Product #: Emergency Phone Number: (800) Information Contacts: (714) GHS CLASSIFICATIONS Health Environmental Physical

Transcription

1 SAFETY DATA SHEET 1. PRODUCT AND COMPANY IDENTIFICATION Product Name: Gelish Dip Base Coat SDS Prepared: 10/5/16 Chemical Name: Cyanoacrylate adhesive SDS Revised: N/A Revision: 00 Product Use: Cosmetics Manufacturer: Hand & Nail Harmony 1545 Moonstone Brea, CA 981 Product #: Emergency Phone Number: (800) Information Contacts: (714) HAZARDS IDENTIFICATION GHS CLASSIFICATIONS Health Environmental Physical Skin corrosion/irritation, Category Serious eye damage/eye irritation, Category A GHS LABEL Acute Hazards to the Aquatic Environment, Category Chronic Hazards to the Aquatic Environment, Category Combustible liquid, Category 4 Environment Exclamation mark WARNING H410: Very toxic to aquatic life with long lasting effects H401: Toxic to aquatic life H315: Causes skin irritation H30: Causes eye irritation WARNING Precautionary statement(s) Prevention: P70: Do not eat, drink, or smoke when using this product P85: In case of inadequate ventilation wear respiratory protection. P73: Avoid release to the environment P33: Keep container tightly closed P10: Keep out of reach of children P80: Wear protective gloves/protective clothing/eye protection/face protection Response: P331: Do not induce vomiting P361: Remove/Take off immediately all contaminated clothing. P337+P313: If eye irritation persists: Get medical advice/attention. EMERGENCY OVERVIEW PHYSICAL APPEARANCE: Transparent Liquid IMMEDIATE CONCERNS: May cause irritation to the eyes, skin, and respiratory tract. POTENTIAL HEALTH EFFECTS EYES: May cause eye irritation Page 1 of 5

2 SKIN: May cause skin irritation SKIN ABSORPTION: May be harmful if absorbed through the skin INGESTION: May be harmful if swallowed; Ingestion is an unlikely route of entry in industrial uses INHALATION: May be harmful if inhaled SIGNS AND SYMPTOMS OF OVEREXPOSURE ACUTE TOXICITY: No data as a product CHRONIC EFFECTS: No data as a product 3. COMPOSITION / INFORMATION ON INGREDIENTS Chemical Name Wt.% CAS EINECS -Ethyl cyanoacrylate FIRST AID MEASURES EYES: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Have eyes examined and tested by medical personnel. SKIN: Immediately wash skin with soap and plenty of water. Remove contaminated clothing. Get medical attention if symptoms (skin irritation or rash) occur. Get medical attention. Wash clothing before reuse. INGESTION: Rinse mouth well with water. Never give an unconscious person anything to ingest. Do not induce vomiting unless directed to do so by medical personnel. Seek immediate medical attention. INHALATION: Remove to fresh air. If not breathing, give artificial respiration or give oxygen by trained personnel. Seek immediate medical attention. 5. FIRE FIGHTING MEASURES FLAMMABLE CLASS: Combustible liquid GENERAL HAZARD: This product is combustible. EXTINGUISHING MEDIA: SMALL FIRE: Use DRY chemical powder. LARGE FIRE: Use water spray or fog. Cool containing vessels with water jet in order to prevent pressure build-up, auto ignition or explosion. HAZARDOUS COMBUSTION PRODUCTS: May produce poisonous and irritating gases FIRE FIGHTING EQUIPMENT: As in any fire, wear self-contained breathing apparatus pressure-demand (MSHA/NIOSH approved or equivalent) and full protective gear. Then extinquish should be performed up wind. HAZARDOUS DECOMPOSITION PRODUCTS: May emit other toxic fumes under fire conditions. 6. ACCIDENTAL RELEASE MEASURES SMALL SPILL: Absorb with dry sand, soil, sawdust, cloth, etc., then place in a sealable container. LARGE SPILL: Dike and prevent overflow. Guide to a safe place then dispose properly. ENVIRONMENTAL PRECAUTIONS WATER SPILL: Do not allow product to flow into rivers or affect the environment GENERAL PROCEDURES: Extinguish all sources of ignition RELEASE NOTES: Keep spilled material from entering storm drains, sewers, or other environmental mediums. SPECIAL PROTECTIVE EQUIPMENT: Wear appropriate personal protection equipment to avoid contact to eyes, skin, and inhalation. Page of 5

