Model YD Style A-B Unit Components
|
|
- Arron Holt
- 6 years ago
- Views:
Transcription
1 Centrifugal Liquid Chillers Renewal Parts Supersedes: RP2 (313) Form RP2 (915) Model YD Style A-B Unit Components R-134a LD09115 Issue Date: September 15, 2015
2 IMPORTANT! READ BEFORE PROCEEDING! GENERAL SAFETY GUIDELINES This equipment is a relatively complicated apparatus. During rigging, installation, operation, maintenance, or service, individuals may be exposed to certain components or conditions including, but not limited to: heavy objects, refrigerants, materials under pressure, rotating components, and both high and low voltage. Each of these items has the potential, if misused or handled improperly, to cause bodily injury or death. It is the obligation and responsibility of rigging, installation, and operating/service personnel to identify and recognize these inherent hazards, protect themselves, and proceed safely in completing their tasks. Failure to comply with any of these requirements could result in serious damage to the equipment and the property in which it is situated, as well as severe personal injury or death to themselves and people at the site. This document is intended for use by owner-authorized rigging, installation, and operating/service personnel. It is expected that these individuals possess independent training that will enable them to perform their assigned tasks properly and safely. It is essential that, prior to performing any task on this equipment, this individual shall have read and understood the on-product labels, this document and any referenced materials. This individual shall also be familiar with and comply with all applicable industry and governmental standards and regulations pertaining to the task in question. SAFETY SYMBOLS The following symbols are used in this document to alert the reader to specific situations: Indicates a possible hazardous situation which will result in death or serious injury if proper care is not taken. Identifies a hazard which could lead to damage to the machine, damage to other equipment and/or environmental pollution if proper care is not taken or instructions and are not followed. Indicates a potentially hazardous situation which will result in possible injuries or damage to equipment if proper care is not taken. Highlights additional information useful to the technician in completing the work being performed properly. External wiring, unless specified as an optional connection in the manufacturer s product line, is not to be connected inside the control cabinet. Devices such as relays, switches, transducers and controls and any external wiring must not be installed inside the micro panel. All wiring must be in accordance with Johnson Controls published specifications and must be performed only by a qualified electrician. Johnson Controls will NOT be responsible for damage/problems resulting from improper connections to the controls or application of improper control signals. Failure to follow this warning will void the manufacturer s warranty and cause serious damage to property or personal injury. 2 JOHNSON CONTROLS
3 CHANGEABILITY OF THIS DOCUMENT In complying with Johnson Controls policy for continuous product improvement, the information contained in this document is subject to change without notice. Johnson Controls makes no commitment to update or provide current information automatically to the manual or product owner. Updated manuals, if applicable, can be obtained by contacting the nearest Johnson Controls Service office or accessing the Johnson Controls QuickLIT website at johnsoncontrols.com. It is the responsibility of rigging, lifting, and operating/ service personnel to verify the applicability of these documents to the equipment. If there is any question regarding the applicability of these documents, rigging, lifting, and operating/service personnel should verify whether the equipment has been modified and if current literature is available from the owner of the equipment prior to performing any work on the chiller. Change Bars Revisions made to this document are indicated with a line along the left or right hand column in the area the revision was made. These revisions are to technical information and any other changes in spelling, grammar or formatting are not included. YD Installation - Style A YD Installation - Style B YD Field Connections YD Field Control Modifications YD Operations YD OptiView TM Renewal Parts YD OptiView TM Operation ASSOCIATED LITERATURE Manual Description Form Number N N PW PW O RP O1 JOHNSON CONTROLS 3
4 NOMENCLATURE YD XF XA J2 CA A and B DESIGN LEVEL Model Evaporator Code XF, YF, YG, YH, ZF, ZG, AF, AG, AH, BB, BC, BD, B2, B3, B4, EB, EC, ED, E2, E3, E4, FB, FC, FD, F2, F3, F4, GB, GC, GD, G2, G3, G4, HB, HC, HD, H2, H3, H4, KB, KC, KD, K2, K3, K4, CB, CC, CD, C2, C3, C4, DB, DC, DD, D2, D3, D4 Power Supply - for 60 Hz 5 for 50 Hz Compressor Code J1, J2, J3, J4, J5 K1, K2, K3, K4, K7 Condenser Code XA, XB, XC, XD, YA, YB, YC, YD, ZA, ZB, ZC, ZD, AA, AB, AC, AD, BB, BC, BD, BE, B2, B3, B4, B5, CB, CC, CD, C2, C3, C4, DB, DC, DD, DE, D2, D3, D4, D5, EB, EC, ED, EE, E2, E3, E4, E5, FB, FC, FD, FE, F2, F3, F4, F5, GB, GC, GD, GE, G2, G3, G4, G5, HB, HC, HD, HE, H2, H3, H4, H5, KB, KC, KD, KE, K2, K3, K4, K5, MOTOR CODE 60 Hz 50 Hz CW 5CS CX 5CT CY 5CU CZ 5CV CA 5CW CB 5CX DA 5DA DB 5DB DC 5DC DD 5DD DE 5DE DF 5DF 5DG DH 5DH DJ 5DJ DK 5DK DL 5DL 4 JOHNSON CONTROLS
5 LIST OF TABLES Table 1 - YD Unit Components...7 Table 2 - YD Unit Piping (Mod A)...10 Table 3 - YD Unit Piping (Mod B)...14 Table 4 - YD Evaporator / Condenser (Mod A)...20 Table 5 - YD Evaporator / Condenser (Mod B)...22 Table 6 - YD Oil Pump Housing (Mod A)...24 Table 7 - YD Oil Pump Housing (Mod B)...26 Table 8 - Oil Filter Arrangement...28 Table 9 - Proximity Probe Kit...30 Table 10 - PRV / VGD Position Sensor Kit...31 Table 11 - YD System Wiring...32 Table 12 - YD Variable Speed Oil Pump Panel...34 Table 13 - YD Variable Speed Oil Pump Panel...36 Table 14 - YD Evaporator Relief Valves...38 Table 15 - YD Condenser Relief Valves...40 Table 16-18' Condenser Shells With 3/4" Tubes...41 Table 17-18' Evaporator Shells With 3/4" Tubes...42 Table 18-18' And 22' Condenser Shells With 3/4" Tubes...43 Table 19-18' And 22' Condenser Shells With 1" Tubes...44 Table 20-18' And 22' Evaporator Shells With 3/4" Tubes...45 Table 21-18' And 22' Evaporator Shells With 1" Tubes...46 Table 22 - Evaporator 150# Compact Waterbox (Mod A)...47 Table 23 - Evaporator 300# Compact Waterbox (Mod A)... Table 24 - Condenser 150# Compact Waterbox (Mod A)...49 Table 25 - Condenser 300# Compact Waterbox (Mod A)...50 Table 26 - Evaporator 150# Marine Waterbox (Mod A)...51 Table 27 - Evaporator 300# Marine Waterbox (Mod A)...52 Table 28 - Condenser 150# Marine Waterbox (Mod A)...53 Table 29 - Condenser 300# Marine Waterbox (Mod A)...54 Table 30 - Evaporator 150# Compact Waterbox (Mod B)...55 Table 31 - Evaporator 300# Compact Waterbox (Mod B)...56 Table 32 - Condenser 150# Compact Waterbox (Mod B)...57 Table 33 - Condenser 300# Compact Waterbox (Mod B)...58 Table 34 - Evaporator 150# Marine Waterbox (Mod B)...59 Table 35 - Evaporator 300# Marine Waterbox (Mod B)...60 Table 36 - Condenser 150# Marine Waterbox (Mod B)...61 Table 37 - Condenser 300# Marine Waterbox (Mod B)...62 JOHNSON CONTROLS 5
