Main Index. Signal & Illumination. Training & Simulation. Minefield Breaching. 2. Main Index 3. About WesCom

Transcription

1

2 Page Content About WesCom Signal & Illumination 5. Signal & Illumination Index 6. 19mm Signal Cartridge Single Star Red, Green, White mm Signal Cartridge, Single Star Red, White, Green, Yellow, Flash Bang 8. Parachute Signal Cartridges mm Signal Cartridge, Single Star Red, White, Green, Yellow mm Signal Cartridge, Single Star Red, Green, White, Yellow mm Signal Cartridge, 2-Star Red, Green, White, Yellow 12. Salute Cartridge 13. Multiple Effect Rocket System (MERS) Illumination Rocket, 300m 14. Multiple Effect Rocket System (MERS) Illumination Rocket, 600m 15. Multiple Effect Rocket System (MERS) Illumination Rocket, 1000m 16. Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 300m 17. Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 600m 18. Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 1000m 19. Standard Military Rocket Para Illumination Rocket Hand Fired Cluster - Red, White, Green 21. Trip Flare DM Alarm Flare DM Ground Flare - Indicating Yellow 24. Smoke Grenade, Coloured, 30 sec 25. Smoke Grenade, Coloured, 60 sec 26. Smoke Grenade, Coloured, 90 sec 27. Smoke Grenade, Screening, 30 sec, low toxic 28. Hand Grenade Smoke Coloured 29. Day & Night Signal 30. Linethrower 250 Page Content 30. White Handflare 31. Red Handflare 32. Red Parachute Signal Rocket 33. Light & Smoke Signal 34. Smoke Signal Orange Training & Simulation 36. Training & Simulation Index 37. Scalable Gun Signature Simulator - SGSS 38. Lightweight Gun Signature Simulator - (LGSS) 39. Simulator for Artillery and Multi-effects (SAM) 40. Mini Launch Unit MLU 41. Portable Control Unit-PCU 42. Main Gun Signature Simulators MGSS 43. Direct/Indirect Fire Cue Simulator APFSDS 44. Direct/Indirect Fire Cue Simulator Smokes 45. Direct/Indirect Fire Cue Simulator Air Burst 46. Surface-to-Air Missile Simulator ManPADS M Flash Bang Smoke Simulator Mini FBSS 48. Micro Pyro Card MiPC 49. Macro Pyro Card MaPC 50. Tank Cannon Fire Simulator DM54 A1 / DM Hit-Indicator Simulator DM29 / DM Impact Simulator (Thunderflash) MECoSt 53. Impact Simulator (Thunderflash) Minefield Breaching 55. Minefield Breaching Index 56. Heavy Portable Explosive Minefield Breaching System H-PEMBS 57. Training Heavy Explosive Minefield Breaching System T-HPEMBS 58. Light Portable Explosive Minefield Breaching System L-PEMBS 59. Training Light Explosive Minefield Breaching System T-LPEMBS Content of these informational data sheets is subject to modification without prior notice. Errors and omissions excepted. The data sheets do not constitute a technical specification.

3 About WesCom WesCom Defence WesCom Defence is a world-renowned specialist manufacturer of pyrotechnic products for Signalling and Illumination and Battlefield Training and Simulation. Additionally, for over five decades WesCom Defence has provided leading edge technology in Minefield Breaching Systems. WesCom also produces a range of state of the art gas pressure generators, both for civil and military applications. Since the beginning, the company, which was founded on its present site in Bremerhaven, Germany has specialised in the broad spectrum of pyrotechnic products and services and this expertise continues to drive customer satisfaction as it has always done. Using applied pyro-technology, paired with mechanical engineering, a fundamental knowledge of inner and outer ballistics and the chemical engineering of effect, delay, propulsion and ejection compositions, the company has developed an extensive range of technologically advanced and innovative products. Considerable investment in the automation of pyrotechnic production enables the highest degree of quality assurance and reliability. Our commitment to constant research and development, paired with our responsibility towards the environment, has and will continue to optimise the range of products and services that we offer. Company History In 1920 Friedrich Wilhelm Sander took over the company founded in 1853 by H.G. Cordes in Bremerhaven-Geestemünde, which developed and produced canons for whaling. In 1930 he opened new industrial premises at Vieländer Weg primarily for testing and proving but also to comply with the increased demand of pyrotechnic signal munitions the factory was taken over by the DONAR GmbH the site was acquired by Industriewerke Karlsruhe Augsburg the company was bought by the Diehl Group Chemring Group Plc. acquired the factory. August 2012 Chemring Group Plc. sold the company to Drew Marine USA. January 2017 Drew Defence GmbH was merged into Drew Marine Signal & Safety. October 2017 Name change to WesCom Signal & Rescue.

4 Signal & Illumination Communication between combat forces and battlefield reconnaissance at night is an essential element in operation. Our scope of products for signal and illumination provide effective means for said purpose. WesCom Defence uses automated production techniques to ensure not only high cost effectiveness but also reliable quality products. Reconnaissance of ground forces during night operations is a prerequisite. Parachute Illumination Cartridges/Rockets provide appropriate visibility during missions at night. Besides the illumination in the visual range, infra-red illumination flares enhance the capability of night vision goggles. Signal Flares in a variety of colours and configurations provide also an appropriate means of communication on the battle field. Product Types Handheld Rockets Ground Illumination Alarm and Trip Flares Smoke Grenade Pyrotechnic Ammunition

5 Signal & Illumination Index Page Content About WesCom Signal & Illumination 5. Signal & Illumination Index 6. 19mm Signal Cartridge Single Star Red, Green, White mm Signal Cartridge, Single Star Red, White, Green, Yellow, Flash Bang 8. Parachute Signal Cartridges mm Signal Cartridge, Single Star Red, White, Green, Yellow mm Signal Cartridge, Single Star Red, Green, White, Yellow mm Signal Cartridge, 2-Star Red, Green, White, Yellow 12. Salute Cartridge 13. Multiple Effect Rocket System (MERS) Illumination Rocket, 300m 14. Multiple Effect Rocket System (MERS) Illumination Rocket, 600m 15. Multiple Effect Rocket System (MERS) Illumination Rocket, 1000m 16. Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 300m Page Content 17. Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 600m 18. Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 1000m 19. Standard Military Rocket Para Illumination Rocket Hand Fired Cluster - Red, White, Green 21. Trip Flare DM Alarm Flare DM Ground Flare - Indicating Yellow 24. Smoke Grenade, Coloured, 30 sec 25. Smoke Grenade, Coloured, 60 sec 26. Smoke Grenade, Coloured, 90 sec 27. Smoke Grenade, Screening, 30 sec, low toxic 28. Hand Grenade Smoke Coloured 29. Day & Night Signal 30. Linethrower Red Handflare 32. Red Parachute Signal Rocket 33. Light & Smoke Signal 34. Smoke Signal Orange

6 19mm Signal Cartridge Single Star Red, Green, White Application Communications between combat forces and battlefield reconnaissance at night are essential elements in operations. The 19mm Signal Cartridges offer an autarkic means for this purpose and is also used as personnel distress signal. The 19mm Signal Cartridge is fired from the HK EFL 19 Flare Launcher and provides short range signalling and illumination. For special fore field illumination missions, the single star is also available with near infrared light. Operation: In preparation of firing the 19mm cartridges are loaded into the magazine of the HK EFL 19 (Notsignalgerät FHK Kaliber 6/19x36mm). Characteristics: Red: Emergency signal, tangible mark at the top = full edge Green: General signal e.g. position cleared, tangible mark at the top, = edge with 4 grooves White: Short illumination of fore field, tangible mark at the top = edge with 3 grooves Calibre: Flare Burning Time: Altitude (firing angle 90 ): 19mm 37mm 17g NEQ each cartridge: 8,6g Light intensity peak for colours: Red: White: Green: Product Codes: > 10,000 cd > 10,000 cd > 3,000 cd 6 + / - 1 sec. 60 to 30m N/A Red: Green: White: UN Number: UN 0054 Proper shipping name: Cartridges, signal Packing: 20 cartridges in 1 cardboard 50 cardboard es = 1000 cartridges in 1 wooden Qty. per NEQ (kg) GR Wgt (kg) G 8.1 kg 30 kg 0.067m³ SIGNAL & ILLUMINATION Issue 4 03/2018

7 26.5mm Signal Cartridge, Single Star Red, White, Green, Yellow, Flash Bang Application Communications between combat forces and battlefield reconnaissance at night are essential elements in operations. The 26.5mm Signal Cartridge is used for short range signalling and for illumination purpose. The 26.5mm Signal Cartridges offer a self-sufficient means for signalling and illumina-tion purpose. Operation: The cartridge is fired from a suitable 26.5mm Very pistol, either vertically (signalling) or with an angle (Illumination). The common instructions of handling a Very pistol are to be strictly followed. Characteristics: : Red cap and full edging - used as signal for emergency : White cap and half edging - used as signal and short illumination of fore field : Green cap and no edging - used as signal : Yellow cap and half edging - used as signal and short illumination of fore field : Brown cap and no edging - firing of an acoustical and optical signal (flash bang). Calibre: 26.5mm 82mm 50g (Red & Green), 58g (White & Yellow), 60g (Flash Bang) Cartridge case: Aluminum Flare Burning Time: ~ 8 sec. (No ). Altitude (firing angle 90 ): 100 (firing angle 90 ) NEQ each cartridge: Light intensity peak for colours: Red: Green: Yellow: White: Qty. per 250 (Coloured Flare) 250 (Flash Bang) > 30,000 cd > 10,000 cd > 40,000 cd > 40,000 cd Flash Bang: Bright flash and a bang of 170 db Product Codes: 1.4 G NEQ (kg) 3.75 (Red), 4.5 (Green & Yellow), 6,6 (White) 27g (Red & Green ), 31g (White & Yellow), 11g (Flash Bang) (measured at 3m distance and 1m above ground) N/A Red: White: Green: Yellow: Flash Bang: UN Number: Art.- No.: UN 0312 Cartridges, signal Art.- No.: UN 0054 Cartridges, signal Packing: 10 signal cartridges in cardboard 25 cardboard es in corrugated board Other packaging methods on request GR Wgt (kg) 10.3 (Red), 10.6 (Green & Yellow), 13.2 (White) 0.027m³ 1.3 G 2.7kg 17.5kg 0.027m³ SIGNAL & ILLUMINATION

8 Parachute Signal Cartridges Application: Efficient reconnaissance is essential during night operations of ground forces. The parachute Signal Cartridge provides sufficient visibility during missions at night. The 26.5mm Parachute Signal Cartridge is used for medium range illumination. Operation: The cartridge is fired from a suitable 26.5mm very pistol at an angle of between 45º and 60º. Infra-red: Infra-red versions of this product are also available. Diameter: Overall weight: Cartridge case: Burn time: Altitude: (firing angle 90º): Light intensity peak: Yellowy white: 210mm 26.5mm 193 gram Aluminium > 15 sec. = > 320m > cd Infra-red versions of this product are also available. Please contact our sales team to discuss your requirements. Characteristics: : white cap and half edging In service with the German Army (DM 536) Product Code: (yellowy white) UN Number: Proper Shipping Name: Packaging: 10 signals per cardboard 30 signals in 1 wooden Qty. per UN0171 Ammunition, Illumination NEQ (kg) GR Wgt (kg) G 1,7kg 12kg 00.01m³ SIGNAL & ILLUMINATION This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements.

