PANGOFOL BLACK NON FLAMMABLE

Transcription

1 PANGOFOL BLACK NON FLAMMABLE Product: 9920 Chemical family: Mixture. Manufacturer emergency phone number: Section 1: PRODUCT INFORMATION Manufacturer: Truflex/Pang Rubber Products Company, Inc. 200 East Coshocton Street P.O. Box 486 Johnstown, Ohio Chemtrec International: Information phone number: Supplier: Same as manufacturer. Product name: Pangofol black non flammable (MSDS #9920) Product uses: Rubber cement. Catalog number(s): 992 series (996,997,998) TDG classification: TRICHLOROETHYLENE SOLUTION UN1710 Class 6.1 PG III. Labels required: Toxic Emergency response guidebook number: 160 EmS number: Reportable Quantity (DOT): 100 lbs May be shipped as Consumer Commodity ORM D. Additional shipping information: IMDG (<1L containers) Dangerous goods in limited quantities of Class 6.1. IATA (<4L containers): may reclassify as miscellaneous Dangerous Goods, Consumer Commodity, 9, ID < 4L containers, may be shipped as a Consumer Commodity, (ORM D Domestic US). Effective date: 2007/03/06 Revision No.: 4 Last review: 2007/03/06 NFPA: PANGOFOL BLACK NON FLAMMABLE Page 1 of 6

2 Section 2: HAZARDOUS INGREDIENTS C.A.S. Concentration% wgt/wgt Ingredient Name ACGIH TLV TWA LD/50 LC/ TRICHLOROETHYLENE 50 PPM 4920 MG/KG RAT ORAL 2400 MG/KG MOUSE ORAL > MG/KG RABBIT DERMAL 8450 PPM/4H MOUSE INHALATION 220,000 MG/M3/20M MOUSE INHALATION MG/M3/1H RAT INHALATION Section 2A: ADDITIONAL INGREDIENT INFORMATION Note: (supplier). Cas# : LD50 10,000 mg/kg rat dermal. Cas# : LC50 12,500 ppm/4hr rat inhalation. Physical state: Liquid. Appearance & odor: Strong solvent odor. Black liquid. High viscosity liquid. Odor threshold (ppm): Not available. Vapour pressure (mmhg): 37.7 C (100 F) Vapour density (air=1): 4.53 Volatiles (%) By volume: 87.3 Evaporation rate (butyl acetate = 1): 3.6 Boiling point ( 760 mm Hg (190 F) Freezing point ( C): Not available. ph: Not applicable. Specific 20 C: 15.5 C (60 F) Solubility in water (%): Not available. Coefficient of water\oil dist.: Not available. VOC: (lb/gal) Flammability: Not flammable. Section 3: PHYSICAL DATA Section 4: FIRE & EXPLOSION DATA Conditions of flammability: Vapours are heavier than air and may travel along the ground and be ignited by flames, sparks or other ignition sources at locations distant from the material handling point. Extinguishing media: Carbon dioxide, dry chemical, foam. Water fog. PANGOFOL BLACK NON FLAMMABLE Page 2 of 6

3 Special procedures: Self contained breathing apparatus required. Firefighters should wear the usual protective gear. Stay upwind if possible. Auto ignition temperature: 420 C (788 F) Flash point ( C), method: None Tag Closed Cup. Lower flammability limit (% vol): 25 C Upper flammability limit (% vol): Explosion Data 25 C Sensitivity to static discharge: Not available. Sensitivity to mechanical impact: Not available. Hazardous combustion products: Oxides of carbon (CO, CO2). Phosgene. Chlorine (Cl2). Hydrogen chloride (HCl). Various hydrocarbons. Explosive power: Containers may rupture if exposed to heat or fire. Chemical stability: Product is stable. Conditions of instability: None known. Hazardous polymerization: Will not occur. Section 5: REACTIVITY DATA Incompatible substances: Strong acids. Strong alkalies. Strong oxidizing agents. Zinc powders. Aluminum powder. Hazardous decomposition products: See hazardous combustion products. Section 6: TOXICOLOGICAL PROPERTIES Route of entry: Eye contact, skin contact, skin absorption, inhalation and ingestion. Effects of acute exposure Eye contact: May cause irritation. May cause redness and tearing. May cause stinging. Corneal injury is unlikely. May cause swelling. Pain and discomfort. Vapours may cause irritation. Skin contact: May cause severe irritation, drying, cracking. May cause mild irritation. May cause redness or burning sensation. May cause numbness in fingers, if immersed in liquid. PANGOFOL BLACK NON FLAMMABLE Page 3 of 6