6 This Page Intentionally Left Blank. 6 JOHNSON CONTROLS
7 Table 1 - YD Unit Components ITEM DESCRIPTION PART NUMBER QUANTITY 20 Hose, Braided Flex Metal Valve, W/ ABZ Actuator 8" Assembly YD (Mod A) a Actuator, ABZ a Actuator, Bray b Valve, ABZ 8" Valve, W/ ABZ Actuator 10" Assembly YD (Mod A) a Actuator, ABZ a Actuator, Bray b Valve, ABZ 10" Valve, Norriseal W/ ABZ Actuator 8" Assembly YD (Early Mod B) a Actuator, ABZ b Valve, Norriseal 8" c O-ring, Neo d Norriseal, Rebuild Kit Kit Valve, Norriseal W/ ABZ Actuator 10" Assembly YD (Early Mod B) a Actuator, ABZ b Valve, Norriseal 10" c O-ring, Neo d Norriseal, Rebuild Kit Kit Valve, Norriseal W/ ABZ Actuator 12" Assembly YD (Early Mod B) a Actuator, ABZ b Valve, Norriseal 12" c O-ring, Neo d Norriseal, Rebuild Kit Kit Valve, Norriseal W/ Bray Actuator 8" YD (Mod B) a Actuator, Bray b Valve, Norriseal 8" c O-ring, Neo d Norriseal, Rebuild Kit Kit Valve, Norriseal W/ Bray Actuator 10" YD (Mod B) a Actuator, Bray b Valve, Norriseal 10" c O-ring, Neo d Norriseal, Rebuild Kit Kit Valve, Norriseal W/ Bray Actuator 12" YD (Mod B) a Actuator, Bray b Valve, Norriseal 12" c O-ring, Neo d Norriseal, Rebuild Kit Kit UNIT COMPONENTS Valve, Ball 3" Flanged Valve, Ball 4" Flanged FIGURE JOHNSON CONTROLS 7
8 TABLE 1 - YD Unit Components (Cont'd) ITEM DESCRIPTION PART NUMBER QUANTITY 26 Valve, Butterfly Size 3" a O-ring, Neo x Valve, Butterfly Size 4" a O-ring, Neo x Gasket (J1-J2 Compressor) Gasket (J3-J5 Compressor) Gasket (J7 Compressor) Gasket (K1, K2 Compressor) Gasket (K3, K4 Compressor) Gasket (K7 Compressor) Gasket, Ansi # (Mod A - X Shells) Gasket, Ansi # (Mod A - Y, Z, A Shells) Gasket, Ansi # (Mod B - B Shells) Gasket, Ansi # (Mod B - C-H Shells) Gasket, Ansi # (Mod B - K Shells) Gasket, Ansi # (K-K Shells) Gasket, Ansi 3-150# (B-L, M-M Shells) Gasket, Ansi 4-150# (E-C, F-D, G-E, H-F, K-K, N-B Shells) O-Ring, Neo id.139thk M O-Ring, Neo id.210thk M O-Ring, Neo id.210thk M (B-L, M-M, N-B Shells) O-Ring, Neo id.275thk M (E-C, F-D, G-E, H-F Shells) O-Ring, Neo id.275thk M (K-K Shells) NOTE: Items with an * are NOT represented. FIGURE 8 JOHNSON CONTROLS
9 Figure 1 - YD Unit Components LD15088 JOHNSON CONTROLS 9
10 UNIT PIPING (Mod A) Table 2 - YD Unit Piping (Mod A) ITEM DESCRIPTION PART NUMBER QUANTITY FIGURE 1 Gasket , 4 2 Seal, O-Ring (1-11/16 ) , 3, 4 3 Seal, O-Ring (9/16 ) , 4 4 Seal, O-Ring (11/16 ) , 3, 4 5 Seal, O-Ring (1-7/16 ) , 4 6 Seal, O-Ring (1-5/16 ) , 4 7 Valve, Relief , 4 8 Seal, O-Ring (7/8 ) , 4 9 Transducer, Pressure Gasket Bottle, High Density A Cap Seal, O-Ring (1-3/16 ) , 4 13 Seal, O-Ring (1-1/16 ) , 4 14 Filter Drier , 3 15 Valve, Solenoid Valve, Stop Vertical Angle Valve, Check Seal, O-Ring (1") Gasket (16-1/4 O.D. X 14 I.D.) Adapter, ORFS x 1-1/ Seal, O-Ring (3 1/8 ) , 3 23 Seal, O-Ring (2 3/4 ) , 4 24 Gasket (11 O.D. X 8 5/8 I.D) Valve, Ball , 3 NOTE: Items with an * are NOT represented. 10 JOHNSON CONTROLS
11 A A 1 Without Isolation Valve With Isolation Valve Figure 2 - YD Unit Piping (Mod A) LD09101 JOHNSON CONTROLS 11
12 Figure 3 - YD Unit Piping (Mod A) LD JOHNSON CONTROLS
13 Figure 4 - YD Unit Piping (Mod A) LD09101 JOHNSON CONTROLS 13
14 UNIT PIPING (Mod B) Table 3 - YD Unit Piping (Mod B) ITEM DESCRIPTION PART NUMBER QUANTITY FIGURE 1 Transducer, Pressure , 7 2 Transducer, Pressure Valve, Ball 1-3/8 Ods Conn Valve, Stop Ang Vertical , 8 12 Valve, Solenoid 3/8 Orfs N.C , 7 12a Solenoid, Coil Replacement Valve, Check 1-1/8" Ods (1" Oil Sump Vent Line) Valve, Check 1-5/8" Ods (1-1/2" Oil Sump Vent Line) Valve, Check 3/8 O-Ring Face Valve, Stop Ang Vertical Solenoid, Valve 3/8 Orfs Nc a Solenoid, Coil Replacement Valve, Ball 1-5/8 Ods Conn Adapter, 1-1/2 Orfs X 1-5/ , 9 26 Connr, 3/8 O.D.Tube Male , 6, 8 27 Connr, 1-1/4 O.D. Tube Male Elbow, 1" O.D. Tube 90 Deg Male (1" Oil Sump Vent Line) Adapter, 1 Orfs X 1-1/8 Ftg (1" Oil Sump Vent Line) Adapter, 1-1/4 Orfs X 1-3/ Elbow, 1-1/2"Od Tube 90deg Male , 9 43 O-Ring, Neo id.118thk M , 9 44 O-Ring, Neo id.078thk M O-Ring, Neo id.116thk M (1" Oil Sump Vent Line) O-Ring, Neo id.070thk M O-Ring, Neo id.070thk M O-Ring, Neo id.070thk M (1" Oil Sump Vent Line) O-Ring, Neo id.118thk M O-Ring, Neo id.070thk M O-Ring, Neo1 01.9id.118thk M , 9 54 O-ring, Neoprene 0.351id.072thk Filter, Drier 3/8 Orfs , 7 83 Bottle, High Density a Cap, High Density Bottle NOTE: Items with an * are NOT represented. 14 JOHNSON CONTROLS
15 J1/K1 and J2/K2 Compressor J3/K3, J4/K4, J5 and J7/K7 Compressor Figure 5 - YD Unit Piping (Mod B) LD14558 JOHNSON CONTROLS 15
16 Figure 6 - YD Unit Piping (Mod B) LD JOHNSON CONTROLS
17 Figure 7 - YD Unit Piping (Mod B) LD14558 JOHNSON CONTROLS 17
18 J1/K1 and J2/K2 Compressors Figure 8 - YD Unit Piping (Mod B) J3/K3, J4/K4, J5 and J7 Compressors LD14562a 18 JOHNSON CONTROLS
19 Figure 9 - YD Unit Piping (Mod B) LD14565a JOHNSON CONTROLS 19
20 EVAPORATOR / CONDENSER Table 4 - YD Evaporator / Condenser (Mod A) ITEM 5 DESCRIPTION PART NUMBER QUANTITY FIGURE Valve, Butterfly Size 5 (J1-J3 X, Y Shells) Valve, Butterfly Size 6 (J4-J5 Z, A Shells) Gasket, Ansi 6-150# Valve, Stop Ang Vertical Valve, Stop Ang Vertical Valve, Stop Ang Vertical O-Ring, Neo id.078thk M O-Ring, Neo id.072thk M O-Ring, Neo id.087thk M Sensor, Temp 3000 Ohms At 25deg Tee, Straight Thread Branch Valve, Ball 6" Flanged Valve, Ball 1 Npti X 1 Npti: Gasket, Seal 1 Od X 7/8 Id X Gasket, Fla 3/4 Od Tube O-Ring, Neo 2.090id.118 Thk Plug, Sight 2-1/4-12Un-2a NOTE: Items with an * are NOT represented. 20 JOHNSON CONTROLS
21 NOTE: J4 Compressor / Z Shells Shown Figure 10 - YD Evaporator / Condenser (Mod A) LD15196 JOHNSON CONTROLS 21
22 Table 5 - YD Evaporator / Condenser (Mod B) ITEM 1 DESCRIPTION PART NUMBER QUANTITY Valve, Butterfly Size 5 (J1-J3, J4 F Shell) Valve, Butterfly Size 6 (J4 E Shell, J5, J7) Gasket, Ansi 6-150# Valve, Stop Ang Vertical Valve, Stop Ang Vertical Valve, Stop Ang Vertical O-Ring, Neo id.078thk M O-Ring, Neo id.072thk M O-Ring, Neo id.087thk M Sensor, Temp 3000 Ohms At 25deg Tee, Straight Thread Branch Valve, Ball 6" Flanged Valve, Ball 1 Npti X 1 Npti: Plug, Hex Hd 3/ Gasket, Seal 1 Od X 7/8 Id X Gasket Fla 3/4 Od Tube: O-Ring, Neo 2.090id.118 Thk Plug, Sight 2-1/4-12Un-2a NOTE: Items with an * are NOT represented. FIGURE 22 JOHNSON CONTROLS
23 NOTE: J4 Compressor / F Shells Shown Figure 11 - YD Evaporator / Condenser (Mod B) LD15197 JOHNSON CONTROLS 23