9 26.5mm Signal Cartridge, Single Star Red, White, Green, Yellow Application Communication between combat forces and battlefield reconnaissance at night are essential elements in operations. The 26.5mm Signal Cartridge is used for short range signalling and for illumination purpose. The 26.5 mm Signal Cartridges offer an self-sufficient means for signalling and illumina-tion purpose. Operation: The cartridge is fired from a suitable 26.5mm very pistol, either vertically (signalling) or with an angle (Illumination). The common instructions of handling a very pistol are to be strictly followed. Characteristics: : Red body and full edging - used as signal for emergency : White body and half edging used as signal and short illumination of fore field : Green body and no edging - used as signal : Yellow body and half edging - used as signal and short illumination of fore field. Caliber: Cartridge case: Flare Burning Time: 26.5mm 82mm 37.5g (Red), 38.5g (Green & Yellow), 49g (White) Plastic ~ 8 sec. Altitude (firing angle 90 ): 100 ± 20m (firing angle 90 ) NEQ each cartridge: Light intensity peak for colours: Red: Green: Yellow: White: Product Codes: Red: N/A White: N/A Green: N/A Illumination: UN Number: Packing: 15g (Red), 18g (Green), 26g (White) > 30,000 cd > 10,000 cd > 40,000 cd > 40,000 cd N/A UN 0312 Cartridges, signal 4 signal cartridges in sealed round plastic container 75 round plastic container in sealed plastic 1 plastic in in plywood SIGNAL & ILLUMINATION Qty. per Hazzard NEQ (kg) GR Wgt (kg) G 3.75 kg (Red) 4.5 kg (Green & Yellow) 6,6 kg(white) 10.3 kg (Red) 10.6 kg (Green & Yellow) 13.2kg (White) 0.027

10 38mm Signal Cartridge, Single Star Red, Green, White, Yellow Application Communication between combat forces and battlefield reconnaissance at night are essential elements in operations. The 38mm Signal cartridges offer an autarkic means for this purpose and is also used as distress signal (colour red). The 38mm Signal Cartridge is generally fired from a 1.5 inch Very pistol and provides short range signalling and illumination both in white and infra-red light. Available for long distance visibility more than 3.2km. (2 miles) during the day, and more than 6.5km. (4 miles) at night with clear vision. Operation: In preparation of firing the 38mm cartridges are loaded into the Very pistol and fired vertically for signalling purposes respectively with an angle of > 45 degrees for illumination purposes. The common instructions of handling a Very pistol are to be strictly followed. Characteristics: Red: Emergency signal, tangible mark at top of cartridge = Cross + Green: General signal for communication purpose, tangible mark at top of cartridge = Triangle White: General signal for communication purpose, tangible mark at the of cartridge = Dot - Yellow: General signal for communication purpose, tangible mark at the of cartridge = Dot Calibre: Cartridge case: Flare Burning Time: Altitude (firing angle 90 ): NEQ each cartridge: Light intensity peak for colours: Red: Green: White: Yellow: Product Codes: > 40,000 cd > 30,000 cd > 70,000 cd > 100,000 cd 38mm (1.5 inch) 97mm 170g Aluminum 7 ±1.5 sec. 90 ± 25m 83.0 g (Red), 99.0 g (Green), 91.0 g (Yellow), 99.0 g (White) N/A Red: N/A Green: N/A White: N/A Yellow: N/A UN Number: UN 0312 Packing: 5 cartridges in a cardboard 60 cardboard es = 300 cartridges in 1 wooden Qty. per NEQ (kg) G 12.5 kg (Red) 14.9 kg (Green) 14.9 kg (White) 13.7 kg (Yellow) GR Wgt (kg) 30 kg 0.168m³ SIGNAL & ILLUMINATION Issue 4 03/2018

11 38mm Signal Cartridge, 2-Star Red, Green, White, Yellow Application Communications between combat forces and battlefield reconnaissance at night are essential elements in operations. The 38mm Signal Cartridges offer an autarkic means for this purpose and is also used as distress signal (colour red). The 38mm Signal Cartridge is generally fired from a 1.5 inch Very pistol and provides short range signalling and illumination both in white and infra-red light. Available for long distance visibility more than 3.2km. (2 miles) during the day, and more than 6.5 km. (4 miles) at night with clear vision. Operation: In preparation of firing the 38mm cartridges are loaded into the very pistol and fired vertically for signalling purposes respectively with an angle of > 45 degrees for illumination purposes. The common instructions of handling a Very pistol are to be strictly followed. Characteristics: Red: Emergency signal, tangible mark at top of cartridge = Cross + Green: General signal for communication purpose, tangible mark at top of cartridge = Triangle White: General signal for communication purpose, tangible mark at the of cartridge = Dot - Yellow: General signal for communication purpose, tangible mark at the of cartridge = Dot Calibre: Cartridge case: Flare Burning Time: Altitude (firing angle 90 ): NEQ each cartridge: Light intensity peak for colours: Red: Green: White: Yellow: Product Codes: > 40,000 cd > 30,000 cd > 70,000 cd > 100,000 cd 38mm (1.5 inch) 97mm 170g Aluminum 7 ±1.5 sec. 90 ± 25m 83.0 g (Red), 99.0 g (Green), 91.0 g (Yellow), 99.0 g (White) N/A Red: N/A Green: N/A White: N/A Yellow: N/A UN Number: UN 0312 Packing: 5 cartridges in a cardboard 60 cardboard es = 300 cartridges in 1 wooden Qty. per NEQ (kg) G 12.5 kg (Red) 14.9 kg (Green) 14.9 kg (White) 13.7 kg (Yellow) GR Wgt (kg) 30 kg 0.168m³ SIGNAL & ILLUMINATION Issue 4 03/2018

12 Salute Cartridge Application: Announcment of sunrise and sunset during the Ramadan in islamic countries. Also used for international morning/evening colours and welcoming ceremonies. The Salute Cartridge consists of an outer casing either from aluminium or brass and is loaded with a flash/ sound composition and hermetically sealed at the top of the cartridge case. Upon ignition the composition will combust with a loud noise 169 db (A). Operation: The operation is dependant upon the instruction to handle/load the salute canon. Diameter: Material: Sound Level: Product Codes: Qty. per 180mm 75mm 650g Aluminium/Brass 169 db (A) N/A N/A UN Number: UN 0327 Proper Shipping Name: Cartridges for weapons, blank NEQ (kg) GR Wgt (kg) C 1,3kg 19,5kg 0.05m³ Wooden is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. SIGNAL & ILLUMINATION

13 Multiple Effect Rocket System (MERS) Illumination Rocket, 300m Application Illumination of the fore field Illumination during search and rescue operations Signalling purpose Smokeless burning of the rocket propellant results in minimal signature at initiation combined with no visible signature throughout flight providing concealment from detection of launch. Flight tube design and induced tail spin provide high level of accuracy. The store architecture requires no stored energy in the initiator. Twist initiation provides for both left & right hand operation. Operation: MERS incorporates a 3 stage safety system comprising of: 1. Turn twist initiator clockwise from Safe Position S into Armed-Position A. This action unlocks the twist initiator allowing it to be pulled in axial direction. 2. Pull twist initiator from Armed-Position into Firing- Position F. This action unlocks the twist initiator allowing it to be rotated clockwise or counterclockwise. 3. Twist initiation clockwise or counter-clockwise to fire the rocket. Provided the twist initiator has not been rotated, MERS can be returned to the safe condition. Diameter: Recoil: 260mm 51mm Approx. 520g <500 N Flare altitude at firing angle 45 : 200 m Range: Burning time: Light intensity: Wavelength: Product Codes: 300 m 30 Sec cd 589±3 nm N/A TBA UN Number: UN 0254 Proper shipping name: Packing: Ammunition, Illuminating 10 rockets packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 1.35kg 8.5kg 0.012m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

14 Multiple Effect Rocket System (MERS) Illumination Rocket, 600m Application Illumination of the fore field Illumination during search and rescue operations Signalling purpose Smokeless burning of the rocket propellant results in minimal signature at initiation combined with no visible signature throughout flight providing concealment from detection of launch. Flight tube design and induced tail spin provide high level of accuracy. The store architecture requires no stored energy in the initiator. Twist initiation provides for both left & right hand operation. Operation: MERS incorporates a 3 stage safety system comprising of: 1. Turn twist initiator clockwise from Safe Position S into Armed-Position A. This action unlocks the twist initiator allowing it to be pulled in axial direction. 2. Pull twist initiator from Armed-Position into Firing- Position F. This action unlocks the twist initiator allowing it to be rotated clockwise or counterclockwise. 3. Twist initiation clockwise or counter-clockwise to fire the rocket. Provided the twist initiator has not been rotated, MERS can be returned to the safe condition. Diameter: Recoil: 260mm 51mm Approx. 530g <500 N Flare altitude at firing angle 45 : 200m Range: Burning time: Light intensity: Wavelength: Product Codes: 600m 30 Sec cd 589±3 nm N/A TBA UN Number: UN 0254 Proper shipping name: Packing: Ammunition, Illuminating 10 rockets packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 1.5kg 8.6kg 0.012m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

15 Multiple Effect Rocket System (MERS) Illumination Rocket, 1000m Application Illumination of the fore field Illumination during search and rescue operations Signalling purpose Smokeless burning of the rocket propellant results in minimal signature at initiation combined with no visible signature throughout flight providing concealment from detection of launch. Flight tube design and induced tail spin provide high level of accuracy. The store architecture requires no stored energy in the initiator. Twist initiation provides for both left & right hand operation. Operation: MERS incorporates a 3 stage safety system comprising of: 1. Turn twist initiator clockwise from Safe Position S into Armed-Position A. This action unlocks the twist initiator allowing it to be pulled in axial direction. 2. Pull twist initiator from Armed-Position into Firing- Position F. This action unlocks the twist initiator allowing it to be rotated clockwise or counterclockwise. 3. Twist initiator clockwise or counter-clockwise to fire the rocket. Provided the twist initiator has not been rotated, MERS can be returned to the safe condition. Diameter: Recoil: 322mm 51mm Approx. 620g < 1000 N Flare altitude at firing angle 45 : 200m Range: 1000 Burning time: Light intensity: Wavelength: Product Codes: 30 Sec cd 589±3 nm N/A TBA UN Number: UN 0254 Proper shipping name: Packing: Ammunition, Illuminating 10 rockets packed in a steel (4A), type BMI Qty. per NEQ (kg) GR Wgt (kg) G 2.3kg 10.2kg This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

