High Build Primer - Health & Safety Data Sheet According to 1907/2006/EC, Article 31

Transcription

1 1. Identification of the substance/mixture and of the company/undertaking. Product Identifier For Professional Use Only. Trade Name Symphony Narrowboat Paint Topcoat Gloss. Relevant identified Surface Coating. uses of the substance and uses advised Application of the Surface Coating. Substance Manufacturer/Supplier Symphony Coatings (West Midlands) Ltd Bradford Street Digbeth Birmingham B12 0JD Tel: +44 (0) Hazards Identification. Classification of the Substance According to Directive 67/548/EEC or Directive 1999/45/EC. Environmental R51-53: Toxic to aquatic organisms, may cause long-term adverse effects in the Flammable R12: Extremely Flammable. Classification System. The product has to be labelled due to the calculation procedure of the "General Classification guideline for preparations of the EU" in the latest valid version Xylene (mix) Risk Phrases. R12 Extremely Flammable. R51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the Safety Phrases. 3 Keep in a cool place. 23 Do not breathe fumes/vapour/spray. 38 In case of insufficient ventilation, wear suitable respiratory equipment. 45 In case of accident or if you feel unwell, seek medical advice immediately. 53 Avoid exposure obtain special instruction before use. 57 Use appropriate container to avoid environmental contamination. Special Labelling of 77.3% by mass of the contents are flammable. Certain Preparations. Page 1 of 7

2 Other Hazards. Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. 3. Composition/Information on Ingredients. Chemical Characterisation: Mixtures Description. Dangerous Components. Mixture of substances listed below with non-hazardous additions. CAS: EINECS: dimethyl ether % CAS: EINECS: CAS: EINECS: R12 Naphtha (petroleum), hydrodesulphurised heavy R65 R51/53 R Trizinc bis(orthophosphate) 10-25% % R50/53 Additional Information. For the wording of the listed risk phrases refer to section First Aid Measures. General Information. After Inhalation. After Skin Contact. After Eye Contact. After Swallowing. Symptoms of poisoning may even occur after several hours; therefore medical observation for at least 48 hours after the accident. Supply fresh air; consult doctor in case of complaints. Generally the product does not irritate the skin. Rinse opened eye for several minutes under running water. Call for a doctor immediately. Information for Doctor. Most important symptoms and effects, both acute and delayed. Indication of any immediate medical attention and special treatment needed. 5. Firefighting Measures. No further relevant information available. No further relevant information available. Suitable Extinguishing CO2, powder or water spray. Fight larger fires with water spray or alcohol resistant Agents. foam. Unsuitable Water with full jet. Extinguishing Agents. Special Hazards Arising No further relevant information available. from the Substance. Advice for Firefighters. Protective equipment: Put on breathing apparatus. Page 2 of 7

3 6. Accidental Release Measures. Personal Precautions, Protective Equipment and Emergency Procedures. Environmental Precautions. Wear protective equipment. Keep unprotected persons away. Inform respective authorities in case of seepage into water course or sewage system. Methods and Material for Containment and Cleaning up. Reference to other Sections. Ensure adequate ventilation. See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information. 7. Handling & Storage. Handling. Precautions for Safe Handling. Ensure good ventilation/extraction at the workplace. Prevent formation of aerosols. Open and handle receptacle with care. Storage. Information about Fire and Explosion Protection. Requirements to be Met by Storerooms and Receptacles. Information about Storage in One Common Storage Facility. Further Information about Storage Conditions. Keep ignition sources away - Do not smoke. Protect against electrostatic charges. Keep respiratory protective device available. Store in a cool location. Not required. Keep receptacle tightly sealed. Store in cool, dry conditions in well-sealed receptacles. Protect from heat and direct sunlight. Specific End Use(s). No further relevant information available. 8. Exposure Controls/Personal Protection Additional information about design of technical facilities. Control parameters. Exposure controls & Personal Protective No further data; see item 7. Ingredients with limit values that require monitoring at the workplace. Additional information. General protective and hygienic measures dimethyl ether Short term value 958 mg/m³ 500ppm Long term value 766 mg/m³ 400ppm The lists valid during the making were used as basis. Keep away from foodstuffs, beverages and feed. Page 3 of 7

