mobility in Soil Other adverse effects Page 6 of 8

7 Potential Environmental Effects This material may be harmful to aquatic organisms and may cause long term adverse effects in the aquatic environment. Section 13 Disposal Considerations Waste treatment methods Product waste Hazard characteristic and regulatory waste classification can change with product use. Accordingly, it is the responsibility of the user to determine the proper handling and disposition for disposal according to local, state and federal regulations. (40 CFR 260 through 271). Packaging waste Section 14 Transport Information DOT UN number NA1993 UN proper shipping name Combustible liquid, N.O.S. (mineral spirits) Transport hazard class (es) Packing group Environmental hazards NDA III NDA TDG NDA NDA NDA NDA NDA IMO/IMDG NDA Not regulated NDA NDA NDA ADN NDA NDA NDA NDA NDA ADR/RID NDA NDA NDA NDA NDA IATA/ICAO NDA Not regulated NDA NDA NDA Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Other information For Industrial/Professional Use Only Keep out of reach of Children. DOT U.S. and Canada ground: Combustible liquid, N.O.S. (Mineral Spirits), NA 1993, PG III, No label required. Not Regulated for transport. IMO/IMDG International ocean: Not Regulated. IATA/ICAO Airfreight : Not Regulated. Section 15 Regulatory Information Safety, health and environmental regulations/legislation specific for the substance or mixture SARA Hazard Classifications SARA Title III, Section 313: No, None. SARA Title III, Section 311,312: Fire Hazard. State Right To Know Component CAS NJ PA Petroleum Distillates Yes Yes Inventory Component CAS Canada DSL EU EINECS TSCA Petroleum Distillates Yes Yes Yes Canada Page 7 of 8

8 Labor Canada WHMIS Classifications of Substances Petroleum Distillates B3, D2B Canada WHMIS Ingredient Disclosure List Petroleum Distillates % Other Information TSCA: All components are on the TSCA inventory. Section 16 Other Information Last Revision Date Preparation Date Disclaimer/Statement of Liability 13/April/ /March/2015 Page 8 of 8