16 Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 300m Application Providing enhancement of infrared image intensifiers such as night vision goggles during combat or surveillance situations in darkness. Smokeless burning of the rocket propellant results in minimal signature at initiation combined with no visible signature throughout flight providing concealment from detection of launch. Flight tube design and induced tail spin provide high level of accuracy. The store architecture requires no stored energy in the initiator. Twist. Initiation provides for both left & right hand operation. Operation: MERS incorporates a 3 stage safety system comprising of: 1. Turn twist initiator clockwise from Safe Position S into Armed-Position A. This action unlocks the twist initiator allowing it to be pulled in axial direction. 2. Pull twist initiator from Armed-Position into Firing- Position F. This action unlocks the twist initiator allowing it to be rotated clockwise or counterclockwise. 3. Twist initiator clockwise or counter-clockwise to fire the rocket. Provided the twist initiator has not been rotated, MERS can be returned to the safe condition. Diameter: Recoil: 260mm 51mm Approx. 535g <500 N Flare altitude at firing angle 45 : 200m Range: Burning time: Radiant Intensity: Frequency Range: Light intensity: Product Codes: 300m 30 Sec 50 Wsr-1 0.7µm to 1.0µm < 200 cd N/A TBA UN Number: UN 0254 Proper shipping name: Packing: Ammunition, Illuminating 10 rockets packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 1.5kg 8.7kg 0.012m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

17 Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 600m Application Providing enhancement of infrared image intensifiers such as night vision goggles during combat or surveillance situations in darkness. Smokeless burning of the rocket propellant results in minimal signature at initiation combined with no visible signature throughout flight providing concealment from detection of launch. Flight tube design and induced tail spin provide high level of accuracy. The store architecture requires no stored energy in the initiator. Twist initiation provides for both left & right hand operation. Operation: MERS incorporates a 3 stage safety system comprising of: 1. Turn twist initiator clockwise from Safe Position S into Armed-Position A. This action unlocks the twist initiator allowing it to be pulled in axial direction. 2. Pull twist initiator from Armed-Position into Firing- Position F. This action unlocks the twist initiator allowing it to be rotated clockwise or counterclockwise. 3. Twist initiator clockwise or counter-clockwise to fire the rocket. Provided the twist initiator has not been rotated, MERS can be returned to the safe condition. Diameter: Recoil: 260mm 51mm Approx. 545g < 500 N Flare altitude at firing angle 45 : 200m Range: Burning time: Radiant Intensity: Frequency Range: Light intensity: Product Codes: 600m 30 Sec TBA 50 Wsr-1 0.7µm to 1.0µm < 200 cd UN Number: UN 0254 Proper shipping name: Packing: Ammunition, Illuminating 10 rockets packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 1.6 kg 8.8 kg 0.012m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

18 Multiple Effect Rocket System (MERS) Infrared Illumination Rocket, 1000m Application Providing enhancement of infrared image intensifiers such as night vision goggles during combat or surveillance situations in darkness. Smokeless burning of the rocket propellant results in minimal signature at initiation combined with no visible signature throughout flight providing concealment from detection of launch. Flight tube design and induced tail spin provide high level of accuracy. The store architecture requires no stored energy in the initiator. Twist initiation provides for both left & right hand operation. Operation: MERS incorporates a 3 stage safety system comprising of: 1. Turn twist initiator clockwise from Safe Position S into Armed-Position A. This action unlocks the twist initiator allowing it to be pulled in axial direction. 2. Pull twist initiator from Armed-Position into Firing- Position F. This action unlocks the twist initiator allowing it to be rotated clockwise or counterclockwise. 3. Twist initiatior clockwise or counter-clockwise to fire the rocket. Provided the twist initiator has not been rotated, MERS can be returned to the safe condition. Diameter: Recoil: 322mm 51mm Approx. 635g < 1000 N Flare altitude at firing angle 45 : 200m Range: Burning time: Radiant Intensity: Frequency Range: Light intensity: 1000m 30 Sec 50 Wsr-1 0.7µm to 1.0µm < 200 cd N/A Product Codes: TBA UN Number: UN 0254 Proper shipping name: Packing: Ammunition, Illuminating 10 rockets packed in a steel (4A), type BMI Qty. per NEQ (kg) GR Wgt (kg) G 2.45 kg kg 0.014m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

19 Standard Military Rocket Para Illumination Application: For use in any situation where illumination is required. The rocket is fired at an elevation of between 45º and 90º dependant on wind speed and is suitable for: Identification and engagement Internal security and counter insurgency operations This 32mm Compact Illumination Rocket is reduced in weight and size and is a light source which produces sufficient light to illuminate areas of terrain. This enables random surveillance to reveal enemy movement in the open, ambush situations to reveal targets or as target illuminators for weapon systems. The Rocket ejects a white flare at 300m (1000 ft), which burns for 30 seconds at 90,000 candela. Operation: Hold signal firmly by ribbed handle. Unscrew WHITE bottom cap. Do not point at people or property. Hold rocket vertically above head pointing away from body. Ensure hand remain clear of top. To fire - pull red ball sharply down. Diameter at handle: Diameter: Net explosive cont: Light intensity: Burn time: Colour of light: Ignition: Altitude: Product Code: 295mm 38mm 32mm 270 gram 94g 90,000cd 30 seconds white pull - wire 300m N/A Not available yet UN Number: UN 0505 Proper Shipping Name: Packing: 2 Metal tins in a fiberboard Qty. per Signals, Distress, Ship NEQ (kg) GR Wgt (kg) G 5.15kg 17.2kg 0.048m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. SIGNAL & ILLUMINATION

20 Rocket Hand Fired Cluster - Red, White, Green Application: Efficient reconnaissance is essential during night operations of ground forces. The Rocket Hand Fired, Cluster White provides visibility during night missions and the cluster Red and Cluster Green offers signalling during said operations, Infra-red illumination in addition provides an enhancement of the night vision capability of ground forces. The Rocket Hand Fired Cluster is equipped with a standard rocket propellant which reliably carries the payload in the fired direction. At the apex of the flightpath, a cluster of four either white, (illumination) or red (signalling) or green (illumination) will be expelled from the rocket. Operation : 1. Remove protection cap at bottom of launching tube by turning left. 2. Hold launching tube into firing direction, with an angle of 45 (for Illumination) and vertical (for signalling) 3. Pull lanyard briskly downwards. Rocket will start without delay Diameter: Diameter at handle: Burning time: Light colour: Ignition method: Product Code: TBA UN Number: Qty. per Box Type 287mm 32mm 38mm 260g nominal 5 Sec. nominal red, white, green Pull-wire-ignitor In service with numerous customers TBA UN0506 NEQ (kg) GR Wgt (kg) 28 4 G 1.4 S 92g 17.0 kg 0,022m³ There are several packaging methods available, which have to be stipulated with the customer. SIGNAL & ILLUMINATION

21 Trip Flare DM 26 Application: Effective perimeter protection and defence in open fields is accomplished besides electronic surveillance systems by means of pyrotechnic flares which alert and direct security forces in the direction of intruders. The Trip Flare is a hand-deployable, non-lethal device. When wire-triggered, it produces a bright white light of at least 30 sec. duration. It disorientates the trespasser for several seconds and illuminates an area of 25m around the ignition point. An infrared variant enhances the night vision capability of the security forces. Operation: 1. Fix angle iron at bottom of trip flare. 2. Fix angle iron with trip flare at suitable place on. 3. Remove protection cap from screw thread at top of trip flare. 4. Screw ignition system tightly onto thread of trip flare. 5. Attach trip wire to top end (brown knurled cap) of ignition system. 6. Unroll wire from spool to necessary length and fix at strong point. 7. Release safety catch by a) turning knurled wheel towards end of thread, and b) by pulling U shaped iron bar forward; this should be safely done with attached lanyard. If trip flare is to be activated by cutting trip wire, apply tensing strings. Unused trip flares can be removed and safely re-packed. Total length: Diameter: Burning Time: Candle Power: Net Explosive Mass: 200mm (plus ignitor) 110mm (Flare Body only) 60mm 592 gram > 30 sec. > cd 365 gram Supply with igniter and completion kit: wire, nails, bobbins, release cords and tension springs. Product Code: In service with German Armed Forces as DM UN Number: UN 0092 Proper shipping name: Packing: Flares, surface 1 signal per fiberboard (including igniter, picket, trip-wire) - 46 signals in 1 wooden. Qty. per NEQ (kg) GR Wgt (kg) G 17.1kg 47kg 0.064m³ SIGNAL & ILLUMINATION This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements

22 Alarm Flare DM 57 Application: Effective perimeter protection and defence in open fields is accomplished besides electronic surveillance systems by means of pyrotechnic flares which alert and direct security forces in the direction of intruders. The Alarm Flare is a hand-deployable, non-lethal device. When wire-triggered, it produces a loud short bang in 15m height and bright white light of at least 15 sec. duration. It disorientates the trespasser for several seconds and illuminates an area of 25m around the ignition point. An infrared variant enhances the night vision capability of the security forces. Operation: 1. Fix angle iron at suitable place. 2. Remove protection cap from screw thread at top of trip flare. 3. Insert screw thread into hole of angle iron. 4. Screw ignition system tightly onto thread of alarm flare. 5. Attach trip wire to top end (brown knurled cap) of ignition system. 6. Unroll wire from spool to necessary length and fix at strong point. 7. Release safety catch by a) turning knurled wheel towards end of thread, and b) by pulling U shaped iron bar forward; this should be safely done with attached lanyard. If alarm flare is to be activated by cutting trip wire, apply tensing strings. Unused alarm flares can be removed and safely re-packed. Total length: Diameter: Burning Time: Candle Power: Net Explosive Mass: Sound pressure: 115mm (plus ignitor) 70mm (Flare Body only) 30mm 50 gram > 15 sec. > cd 16 gram Height of flash bang effect: min. 10 meter min. 165 db (measured in 3m distance) Supply with igniter and completion kit: wire, nails, bobbins, release cords and tension springs. Product Code: In service with German Armed Forces as DM UN Number: UN 0092 Proper shipping name: Packing: Flares, surface 1 signal per fiberboard (including igniter, picket, trip-wire) - 46 signals in 1 wooden. Qty. per NEQ (kg) GR Wgt (kg) G 0.48kg 11kg 0.01m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. SIGNAL & ILLUMINATION