3 COMMENTS: Disposal of clean-up materials may be governmentally regulated. Observe all applicable local, state, and federal waste management regulations. 7. HANDLING AND STORAGE GENERAL PROCEDURES: Avoid contact with eyes, skin, and clothing. Use with adequate ventilation. Take precaution against fire. HANDLING: Fire strictly prohibited. Wear appropriate personal protection equipment. Wash thoroughly after handling. STORAGE: Protect from direct sunlight. Store the product at moderate temperature. Store in original container at room temperature. COMMENTS: Containers, even those that have been emptied, will retain product residue and vapors. Always obey hazard warnings and handle empty containers as if they were full. Do not mix this product with other cleaning agents. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION EXPOSURE GUIDELINES OSHA HAZARDOUS COMPONENTS (9 CFR ) EXPOSURE LIMITS OSHA PEL ACGIH TLV Chemical Name ppm mg/m 3 ppm mg/m 3 -Ethyl cyanoacrylate TWA [1] [1] 0. ppm OSHA TABLE COMMENTS: 1. Not Established ENGINEERING CONTROLS: Adequate ventilation may be necessary to control any air contaminants to within the TLV control parameters during the use of this product. PERSONAL PROTECTIVE EQUIPMENT EYES AND FACE: Safety glasses. Wear splash goggles if the potential for splashing or spraying exists. SKIN: Gloves (impervious). RESPIRATORY: In case of insufficient ventilation, wear NIOSH approved respiratory equipment when exposure limits are exceeded. PROTECTIVE CLOTHING: Wear chemically impervious clothing, gloves, boots, aprons and gauntlets to prevent prolonged or repeated skin contact. Wear protective eyeglasses or chemical safety googles, per OSHA eye- and face-protection regulations (9 CFR ). Contact lenses are not eye protective devices. Appropriate eye protection must be worn instead of, or in conjunction with contact lenses. WORK HYGIENIC PRACTICES: Wash hands before eating, smoking, or using restroom. Food or beverages should not be consumed anywhere this product is handled or stored. Wash thoroughly after handling. OTHER USE PRECAUTIONS: Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. 9. PHYSICAL AND CHEMICAL PROPERTIES PHYSICAL STATE: Liquid ODOR: Acrid APPEARANCE: Transparent liquid COLOR: Clear FLASHPOINT AND METHOD: 85 C (185 F) SOLUBILITY IN WATER: Slight VISCOSITY #1: 100 mpa s 10. STABILITY AND REACTIVITY STABILITY: May cause sudden polymerization POLYMERIZATION: Yes, due to heat generated during polymerization. CONDITIONS TO AVOID: High temperature, high humidity and direct sunlight Page 3 of 5

4 HAZARDOUS DECOMPOSITION PRODUCTS: Carbon oxides. Nitrogen oxides. INCOMPATIBLE MATERIALS: Reactive with alkalis, oxidizing agents, and water. 11. TOXICOLOGICAL INFORMATION ACUTE Chemical Name ORAL LD 50 (rat) DERMAL LD 50 (rabbit) INHALATION LC 50 (rat) -Ethyl cyanoacrylate > 5000 Rat / mg/kg > 000 Rabbit/mg/kg SKIN EFFECTS: No data as a product CHRONIC: No data as a product 1. ECOLOGICAL INFORMATION ENVIRONMENTAL DATA: One or more substance in this product may be hazardous to the aquatic environment. ECOTOXICOLOGICAL INFORMATION: No data as a product 13. DISPOSAL CONSIDERATIONS DISPOSAL METHOD: Waste must be disposed of in accordance with federal, state and local environmental control regulations. Consult your licensed waste contractor for detailed recommendations. 14. TRANSPORT INFORMATION DOT (49 CFR 17): IATA (Air): IMDG (OCN): TDGR (Canadian GND): ADR/RID (EU): SCT (Mexico): ADGR (AUS): UN3334, Aviation regulated Liquid, N.O.S (Ethyl Cyanoacrylate), 9 (500 ml max. per package) 15. REGULATORY INFORMATION UNITED STATES TSCA (TOXIC SUBSTANCE CONTROL ACT) TSCA REGULATORY: All chemical substances in this material are included on or exempted from listing on the TSCA Inventory of Chemical Substances. Page 4 of 5

5 TSCA STATUS: All ingredients are in compliance with the TSCA 16. OTHER INFORMATION HMIS RATING HEALTH * FLAMMABILITY PHYSICAL HAZARD PERSONAL PROTECTION NFPA CODES This information presented herein was obtained from sources considered to be reliable. However, this information is provided without any warranty, expressed or implied, regarding its correctness or suitability for consumers intended use and/or application. For this and other reasons, we assume no responsibility and expressly disclaim liability for loss, damage or expense arising out of any way connected with the handling, storage use or disposal of the product. This SDS was prepared expressly for this product. Use the materials only as directed. If the product is used as a component of another product, the information contained within the SDS may not be applicable. If there are any problems or concerns understanding this SDS form, please direct all questions to INFOTRAC, Chemical Emergency Resources System at ( ). Page 5 of 5