24 Table 6 - YD Oil Pump Housing (Mod A) ITEM DESCRIPTION PART NUMBER QUANTITY 1 Oil Cooler Seal, O-Ring (1-3/16 ) Seal, O-Ring (1-7/16 ) Valve, Control Thermostatic Seal, O-Ring (1-1/16 ) Tee, Oil Pump Housing Seal, O-Ring (1-5/8 ) Seal, O-Ring (1 11/16 ) Valve, Stop Vertical Angle Seal, O-Ring (1-3/16 ) Seal, O-Ring (1-1/16 ) Block, Oil Eductor Seal, O-Ring (1-3/16 ) Cage, Liquid Level Sight Seal, O-Ring (1/2 ) Valve, Stop Vertical Angle Seal, O-Ring (1 1/16 ) Box, Electrical, 4 Octagon Cover, Filter Output Assembly Oil Pump Housing Seal, O-Ring (1 11/16 ) Oil Heater, Retrofit Kit for 230/60Hz (replaces ) a Heater, 230V 500W Oil Heater, Retrofit Kit for 400/50Hz (replaces ) a Heater, 200V 500W Oil Heater, Retrofit Kit for 460/60Hz (replaces ) a Heater, 230V 500W Valve, Relief 7/8-14unf-2a O-ring, Neoprene.755id.097thk NOTE: Items with an * are NOT represented. Oil Pump Housing FIGURE 24 JOHNSON CONTROLS
25 Figure 12 - YD (Mod A) Oil Pump Housing LD09100 JOHNSON CONTROLS 25
26 Table 7 - YD Oil Pump Housing (Mod B) ITEM DESCRIPTION PART NUMBER QUANTITY 1 O-ring, Neo 16.45id.275thk M Pump, Oil 20 Gpm * 3 Plate, Spacer FIGURE Cooler, Oil K1 Thru K4 Compressor Cooler, Oil K7 Compressor Gage, Liquid Level Sight Front O-Ring, Neo id.070thk M Tee, Union 1-1/2" O-Ring, Neo1 01.9id.118thk M O-Ring, Neo id.070thk M Sleeve, Reducing 1-1/2 To Nut, 1-1/4 O.D. Tube O-Ring, Neo id.070thk M Sleeve, 1" O.D. Tube Nut, 1" O.D. Tube Box, Elec 4 Octagon X 4 Deep O-Ring, Neo id.072thk M Terminal, Hv Fused Glass * 21 Valve, Stop Ang Vertical O-Ring, Neo id.087thk M Block, Oil Eductor YD O-Ring, Neo id.116thk M Valve, Stop Ang Vertical Sensor, Temp 50,000 Ohms Din Valve, Thermal Expansion Filter, In-Line Orfs Elbow, 3/4 O.D.Tube 90 Deg Male Valve, Stop Ang Vertical O-Ring, Neo1 00.7id.103thk M Tee, Union 1-1/ Sleeve, Reducing 1-1/4 To 3/ O-Ring, Neo id.078thk M Reducer, Straight Thread 3/ Oil Pump Housing Volt Heater Volt Heater Volt Heater Volt Heater O-Ring, Neo id.118thk M Term Push-On Str * 52 Term Push On Str * 56 Valve, Stop Ang Vertical Liquid Level Housing JOHNSON CONTROLS
27 TABLE 8 - YD Oil Pump Housing (Mod B) (CONT'D) ITEM DESCRIPTION PART NUMBER QUANTITY 61 Connr, Swivel 3/8 Od Tube Connr, 3/8 Od Tube Male Seal, Washer O Ring O-Ring, Neo id.070thk M Hose, Refrig Orfs 3/4" X 35" Hose, Refrig Orfs 3/4" X 28" Transmitter, with Conduit Box and Connector a Connector, for Transmitter at Conduit Box Gasket, Seal 1 Od X 7/8 Id X Valve, Relief 7/8-14unf-2a (J1, J2) Plug, Hex Hd 7/8 (J3/K3, J4/K4, J5, J7) a O-Ring, Neo id.097thk M NOTE: Items with an * are NOT represented. FIGURE Figure 13 - YD Oil Pump Housing (Mod B) LD09100 JOHNSON CONTROLS 27
28 OIL FILTEr Table 8 - Oil Filter Arrangement ITEM DESCRIPTION SINGLE OIL FILTER PART NUMBER QUANTITY 1 Filter, Oil Seubert Housing (Prior to 2/2012) A Filter Element, Replacement * 1B O-ring, Filter Housing 3.4ID.139THK * 1 Filter, Oil Seubert Housing (After 2/2012) Valve, Stop Angle Vertical Valve, Stop Angle Vertical O-ring, Neoprene.351 ID.072 Thk O-ring, Neoprene.924 ID.116 thk O-ring, Neoprene.739 ID.070 thk Connr, 3/4 OD Tube Male DUAL OIL FILTERS 1 Filter, Oil Seubert Housing A Filter Element, Replacement * 1B O-ring, Filter Housing 3.4ID.139THK * 2 Valve, Stop Angle Vertical Valve, Stop Angle Vertical O-ring, Neoprene.351 ID.072 THK O-ring, Neoprene.924 ID.116 THK O-ring, Neoprene.739 ID.070 thk Connr, 3/4 OD Tube Male Valve, 3-way Ball Tee, Union 3/ NOTE: Items with an * are NOT represented. FIGURE 28 JOHNSON CONTROLS
29 9 Figure 14 - Oil Filter Arrangements LD134 JOHNSON CONTROLS 29
30 PROXIMITY PROBE KIT ( ) Table 9 - Proximity Probe Kit ITEM DESCRIPTION PART NUMBER QUANTITY 1 Probe, Proximity Tip O-Ring, Neo id.064thk M Cable,Connecting Electronics, Module with PVC Bushing Connector, Din Cable,Connecting (to Control Panel) Instructions, Assembly * NOTE: Items with an * are NOT represented. FIGURE Figure 15 - Proximity Probe Kit LD JOHNSON CONTROLS
31 PRV / VGD POSITION SENSOR KIT ( ) FORM RP2 Table 10 - PRV / VGD Position Sensor Kit ITEM DESCRIPTION PART NUMBER QUANTITY 1 Cover, PRV Position Sensor Bracket, Suppport Upper PRV Screw, Tapping Thread Forming POT, 2500 Ohms 2 Watt Bushing, Strain Relief Straight Cable, PRV Sensor VSD Coupling, Shaft, Flexible Screw, Cap Hex Soc Hd # Lockwasher, Hel Spg # Strap, Cable T&B L M Cap, PRV Sensor Shaft, PRV Position Sensor Screw, Washer Assembly NOTE: Items with an * are NOT represented. FIGURE Figure 16 - PRV / VGD Position Sensor Kit LD179 JOHNSON CONTROLS 31
32 SYSTEM WIRING Table 11 - YD System Wiring ITEM DESCRIPTION PART NUMBER QUANTITY 3 Sensor, Temperature 3000 Ohms Contact, Receptacle, 070 Series Collar, Rubber, Black, Connector, Plug Hsg, 3 Pos (RT1, RT4, RT5, RT6, & RT9) Connector, Plug Hsg, 2 Pos (CP, EP, LOP, HOP, PRV, & VGD) * 19 Flow, Sensor Connector Well, Thermo O-Ring, Neo id.087thk M Valve, Ball 3/4-16unf-2a Transducer, Stall O-Ring, Neo id.072thk M Connector, Multi Control FIGURE Sensor, Flow 1/4" Npt Conn Sensor, Flow 1/2" Npt Conn Actuator, Electric Sensor, Temperature 50,000 Ohms Din Complete, Sensor Level Polyolester Assembly a Transmitter, with Conduit Box and Connector b Connector, for Transmitter at Conduit Box Connector, Din Gasket, Seal 1 Od X 7/8 Id X Sensor, Level R-134a Assembly (K1-K2, and K3 E Shell) a Transmitter, with Conduit Box and Connector b Connector, for Transmitter at Conduit Box Sensor, Level R-134a Assembly (K3 F Shell, and K4-K7) a Transmitter, with Conduit Box and Connector b Connector, for Transmitter at Conduit Box Actuator, Electric Connector, Iso 4400/Din NOTE: Items with an * are NOT represented. 32 JOHNSON CONTROLS
33 Figure 17 - YD System Wiring LD15187 JOHNSON CONTROLS 33
34 VARIABLE SPEED OIL PUMP PANEL 200/208V 60Hz, 220/230/240V 60Hz, 380/416V 60Hz, 440/460/0V 60Hz, 380/400/415 50Hz Table 12 - YD Variable Speed Oil Pump Panel ITEM DESCRIPTION PART NUMBER QUANTITY 3 Contactor, W/Suppressor 3 Pole Heatsink, 2 Hp Vsop Drive Block, Terminal Fuse, Cartridge Type 20 Amp Sealant, Silicon Rubber Fuseholder, 1 Pole 30 Amp 600v Fuseholder, 2 Pole 30 Amp 600v Fuseholder, 3 Pole 30 Amp 600v Switch, Disconnect Kit, Door Mtg. Disconnect O-Ring, Neo id.064thk M Switch, High Pressure Cutout Adapter, Bulkhead Conversion FIGURE Oil Pump Drive 2hp Vs 230V (200/208V 60Hz, 220/230/240V 60Hz) Oil Pump Drive 2hp Vs 460V (380/400/415V 50Hz, 440/460/0V 60Hz, 380/416V 60Hz) Transformer Kit (200/208V 60Hz) Transformer Kit (220/230/240V 60Hz) Transformer Kit (440/460/0V 60Hz) Transformer Kit (575/600V 60Hz) Inductor, 230V-VSOP Drive Inductor, 460V-VSOP Drive Fuse, Cartridge Type 15 Amp (200/208/220/230/240V 60Hz) Fuse, Cartridge Type 5 Amp (440/460/0V 60Hz) Fuse, Cartridge Type 6 Amp (380/400/415V 50Hz, 380/416V 60Hz) Fuse, Cartridge Type 15 Amp (200/208V 60Hz) Fuse, Cartridge Type 20 Amp (220/230/240 60Hz) Fuse, Cartridge Type 10 Amp (380/400/415/V 50Hz, 380/416/440/460/0V 60Hz) Fuse, Cartridge Type 12 Amp (200/208/220/230/240V 60Hz) Fuse, Cartridge Type 7 Amp (380/400/415/V 50Hz, 380/416/440/460/0V 60Hz) NOTE: Items with an * are NOT represented. 34 JOHNSON CONTROLS
35 Figure 18 - YD Variable Speed Oil Pump Panel LD15089 JOHNSON CONTROLS 35