23 Ground Flare Indicating Yellow Application Marking of landing zones and wind direction indicator for Helicopters as well as emergency landing path for fixed wing aircrafts. The Ground Flare, Indicating Yellow consists of a plastic tube filled with a high performance flare composition. At the lower end of the flare tube is a pedestal, consisting of 3 spikes, enabling the flare tube to be either place into or onto the ground longitudinal respectively perpendicular direction of spikes. Due to the flexible positioning of the 3 spikes a stable placement in uneven terrain is possible. Operation: Ground Flare Soft ground Solid ground Pull ignitor Yellow flame 1. Choose the correct position of the spikes for mounting. Soft ground: Spikes parallel to the tube Solid ground. Spikes perpendicular to the tube 2. Push or put Ground Flare assembly into safe vertical position. 3. Pull off top cap of igniter and fold out the pull striker ring. 4. To ignite the flare, pull off the striker ring sideward. After a delay time of 3 sec. the ground flare starts to burn. Total length: Spike length: Diameter: Delay time: Burning time: Candle Power: Net Explosive Mass: Product Codes: 440mm (spikes in transport position) 100mm 28.7mm 280 gram 3. sec. nominal 100 sec cd 220 gram N/A TBA UN Number: UN 0092 Proper shipping name: Packing: Qty. per Hazzard NEQ (kg) Flares, surface GR Wgt (kg) G 11kg 24kg 0.03m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements SIGNAL & ILLUMINATION

24 Smoke Grenade, Coloured, 30 sec Available Smoke Colours Application: Smoke Grenades provide combat forces with a means of communication / signalling during daylight. Besides individual signalling codes, smoke grenades are used, for example, as indicator for wind direction on helicopter landing zones or marking of drop zones. The smoke grenade consists of a cylindrical body filled with a smoke composition which is ignited by the next generation of a fly-off lever igniter. Its outstanding design fulfils STANAG 4497 (Hand- Emplaced Munitions) which means no stored energy in the ignition chain. In the unlikely case the grenade was armed but not used, it can be disarmed again easily. Upon ignition the smoke grenade will produce a dense coloured smoke over the specified period. Operation: 1. Place the grenade into throwing hand; fly-off lever pointing inwards. 2. Rotate / turn cap counter-clockwise. 3. Throw smoke grenade downwind side. Lenght: Diameter: Smoke burning time: 131mm 55mm 246 gram nominal 30 sec Delay time : 2,5 ±1 sec Colours Operational temperature: -33 to +71 C Net Explosive Mass: Product Code: orange, green, violet, red, yellow, white, blue 130 gram N/A (orange) TBA (green) TBA (violet) TBA (red) TBA (yellow) TBA (white) TBA (blue) TBA UN Number: Packing: UN 0197 Signals, smoke 20 Smoke Grenades packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 2.6kg 8.1kg 0.012m³ SIGNAL & ILLUMINATION This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements.

25 Smoke Grenade, Coloured, 60 sec Available Smoke Colours Application: Smoke Grenades provide combat forces with a means of communication / signalling during daylight. Besides individual signalling codes, smoke grenades are used, for example, as indicator for wind direction of helicopter landing zones or marking of drop zones. The smoke grenade consists of a cylindrical body filled with a smoke composition which is ignited by the next generation of a fly-off lever igniter. Its outstanding design fulfils STANAG 4497 (Hand- Emplaced Munitions) which means no stored energy in the ignition chain. In the unlikely case the grenade was armed but not used, it can be disarmed again easily. Upon ignition the smoke grenade will produce a dense coloured smoke over the specified period. Operation: 1. Place the grenade into throwing hand; fly-off lever pointing inwards. 2. Rotate / turn cap counter-clockwise. 3. Throw smoke grenade downwind side. Diameter: Smoke burning time: 131mm 55mm 246 gram nominal 60 sec Delay time : 2,5 ±1 sec Colours Operational temperature: -33 to +71 C Net Explosive Mass: Product Code: orange, green, violet, red, yellow, white, blue 130 gram N/A (orange) TBA (green) TBA (violet) TBA (yellow) TBA (white) TBA (blue) TBA (red) TBA UN Number: UN 0197 Proper Shipping Name: Packing: Signals, smoke 20 Smoke Grenades packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 2.6 kg 8.1 kg m³ SIGNAL & ILLUMINATION This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements.

26 Smoke Grenade, Coloured, 90 sec Available Smoke Colours Application: Smoke Grenades provide combat forces with a means of communication / signalling during daylight. Besides individual signalling codes smoke grenades are used, for example, as indicator for wind direction on helicopter landing zones or marking of drop zones. The smoke grenade consists of a cylindrical body filled with a smoke composition which is ignited by the next generation of a fly-off lever igniter. Its outstanding design fulfils STANAG 4497 (Hand- Emplaced Munitions) which means no stored energy in the ignition chain. In the unlikely case the grenade was armed but not used, it can disarmed again easily. Upon ignition the smoke grenade will produce a dense coloured smoke over the specified period. Operation: 1. Place the grenade into throwing hand; fly-off lever pointing inwards. 2. Rotate / turn cap counter-clockwise. 3. Throw smoke grenade downwind side. Diameter: Smoke burning time: 131mm 55mm 246 gram nominal 90 sec Delay time : 2,5 ±1 sec Colours Operational temperature: -33 to +71 C Net Explosive Mass: Product Code: orange, green, violet, red, yellow, white 130 gram N/A (orange) TBA (green) TBA (violet) TBA (red) TBA (yellow) TBA (white) TBA UN Number: UN 0197 Proper Shipping Name: Packing: Signals, smoke 20 Smoke Grenades packed in a steel (4A), type PA19 Qty. per NEQ (kg) GR Wgt (kg) G 2.6kg 8.1kg 0.012m³ SIGNAL & ILLUMINATION This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements.

27 Smoke Grenade, Screening, 30 sec, low toxic Application: The Screening Smoke Grenade is designed to produce a dense curtain of smoke to mask the removal or deployment of personnel in tactical and training situations. The grenade can be used in various military and law enforcement operational and training scenarios such as: Interruption of line-of-sight in visible spectrum. Reducing the accuracy of enemy fire. Situations where temporary invisibility can substantially increase the survivability of individuals or groups of soldiers. The smoke grenade consists of a cylindrical body filled with a smoke composition which is ignited by the next generation of a fly-off lever igniter. Its outstanding design fulfils STANAG 4497 (Hand- Emplaced Munitions) which means no stored energy in the ignition chain. In the unlikely case the grenade was armed but not used, it can disarmed again easily. Upon ignition the smoke grenade will produce a dense coloured smoke over the specified period. Operation: 1. Place the grenade into throwing hand; fly-off lever pointing inwards. 2. Rotate / turn cap counter-clockwise. 3. Throw smoke grenade downwind side. Lenght: Diameter: Smoke burning time: Delay time: Colours Qty. per 131mm 55mm 246 gram nominal 30 sec (other smoke durations on request) 2,5 ±1 sec white to greyish Operational temperature: -33 to +71 C Net Explosive Mass: Product Code: 130 gram N/A TBA UN Number: UN 0197 Proper shipping name: Packing: Signals, smoke 20 Smoke Grenades packed in a steel (4A), type PA19 NEQ (kg) GR Wgt (kg) G 2.6kg 8.1kg 0.012m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. SIGNAL & ILLUMINATION

28 Hand Grenade Smoke Coloured Application: Smoke grenades provide to combat forces a means of communication and signalling during daylight. Besides individual signalling codes smoke grenades are used to mark e.g. landing zones with the indication of wind for helicopter pilots. The smoke grenade consists of a cylindrical body filled with a smoke composition which is ignated by a fly-off-igniter, which is integrated into the closure lid of the grenade. Upon ignition the smoke grenade will produce a dense coloured smoke over the specified period. Operation: 1. Place smoke grenade into throwing hand; fly-off lever pointing inwards. 2. Remove safety ring. 3. Throw smoke grenade downwind side. Weight Burning time: Net Explosive Mass: Colours: Product Code: TBA UN Number: Proper Shipping Name: Qty. per (PA19) 135mm 60mm 600 gram 60 sec. 150 gram blue, yellow, green, red, violet, white, orange not yet applied for tbd. tbd. NEQ (kg) GR Wgt (kg) G 2,1kg 4,2kg 0.012m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. SIGNAL & ILLUMINATION

29 Day & Night Signal Art No The compact, handheld Comet Day & Night Signal consists of a red flare at one end and an orange smoke at the other. Housed in a rugged, corrosion-resistant case and protected by end caps with O ring seals. Application This handheld signal has been designed for personal distress signalling and is ideal for divers, windsurfers, dinghy sailors and small boats operating inshore as well as outdoor pursuits such as mountaineering, and was originally designed for naval divers and helicopter/aircrew. Incorporates a red flare 15,000 candela at one end, for use at night and day, and a dense orange smoke at the other for daytime use. Both ends can be fired independently and can be doused in water after firing, allowing the unused end to be stowed until required. Operation (identical both ends) FOR DAY OR NIGHT USE ONLY WHEN RESCUE SERVICES ARE SIGHTED 1. Select the end to be used smoke by day, flare at night. Due to its high power the flare also has good visibility by day if required. The Signal has differently coloured and ribbed end caps to aid identification at night. 2. Remove end cap. 3. Hold clear of face and point downwind. 4. To activate pull toggle sharply away from body. Packing & Transport Information 100 signals in fibreboard carton Gross weight: 19.3 kg (45.55 lb.) Net 18.7 kg (41.23 lb.) Measurements of fibreboard : 37 x 27 x 27 cm (15 x 11 x 11 in) Net Explosive Content per carton: 5.14 kg (11.33 lb.) : 1.4G UN 0191 Proper Shipping name: Signal Devices, Hand Other Information: Cargo Aircraft Only Storage Ideally, should be stored in the robust, specially designed Polybottle, or in a dry, easily accessed location at ambient temperature. Specifications 190mm (7.48 in) Diameter: 30mm (1.18 in) Burning time: Smoke 18 seconds, Flare 20 seconds Light intensity: 15,000 candela Colour of smoke: Orange Colour of flare: Red 187g (6.603oz) NEC: 51.49g (1.8 oz) Ignition: Pull wire ignitor WARNING Produces red hot flame - do not point at people Produces dense orange smoke - do not inhale Do not fire in a confined space Keep out of reach of children Only for emergency use at sea If damaged or dented do not use Do not dismantle Keep away from source of heat Do not use after expiry date DISPOSAL Pyrotechnics must be treated as hazardous items and must be disposed of responsibly in accordance with local regulations. For help and advice, visit our website Issue 3 10/2017

