Mopar MasterShield Rust Inhibitor. Relevant identified uses of the substance or mixture and uses advised against

Transcription

1 Mopar MasterShield Rust Inhibitor Safety Data Sheet Section 1: Identification Product identifier Product Name Synonyms Product Description Mopar MasterShield Rust Inhibitor 0MS01003; 0MS01003AB; 0MS01005; 0MS01005AB; AA (Kit containing AA); AB (Kit containing AB); AA; AB; ; AB; ; AB Anti rust coating Cavity wax. Relevant identified uses of the substance or mixture and uses advised against Recommended use Corrosion protective coating Restrictions on use No information available Details of the supplier of the safety data sheet Manufacturer Mopar (FCA US LLC Service & Customer Care Division) Lawrence Ave. Center Line, MI United States Telephone (General) Mopar Emergency telephone number Manufacturer Section 2: Hazard Identification United States (US) According to: OSHA 29 CFR HCS Classification of the substance or mixture H227: Combustible liquid Category 4 H315: Skin corrosion/irritation Category 2 H319 Serious eye damage/eye irritation Category 2 H373: Target organ toxicity, repeat exposure Category 2 Label elements DANGER Page 1 of 8

2 Hazard statements H227 Combustible liquid H315 Causes skin irritation H319 Causes serious eye irritation H373 May cause damage to organs through prolonged or repeated exposure. Precautionary statements Prevention P270 Do Not Eat, Drink or Smoke When Using This Product. P210 Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. P261: Avoid breathing mists, spray or vapors P264 Wash thoroughly after handling. P280 Wear protective gloves, protective clothing, eye protection, face protection. Response P303 +P361+P364+P352: IF ON SKIN (or hair): Take off immediately all contaminated clothing and wash it before reuse. Wash with plenty of soap and water. P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P370 + P378 In case of fire; Use water spray, carbon dioxide, dry chemical or alcohol foam to extinguish. P332 + P313 If Skin Irritation or Rash Occurs: Get Medical Advice/Attention. P337 + P313: If Eye Irritation Persists: Get Medical Advice/Attention. P308 + P311 IF exposed or concerned: Call a POISON CENTER or doctor Storage/Disposal P402 + P404 Store in a dry place. Store in a closed container. P501 Dispose of contents and/or container in accordance with local, regional, state, national, and international regulation P102 KEEP OUT OF REACH OF CHILDREN Other hazards Other information Canadian WHIMS: Class B Division 3 Combustible Liquid Section 3 Composition/Information on Ingredients Substances Mixtures Composition Chemical Name Identifiers % Wax CAS: % TO 25% Petroleum Distillates CAS: % TO 45% Section 4: First Aid Measures Description of first aid measures Inhalation Remove person to fresh air and keep comfortable for breathing. Get Medical attention Page 2 of 8

3 Skin Eye Ingestion if you feel unwell. Take off immediately all contaminated clothing and wash it before reuse. Wash with plenty of soap and water. If skin irritation or a rash occurs: Get medical advice/attention. Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical attention. IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. Get Medical advice/attention if you feel unwell. Most important symptoms and effects, both acute and delayed Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling and blurred vision. Indication of any immediate medical attention and special treatment needed Notes to Physician Provide general supportive measures and treat symptomatically. Other information General Advice: Take off immediately all contaminated clothing. Get Medical advice/attention if you feel unwell. Wash contaminated clothing before reuse. Section 5: Fire Fighting Measures Extinguishing media Suitable Extinguishing Media Carbon dioxide (CO2), foam, water fog or dry chemical. Unsuitable Extinguishing Media Do not use stream/jet of water as this will spread fire. Special hazards arising from the substance or mixture Unusual Fire and Explosion Hazards Hazardous Combustion Products Advice for firefighters Vaporized material may form explosive mixture with air. Thermal decomposition (burning) will produce oxides of carbon including carbon monoxide and may also produce irritating, corrosive and/or toxic gases, vapors and fumes. Self contained breathing apparatus and full protective gear must be worn in case of fire. Section 6 Accidental Release Measures Personal precautions, protective equipment and emergency procedures Personal Precautions Emergency Procedures Remove all sources of ignition. Provide adequate ventilation. Environmental precautions In the event of a large spill, contain material and recover for use if possible. Avoid discharge into drains, water courses and the ground. Methods and material for containment and cleaning up Containment/Clean up Measures Section 7 Handling and Storage Contain and absorb with inert material. (e.g. oil dry, sand). Dispose in accordance with all local, state and federal regulations. Precautions for safe handling Handling Avoid prolonged or repeated skin contact and avoid breathing vapors. Page 3 of 8