36 Table 13 - YD Variable Speed Oil Pump Panel ITEM VARIABLE SPEED OIL PUMP PANEL 346V 50Hz, 575/600V 60Hz DESCRIPTION PART NUMBER QUANTITY 3 Contactor, W/Suppressor 3 Pole Heatsink, 2 Hp VSOP Drive Block, Terminal Fuse, Cartridge Type 20 Amp Sealant, Silicon Rubber Fuseholder, 1 Pole 30 Amp 600v Fuseholder, 2 Pole 30 Amp 600v Fuseholder, 3 Pole 30 Amp 600v Switch, Disconnect Kit, Door Mtg. Disconnect O-Ring, Neo id.064thk M Switch, High Pressure Cutout Adapter, Bulkhead Conversion FIGURE Oil Pump Drive, 2hp Vs 230v (346V 50Hz) Oil Pump Drive, 2hp Vs 460v (575/600V 60Hz) Transformer Kit (346V 50Hz) Transformer Kit (575/600V 60Hz) Transformer (346V 50Hz) Transformer (575/600V 60Hz) Fuse, Cartridge Type 7 Amp (346V 50Hz) Fuse, Cartridge Type 4 Amp (575/600V 60Hz) Fuse, Cartridge Type 20 Amp (346V 50Hz) Fuse, Cartridge Type 8 Amp (575/600V 60Hz) Fuse, Cartridge Type 7 Amp (346/575/600V 60Hz) NOTE: Items with an * are NOT represented. 36 JOHNSON CONTROLS
37 Figure 19 - YD Variable Speed Oil Pump Panel LD15090 JOHNSON CONTROLS 37
38 Relief Valves Evaporator Table 14 - YD Evaporator Relief Valves ITEM DESCRIPTION MOD A PART NUMBER QUANTITY 100 Valve, Relief 1-5/8-12unf-2a (J1, J2) a O-ring, Neo id.118thk (J1, J2) Valve, Relief 1-1/4- x 2 Npti (J3-J5) Flange, Relief Valve Companion (J3-J5) MOD B 100 Valve, Relief 1-5/8-12unf-2a (J1, J2) a O-ring, Neo id.118thk (J1, J2) Valve, Relief 1-1/4- x 2 Npti (J3-J5, J7) Flange, Relief Valve Companion (J3-J5, J7) NOTE: Items with an * are NOT represented. FIGURE 38 JOHNSON CONTROLS
39 a a Figure 20 - YD Evaporator Relief Valves LD13049c JOHNSON CONTROLS 39
40 Relief Valves CONDENSER Table 15 - YD Condenser Relief Valves ITEM DESCRIPTION MOD A-B PART NUMBER QUANTITY 45 Valve, Stop 3-Way 1-5/8 (J1, J2) a O-ring, Neo id.118thk (J1, J2) Valve, Relief 1-5/8-12un-2a (J1, J2) a O-ring, Neo id.118thk (J1, J2) Valve, Stop 3-Way 1-5/16 (J1, J2) a O-ring, Neo 01.17id.116thk (J1, J2) Valve, Relief 1-5/16-12un-2a (J1, J2) a O-ring, Neo 01.17id.116thk (J1, J2) Valve, Relief (J3-J5, J7) a O-ring, Neo id.118thk (J3-J5, J7) Valve, Stop Dual Manifold (J3-J5, J7) Adapter, Male Pipe (J3-J5, J7) a O-ring, Neo id.118thk (J3-J5, J7) NOTE: Items with an * are NOT represented. FIGURE 45 45a 46 46a 47 47a a a MOD A-B Figure 21 - YD Condenser Relief Valves LD13049b 40 JOHNSON CONTROLS
41 SHELL CODE 3/4" CONDENSER TUBES (Mod A) Table 16-18' Condenser Shells With 3/4" Tubes TUBE QTY. STANDARD OPTIONS COND XA 1826 XB 1992 XC 2183 XD 2233 YA 2220 YB 2496 YC 2777 YD 2900 ZA 2670 ZB 2977 ZC 3218 ZD 3353 AA 3158 AB 3539 AC 3757 AD 3973 SUB COOLER Wall.028 Wall.035 Wall.028 Wall.035 Wall.028 Wall.035 Wall MT #260 MT #261 MT #262 MT #201 MT #203 MT #225 MT # SHELL CODE COND XA 1826 XB 1992 XC 2183 XD 2233 YA 2220 YB 2496 YC 2777 YD 2900 ZA 2670 ZB 2977 ZC 3218 ZD 3353 AA 3158 AB 3539 AC 3757 AD 3973 TUBE QTY. SUB COOLER OPTIONS.025 Wall.028 Wall.035 Wall MT #230 MT #231 MT # JOHNSON CONTROLS 41
42 3/4" EVAPORATOR TUBES (Mod A) Table 17-18' Evaporator Shells With 3/4" Tubes SHELL CODE TUBE QTY. XF 1,493 STANDARD OPTIONS.025 Wall.028 Wall.035 Wall.028 Wall.035 Wall.025 Wall.028 Wall.035 Wall MT #271 MT #272 MT # 273 MT #177 MT #179 MT #181 MT #182 MT #183 XH 1,742 YF 2,004 YG 2,258 YH 2,504 ZF 2, ZG 2,822 ZH 3,126 AF 2,888 AG 3,176 AH 3,5 42 JOHNSON CONTROLS
43 SHELL CODE TUBE QTY. 3/4" CONDENSER TUBES (Mod B) Table 18-18' And 22' Condenser Shells With 3/4" Tubes COND BB 1 1,826 BC 1 1,993 BD 1 2,112 CB 2 1,799 CC 2 2,029 CD 2 2,325 DB 1 2,220 DC 1 2,496 DD 1 2,777 EB 2 2,220 EC 2 2,496 ED 2 2,504 FB 1 2,668 FC 1 2,978 FD 1 3,221 GB 2 2,668 GC 2 2,978 GD 2 3,221 HB 1 3,158 HC 1 3,539 HD 1 3,754 KB 2 3,158 KC 2 3,539 KD 2 3,754 NOTE: 1 = 18' Condenser Shells 2 = 22' Condenser Shells SUB COOLER STANDARD OPTIONS.025 Wall.028 Wall.035 Wall.028 Wall.035 Wall.028 Wall.035 Wall MT #260 MT #261 MT # 262 MT #201 MT #203 MT #225 MT # JOHNSON CONTROLS 43
44 SHELL CODE TUBE QTY. 1" CONDENSER TUBES (Mod B) Table 19-18' And 22' Condenser Shells With 1" Tubes COND B B B4 1 1,053 B5 1 1,171 C C C4 2 1,215 D2 1 1,071 D3 1 1,190 D4 1 1,321 D5 1 1,507 E2 2 1,071 E3 2 1,190 E4 2 1,321 E5 2 1,507 F2 1 1,293 F3 1 1,438 F4 1 1,597 F5 1 1,774 G2 2 1,293 G3 2 1,438 G4 2 1,597 G5 2 1,774 H2 1 1,474 H3 1 1,638 H4 1 1,819 H5 1 2,077 K2 2 1,474 K3 2 1,638 K4 2 1,819 K5 2 2,077 NOTE: 1 = 18' Condenser Shells 2 = 22' Condenser Shells SUB COOLER STANDARD OPTIONS.025 Wall.028 Wall.035 Wall.028 Wall MT #266/260 MT #267/261 MT #268/262 MT #317/261 C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= C= S= JOHNSON CONTROLS
45 3/4" EVAPORATOR TUBES (Mod B) Table 20-18' And 22' Evaporator Shells With 3/4" Tubes SHELL CODE TUBE QTY. BB 1 1,215 BC 1 1,4 BD 1 1,742 CB 2 1,537 CC 2 1,699 CD 2 1,850 DB 1 2,004 DC 1 2,258 DD 1 2,504 EB 2 2,004 EC 2 2,258 ED 2 2,504 FB 1 2,522 FC 1 2,822 FD 1 3,126 GB 2 2,522 GC 2 2,822 GD 2 3,126 HB 1 2,888 HC 1 3,176 HD 1 3,5 KB 2 2,888 KC 2 3,176 KD 2 3,5 NOTE: 1 = 18' Evaporator Shells 2 = 22' Evaporator Shells STANDARD OPTIONS.025 Wall.028 Wall.035 Wall.028 Wall.035 Wall MT #271 MT #272 MT #273 MT #177 MT # JOHNSON CONTROLS 45
46 1" EVAPORATOR TUBES (Mod B) Table 21-18' And 22' Evaporator Shells With 1" Tubes SHELL CODE TUBE QTY. B B B C C C4 2 1,063 D2 1 1,064 D3 1 1,178 D4 1 1,298 E2 2 1,064 E3 2 1,178 E4 2 1,298 F2 1 1,332 F3 1 1,0 F4 1 1,642 G2 2 1,332 G3 2 1,0 G4 2 1,642 H2 1 1,490 H3 1 1,656 H4 1 1,840 K2 2 1,490 K3 2 1,656 K4 2 1,840 NOTE: 1 = 18' Evaporator Shells 2 = 22' Evaporator Shells STANDARD OPTIONS.025 Wall.028 Wall.035 Wall.025 Wall.028 Wall.035 Wall MT#286 MT #287 MT #288 MT #326 MT #327 MT # JOHNSON CONTROLS
47 EVAPORATOR Compact WATERBOX Table 22 - Evaporator 150# Compact Waterbox (Mod A) SHELL XF XH YF YG YH ZF ZG ZH AF AG AH 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 6' 6' 6' 6' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 12' 12' 12' 12' 1 PASS 2 PASS 3 PASS Figure 22 - Evaporator 150# Compact Waterbox (Mod A) LD15198 JOHNSON CONTROLS 47
48 Table 23 - Evaporator 300# Compact Waterbox (Mod A) SHELL XF XH YF YG YH ZF ZG ZH AF AG AH 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 6' 6' 6' 6' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 12' 12' 12' 12' 1 PASS 2 PASS 3 PASS LD15199 Figure 23 - Evaporator 300# Compact Waterbox (Mod A) JOHNSON CONTROLS
49 CONDENSER Compact WATERBOX Table 24 - Condenser 150# Compact Waterbox (Mod A) SHELL XA XB XC XD YA YB YC YD ZA ZB ZC ZD AA AB AC AD 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 28' 28' 28' 28' 4.5' 28' 5' 33' 5.5' 35' 5.5' 35' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 8.5' 28' 10' 33' 11' 35' 11' 35' 1 PASS 2 PASS 3 PASS Figure 24 - Condenser 150# Compact Waterbox (Mod A) LD15192 JOHNSON CONTROLS 49
50 Table 25 - Condenser 300# Compact Waterbox (Mod A) SHELL XA XB XC XD YA YB YC YD ZA ZB ZC ZD AA AB AC AD 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 33' 33' 33' 33' 5' 33' 5' 33' 5.5' 35' 5.5' 35' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 10' 33' 10' 33' 11' 35' 11' 35' 1 PASS 2 PASS 3 PASS Figure 25 - Condenser 300# Compact Waterbox (Mod A) LD JOHNSON CONTROLS
51 EVAPORATOR MARINE WATERBOX Table 26 - Evaporator 150# Marine Waterbox (Mod A) SHELL XF XH YF YG YH ZF ZG ZH AF AG AH 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 76' 76' 76' 76' 12' 57' 12' 57' 12' 57' 12' 57' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 23.5' 76' 23.5' 76' 227' 86' 227' 86' 1 PASS 2 PASS 3 PASS Figure 26 - Evaporator 150# Marine Waterbox (Mod A) LD15383 JOHNSON CONTROLS 51