30 Linethrower 250 Art Nos. Complete unit Body and line Rocket A self-contained line-throwing appliance consisting of a weatherproof plastic casing with end cap, twist-grip trigger assembly, rocket and line. To comply with SOLAS requirements, four complete rocket and line assemblies (Art. No ) should be carried on board. The device has a throwing range of between 230m and 250m. A solid propellant is used which guarantees a highly accurate flight path even in strong sidewinds. Rocket Application The Comet Linethrower 250 is designed for ease of operation in the most extreme weather conditions. It can be used in all situations where a line is required to be passed accurately and quickly, these include:- All line-throwing operations at sea between vessels, ship-to-shore, shore-to-ship and shore based rescue services. Rescue of swimmers in distress. Line carrying across obstacles and rough terrain. Operation Specifications Projects a line to a nominal range of 250m in calm conditions. 33 cm (13.0 ) Height: 31.3 cm (12.3 ) Diameter: 20.5 cm (8.1 ) 4.4 kg (9.7 lb.) Rocket Weight Max: 472g (1 lb.) Explosive Content Max.:118g (4.16 oz.) Line breaking strain: >2 kn Polystyrene plug Disc Lid Remove the front cover and point in the desired flight direction. 2. Pull out safety pin. 3. Aim over the top of target. Be prepared for recoil. 4. Turn grip to left or right to fire. 5. If misfire occurs hold unit in firing position for at least 60 seconds, then dispose of overboard. Product Life Body and line kit: 9 years Rocket 3 years Spare rockets are available to replace consumed or time expired rockets. Packing & Transport Information Body and Line, less rocket in packing case, L 37 cm (14.57 in) x W 27 cm (10.63 in) x H 27 cm (10.63 in) Gross weight 4.2 kg (9.26 lb.) Net weight 3.6 kg (7.94 lb.) Other Information: Non-hazardous 20 Spare Rockets in metal tin in a fibreboard, L 37 cm (14.57 in) x W 27 cm (10.63 in) x H 27 cm (10.63 in) Gross Weight Max: kg (27.99 lb.) Net Weight Max: 9.40 kg (20.72 lb.) Net Explosive Content per : 2.36 kg (5.2 lb.) class 1.4G UN 0431 Proper shipping name: Articles, Pyrotechnic Other Information: Cargo Aircraft Only Spring Cap Safety Pin Rope container Storage This compact appliance is ideally stored in a water-resistant locker at ambient temperature allowing easy access in an emergency. The set of 4 appliances normally carried onboard can be dispersed in strategic positions throughout the vessel. Approvals Conforms to: BAM-P2-0014, 0589-P2-0016, SOLAS 74 as amended, IMO resolutions MSC. 81(70) Part 1, (MED) 96/98/EC, BGV , SAS S010012, USCG - and other major maritime authorities worldwide. Line Line-throwing rocket Firing Handle Issue 3 10/2017

31 Art No The White Handflare is for use as a collision warning signal or for illumination of small areas. Designed to withstand exceptional environmental exposure and to perform reliably even after immersion in water. Featuring a unique telescopic handle with improved grip, making it very compact for stowage. Easily extended for safe handling and operation by pull wire ignitor. Produces hot white flame for 60 seconds at 2,500 candela. Application For use by day or night as a short-range collision warning signal, to pinpoint position and to illuminate small areas at night. These may be carried on the ship s bridge and are recommended for yachts making night passages. Four white handflares are included in our RORC kits. Also available is the similar red handflare (Art No ), which is used to signal distress. Operation Specifications 175mm (6.9 in) Length with handle pulled out: 280mm (11 in) Diameter: 28mm (1.1 in) 170g (6.003oz) Light intensity: 2,500 candela Burning time: 60 seconds Colour of light: white Ignition: pull wire ignitor Net explosive content: 60g (2.12oz) Pull Downwind Pull wire Ball Screwed cap 1. Pull out white end until telescopic tube is fully extended and engaged. 2. Unscrew white end cap and point away. 3. Pull ball out sharply to fire. 4. Hold at arms length. Point Downwind. End plug ejects after 2 seconds delay. Packing & Transport Information 100 flares in 1 fibreboard Gross weight 17.6 kg (38.80 lb.) Net weight 17 kg (37.48 lb.) Measurements of fibreboard : 37 x 27 x 27cm (15 x 11 x 11 in) Net Explosive Content per : 6 kg (13.23 lb.) 1.4G UN0191 Proper Shipping Name: Signal Devices Hand Other Information: Cargo Aircraft Only Storage The telescopic handle saves stowage space. Ideally, both red and white handflares should be stored in our robust, specially designed polybottles, or in a dry, easily accessed location at ambient temperature. Do not store near sources of heat. Adhesive tape Disc Ignitor housing Primer composition Handle Ring Primer Pull wire Delay composition Flare composition Telescopic tube Retaining collar Issue 3 10/2017

32 Red Handflare Art No The Handflare MK8 conforms to SOLAS 74 as amended. Designed to withstand exceptional environmental exposure and to perform reliably even after immersion in water. Featuring a telescopic handle with improved grip, making it very compact for stowage. Easily extended for safe handling and operation by pull wire ignitor. Produces hot red flame for 60 seconds at candela. Application For use day or night the Comet Red Handflare is a short-range distress signal used to pinpoint position. May be carried on ships bridge and six are required to be fitted in ships lifeboats and liferafts. The handflare is suitable for use on other commercial and recreational boats. Also available is the Comet White Collision Warn-off Handflare which is for use day or night when a collision danger exists or for the illumination of small areas outside. (Art No ) Operation 1. Pull out red end until telescopic tube is fully extended and engaged. 2. Unscrew red end cap and point away. 3. Pull ball out sharply to fire. 4. Hold at arms length. Point Downwind. End plug ejects after 2 seconds delay. Pull Downwind Specifications 175mm (6.9 in) Length with handle pulled out: 280mm (11 in) Diameter: 28mm (1.1 in) Weight Max:176g (6.2 oz) Light intensity: 15,000 candela Burning time: 60 seconds Colour of light: red Ignition: pull-wire ignitor Net Explosive Content Max.: 63g (2.22 oz) Pull wire Adhesive tape Disc Ignitor housing Primer composition Ball Screwed cap Primer Pull wire Delay composition Flare composition Packing & Transport Information 100 flares in 1 fibreboard Gross Weight Max: kg (40.12 lb.) Net Weight Max: 17.6 kg (38.8 lb.) Measurements of fibreboard : 37 x 27 x 27cm (15 x 11 x 11 in) Net Explosive Content per Max: 6.3 kg (13.89 lb.) 1.4G l UN 0191 Proper Shipping Name: Signal Devices, Hand Other Information: Cargo Aircraft Only Storage Ideally, both products should be stored in the robust, specially designed Polybottle, or in a dry, easily accessed location at ambient temperature. Approvals Handle Ring Telescopic tube Retaining collar Conforms to: SOLAS 74 as amended, IMO resolution MSC. 81(70) Part 1, (MED) 96/98/EC, BGV , BAM P1-0594, 0589-P1-0617, USCG and other major maritime authorities worldwide. Issue 3 10/2017

33 Red Parachute Signal Rocket Art No The Comet Red Parachute Signal Rocket conforms to SOLAS 74 as amended. Designed to withstand exceptional environmental exposure and to perform reliably even after immersion in water, the pull wire ignitor and improved grip provides easy handling. Ejecting a red flare suspended on a parachute at 300m (1000ft), burning for 40 seconds at 30,000 candela. Application A day or night long-range distress signal. 12 may be carried on ships bridge and there is a requirement for 4 in ships lifeboats and liferafts. Also suitable for use in other commercial and recreational boats. Operation 1. Hold signal firmly by ribbed handle. Unscrew RED bottom cap. Do not point at people or property. 2. Hold rocket vertically above head pointing away from body. 3. Ensure hands remain clear of top. To fire - pull red ball sharply down. Packing & Transport Information 56 rockets in 2 metal tins in a fibreboard Gross weight 16.3 kg (35.93 lb.) Net weight 13.7 kg (30.20 lb.) Measurements of fibreboard : 47 x 27 x 35 cm (18.5 x 10.6 x 13.8 in Net Explosive Content per Max: kg (11.36 lb.) 1.4G l UN 0505 Proper Shipping Name: Signals, Distress, Ship Other Information: Cargo Aircraft Only Storage Ideally, should be stored in the robust, specially designed Polybottle, or in a dry, easily accessed location at ambient temperature. Approvals Conforms to SOLAS 74 as amended, IMO Resolution 96/98/EC. MED - BGV : BAM-P2-0059, 0589-P2-0046, USCG and other major maritime authorities world wide. Specifications 287 mm (11.3 in) Diameter at handle: 38 mm (1.5 in) Diameter: 32 mm (1.25 in) Weight Max: 245g (8.23 oz) NEC Max: 92g (3.25 oz) Light intensity: 30,000 candela Burning time: 40 seconds Colour of light: red Ignition: pull-wire ignitor Altitude: 300 m (985 ft) Rubber Cap Band Split pin Disc Flare composition Tube Ejection charge Combustion chamber Propellant Ignition composition Ignition cap Carrier tube Pull wire Glue Sealing ring Adhesive String Disc Cap Parachute Cotton strand Washer disc Intermediate composition Ignition composition Delay composition Isolation Ring Ignition composition Outer tube with inside thread Ignition cap holder with outside thread Screwed cap Ball