4 Conditions for safe storage, including any incompatibilities Storage Incompatible Materials or Ignition Sources Keep away from ignition sources. Keep containers tightly closed. Store in a cool, dry and well ventilated area. Avoid exposure to oxidizing agents. Section 8 Exposure Controls/Personal Protection Control parameters Exposure Limits/Guidelines Exposure controls Engineering Component: Petroleum Distillate OSHA PEL 500ppm and ACGIH TLV TWA 100ppm. Use with adequate ventilation. Measures/Controls Personal Protective Equipment Respiratory Level of exposure needs to be determined. If required, use a particulate filter, a NIOSH approved air purifying respirator with organic vapor cartridge or a supplied air respirator. Eye/Face Face shield, goggles. Skin/Body Chemical protective gloves. Environmental Exposure Controls Section 9 Physical and Chemical Properties Information on Physical and Chemical Properties Material Description Physical Form Liquid Appearance/Description Viscous Color Tan or amber. Odor Mild Solvent. Taste Particulate Type Particulate Size Aerosol Type Odor Threshold General Properties Physical and Chemical Properties Boiling Point > 177 C(> F) Melting Point/Freezing Point Decomposition Temperature Heat of Decomposition ph Not applicable Specific Gravity/Relative Density > 16 C(60.8 F) Water=1 Density Bulk Density Water Solubility Very slight Solvent Solubility Viscosity Time/shear dependant Oxidizing Properties: Volatility Vapor Pressure < 3 mmhg 20 C(68 F) Based on solvent Explosive Properties Vapor Density > 1 Air=1 Evaporation Rate VOC (Wt.) Page 4 of 8

5 VOC (Vol.) Volatiles (Wt.) Volatiles (Vol.) Flammability Flash Point 61 C(141.8 F) UEL 6 % LEL 0.8 % Autoignition > 410 F(> 210 C) Self Accelerating Decomposition Temperature (SADT) Heat of Combustion (ΔHc) Burning Time Flame Height Flame Extension Ignition Distance Flame Duration Burning Rate Test Flammability (solid, gas) Environmental Half Life Octanol/Water Partition coefficient Coefficient of water/oil distribution Bioaccumulation Factor Bioconcentration Factor Biochemical Oxygen Demand BOD/BOD5 Chemical Oxygen Demand Persistence Degradation Other Information Combustibility: class 4. Section 10: Stability and Reactivity Reactivity Chemical stability. Stable Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous reactions: Combustion. Polymerization: Will not occur. Strong oxidizing agents: sources of ignition. Strong oxidizing agents. Hazardous decomposition products Combustion products: Oxides of carbon, nitrogen, and sulfur and potentially irritating and/or toxic fumes. Section 11 Toxicological Information Information on toxicological effects Components Petroleum Distillates (40% TO 45%) Acute Toxicity: Ingestion/Oral Rat LD50 >5 mg/kg; Unreported Route Rat >5500 mg/m³ 4 Hour (s) Comments: LC50 Page 5 of 8

6 GHS Properties Acute toxicity Aspiration Hazard Carcinogenicity Germ Cell Mutagenicity Skin corrosion/irritation Skin sensitization STOT RE STOT SE Toxicity for Reproduction Respiratory sensitization Serious eye damage/irritation Route(s) of entry/exposure Potential Health Effects Inhalation Acute (Immediate) Skin Acute (Immediate) Eye Acute (Immediate) Ingestion Acute (Immediate) Other Carcinogenic Effects Classification Eye contact; skin contact; inhalation; ingestion. May cause damage to organs. Causes skin irritation. Causes severe eye irritation. Unlikely and Expect low ingestion hazard. Do NOT induce vomiting. Prolonged or repeated inhalation of petroleum distillates may cause damage to organs. None of the components of this mixture are considered to be a carcinogen by IARC, ACGIH, NTP, OR OSHA. Section 12 Ecological Information Toxicity Eco toxicity: This mixture contains components that are potentially toxic to freshwater and saltwater ecosystems. Persistence and degradability Bioaccumulative potential Mobility in Soil Page 6 of 8

7 Other adverse effects Potential Environmental Effects This material may be harmful to aquatic organisms and may cause long term adverse effects in the aquatic environment. Section 13 Disposal Considerations Waste treatment methods Product waste Packaging waste Other Information Hazard characteristic and regulatory waste classification can change with product use. Accordingly, it is the responsibility of the user to determine the proper handling and disposition for disposal according to local, state and federal regulations. (40 CFR 260 through 271) Section 14 Transport Information UN number UN proper shipping name Transport hazard class (es) Packing group Environmental hazards NDA NDA NDA NDA NDA NDA Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Other information For Industrial/Professional Use Only Keep out of reach of Children.. U.S. and Canada ground: Combustible liquid, No label required. NFMC#50315 Not regulated for transport. Airfreight and International ocean: Not regulated. Section 15 Regulatory Information Safety, health and environmental regulations/legislation specific for the substance or mixture All components are on the TSCA inventory. SARA Hazard Classifications Canada Labor Canada WHMIS Classifications of Substances Not Listed SARA Title III, Section 313: No hazard, none. SARA Title III, Section 311,312: Fire Hazard. Section 16 Other Information Last Revision Date Preparation Date Disclaimer/Statement of Liability 21/April/ /February/2015 Page 7 of 8

8 Page 8 of 8