52 Table 27 - Evaporator 300# Marine Waterbox (Mod A) SHELL XF XH YF YG YH ZF ZG ZH AF AG AH 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 76' 76' 76' 76' 23.5' 57' 23.5' 57' 23.5' 57' 23.5' 57' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 23.5' 76' 23.5' 76' 28.5' 92' 28.5' 92' 1 PASS 2 PASS 3 PASS LD15385 Figure 27 - Evaporator 300# Marine Waterbox (Mod A) 52 JOHNSON CONTROLS
53 CONDENSER MARINE WATERBOX Table 28 - Condenser 150# Marine Waterbox (Mod A) SHELL XA XB XC XD YA YB YC YD ZA ZB ZC ZD AA AB AC AD 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 66' 66' 66' 66' 10' 49.5' 10' 49.5' 12' 57' 12' 57' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 20' 66' 20' 66' 24' 76' 24' 76' 1 PASS 2 PASS 3 PASS Figure 28 - Condenser 150# Marine Waterbox (Mod A) LD15386 JOHNSON CONTROLS 53
54 Table 29 - Condenser 300# Marine Waterbox (Mod A) SHELL XA XB XC XD YA YB YC YD ZA ZB ZC ZD AA AB AC AD 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D 66' 66' 66' 66' 10' 49.5' 10' 49.5' 11' 52.5' 11' 52.5' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 19.5' 66' 19.5' 66' 12' 12' 1 PASS 2 PASS 3 PASS LD15385 Figure 29 - Condenser 300# Marine Waterbox (Mod A) 54 JOHNSON CONTROLS
55 EVAPORATOR Compact WATERBOX Table 30 - Evaporator 150# Compact Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B C D/E F/G H/K 6' 6' 6' 6' 6' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 12' 12' 12' 14' 43' 14' 43' 1 PASS 2 PASS 3 PASS Figure 30 - Evaporator 150# Compact Waterbox (Mod B) LD15388 JOHNSON CONTROLS 55
56 Table 31 - Evaporator 300# Compact Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B C D/E F/G H/K 6' 6' 6' 6' 6' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 12' 12' 12' 14' 43' 14' 43' 1 PASS 2 PASS 3 PASS LD15189 Figure 31 - Evaporator 300# Compact Waterbox (Mod B) 56 JOHNSON CONTROLS
57 CONDENSER Compact WATERBOX Table 32 - Condenser 150# Compact Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B 28' C 28' D/E 28' F/G 28' H/K 28' 4.5' 28' 5' 33' 5' 33' 5.5' 35' 5.5' 35' 9.25' 30.25' 9.25' 30.25' 10' 33' 11' 35' 11' 35' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 1 PASS 2 PASS 3 PASS Figure 32 - Condenser 150# Compact Waterbox (Mod B) LD15392 JOHNSON CONTROLS 57
58 Table 33 - Condenser 300# Compact Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B 33' C 33' D/E 33' F/G 33' H/K 33' 4.5' 28' 5' 33' 5' 33' 5.5' 35' 5.5' 35' 9.25' 30.25' 9.25' 30.25' 10' 33' 11' 35' 11' 35' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 1 PASS 2 PASS 3 PASS Figure 33 - Condenser 300# Compact Waterbox (Mod B) LD JOHNSON CONTROLS
59 EVAPORATOR MARINE WATERBOX Table 34 - Evaporator 150# Marine Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B 76' C 76' D/E 76' F/G 76' H/K 76' 12' 57' 12' 57' 12' 57' 12' 57' 12' 57' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 23' 76' 23' 76' 23.5' 76' 27' 86' 27' 86' 1 PASS 2 PASS 3 PASS Figure 34 - Evaporator 150# Marine Waterbox (Mod B) LD15190 JOHNSON CONTROLS 59
60 Table 35 - Evaporator 300# Marine Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B 76' C 76' D/E 76' F/G 76' H/K 76' 23.5' 57' 23.5' 57' 23.5' 57' 23.5' 57' 23.5' 57' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 23.5' 76' 23.5' 76' 23.5' 76' 26.5' 86' 26.5' 86' 1 PASS 2 PASS 3 PASS Figure 35 - Evaporator 300# Marine Waterbox (Mod B) LD JOHNSON CONTROLS
61 CONDENSER MARINE WATERBOX Table 36 - Condenser 150# Marine Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B 56' C 56' D/E 56' F/G 56' H/K 56' 9' 42' 9.5' 45' 9.5' 45' 10' 49' 10' 49' 18.25' 60' 18.25' 60' 20' 66' 22' 70' 22' 70' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 1 PASS 2 PASS 3 PASS Figure 36 - Condenser 150# Marine Waterbox (Mod B) LD15194 JOHNSON CONTROLS 61
62 Table 37 - Condenser 300# Marine Waterbox (Mod B) SHELL 1 PASS 2 PASS 3 PASS GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D GASKET P/N FEET REQ'D B 56' C 56' D/E 56' F/G 56' H/K 56' 9' 42' 9.5' 45' 9.5' 45' 11' 52.5' 11' 52.5' 18.25' 60' 18.25' 60' 19.5' 66' 22' 70' 22' 70' NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'. 1 PASS 2 PASS 3 PASS Figure 37 - Condenser 300# Marine Waterbox (Mod B) LD JOHNSON CONTROLS
63 INLET CHILLED WATER STRAINER COMPACT HEADS AND MARINE WATERBOXES NOZZLE SIZE PART NUMBER MOTOR VOLTAGE 200/ CURRENT TRANSFORMER KIT AND TRANSFORMER ONLY Use with factory-mounted motors only FLA "CT" RATIO TRANSFORMER KIT (Includes Transformer) PART NUMBER TRANSFORMER ONLY : : : : : : : : : JOHNSON CONTROLS 63
64 MULTIPLE UNIT SEQUENCE KIT CONTROLS TWO UNIT ITEM DESCRIPTION PART NUMBER QUANTITY 11 Controller, RWT Relay, Time Delay Switch, Toggle Not Shown. Remote Mounted. THREE UNIT ITEM DESCRIPTION PART NUMBER QUANTITY 2 Control, Temp 2 Stage Relay, TD 115V Relay, Control 120V Coil Relay Assy Switch, Toggle 3 Position Switch, Toggle FOUR UNIT ITEM DESCRIPTION PART NUMBER QUANTITY 2 Control, Temp. 3-Stage Relay, TD 115V Relay Assy Relay, Control 120V Coil Switch, Toggle Switch, Rotary 4 Ckt 15A LD JOHNSON CONTROLS
65 DESCRIPTION MISCELLANEOUS AND ACCESSORIES DESCRIPTION STEEL TUBING COMPOUNDS COMMON PIPING PARTS STAINLESS STEEL TUBING NUT PART NUMBER STEEL SLEEVE QUANTITY Compound, Heat Conductive (for Thermometer Wells) oz. Grease, POE lb. Lub, Valve Stem oz. Primer, Locquic Grade N oz. Sealer, Gasket Eliminator ml Sealer, Grade AVV Loctite ml Sealer, Refrigerant Pipe ml Sealer, Removable Thread ml STAINLESS STEEL SLEEVE 3/8" /2" /4" " FLOW SWITCH CONTROL Description Part Number 150 DWP DWP TEMPERATURE RECORDER HZ Description Number Of Pens Part Number DIFFERENTIAL PRESSURE CONTROL Description Part Number Control, Differential Pressure* *300 PSI Maximum Working Pressure TOUCH-UP PAINTS - SPRAY CANS Description Caribbean Blue Enamel Black (Control Center) Part Number Purchase Locally JOHNSON CONTROLS 65
66 P.O. Box 1592, York, Pennsylvania USA Subject to change without notice. Printed in USA Copyright by Johnson Controls ALL RIGHTS RESERVED Form RP2 (915) Issue Date: September 15, 2015 Supersedes: RP2 (313)
Supersedes: RP1(495) Form RP1 (1102)
RENEWAL PARTS CENTRIFUGAL LIQUID CHILLERS Supersedes: 0.9-RP(9) Form 0.9-RP (0) UNIT COMPONENTS MODEL YK (STYLES A & B) WITH MICROCOMPUTER CONTROL CENTER PART #3-000-00 FOR ELECTRO-MECHANICAL STARTER &
More informationMODEL YR T0 - T3 MOD LEVEL A-C. 200 thru 430 tons (60 hz) 170 thru 365 tons (50 hz) 600 thru 1280 KW (50 hz)
MODEL YR T0 - T3 MOD LEVEL A-C ROTARY SCREW LIQUID CHILLERS renewal parts Supersedes: 160.81-RP5 (710) Form 160.81-RP5 (1113) 200 thru 430 tons (60 hz) 700 thru 1500 Kw (60 HZ) 170 thru 365 tons (50 hz)
More informationNOTE: Inserted Literature Supplement - YT Style "J" Chillers New Style Oil Filter/"O"-Ring
MILLENNIUM TM CENTRIFUGAL LIQUID CHILLERS RENEWAL PARTS Supersedes: 160.48-RP5(LS2)(800) UNIT COMPONENTS MODEL YT STYLE J Form 160.48-RP6 (501) NOTE: Inserted Literature Supplement - YT Style "J" Chillers
More informationINSTALLATION & OPERATION MANUAL. Dual Duct VAV Terminals. Redefine your comfort zone.