34 Application Day and night signal attached to 4kg lifebuoy and used in an emergency to mark the position of man overboard. Provides 15 minutes of dense orange smoke. Far exceeds SOLAS requirements of 2 hours at 2 candela for light output and duration. Safe to use on petrol or oil covered water. Lithium batteries sealed for life - no annual replacement. Screw fit, inversion switched, LED light units. Automatic or manual deployment. Universal stainless steel mounting bracket. Usually mounted on a ships bridge wing Approved mounting height: 56m - but manufacturer tested to survive 100m drop into water. (SOLAS only requires 30m). Ideal for use on ships or rigs with high freeboard. Operation Light and Smoke Signal Art No The Light and Smoke Lifebuoy Marker produces dense orange smoke for 15 minutes and features two self contained, inversion switched, LED lights which far exceed SOLAS requirements for output and duration. Ships are required to carry 2 markers, one mounted on each bridge wing with the brackets supplied and attached by line to a 4kg Lifebuoy. The signal is used to mark the position of a man overboard by day or night. It can be automatically deployed by releasing the attached lifebuoy, or manually activated. The Comet Smoke Signal Art. No is identical, except that it does not feature the lighting system, so is an orange smoke daytime marker only. Specifications Height: 375mm (14.76 in) Diameter: 183mm (7.20 in) 3.3kg (7.27 lb.) Weight including bracket and angles: 3.85kg (8.5 lb.) Net Explosive Content: 1.287kg (2.84 lb.) Lamps (bulbs): 2 x 3.6v 2.0A Temperature range: -30 C to +65 C Burning time: 15 minutes Colour of light: white Duration: 2 candela for 2 hours Use with lifebuoy weighing: 4.0kg (8.82 lb.) Attach to lifebuoy with line: 4m (13ft) long, 9.5mm (0.37 in) diameter Ballast weight Smoke composition 1. S ignal and Lifebuoy mounted on bridge wing in ready to fire position. 2. Release locking pin and lifebuoy falls, automatically deploying marker. 3. Alternatively, manually throw lifebuoy overboard. Lithium battery Foamed float Screw fit light unit Packing & Transport Information 2 x signals in 1 fibreboard Max. Gross 9.5 kg (20.94 lb.) per Max. Net 7.7 kg (17 lb.) Measurements of fibreboard : 36 x 27 x 40 cm (14.2 x 10.6 x 15.8 in) Max. Net Explosive Content per : 2.574kg (5.67 lb.) class 1.4S UN 0507 Proper shipping name: Signals, Smoke Other information: Passenger and cargo aircraft Storage Firing Mechanism Bracket This compact unit is ideally stored in good magazine conditions in an upright position, mounted to its stainless steel bracket in our original packaging. Onboard vessel: Two units are normally required to be carried. Mounted inverted and attached to a Lifebuoy. Usually positioned on each bridge wing and need a clear, uninterrupted drop into the water Approvals Conforms to SOLAS 74 as amended. IMO Resolution MSC 81 (70) part 1. MED: Light & Smoke Signal - BGV , Smoke Signal - BGV BAM-P1-0596, 0589-P Lamp

35 Smoke Signal Orange Art No The Smoke Signal Orange is a compact, daylight distress signal designed to be easy and safe to handle. It provides effective position marking during rescue operations and can be used to indicate wind direction, producing dense orange smoke for a minimum of 3 minutes. Application Day and night signal attached to 4kg lifebuoy and used in an emergency to mark the position of man overboard. Provides 15 minutes of dense orange smoke. Far exceeds SOLAS requirements of 2 hours at 2 candela for light output and duration. Safe to use on petrol or oil covered water. Lithium batteries sealed for life - no annual replacement. Screw fit, inversion switched, LED light units. Automatic or manual deployment. Universal stainless steel mounting bracket. Usually mounted on a ships bridge wing Approved mounting height: 56m - but manufacturer tested to survive 100m drop into water. (SOLAS only requires 30m). Ideal for use on ships or rigs with high freeboard. Operation Specifications Height: 114 mm (4.5 in) Diameter: 82 mm (3.2 in) Gross Weight Max. 370g (13.05 oz) NEC Max. 239g (8.43 oz) Burning time: 3 minutes minimum Colour of smoke: orange Ignition: percussion ignitor with 2 seconds safety delay Lid Firing pin Downwind Ignition charge Outer casing 1. S ignal and Lifebuoy mounted on bridge wing in ready to fire position. 2. Release locking pin and lifebuoy falls, automatically deploying marker. 3. Alternatively, manually throw lifebuoy overboard. Packing & Transport Information 2 x signals in 1 fibreboard Max. Gross 9.5 kg (20.94 lb.) per Max. Net 7.7 kg (17 lb.) Measurements of fibreboard : 36 x 27 x 40 cm (14.2 x 10.6 x 15.8 in) Max. Net Explosive Content per : 2.574kg (5.67 lb.) class 1.4S UN 0507 Proper shipping name: Signals, Smoke Other information: Passenger and cargo aircraft Storage Smoke composition This compact unit is ideally stored in a water-resistant locker at ambient temperature allowing easy access in an emergency or in the robust, specially designed polybottle. Approvals Conforms to SOLAS 74 as amended, Res. MSC 81 (70). Approvals: CE 0589, BAM P1-0191, 0589-P1-0324, BGV MED , USCG /21/0, /21/0, and other major maritime authorities worldwide. Issue 3 10/2017

36 Training & Simulation Applied Pyro-Technology to modern Battlefield Training and Simulation provides realistic theatre of war scenarios and effective stress inoculation to the participants. Tailored around our customers requirements the range of type-qualified pyrotechnic products for Training and Simulation enhances realism during tactical training of land forces. The use of laser or radio-frequency based training systems allows for very sophisticated weapon training. Visible and audible effects on the training ground are only achieved by applying pyrotechnic battle and weapon effect systems. Pyrotechnic effects support a variety of training scenarios such as IED Awareness, MOUT, Force on Force, Force on Target and ManPADS exercises. In combat training centres soldiers are prepared how to react in various combat situations. Product Types Battlefield Effects Weapon Effects Launchers

37 Training & Simulation Index Page Content 31. Scalable Gun Signature Simulator - SGSS 32. Lightweight Gun Signature Simulator - (LGSS) 33. Simulator for Artillery and Multi-effects (SAM) 34. Mini Launch Unit MLU 35. Portable Control Unit-PCU 36. Main Gun Signature Simulators MGSS 37. Direct/Indirect Fire Cue Simulator APFSDS 38. Direct/Indirect Fire Cue Simulator Smokes 39. Direct/Indirect Fire Cue Simulator Air Burst 40. Surface-to-Air Missile Simulator ManPADS M Flash Bang Smoke Simulator Mini FBSS 42. Micro Pyro Card MiPC 43. Macro Pyro Card MaPC 44. Tank Cannon Fire Simulator DM54 A1 / DM Hit-Indicator Simulator DM29 / DM Impact Simulator (Thunderflash) MECoSt 47. Impact Simulator (Thunderflash)

38 Scalable Gun Signature Simulator - SGSS Application: SGSS 32 (operation mode) SGSS 16 (operation mode) SGSS 8 (operation mode) To enhance realism during tactical training the possibility to simulate different weapon effects such as hostile and artillery fire, booby traps or a tank main gun, is needed. The SGSS enables the soldier to train under stress in force-on-force or force-on-target exercises by simulating direct or indirect fire and hits. It is also deployable in urban operation training as a scalable means to simulate detonation from bombs or IED. The SGSS is a launcher available in 32, 16 and 8 shots version. It is using pyrotechnic cartridges from the MECS family (Multiple Effects Cartridge System) such as the MGSS, the FBSS, the airburst and the colour smokes simulators. By means of these cartridges the launcher delivers single shots, bursts or salvo firings and therefore provides realistic combat situations. It can be wirelessly initiated by an instructor as well as by hardwire when connected to a trigger, a trip wire or a motion sensor. Characteristics: The effects characteristics depend on the cartridge configuration chosen. The firing sequence can be programmed by the user to meet the requirements. The effects available are those provided by the MECS cartridges (flash-bang-smoke and coloured smokes) which stay in the launcher until they are unloaded. Dimensions: (length/width/height) (including battery) Battery: Operating time: Power supply: Power consumption: Peak power: Safety delay time: Safety warning signal: Temperatures: Service interface: Operational interface: Ammunition type: Product Codes: SGSS 32: SGSS 16: SGSS 8: Packaging: SGSS 32 = 405 x 225 x 135mm SGSS 16 = 285 x 225 x 135mm SGSS 8 = 155 x 130 x 135mm SGSS 32 = 11.3kg SGSS 16 = 8.5kg SGSS 8 = 2.8kg SGSS 32 = Pb, 12V, 7200mAh SGSS 16 = Pb, 12V, 7200mAh SGSS 8 = 2 pcs. Li-ion 9V-650mAh up to 120h with battery Ext 12 V 32 V DC 20 ma (Standby) 3.5 A per round (max. 300 ms) 30 seconds acoustical and optical Storage -33 C to +71 C Operation -30 C to +49 C (ext. Power supply) RS 232 / charging Trigger input (5-36V DC): 20mA READY-TO-FIRE-OUT Radio (433MHz/315MHz/458MHz) 2 x RS 485 (daisy chain) Ethernet (prepared) CAN Bus (prepared) MECS M30/M31 Optional as per customer requirement TRAINING & SIMULATION

39 Lightweight Gun Signature Simulator (LGSS) Application To enhance realism during tactical training the possibility to simulate different weapon effects such as hostile and artillery fire, booby traps or a tank main gun, is needed. The LGSS enables the soldier to train under stress in force-on-force or force-on-target exercises by simulating direct or indirect fire and hits. It is also deployable in urban operation training as a scalable means to simulate detonation from bombs or IED. The LGSS is a launcher available in 16 or 32 shots versions. It is using pyrotechnic cartridges from the MECS family (Multiple Effects Cartridge System) such as the MGSS, the FBSS, the airburst and the colour smokes simulators. By means of these cartridges the launcher delivers single shots, bursts or salvo firings and therefore provides realistic combat situations. It can be wirelessly initiated by an instructor as well as by hardwire when connected to a trigger, a trip wire or a motion sensor. Characteristics: LGSS 16 (operation mode) LGSS 32 (operation mode) LGSS without frame e.g. for vehicle mounting The effects characteristics depend on the cartridges configuration chosen. The firing sequence can be programmed by the user to meet his requirements. The effects available are those provided by the MECS cartridges (flash-bang-smoke and coloured smokes) which stay in the launcher until they are unloaded. Dimensions: (length/width/height) (steel frame + battery) Battery: Operating time: Power supply: Power consumption: Peak power: Safety delay time: Safety warning signal: Temperatures: Service interface: Ammunition type: Product Codes: LGSS 16 = 335 x 302 x 285mm LGSS 32 = 485 x 302 x 285mm LGSS 16 = 10.2kg LGSS 32 = 14.7kg Pb, 12V, 7200mAh up to 120h with battery Ext 12 V 32 V DC 20 ma (Standby) 3 A per round (max. 500 ms) 30 seconds acoustical and optical Storage -33 C to +71 C Operation -30 C to +49 C Trigger input (5-32V DC): 20mA READY-TO-FIRE-OUT Radio (433MHz/315MHz/458MHz) 2 x RS 485 (daisy chain) Ethernet (prepared) CAN Bus (prepared) MECS M30/M31 In service with various NATO-Countries LGSS 16: LGSS 32: TRAINING & SIMULATION Packaging: Optional as per customer requirement