4 Skin absorption: May be harmful if absorbed through the skin. Inhalation: Upper respiratory tract irritation may occur. May cause dizziness or drunkenness effects. May cause an irregular heartbeat. In extreme cases, unconsciousness and death may occur. Ingestion: May cause nausea, vomiting and diarrhea. Ingestion of large amounts may cause injury. May cause gastro intestinal irritation. No hazard known for ingestion of small quantities. Aspiration hazard if swallowed. May cause central nervous system depression. Large amounts may be fatal. Effects of chronic exposure: May affect the central nervous system. May cause kidney effects. May cause hearing loss. May cause liver effects. May affect the cardiovascular system. LD50 of product, species & route: Not available for mixture, see the ingredients section. LC50 of product, species & route: Not available for mixture, see the ingredients section. Exposure limit of material: Not available for mixture, see the ingredients section. Sensitization to product: Not available. Carcinogenic effects: Contains reported carcinogen. Reproductive effects: None known. Teratogenicity: Not available. Mutagenicity: Not available. Synergistic materials: Alcohol. Precautionary Measures Gloves/Type: Section 7: PREVENTATIVE MEASURES Respiratory/Type: Chemical resistant gloves. Footwear/Type: NIOSH approved respirator, if necessary. (negative pressure type). Impervious boots. Clothing/Type: Impervious clothing. PANGOFOL BLACK NON FLAMMABLE Page 4 of 6

5 Other/Type: Eye wash facility should be in close proximity. Emergency shower should be in close proximity. Ventilation requirements: Explosion proof ventilation equipment. Local exhaust and/or general ventilation. Provide sufficient mechanical ventilation to maintain exposure below TLV. Leak/Spill: Recover using a pump. Eliminate all sources of ignition. Dike area to prevent spreading. Evacuate all non essential personnel. Prevent entry into drains, sewers, and other waterways. Absorb residual material with sand or other absorbent material. Stop leak if without risk. Wear appropriate protective equipment. Ground handling equipment. Stay upwind. Transfer to an approved container for disposal. Notify the appropriate authorities as required. Waste disposal: In accordance with municipal, provincial and federal regulations. Handling procedures and equipment: Maintain a good personal hygiene. Keep away from heat, sparks, and open flame. Avoid breathing vapors/mists. Use adequate ventilation. Wash thoroughly after using, particularly before eating or smoking. Wear personal protective equipment appropriate to task. Empty containers containing residue may cause a hazard. Do not cut, grind, weld or drill empty container. Use proper grounding procedures. Avoid contact with skin, eyes and clothing. Do not eat, drink or smoke in handling area. Launder contaminated clothing prior to reuse. Do not ingest. Storage requirements: Store away from all sources of ignition. Store away from incompatible materials. Store in a dry place. Keep containers tightly closed. Do not store in aluminum containers. Do not store in plastic containers. Do not store in zinc containers. Special shipping information: See transportation information. Section 8: FIRST AID MEASURES Skin contact: Remove contaminated clothing. Wash with mild soap and water. Consult a physician if irritation persists. Eye contact: Flush with water for at least 15 minutes, holding eyelids open with fingers. Consult a physician if irritation persists. Inhalation: Keep person warm and at rest. Remove victim to fresh air. If breathing is difficult administer oxygen. If not breathing, have qualified person give artificial respiration. Obtain medical attention. PANGOFOL BLACK NON FLAMMABLE Page 5 of 6

6 Ingestion: If victim is drowsy or unconscious, place on left side with head down. Do not leave individual unattended. Never give anything by mouth to an unconscious person. Do not induce vomiting, seek immediate medical attention. Additional information: The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any inaccuracies. Section 9: ADDITIONAL INFORMATION General note: This material safety data sheet was prepared from information obtained from various sources, including product suppliers and the Canadian Center for Occupational Health and Safety. Data prepared by: Global Safety Management 3340 Peachtree Road, #1800 Atlanta, GA Phone: Fax: (877) See for the latest MSDSs. Web: info@globalsafetynet.com. PANGOFOL BLACK NON FLAMMABLE Page 6 of 6