4 Equipment. Wash hands before breaks and at the end of work. Respiratory protection. When spraying the product, use a respiratory protective device. Protection of hands. When skin exposure may occur, advice should be sought from the glove supplier on appropriate types and usage times for this product. The glove material has to be impermeable and resistant to the product/ the substance/ the preparation. Selection of the glove material on consideration of the penetration times, rates of diffusion and the Degradation. The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material cannot be calculated in advance and has therefore to be checked prior to the application. Eye protection. Tightly Sealed Goggles. 9. Physical and Chemical Properties Information on basic physical and chemical properties. ph-value. Appearance. Colour. Odour. Odour threshold. Fluid Liquid. According to product specification. Characteristic. Change in condition. Melting point/melting range. Undetermined. Boiling point/boiling range. -24 C Flash point. -42 C Flammability (solid, Not applicable. gaseous) Ignition temperature. 235 C Decomposition temperature. Self-igniting. Product is not self-igniting. Page 4 of 7

5 Danger of explosion. Explosion limits. Lower 3.0 Vol% Upper 18.6 Vol% Vapour pressure hpa Density Density at 20 C g/cm³ Relative density. Vapour density. Evaporation rate. Solubility in/miscibility Not miscible. with water. Partition coefficient (noctanol/water). Viscosity. Dynamic. Kinematic. Solvent content. 17.0% (Organic solvents) Solids content. 77.1% No further relevant information available. Physical and chemical properties 10. Stability & Reactivity Thermal decomposition conditions to be avoided. Possibility of hazardous reactions. Conditions to avoid. No decomposition if used according to specifications. No dangerous reactions known. No further relevant information available. Incompatible materials. No further relevant information available. Hazardous decomposition products. 11. Toxicological Information Acute toxicity & Primary irritant effect. Sensitization. Additional toxicological information. No dangerous decomposition products known. On the skin. On the eye. No sensitizing effects known. No irritant effect. No irritating effect. LD/Lc50 values relevant for classification trizinc bis(orthophosphate) Oral LD50 >5000mg/kg (rat) Page 5 of 7

6 12. Ecological Information Toxicity. Aquatic toxicity. No further relevant information available. Persistence and No further relevant information available. degradability. Behaviour in Bioaccumulative potential. No further relevant information available. environmental systems. Mobility in soil. No further relevant information available. Ecotoxical effects. Toxic for fish Additional ecological information. Results of PBT and vpvb assessment. Other adverse effects. Ecological information 13. Disposal Considerations. Also poisonous for fish and plankton in water bodies. Toxic for aquatic organisms. Water hazard class 1 (German Regulation) (Self-assessment):slightly hazardous for water. Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system. PBT. Not applicable. vpvb. Not applicable. No further relevant information available. Waste treatment Must not be disposed together with household garbage. Do not allow product to methods. reach sewage system. Uncleansed packaging. Disposal must be made according to official regulations. 14. Transportation Information. UN Number UN1263 ADR, IMDG, IATA UN proper shipping ADR 1263 PAINT (not viscous), ENVIRONMENTALLY HAZARDOUS name. IMDG PAINT (Naphtha(petroleum), MARINE POLLUTANT IATA PAINT Transport hazard class(es) ADR IMDG IATA Class: 3 Flammable Liquids. Label: 3 Packaging Group ADR, IMDG, IATA. III Environmental Hazards. Product contains environmentally hazardous substances: trizinc bis(orthophosphate). Marine Pollutants. No. Special Marking (ADR). Symbol (fish and tree). Special precautions for Warning: Flammable liquids. user. Danger code (Kemler). - Page 6 of 7

7 EMS Number Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code. Transport/Additional information. ADR F-D,S-U Not applicable. Limited quantities (LQ) Transport category Tunnel restriction code 1L 2 D 15. Regulatory Information. Safety, health and environmental regulations/legislation specific for the substance or mixture. National regulations. Technical instructions (air). Class Share in % Chemical safety assessment. I 0.1 NK 77.1 A Chemical Safety Assessment has not been carried out. 16. Other Information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Relevant phrases R10 Flammable. R12 Extremely Flammable R50/53 Very toxic to aquatic organisms, may cause long term effects in the R51/53 Toxic to aquatic organisms, may cause long-term adverse effects in the R65 Harmful: may cause lung damage if swallowed. R66 Repeated exposure may cause skin dryness or cracking. R67 Vapours may cause drowsiness and dizziness. Issued By. Symphony Coatings (West Midlands) Ltd Bradford Street Digbeth Birmingham B12 0JD Contact. James Nuttall +44 (0) Page 7 of 7