40 Simulator for Artillery and Multi-effects (SAM) Application SAM 16 (operation mode) Portable Control Unit SAM 32 (operation mode) The Simulator for Artillery and Multi-effects (SAM) is a launching device for Multiple Effect Cartridge System (MECS). It can be RF controlled via Portable Control Unit (PCU). The SAM is available as a 16 (SAM 16) or 32 (SAM 32) shots device. The SAM is a device for Simulation of Hostile Fire like Artillery. Its application is for outdoor training as a stand-alone device with an integrated battery. Initiation can be done via RF. It is possible to ignite up to six rounds simultaneously or as a burst. Technical Data Article No SAM 16: Article No SAM 32: Dimensions SAM 16: transportation (Depth/Width/Height): 267x298x283mm Dimensions SAM 32: transportation (Depth/Width/Height): 427x298x283mm Weight SAM 16: Weight SAM 32: 10,2kg 14,7kg Rechargeable Battery: Bb, 12V, 7200mAh Operating time: Power Supply: up to 72hrs. with battery Ext 12V 32V Safety Delay Time Initial: Safety Warning Signal: Temperature: Service Interface: Operational Interfaces: 30 seconds Upon completion of safety delay an acoustical and optical warning signal is given -18 C +49 C (operating) -40 C +70 C (storage) RS 232, Charge 1x RF-Module (433 MHz) TRAINING & SIMULATION

41 Mini Launch Unit MLU Application: To enhance tactical realism during training the possibility to simulate different weapon effects such as hostile and counter fire, hits or booby traps, is needed. The MLU, which can be used for outside and inside trainings, as well as on vehicles, enables the soldier to train under stress in force-on-force exercises by providing direct fire and hit simulations. It is also deployable in military operations on urban terrain trainings as a scalable means to simulate detonation from grenades or IED. The MLU is a launching device for the Macro Pyro Card (MAPC) and the Micro Pyro Card (MIPC). Their various effects enable to replicate combat situations. By means of those cards, the launcher provides single shots, bursts or salvo firings. The device can be operated with either an external power supply or with integrated battery. It can be wirelessly initiated by an instructor as well as by hardwire when connected to a trigger, a trip wire or a motion sensor. Characteristics: The effects available are those provided by the Macro Pyro Card and the Micro Pyro Card (flash-bang-smoke) which stay in the launcher until they are unloaded. The firing sequence can be programmed by the user to meet his requirements. Dimensions: w. battery = 156x160x154mm (length/width/height) w/o battery = 156x160x125mm w. battery = 2,3kg w/o battery = 1,7kg Battery: Operating time: Power supply: Power consumption: Peak power: Safety Delay Time: Safety warning signal: Temperatures: Service Interface: Operational Interface: Ammunition type: Product Code: Pb, 12V, 7200mAh up to 72h with battery xt 12 V 32 V DC 20 ma (Standby) 3,5 A per round (max. 500 ms) 30 seconds pending UN Number: Proper Shipping Name: acoustical and optical Storage -30 C to +70 C Operation 20 C to +50 C RS 232/charging trigger input (5-32V DC): 20mA READY-TO-FIRE-OUT Radio (433MHz/315MHz/458MHz) 2 x RS 485 (daisy chain) Ethernet (prepared) CAN Bus (prepared Macro Pyro Card/Micro Pyro Card N/A N/A TRAINING & SIMULATION Packaging: Optional as per customer requirement

42 Portable Control Unit-PCU Application: To enhance tactical realism during training the possibility to simulate different weapon effects such as hostile and artillery fire, hits or booby traps, is needed. Through the PCU the instructor can provide realistic simulations of battlefield effects at all times by remotely controlling the launching devices. And when facing changing training situations, the software enables him to react quickly. Due to this capability the soldier is able to train efficiently under stress in force-on-force or force-on-target exercises. The PCU can be set up to control up to 20 devices, such as the LGSS and the MLU. By mean of its user interface the controlled devices can be placed virtually on the PCU s screen and switching between devices can be done with a simple touch on the screen. Depending on the training, firing sequences and combinations can be chosen by the user to provide the most desirable effects to each situation. This enables the instructors to react very quickly on changing training situations and to be ahead with realistic simulation of battlefield effects all the time. Characteristics: The effects characterising the use of the PCU are those of the simulators set in the devices controlled by the PCU. It includes flash-bang-smoke and coloured smokes from the MECS family cartridges and the pyro cards. Dimensions: (length/width/height) Battery: Operating time: Display: Processor: Temperatures: RF unit: Frequency: Wireless range: Interoperability: Product Code: 217x95x45mm 0,9kg NiMH Akku up to 10h with battery 1/4 VGA, TFT display with LED background and touchscreen, size 240x320 pixel Intel PXA255 X-Scale, 400 MHz Storage 40 C to +70 C Operation 30 C to +60 C UHF Narrow Band FM multi channel radio module 433MHz/315MHz/458MHz up to 150m LGSS MLU Other device possible In service with various NATO-Countries UN Number: Proper Shipping Name: Packaging: N/A N/A Optional as per customer requirement TRAINING & SIMULATION

43 Main Gun Signature Simulators MGSS Application: Laser-based firing during force-on-force training demand a visual differentiation between firing and hit. The simulation of muzzle flashes of the main gun of main battle tanks provide clear information to all participants during combat training which tank is engaged in active combat. The same applies to Range Gunnery Signature Simulators (RGSS) providing hostile fire to tank crews engaging tank targets. The principle of improving the stress inoculation of tank crews adds an important element to the preparedness for combat. Main Gun Signature Simulators are used in: Lightweight Gunnery Signature Simu-lators on tanks. Range Gunnery Signature Simulators on tank firing ranges. Fire marker units to simulate IED simulation. Fire Marker Units to simulate ground burst of artillery and mortar shells. The Main Gun Signature Simulator produces a bright flash, a well audible report and a clearly visible cloud of white smoke. Characteristics: Signature: MGSS M30 and FBSS L1A1 Launching devices: LGSS / SGSS Smoke effect on tank Muzzle flash, loud report and white smoke Sound pressure: 162 db at 1m (MGSS M30) Sound pressure: 150 db at 1m (FBSS L1A1) Visibility: at least 3,000m Safety distance: 5m in firing direction and 1,0m to both sides (ear protection) Diameter: Diameter: 60mm 28mm (middle section) 34mm (bottom) 26 gram Net Explosive Mass: 6 gram (MGSS M30) Net Explosive Mass: Product Code: 5 gram (FBSS L1A1) In service with several NATO Countries. MGSS M30: FBSS L1A1: UN Number: wooden UN 0431 steel UN 0430 Proper Shipping Name: Packing: Articles, pyrotechnic 30 items in 1 cardboard 12 cardboard es = 360 items in wooden 2 cardboard es = 60 items in steel (FBSS L1A1) Other packaging methods on request Type Qty. per NEQ GR Wgt M G 2.16 kg 19.0 kg m³ L1A G 1.80 kg 18.6 kg m³ Vol TRAINING & SIMULATION L1A G 0.30 kg 4.4 kg m³

44 Direct/Indirect Fire Cue Simulator APFSDS Application: Laser-based firing during force-on-force training demands a visual differentiation between firing and hit. Most of today s laser based firing simulators allow the selection of ammunition to engage an opposing tank, e.g. HEAT, APFSDS munitions. It is, therefore, essential to provide an accurate effect of hits caused by APFSDS ammnution. The APFSDS cartridge is fired from the Light Gunnery Signature Simulator attached to the tank and delivers a glaring flash in the centre followed by small flares streaming upwards. It thus offers the gunner the visual effect of hitting a steel target with kinetic energy penetrator. Characteristics: Signature: Centre-flash: 12 flares at 15m height Sound level: 135 db at 2m distance Burning time: nom 2 sec. (flares) Visibility: 3.000m Safety distance: 50m in firing direction and 1,0m to the sides (ear protection) Diameter: Diameter: Net Explosive Mass: Qty. per 74mm 28mm (middle section) 32mm (bottom) 28 gram 9 gram In service with US Army ( ) (M31A1) Product Codes: (yellow) (green) to be applied for (red) to be applied for UN Number: Proper Shipping Name: UN0431 Articles, pyrotechnic NEQ (kg) GR Wgt (kg) G 3,24kg 20,0kg 0.050m³ TRAINING & SIMULATION

45 Direct/Indirect Fire Cue Simulator Smokes Application: Laser-based and/or radio transmitted firing of integrated weapons during force-on-force training either in closequarter combat scenarios, or battlefield training demand a visual differentiation between firing and hit. Depending on the training doctrine of the users certain colours stipulate hits whilst black smoke indicates a tank kill. Colour-Smoke-Cartridges are used to indicate and to differentiate effects from hits of direct and indirect fire. The cartridges are fired from Light-weight Gunnery Signature Simulators (LGSS) or from type classified launchers. Prolonged burning times and extended visibility provide clear information to all participants during combat training. Characteristics: Signature: Sound level: Smoke duration: 8-15 sec. Smoke: yellow, red, blue, green, white, orange, violet and black 125 db at 1m Visibility: approx 1.800m Safety distance: 1m in firing direction and 0,5m to the sides (ear protection) Diameter: Diameter: Net Explosive Mass: Product Codes: Qty. per 74mm 28mm (middle section) 32mm (bottom) 30 gram 10,5 gram In service with various NATO-Countries (yellow) (red) (blue) (green) to be applied for (white) to be applied for (orange) to be applied for (violet) to be applied for (black) to be applied for UN Number: Proper Shipping Name: UN0197 Signals, smoke NEQ (kg) GR Wgt (kg) G 3,78kg 21,0kg 0.012m³ TRAINING & SIMULATION

46 Direct/Indirect Fire Cue Simulator Air Burst Application: An indirect firing (simulation of artillery and or mortar fire) during force-on-force engagement training demands a visualisation of shells detonating either as ground or airbursts in the assumed combat zone. The Air Burst Cartridges can be activated from the Lightweight Gunnery Signature Simulator (LGSS) in either a static (placed permanently on the training ground) or movable configuration (placed on a vehicle) to simulate the effect of artillery or mortar shells, detonating in the air. Ground-bursts can be simulated by firing Main Gun Signature Simulators from LGSS. Characteristics: Signature: Sound level launch: airburst: Altitude: Launch blast, bright flash, white smoke cloud and loud report. 135 db at 2m distance 140 db at 18m distance 18 to 20m Visibility: 3,000m Safety distance: 50m in firing direction and 1,0m to the sides (ear protection) Diameter: Diameter: Net Explosive Mass: Product Code: Qty. per 74mm TBA UN Number: Proper Shipping Name: 28mm (middle section) 32mm (bottom) 26 gram 4 gram In service with several armies (M31) UN0431 Articles, pyrotechnic NEQ (kg) GR Wgt (kg) G 1,44kg 20,0kg 0.050m³ TRAINING & SIMULATION

