MATERIAL SAFETY DATA SHEET

Transcription

1 SECTION 1: PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME: G96 MILITARY GRADE BORE SOLVENT PRODUCT CODES: G96 Part Numbers: #1107, #1108 MANUFACTURER: G96 Products Inc. ADDRESS: 85 5 th Ave, Bldg #6 Paterson, NJ USA Website: info@g96.com ph fax EMERGENCY PHONE: 3E Company PRODUCT USE: PREPARED BY: Bore Solvent for firearms G96 Products Inc. SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS Ingredients CAS# % Wt. ACGIH-TLV-TWA Monoethanolamine % 3ppm 8 hours Amonium Oleate % not regulated Aromatic Hydrocarbons % 10 ppm Glycol Ether % 800 ppm SECTION 3: HAZARDS IDENTIFICATION: Contents Harmful. Fumes Harmful. Causes Burns. Dangerous Fumes form when mixed with other products. Do NOT mix with bleach. Do NOT swallow. Do NOT get in eyes or on skin or clothing. Do NOT breathe fumes. Keep away from flames or sparks. Handle with care. Keep out of reach of children. Wear rubber gloves, safety glasses. Use only in a well-ventilated area. Wear a mask or a respirator. SECTION 4: FIRST AID MEASURES Contains petroleum distallates. If swallowed call a poison control center immediately. Do NOT induce vomiting. EYES: If in eyes, rinse with water for 15 minutes. Remove contact lens. Protect unharmed eye. Keep eye wide open while rinsing. Be sure to flush under eye lid. If eye irritation persists, consult a specialist. SKIN: If on skin, rinse well with water. If on clothes, remove clothes. If skin irritations persist, call a physician. G96 PRODUCTS INC. MSDS #1107 / 1108 MILITARY GRADE BORE SOLVENT Page 1 of 6

2 INGESTION: If swallowed call a poison control center or doctor immediately. Do NOT induce vomiting.. INHALATION: If inhaled move person to fresh air. If unconscious place in recovery position and seek medical advice. If symptoms persist, call a physician. SECTION 5: FIRE-FIGHTING MEASURES HMIS HAZARD CLASSIFICATION HEALTH: 1 FLAMMABILITY: 2 REACTIVITY: 0 PERSONAL PROTECTION: B NFPA CODE 30B LEVEL 3 HEALTH: 1 FLAMMABILITY: 2 REACTIVITY: 0 EXTINGUISHING MEDIA: CO 2, foam, dry powder. Avoid high volume water jet. SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS Wear self-contained breathing apparatus for firefighting if necessary. Same as for petroleum fires. UNUSUAL FIRE AND EXPLOSION HAZARDS: Heated surfaces, open flames or sparks. HAZARDOUS POLYMERIZATION: Not expected to occur. ADDITIONAL INFORMATION: Standard procedure for chemical fires. Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. FLASH POINT: 145 F (63 C) TCC Flammability Limit: Not determined. SECTION 6: ACCIDENTAL RELEASE MEASURES PERSONAL PRECAUTIONS: Use personnel protective equipment. Ensure adequate ventilation. ACCIDENTAL RELEASE MEASURES: Absorb with liquid binding material such as sand, sawdust, universal binders. Keep in suitable, closed containers for disposal. WASTE DISPOSAL METHOD: Dispose of all wastes in accordance with Federal, State, and Local regulations. SECTION 7: HANDLING AND STORAGE HANDLING: Product should be handled in accordance with good industrial hygiene and safety practices. Use in a well ventilated area. Avoid inhalation of concentrated vapors. Be careful not to damage containers. Do NOT puncture or incinerate container. Wear protective clothing. i.e. gloves, respirator and goggles. G96 PRODUCTS INC. MSDS #1107 / 1108 MILITARY GRADE BORE SOLVENT Page 2 of 6