INSTALLATION & OPERATION MANUAL Dual Duct VAV Terminals IOM Dual Duct VAV Terminals IMPORTANT! READ BEFORE PROCEEDING! GENERAL SAFETY GUIDELINES This equipment is a relatively complicated apparatus. During
More informationCENTRIFUGAL COMPRESSORS
CENTRIFUGAL COMPRESSORS RENEWAL PARTS Supersedes: 60.49-RP2 (27) Form 60.49-RP2 (37) COMPRESSOR MODEL YDHA-36 and LHA-36 YDHA-4 and LHA-4 YDHA-46 and LHA-46 YPHA-50N and LHA-50N YDHA-50W and LHA-50W HA-57,
More informationMODELS YLAA YLAA0175 DESIGN SERIES A, B & C DEVELOPMENT LEVEL A
AIR-COOLED SCROLL CHILLERS RENEWAL PARTS Supersedes: 50.72-RP (80) Form 50.72-RP () MODELS YLAA0070 - YLAA075 DESIGN SERIES A, B & C DEVELOPMENT LEVEL A GS5608 R-0A 70-75 TON 60 Hz Issue Date: January,
More informationGM Series Dual-Block Multi-Function Gas Control Valves
Installation Sheets Manual 121 Gas Combustion Combination Controls and Systems Section G Technical Bulletin GM Issue Date 0297 GM Series Dual-Block Multi-Function Gas Control Valves Figure 1: GM Series
More informationPressure Dump Valve Service Kit for Series 2300 Units
Instruction Sheet Pressure Dump Valve Service Kit for Series 00 Units. Overview The Nordson pressure dump valve is used to relieve hydraulic pressure instantly in Series 00 applicator tanks when the unit
More informationWaterSource Heat Pump Hose Kit Performance Specification-Summary
WaterSource Heat Pump Hose Kit Performance Specification-Summary AUTOMATIC & MANUAL BALANCING HOSE KITS Contractor shall provide and install Hays Hose Kits. Each kit, shall include a Hays 2500 Series Mesurflo
More informationCrest Heating Boilers FBN(L) Series &
Replacement Parts List PARTS & SERVICE DEPARTMENT Nashville, Tennessee 877-554-5544 Fax: 615-882-2918 parts_team@lochinvar.com www.lochinvar.com Crest Heating Boilers FBN(L) 751-2001 Series 100-101 & 110-111
More informationPressure Dump Valve Service Kit for Series 3000 Units
Instruction Sheet Pressure Dump Valve Service Kit for Series 000 Units. Overview The Nordson pressure dump valve is used to relieve hydraulic pressure instantly in Series 00, 400, 500, and 700 applicator
More informationFOR INSTALLING CO 2 BLENDER KIT (P/N IN BEER SYSTEM
IMI CORNELIUS INC One Cornelius Place Anoka, MN 55303-623 Telephone (800) 238-3600 Facsimile (612) 22-326 INSTALLATION INSTRUCTIONS FOR INSTALLING CO 2 BLENDER KIT (P/N 111612000 IN BEER SYSTEM SECONDARY
More informationOperating Instructions Models and Hydrostatic Test Pumps
Operating Instructions Models 33100 and 33101 Hydrostatic Test Pumps 33100 DIMENSIONS: WEIGHT: PUMP: MOTOR: CONTROL: GAUGE: DISCHARGE HOSE: 16 (40cm) L x 22 (55cm) W x 18 (45cm) H 87 lbs., 39.5 kg Triplex
More informationOperating Instructions
Operating Instructions ProMinent CO2 Feeder CO2 - ProMinent P/N: 7746944 (Revision C), Date 09-14-12 Please completely read through these operating instructions first! Do not discard! The warranty shall
More informationBGA158 Series CE Approved Class A Shutoff Gas Valve
Installation Instructions BGA158 Issue Date August 24, 2011 BGA158 Series CE Approved Class A Shutoff Gas Valve Applications The BGA158 Series shutoff gas valve is an electrically operated gas valve that
More informationG196 Series BASOTROL Redundant Combination Gas Valve with Manual Shutoff Valve
Installation Instructions Issue Date August 19, 2008 G196 Series BASOTROL Redundant Combination Gas Valve with Manual Shutoff Valve Application The G196 valves are suitable for use with natural gas, Liquefied
More informationTWC Services, Inc. Structured On-The-Job Training for JT- 1, 2, 3
TWC Services, Inc. Structured On-The-Job Training for JT- 1, 2, 3 The following tasks parallel the Jr. Tech (JT-1, 2, 3) description and development plan and use the Refrigeration and Air conditioning
More informationG196 Series BASOTROL Redundant Combination Gas Valve with Manual Shutoff Valve
Installation Instructions Issue Date March 13, 2013 G196 Series BASOTROL Redundant Combination Gas Valve with Manual Shutoff Valve Application The G196 valves are suitable for use with natural gas, Liquefied
More informationRIX COMPRESSORS. MICROBOOST Owner s Manual CONFIGURATION A MB-115 MB-230. November 21, 2002 APPLICABILITY [ A]
RIX COMPRESSORS MICROBOOST Owner s Manual CONFIGURATION A MB-115 MB-230 November 21, 2002 APPLICABILITY [ A] INTRODUCTION Safety This electromechanical equipment is designed to produce high pressure gas.
More informationG96 Series BASOTROL Dual Operator Valve
Installation Instructions 9. Issue Date February 22, 2013 G96 Series BASOTROL Dual Operator Valve Applications The G96 valves are combination, dual operator, automatic valves available with or without
More informationSpare parts list ( ) Spare parts list HDS 990
Spare parts list (5.952-855.0) Spare parts list HDS 990 13.10.2014 www.kaercher.com EN Page 2 Page 3 Page 4 Table of contents Spare parts list HDS 990 (5.952-855.0)... 6 10 Individual parts... 7 49 Spare
More informationSpare parts list ( ) Spare parts list HDS 700 B
Spare parts list (5.955-875.0) Spare parts list HDS 700 B 02.09.2013 www.kaercher.com EN Page 2 Page 3 Page 4 Table of contents Spare parts list HDS 700 B (5.955-875.0)... 6 10 Individual parts... 7 11
More information14. Exploded View. Page 68
14. Exploded View Page 68 15. View of housing Page 69 11. Spare Parts HY05 HY13 55 E-2124010 Keys for safety, set=2pc. 54 E-2124012 Safety lock incl. 2 keys 1 B-3204031 1 B-2204101 1 B-2204111 1 2 B-2204105
More informationGM-7000 Series CE Approved Gas Control Valve
Installation Instructions GM-7000 Issue Date November 9, 2012 GM-7000 Series CE Approved Gas Control Valve Installation IMPORTANT: These instructions are intended as a guide for qualified personnel installing
More informationK Page 1 of 48 Air Intake - Pg. 17
K532-53168 Page 1 of 48 Air Intake - Pg. 17 Ref # Part Number Qty Description 24 25 041 06-S 1 Gasket, elbow 25 48 054 09 1 Elbow, air cleaner Discontinued not available at Kohler Co. 35 277116-S 1 Brace,
More informationBGA158 Series CE Approved Class B Shutoff Gas Valve
Installation Instructions BGA158 Issue Date March 22, 2016 BGA158 Series CE Approved Class B Shutoff Gas Valve Applications The BGA158 Series shutoff gas valve is an electrically operated shutoff valve
More informationPROPORTIONING VALVE. Model 150 INSTRUCTION MANUAL. March 2017 IMS Company Stafford Road
PROPORTIONING VALVE Model 150 INSTRUCTION MANUAL March 2017 IMS Company 10373 Stafford Road Telephone: (440) 543-1615 Fax: (440) 543-1069 Email: sales@imscompany.com 1 Introduction IMS Company reserves
More information2 Overview. SITRANS P measuring instruments for pressure. Transmitters for gage and absolute pressure. Z series for gage pressure
Z series for gage pressure Overview Design The main components of the pressure transmitter are: Brass housing with silicon measuring cell and electronics plate Process connection Electrical connection
More informationTECHNICAL DATA. Trimpac 257a. September 16, 2013
September 16, 2013 Trimpac 257a 1. DESCrIpTION DESCRIPTION The Viking Double SUREFIRE SIngle Interlock Preaction TRIMPAC Model D-2 and D-2B used with either a Model E or F Deluge Valve (A.1), a Viking
More informationBudget Range Operators Handbook
Budget Range Operators Handbook BAMBI AIR COMPRESSORS LTD 152 Thimble Mill Lane Heartlands Birmingham B7 5HT United Kingdom Tel: 0121 322 2299 Fax: 0121 322 2297 Email: sales@bambi-air.co.uk www.bambi-air.co.uk
More informationTECHNICAL DATA. Trimpac 251a. Spetember 16, 2013
Spetember 16, 2013 Trimpac 251a 1. DEsCrIpTION DESCRIPTION TRIMPAC Model B-6 and B-6B is a factory assembled trim package for a double interlocked preaction system with an electric/pneu-lectric release
More informationSPECIFICATIONS Type: Twin stack, single phase Tank: 4 gallon Air Output: PSI; PSI Max PSI: 125 PSI HP: 1.
2 GALLON TWIN STACK AIR COMPRESSOR Model: 9526 DO NOT RETURN TO STORE. Please CALL 800-348-5004 for parts and service. CALIFORNIA PROPOSITION 65 WARNING: You can create dust when you cut, sand, drill or
More informationBGA158, BGA171 and BGA110 Series Shutoff Gas Valve
Installation Instructions BGA Series Issue Date October 3, 2017 BGA158, BGA171 and BGA110 Series Shutoff Gas Valve Applications The BGA Series shutoff gas valve is an electrically operated gas valve that
More information11. Spare Parts. applications since applications since
2 8 2 6 20 2 8 0 5 6 8 9 2 2 25 7 8 9 5 0 2 2 7 . Spare Parts * C0 C02 C06 C0 C7 C C0 C5 C58 Article No. Description B-26 B-2009 Steam generation Steam cylinder CY DN20 compl. with electrodes and hand
More informationDual Solenoid Gas Valve Installation
Installation IMPORTANT: These instructions are intended as a guide for qualified personnel installing or servicing FLYNN Gas Products. Carefully follow all instructions in this bulletin and all instructions
More informationThis parts list is current as of the above revision date. See for the current revision.
Parts List This parts list is current as of the above revision date. See http://www.rheempartslists.net/92-42800-.pdf for the current revision. Heat Pumps - Commercial Table of Contents Model Explanation...................................................................................................................