47 Surface-to-Air Missile Simulator ManPADS M 176 Application: Shoulder launched, man-portable surface to air missiles (ManPADS) are a serious threat to helicopters and other low flying aircrafts. With an identified incoming missile, pilots are required to carry out escape manoeuvres besides the usage of the on board decoy systems. To visualise the threat scenario is essential during training. The ManPADS Simulator provides upon ignition a blast, a flare and a white smoke trail for about 10 seconds, thus simulating the launch and the flight path of a groundto-air-missile. The ManPADS Simulator, which is self consuming and thus leaves no debris after launch, is fired from the original WESS launcher system and can be configured as: Single shot simulator Multiple-launch device Add-on to any LGSS system. The ManPADS Simulator provides sufficient signature for the detection MLRS-Launches. Characteristics: Signatures: Flash-bang upon ignition on ground Flare and white smoke trail during flight Sound pressure: 140 db at 20m (launch noise) Flight time: nom. 10 seconds Light intensity: cd. Visibility: at least 3,000m WESS Launcher Safety distance: 15m from point of firing with ear protection Diameter: Diameter Bottom: 100mm 72mm 80mm 465g Pyrotechnic Effect Charge: 320g Ejection Charge: Cartridge Material: 40g Plastic In service with US Armed Forces (M 176) Product Code: UN Number: UN 0431 Proper Shipping Name: Packing: Articles, pyrotechnic 12 items in Steel Box (4A) 2 Steel Boxes = 24 items in wire bound (4D) Qty. per Product picture NEQ (kg) Smoke signature GR Wgt (kg) G 8.6 kg 21.7 kg 1.05 m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. TRAINING & SIMULATION

48 Flash Bang Smoke Simulator Mini FBSS Application: The usage of explosive hand grenades in tactical close combat operations requires constant exercise. Hand grenade simulators (e.g. SAAB Training Systems AB) will upon functioning enable the combatant to use his training equipment. The usage of Mini FBSS in these hand grenades provide a realistic effect of an exploding hand grenade and increase the level of stress inoculation of the trainee FBSS-Mini simulates the effects of a hand grenade being ignited. It produces a bright flash, an audible report and a cloud of white smoke. Characteristics: Signatures: Sound level: Flash effect Product picture Concept Muzzle flash, smoke and report 167 db in 10cm Safety distance: 10cm in firing direction (ear and eye protection) Diameter: Diameter: Effect Charge: Material: Sound Level: Product Code: 36mm TBA 28mm (middle section) 34mm (bottom) 11 gram Pyrotechnic 0,8 g flash charge High Impact plastic 167 db at 10 cm UN Number: UN 0431 Proper Shipping Name: Packing: In service with Swedish Army Articles, pyrotechnic 30 items in cardboard 12 cardboard es = 360 items in 1 wooden Qty. per NEQ (kg) GR Wgt (kg) G 0.29 kg 12.0 kg This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. TRAINING & SIMULATION

49 Micro Pyro Card MiPC Application: Military Operations on Urban Terrain (MOUT) required a paradigm change of operational and tactical doctrines. Accordingly, the training of soldiers in urban environments has to be adapted. The inclusion of combat effects (rifle fire, explosives, grenades and IEDs) during training demands realistic effects as well as the highest degree of safety. Micro Pyro Cards offer this realism whilst the trainee is still faced with demanding threat situations during the exercise. The Micro Pyro Cards use circuit board technology for the transmission of electronic information to the operator and the ignition of the effect charges without using additional electric squibs. 11 pyrotechnic effects are applied to a credit-card-size board which is designed mainly for indoor usage. Characteristics: Signature: Flash, bang and smoke Sound pressure: 140 db at 1m Reaction time: Visibility: 100ms at least 500m Safety distance: 2,5m in firing direction, 1m sidewards without protection. 1,5m safety area around (wearing safety goggles with side protection) Width: Height: Grossweight: Net Explosive Mass: Product Code: Qty. per 107mm 50mm max. 3mm 17 gram 0,33 gram Safety certification ongoing by US Army to be applied for UN Number: Proper Shipping Name: UN0432 Articles, explosive, n.o.s. NEQ (kg) GR Wgt (kg) S 0,055kg 7,3kg 0.024m³ TRAINING & SIMULATION

50 Macro Pyro Card MaPC Application: Military Operations on Urban Terrain (MOUT) required a paradigm change of operational and tactical doctrines. Accordingly, the training of soldiers in urban environments has to be adapted. The inclusion of combat effects (rifle fire, explosives, grenades and IEDs) during training demands realistic effects as well as the highest degree of safety. Macro Pyro Cards offer this realism whilst the trainee is still faced with demanding threat situations during the exercise. The Macro Pyro Cards use circuit board technology for the transmission of electronic information to the operator and the ignition of the effect charges without using additional electric squibs. 5 pyrotechnic effects are applied to a credit-card-size board which is designed mainly for outdoor usage. Characteristics: Signature: Sound pressure: 145 db at 1m Reaction time: Muzzle flash, loud report and white smoke 100ms Visibility: at least 1.000m Safety distance: 1m in firing direction and 1m sideways (ear protection) Width: Height: Grossweight: Net Explosive Mass: Product Code: Qty. per 96mm 80mm 40mm 50 gram/mapc 2 gram/effect Safety certification ongoing by US Army to be applied for UN Number: Proper Shipping Name: UN0353 Articles, explosive, n.o.s. NEQ (kg) GR Wgt (kg) G 0,4kg 7,5kg 0.025m³ TRAINING & SIMULATION

51 Tank Cannon Fire Simulator DM54 A1 / DM64 Application: Laser based firing during force-on-force training demands a visual differentiation between firing and hit. The simulation of muzzle flashes of the main gun on battle tanks provides clear information to all participants during combat training which tank is engaged in active combat. The same applies to Range Gunnery Signature Simulation (RGSS) indicating hostile fire to tank crew engaging tank target: Main Gun Signature Simulators are used in: Operation: Tank mounted launchers e.g. DARKAS. Range Gunnery Signature Simulators on firing. Fire Marker Units to simulate IED-Simulation. Ground burst simulation of artillery and mortar shells. Characteristics: The Main Gun Signature Simulator produces a bright flash, a very loud report (175 db) and a clearly visible cloud of white smoke. Signature: Sound pressure: Muzzle flash, loud report and white smoke 170 db at 1m (DM54) 140 db at 1m (DM64) Visibility: at least 3.000m Safety Distance: Main Gun Signature Simulators Launcher DARKAS 17 with Simulators Launcher mounted on tank 50m in firing direction and 30m to each side. Width: 143mm 50mm 130g Net Explosive Mass DM54: 42g Net Explosive Mass DM64: 25g (DM64) Product Code: In service with German Army both DM 54 and DM (DM54) (DM64) UN Number: UN 0430 Proper Shipping Name: Packing: Articles, Pyrotechnic 9 items in 1 cardboard 18 cardboard es = 162 items in 1 wooden Type Qty. per NEQ (kg) GR Wgt (kg) DM G 6.8kg 43kg 0.13m³ DM G 4.1kg 36kg 0.13m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. TRAINING & SIMULATION

52 Hit-Indicator Simulator DM29 / DM39 Application: The Hit-Indicator Simulator serve the visible/ audible (DM29) or the visible (DM39) simulation of hits during e.g. tank training. The pyrotechnic effect of the hit simulation on a tank or target device is realised by a red flash followed by a red smoke and followed by a loud report of 165 db (with report only DM39). Hit-Indicator Simulators are used in: Tank mounted launchers e.g. DARKAS. One Hit Simulator will be installed together with the Simulators Tank Cannon Firer. Range Gunnery Signature Simulators on firing. Fire Marker Units to simulate IED-Simulation. Characteristics: Flash: Sound pressure: Hit-Indicator Simulators Launcher DARKAS 17 with Simulators Pyrotechnic effect on tank colour red light intensity of cd duration 1.5 sec. colour red duration 5 sec. 165 db at 3m (DM29) no report (DM39) Visibility: at least 3.000m Safety Distance: 50m in firing direction and 30m to each side Width: Net Explosive Mass: 143mm 50mm 195g (DM29) 135g (DM39) 60g (DM29) 38g (DM39) In service with German Army both DM29 and DM39 Product Code: (DM29) (DM39) UN Number: UN 0430 Proper Shipping Name: Packing: 9 items in 1 cardboard Articles, Pyrotechnic 18 cardboard es = 162 items in 1 wooden Type Qty. per NEQ (kg) GR Wgt (kg) DM G 9.7kg 50kg 0.13m³ DM G 6.2kg 43kg 0.13m³ This is the standard method of pack. Other packs may be available subject to specification. Please contact our sales team to discuss your requirements. TRAINING & SIMULATION

53 Impact Simulator (Thunderflash) MECoSt Flash effect Product picture Smoke effect Application Simulation of grenade impacts during infantry training, both force on force and rifle fire training. The Impact Simulator MECoSt is based upon the proven quality of the MECS family and is the first impact simulator, which has no fragments or debris after the ignition. This mechanically ignited simulator provides upon ignition a glaring flash, a smoke cloud and a loud bang. Operation: The simulator is equipped with an uncocked striker mechanism. By removing the protection cap at the lower end of the simulator, the ignition strap will be exposed. When pulling the ignition strap, the ignition of the effect charge will occur after a delay of 5 seconds. Diameter: Dimensions: Pyrotechnic Effect Charge: Material: Sound Level: Delay Time Operation Temperature: Water Resistance: Product Codes: 162mm 34/28mm at the top 47g 490 x 400 x 210mm 5g High Impact plastic / cardboard up to 150 db at 3 meter 5 ±1 seconds between -33 C and +63 C submerge 1 meter deep under water for 1 hour N/A TBA UN Number: UN 0431 Proper Shipping Name: Articles, pyrotechnic Packing: 6 items in 1 cardboard 16 cardboard es = 96 items in 1 wooden Qty. per NEQ (kg) GR Wgt (kg) TRAINING & SIMULATION G 0.49kg 11.3kg 0.036m³

54 Impact Simulator (Thunderflash) DM32 / KK81/ KK78 Flash effect Smoke effect Other Thunderflash variations are available upon request. Please contact our sales team to discuss your requirements. Click link below to send enquiry: info@wescomdefence.com TRAINING & SIMULATION