3 STORAGE: Product should be stored in a dry place at room temperature. Keep out of sunlight. Keep away from flames such as a pilot light and any object that sparks such as an electric motor. Keep away from excessive heat. Store in a well ventilated area. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION VENTILATION: Local exhaust ventilation as needed in confined areas to ensure that occupational exposure limits are not exceeded. RESPIRATORY PROTECTION: Forced air if TLV is exceeded. EYE PROTECTION: Use safety glasses, goggles, or face shield. SKIN PROTECTION: Wear protective clothing and gloves. OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Use polyethylene gloves and plastic apron. WORK HYGIENIC PRACTICES: Avoid contact with skin and eyes. Wash hands thoroughly after handling and before eating, drinking, and smoking. Keep away from food, beverages, and feed. If clothing is soaked by oil, remove and discard. Keep out of reach of children. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE: Clear to dark amber colored solution ODOR: ammonical VAPOR PRESSURE: N/A PHYSICAL STATE: clear liquid ph AS SUPPLIED: 11 BOILING POINT: F: N/D C: N/D MELTING POINT: FREEZING POINT: VAPOR PRESSURE (mmhg): VAPOR DENSITY (AIR = 1): SPECIFIC GRAVITY (H2O = 1): Conc G96 PRODUCTS INC. MSDS #1107 / 1108 MILITARY GRADE BORE SOLVENT Page 3 of 6

4 EVAPORATION RATE: Heavier than air. 80% SOLUBILITY IN WATER: negligible FLASH POINT: 145 F (63 C) SECTION 10: STABILITY AND REACTIVITY STABILITY: STABLE CONDITIONS TO AVOID (STABILITY): Keep away from flames such as a pilot light and any object that sparks such as an electric motor. Keep away from excessive heat. INCOMPATIBILITY (MATERIAL TO AVOID): Strong Oxidizing Agents HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: Not determined. HAZARDOUS POLYMERIZATION: WILL NOT OCCUR SECTION 11: TOXICOLOGICAL INFORMATION Irritancy of Material: skin / eye irritant Sensitizing capability of Material: none known SECTION 12: ECOLOGICAL INFORMATION Do NOT allow the product to enter waterways, storm drains, or soil. The liquid content of this product is toxic to aquatic species and may cause long-term adverse effects in the aquatic environment. SECTION 13: DISPOSAL CONSIDERATIONS Dispose of in accordance with local, provincial and federal regulations. G96 PRODUCTS INC. MSDS #1107 / 1108 MILITARY GRADE BORE SOLVENT Page 4 of 6

5 SECTION 14: TRANSPORT INFORMATION Department of Transportion (D.O.T.) Proper Shipping Name: Petroleum Distallates, n.o.s. Hazard Class Combustible Liquid ID Number 1268, PG II Label Required Flammable Liquid International - IMDG Proper Shipping Name: Petroleum Distallates, n.o.s. UN # UN 1268 Hazard Class 3 PGII Packaging Exceptions LTD QTY Label Required Flammable Liquid, Limited Quantity Air - IATA Proper Shipping Name: Petroleum Distallates, n.o.s. Hazard Class 3 PG II UN # UN 1268 Packaging Exceptions LTD QTY Label Required Flammable Liquid Pasenger and Cargo Aircraft Limited Qty Packing Instructions: Y341 Ltd Qty Max 1 L Cargo AIrcraft Packing Instructions: 364 Max Net Qty 1 L SECTION 15: REGULATORY INFORMATION SARA 313 INFORMATION:... THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:. CALIFORNIA PROPOSITION 65:... THE FOLLOWING STATEMENT IS MADE IN ORDER TO COMPLY WITH THE CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986:.WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER. NONE TSCA (Toxic Substances Control Act)... ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. ANY IMPURITIES PRESENT IN THIS PRODUCT ARE EXEMPT FROM LISTING. NONE G96 PRODUCTS INC. MSDS #1107 / 1108 MILITARY GRADE BORE SOLVENT Page 5 of 6

6 SECTION 16: OTHER INFORMATION The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, express or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigations to determine the suitability of the information for their particular purposes. In no way shall the company be liable for any claims, losses, or damages of any third party or for lost profits or any special, indirect, incidental, consequential or exemplary damages, howsoever arising, even if the company has been advised of the possibility of such damages. G96 PRODUCTS INC. MSDS #1107 / 1108 MILITARY GRADE BORE SOLVENT Page 6 of 6