More informationTECHNICAL DATA. Trimpac 244a. September 16, 2013
September 16, 2013 Trimpac 244a 1. DEsCrIpTION DESCRIPTION TRIMPAC Model B-1 and B-1B is a factory-assembled trim package with an electric release module in a metal enclosure. The standard trim normally
More informationTECHNICAL DATA. Trimpac 256a. October 31, 2013
October 31, 2013 Trimpac 256a 1. DESCRIPTION The Viking SUREFIRE SIngle Interlock Preaction TRIMPAC Model D-1 and D- 1B used with either a Model E or F Deluge Valve (A.1), a Viking Easy Riser check valve
More informationINSTRUCTION MANUAL MST AFTERCOOLER SYSTEM MODEL
INSTRUCTION MANUAL MST AFTERCOOLER SYSTEM MODEL 8059601 To be used with MST Model 8050501 Ambient Air Pump 7/12/05 2 TABLE OF CONTENTS GENERAL INFORMATION... 3 WARNING...4,5 UNPACKING AND AFTERCOOLER ASSEMBLY
More informationSITRANS P measuring instruments for pressure
SITRANS P measuring instruments for pressure Z series for gage pressure Siemens AG 008 Overview Design The main components of the pressure transmitter are: Brass housing with silicon measuring cell and
More informationULTRA HIGH PRESSURE PAINT GRATE CLEANER FCT-JS OPERATION AND MAINTENANCE MANUAL
ULTRA HIGH PRESSURE PAINT GRATE CLEANER FCT-JS OPERATION AND MAINTENANCE MANUAL 466 S. Skylane Drive DURANGO, COLORADO 81303 970-259-2869 PHONE 970-259-2868 FAX www.stoneagetools.com sales@stoneagetools
More information2 GALLON TWIN STACK AIR COMPRESSOR W/ HOSE REEL
2 GALLON TWIN STACK AIR COMPRESSOR W/ HOSE REEL Model: 52024 CALIFORNIA PROPOSITION 65 WARNING: You can create dust when you cut, sand, drill or grind materials such as wood, paint, metal, concrete, cement,
More informationModel PSI Compressor with 3-Gallon Air Tank 12VDC
Model 6350 150 PSI Compressor with 3-Gallon Air Tank 12VDC IMPORTANT: It is essential that you and any other operator of this product read and understandd the contents of this manual before installing
More informationData sheet Pressure switch type CS December 2001 DKACT.PD.P10.A B1119
Pressure switch type CS December 2001 DKACT.PD.P10.A2.02 520B1119 Introduction Pressure switch type CS is part of the Danfoss pressure control range. All CS pressure switches have a built-in pressure-operated,
More informationInstallation Instructions
48011HW NATURAL GAS TO PROPANE CONVERSION KIT 58HDX, 359AAV, PG9YAB, PG9YAA Installation Instructions SAFETY REQUIREMENTS Installing and servicing heating equipment can be hazardous due to gas and electrical
More informationBARNES PROSSER CROWN SERVICE PARTS
MODEL PART NO. SGV3002L 084798 SGV3022L 084799 SGV3062L 084800 SGV3032L 084801 SGV3042L 084802 SGV3052L 088861 SGV5002L 084803 SGV5022L 084804 SGV5062L 084805 SGV5032L 084806 SGV5042L 084807 SGV5052L 088862
More informationTECHNICAL DATA. TRIMPAC Model B-5 & B-5B
September 16, 2013 Trimpac 250a 1. DESCRIPTION DEsCRIPTIoN is a factory assembled trim package for a ed an electric/pneumatic release module in a metal enclosure. The standard trim normally required on
More informationGS-20/25 and GS-40/45 Series Single-block Multi-function Gas Control Valves
Installation Sheets Manual 121 Gas Combustion Combination Controls and Systems Section G Technical Bulletin GS-20/25 GS-40/45 Issue Date 1298 GS-20/25 and GS-40/45 Series Single-block Multi-function Gas
More informationSpare parts list ( ) Spare parts list HDS 5.0/30 S-4 Eh
Spare parts list (5.970-508.0) Spare parts list HDS 5.0/30 S-4 Eh 21.05.2012 www.kaercher.com EN Page 2 Page 3 Page 4 Table of contents Spare parts list HDS 5.0/30 S-4 Eh (5.970-508.0)... 6 10 Housing
More informationGX200 QX2 ENGINE, JPN, VIN# GCAE Page 1 of 34 AIR CLEANER (DUAL)
GX200 QX2 ENGINE, JPN, VIN# GCAE-1000001 Page 1 of 34 AIR CLEANER (DUAL) GX200 QX2 ENGINE, JPN, VIN# GCAE-1000001 Page 2 of 34 Ref # Part Number Qty Description AIR CLEANER (DUAL) 1 16271-ZE1-000 1 GASKET,
More information36C/36D HSI, DSI Proven Pilot Gas Valves INSTALLATION INSTRUCTIONS
36C/36D HSI, DSI Proven Pilot Gas Valves INSTALLATION INSTRUCTIONS Operator: Save these instructions for future use! FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLING OR OPERATING
More informationThis parts list is current as of the above revision date. See for the current revision.
Parts List This parts list is current as of the above revision date. See http://www.rheempartslists.net/92-42800-.pdf for the current revision. Condensing Units Table of Contents Model Explanation...................................................................................................................
More informationD. ACCESSORIES ADAPTER KITS IMPELLER & SEAL INSTALLATION TOOLS CARRYING HANDLES & LIFT CORDS GALVANIC PROTECTION KITS MUSHROOM STRAINER
. ACCESSORIES AAPTER KITS IMPELLER & SEAL INSTALLATION TOOLS CARRYING HANLES & LIFT CORS GALVANIC PROTECTION KITS MUSHROOM STRAINER SLUGE STRAINERS NEMA 4 WATERTIGHT CONTROL & UAL LEVEL CONTROL (Replaces
More informationG92 Series BASOTROL Automatic Pilot Gas Valve
Installation Instructions Issue Date September 17, 2008 G92 Series BASOTROL Automatic Pilot Gas Valve Installation IMPORTANT: Only qualified personnel should install or service BASO Gas Products. These
More informationPipe threads for tubes and fittings where pressure-tight joints are not made on the threads. (requires PTFE sealing tape or liquid sealant).
Fittings for CO 2 Pipe Threads Pipe thread references quoted in this catalogue conform with the requirements specified in the latest issue and amendments of the following ISO Standards: ISO 7-1 (BS21)
More informationOPERATOR S MANUAL 1.5 HP/6-GALLON 6 GAL AIR COMPRESSOR IMPORTANT: READ OPERATOR S MANUAL BEFORE USING. Toll Free Helpline:
ITEM# 0306 SKU# 07-55 OPERATOR S MANUAL.5 HP/6-GALLON 6 GAL AIR COMPRESSOR IMPORTANT: READ OPERATOR S MANUAL BEFORE USING Toll Free Helpline: -888-899-06 VY03A36669 TABLE OF CONTENTS Specifications------------------------------------------------------------------------------------------------
More informationInstruction Manual Updated 7/26/2011 Ver. 2.2
4-Unit Model MB HTHP Filter Press #171-50-4: 115-Volt #171-51-4: 230-Volt Instruction Manual Updated 7/26/2011 Ver. 2.2 OFI Testing Equipment, Inc. 11302 Steeplecrest Dr. Houston, Texas 77065 U.S.A. Tele:
More informationMedia-Isolated Mag Plus Probe Low Pressure-ISO Kit
Manual No: 577013-975 Revision: B Media-Isolated Mag Plus Probe Low Pressure-ISO Kit Installation Guide Notice Veeder-Root makes no warranty of any kind with regard to this publication, including, but
More informationSafety Please read and keep in a safe place Operating instructions Linear flow control VFC Linear flow control with actuator IFC
07 Elster GmbH Edition 06.7 Translation from the German 058 D GB F NL I E DK S N P GR TR CZ PL RUS H www.docuthek.com Operating instructions Linear flow control VFC Linear flow control with actuator IFC
More informationCode AWC20HP Air Compressor
Code 951816 AWC20HP Air Compressor Index of Contents Index of Contents 02 Declaration of Conformity 02 What s Included 03 Safety Precautions 03 Specifications (AWC20HP Air Compressor) 04 Assembly Instructions
More informationOperating Instructions Models 36200, , 46200, Hydrostatic Test Pumps
Operating Instructions Models 36200, 362000, 46200, 462000 Hydrostatic Test Pumps 46200 DIMENSIONS: 28 (70cm) L x 24 (60cm) W x 38 (87.5cm) H WEIGHT: PUMP: ENGINE: CONTROL: GAUGE: DISCHARGE HOSE: INTAKE
More informationTribomatic II Powder Pump
Instruction Sheet P/N Tribomatic II Powder Pump WARNING: Allow only qualified personnel to perform the following tasks. Follow the safety instructions in this document and all other related documentation.
More informationSINGLE VALVE WITH LOW-FLOW BYPASS
CONTROL VALVES Pressure Reducing Valve Sizing Guide Sizing pilot operated reducing valves is not a complicated process. It starts with determining requirements and following these guidelines in valve size
More informationMODELS YCAS0373, 0403, 0453, 0503, 0543, 0573, 0623, and YCAS0653 STYLE "G"
AIR-COOLED SCREW LIQUID CHILLERS RENEWAL PARTS New Release Form: 20.9-RP2 (204) MODELS YCAS0373, 0403, 0453, 0503, 0543, 0573, 0623, and YCAS0653 STYLE "G" 02897-G 24-22 TON 270-457Kw 50 Hz 380/45-3-50
More informationMODELS YCAL0287, 0317, 0347 and YCAL0377 STYLE "C"
AIR-COOLED CONDENSING UNIT HERMETIC SCROLL RENEWAL PARTS Supercedes: NONE Form: 150.64-RP2 (105) MODELS YCAL0287, 0317, 0347 and YCAL0377 STYLE "C" YCALMMHPd 90-135 TON 270-457Kw 50 Hz 380/415-3-50 MODELS
More informationNordic Model CCM0330, 0430, 0530, 0630 Service Parts Manual (Includes 50Hz. Units)
IMI CORNELIUS INC. www.cornelius.com Nordic Model CCM0330, 0430, 0530, 0630 Service Parts Manual (Includes 50Hz. Units) Publication Number: 631806058 Revision Date: October 13, 2009 Revision: E Visit the
More informationPVQ 13 A2 R SE 1 S 20 C-11 D
PVQ - Variable Displacement Piston Pump PVQ 13 A2 R SE 1 S 2 C-11 D 1 2 3 4 6 7 8 9 1 1 Model Series PVQ Inline Piston Pump Variable Volume Quiet Series 4 Rotation Viewed from shaft end R Right hand, standard
More informationInstallation, Operation and Maintenance Instructions for Electronically Controlled Pressurisation Units
Installation, Operation and Maintenance Instructions for Electronically Controlled Pressurisation Units Models: EPS Single Pump EPT Twin Pump EPS-HP EPT-HP Single Pump High Pressure Twin Pump High Pressure
More informationMODEL 300 BACKLAPPER OWNERS MANUAL
MODEL 300 BACKLAPPER OWNERS MANUAL Neary Technologies 1173 Benson Street River Falls, WI 54022 1 Manual No. 30019 (7-07) SAFETY INSTRUCTIONS Safety Awareness Symbols are inserted into this manual to alert
More informationInstallation Instructions
32LT900301 32LT900611 32LT901247 32LT901647 SMALL ROOFTOP S ACCESSORY MOTORMASTERR I HEAD PRESSURE CONTROLLER 3to10TONS Installation Instructions TABLE OF CONTENTS PACKAGE CONTENTS... 1 PACKAGE USAGE-
More informationSafety Please read and keep in a safe place Operating instructions Linear flow control VFC Linear flow control with actuator IFC
05 Elster GmbH Edition 0.5 Translation from the German 058 D F NL I E DK S N P GR TR CZ PL RUS H www.docuthek.com Operating instructions Linear flow control VFC Linear flow control with actuator IFC Contents
More informationHalsey Taylor Owners Manual 4410 Freeze Resistant Tubular Fountain STOP!
Halsey Taylor Owners Manual 4410 Freeze Resistant Tubular Fountain STOP! PLEASE READ THE FOLLOWING INFORMATION. ITALLATION ITRUCTIO FOR THE 4410FR FTN. WITH 97243C SINGLE VALVE CONTROL ASSEMBLY ARE LOCATED
More informationInstallation and Operation 370ESP (Electric Single-Point Purger) & 370ESPR (Retrofit Purger)
IB-77 Installation and Operation 370ESP (Electric Single-Point Purger) & 370ESPR (Retrofit Purger) These installation, operation and technical instructions should be used by experienced personnel as a
More informationUL Listed GM-20/25 and GM-40/45 Series Dual-block Multi-function Gas Control Valves
Installation Sheets Manual 121 Gas Combustion Combination Controls and Systems Section G Technical Bulletin GM-20/25 GM-40/45 Issue Date 1298 UL Listed GM-20/25 and GM-40/45 Series Dual-block Multi-function
More informationSABERINDO PACIF SABERINDO PACIFIC CIFIC SABERINDO PA. A Tyco International Company
CIF A Tyco International Company 1 Foam Concentrate CIF 3% AFFF -UL Listed -UL Canada Listed 6% AFFF 6 parts AFFF concentrate to 94 parts water -UL Listed- Foam Liquid -UL Canada Listed 3% FLUOROPROTEIN
More informationGEN20AD-GEN20AL-GEN18AN
AD-- Parts List 02-August-16 This parts list is current as of the above revision date. See http://www.rheempartslists.net/92-42800-ad--.pdf for the current revision. Standby Generators Table of Contents
More informationSERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0250A4-T4-W4, ICE0400A3-T3-W3 MODEL - ICE0500A3-T3-W3-R4, ICE0606A3-T3-W3-R4 Includes 50Hz.
SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0250A4-T4-W4, ICE0400A3-T3-W3 MODEL - ICE0500A3-T3-W3-R4, ICE0606A3-T3-W3-R4 Includes 50Hz. Units ICE-O-Matic 11100 East 45th Ave Denver, Colorado 80239
More informationSERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0250A5-T5-W5, ICE0400A4-T4-W4 MODEL - ICE0500A4-T4-W4-R5, ICE0606A4-T4-W4-R5 Includes 50Hz.
SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0250A5-T5-W5, ICE0400A4-T4-W4 MODEL - ICE0500A4-T4-W4-R5, ICE0606A4-T4-W4-R5 Includes 50Hz. Units Date 1/09 Table Of Contents This parts list contains
More informationCM MBC & CM MBC PARTS LIST
8650 Enterprise Drive, Peosta IA 52068 319-556-7484 / Fax 319-556-1235 CM-1500-0MBC & CM-1503-1MBC Engine Oil Grade: Engine Oil Capacity: Pump Oil Grade: Pump Oil Capacity: Nozzle Size: PARTS LIST (After
More informationPressure Automated Calibration Equipment
GE Measurement & control Pressure Automated Calibration Equipment Safety Instructions and User Guide - K0447 PACE5000 PACE6000 K0447 Issue No. 9 1 10 1 PACE5000 1 2 3 4 5 PACE6000 2 6 7 8 3 4 5 6 7 8 9
More informationMUELLER. Mega-Lite Drilling Machine. Reliable Connections. table of contents PAGE. Equipment 2. Operating Instructions 3-4. Parts Information 5
operating Instructions manual MUELLER Mega-Lite Drilling Machine table of contents PAGE Equipment 2 Operating Instructions 3-4 Parts Information 5 Travel Charts 6-11! WARNING: 1. Read and follow instructions
More informationCROSS REFERENCE PARTS LIST T & S
002711-40 KL41-Y006-KT Cold Spindle Assembly 002712-40 KL41-Y007-KT Hot Spindle Assembly 004R K50-Y011 Finger Hook Assembly 005312-40 KL50-Y027 Pedal Valve Bonnet Assembly 006678-45 K30-1000 Dipperwell
More informationQuincy QSG Gasends 225, 430, 580, 730 & 850
Quincy QSG Gasends 225, 430, 580, 730 & 850 Parts Manual This publication contains important safety information and should be made available to all personnel who operate and/or maintain this product. Carefully
More informationGT20 String Trimmer UT Page 1 of 16 Accessories
GT20 String Trimmer UT-26037 Page 1 of 16 Accessories GT20 String Trimmer UT-26037 Page 2 of 16 Accessories Ref # Part Number Qty S/P/F Description 1 PS01443 1 TOOL KIT 2 DG07819 1 /P STRAP 3 G07830 1
More informationSpare Parts catalogue 2012
Spare Parts catalogue 2012 TriFlo Pump Number Description Part # Pump Model Quantity 1 Barrel Union Nut 9-2008 AH, XH, ET, ST, SK 2 2 Barrel Union Pipe Socket 9-2007 AH, XH, ET, ST, SK 2 3 O-ring Barrel
More informationATS430 turbidity sensor Retractable insertion assembly
A MEASUREMENT & ANALYTICS INSTRUCTION ATS430 turbidity sensor Retractable insertion assembly Measurement made easy 1 Introduction This publication details installation procedures for the retractable insertion
More informationEncore PE 50-lb Feed Hopper
Instruction Sheet P/N 160429-01 Encore PE 50-lb Feed Hopper WARNING: Allow only qualified personnel to perform the following tasks. Follow the safety instructions in this document and all other related
More information36G22, 36G23, 36G24 & 36G52 36J22, 36J23, 36J24 & 36J52 DSI and HSI Single Stage Combination Gas Valve
Operator: Save these instructions for future use! FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLING OR OPERATING THIS CONTROL COULD CAUSE PERSONAL INJURY AND/OR PROPERTY DAMAGE. DESCRIPTION
More informationYour safety and the safety of others are very important.
NATURAL GAS TO PROPANE CONVERSION KIT ALPKT57- INSTALLATION INSTRUCTIONS PROPANE CONVERSION KIT SAFETY... INSTALLATION REQUIREMENTS... Tools and Parts... LP Gas Requirements... Table of Contents INSTALLATION
More informationWorkhorse-15 Oxygen Generator
11436 Sorrento Valley Road, San Diego CA 92121 USA 858-558-0202 Fax 858-558-1915 Workhorse-15 Oxygen Generator Model No. 5719, 5727, 5735 for Domestic and International Units Part number 1432 Revision
More informationBRILLIANT WONDERS LED BUBBLERS INSTALLATION INSTRUCTIONS & PRODUCT MANUAL CMP SERIES
BRILLIANT WONDERS LED BUBBLERS INSTALLATION INSTRUCTIONS & PRODUCT MANUAL CMP 25503 SERIES TABLE OF CONTENTS A. PRODUCT OVERVIEW A.1 SPECIFICATIONS A. PRODUCT OVERVIEW... 3 A.1 Specifications A.2 Packing
More informationHalsey Taylor Owners Manual STOP!
Halsey Taylor Owners Manual 4710 Freeze Resistant Floor Mounted Steel Fountain STOP! PLEASE READ THE FOLLOWING INFORMATION. ITALLATION ITRUCTIO FOR THE 4710FR FTN. WITH 97243C SINGLE VALVE CONTROL ASSEMBLY
More informationMounting and Operating Instructions EB 8546 EN. Type 4708 Supply Pressure Regulators. Translation of original instructions. Type Type
Type 4708 Supply Pressure Regulators Translation of original instructions Type 4708-53 Type 4708-64 Type 4708-12 Mounting and Operating Instructions Edition March 2018 Note on these mounting and operating
More informationThis parts list is current as of the above revision date. See for the current revision.
Parts List This parts list is current as of the above revision date. See http://www.rheempartslists.net/92-42800-.pdf for the current revision. Condensing Units Table of Contents Model Explanation...................................................................................................................
More informationSPECIFICATIONS ATTENTION
VPS 504 S06 Installation Manual - P/N 80122 - Ed. 01/09 VPS 504 S06 and S05 Valve Proving System Installation Instructions VPS 1 6 Gases Natural gas, air and other inert gases. NOT suitable for butane
More informationACCESSORY KIT INSTALLATION INSTRUCTIONS
ACCESSORY KIT INSTALLATION INSTRUCTIONS 1NP0680 - PROPANE CONVERSION FOR USE WITH MODELS: PM8, PC8, PM9, PC9, FL9M, FL9C, FC9M, FC9C This conversion kit is to be installed by a qualified service agency
More informationInstallation Instructions
Low -Ambient Pressure Switch 0201R22 0301410 Installation Instructions NOTE: Read the entire instruction manual before starting the installation. SAFETY ONSIDERATIONS Improper installation, adjustment,
More informationAIR COMPRESSOR OPERATION & MAINTENANCE INSTRUCTIONS MODEL NO: CHAMP 3 PART NO: LS0115
AIR COMPRESSOR MODEL NO: CHAMP 3 PART NO: 2225222 OPERATION & MAINTENANCE INSTRUCTIONS LS0115 INTRODUCTION Thank you for purchasing this CLARKE Air Compressor. Please read this manual fully before use
More informationI.H.S INSTALLATION INSTRUCTIONS
I.H.S INSTALLATION INSTRUCTIONS TOOLS REQUIRED The following tools will be required for installation of your I.H.S. system. Item Qty Needed 9/16 Open End Wrench 2 3/4 Open End Wrench 1 1/2 Open End Wrench
More information97C COMPRESSOR KIT 12V PART NO C COMPRESSOR KIT 24V PART NO C COMPRESSOR KIT PART NO
97C COMPRESSOR KIT 12V PART NO. 00097 97C COMPRESSOR KIT 24V PART NO. 02497 98C COMPRESSOR KIT PART NO. 00098 97C 98C IMPORTANT: It is essential that you and any other operator of this product read and
More information