MATERIAL SAFETY DATA SHEET SPRAY 'N' LIFT/LABEL REMOVER AUGUST Distributor's name and address

Transcription

1 MATERIAL SAFETY DATA SHEET AUGUST 2000 SECTION I GENERAL INFORMATION Distributor's name and address PerfectData Corporation 110 West Easy Street Simi Valley, California (805) PRODUCT NAME: ( ) EMERGENCY CONTACT: CHEMTRAC (800) NFPA HAZARD RATING HEALTH (blue): 1 FLAMMABILITY (red): 2 REACTIVITY (yellow): 0 Least-0 Slight-1 Moderate-2 High-3 Extreme-4 SECTION II CHEMICAL OR COMMON NAME: HAZARDOUS COMPONENTS Blend of Petroleum and Citrus Solvents 1. The specific chemical identities of the ingredients are considered to be trade secrets and are withheld in accordance with the provisions of of Title 29 of the Code of Federal Regulations. 2. Recommended Occupational Exposure Limit 100 parts per million (8 hour time weighted average) is based upon the ACGIH recommendation for components of the same chemical family. UN # 1255 SECTION III PHYSICAL DATA BOILING POINT (Deg F): >212o F FREEZE POINT (Deg F): <32 SPECIFIC GRAVITY: 0.8 SOLUBILITY IN WATER: Slightly miscible APPEARANCE: Red solution VOLATILES (% by wt): 99 PERCENT ACTIVE: 99 VAPOR DENSITY (Air=1) over 1 VAPOR PRESSURE(@68o F): <5 mm Hg ODOR: Citrus EVAPORATION RATE (butyl acetate=1): >1 1

2 MATERIAL SAFTY DATA SHEET SECTION IV FIRE AND EXPLOSION HAZARD INFORMATION FLASH POINT (Deg F--TCC): AUTOIGNITION TEMP (Deg F): No Data EXTINGUISHING MEDIA: SPECIAL FIRE FIGHTING PROCEDURES: UNUSUAL FIRE AND EXPLOSION HAZARDS: Foam, CO2, DryChemical. product will float and can be re-ignited on surface of water. Evacuate non-essential people from the fire area. Fire fighters should wear a positive pressure NIOSH approved self-contained breathing apparatus. Cool fire exposed containers with water fog. Containers exposed to intense heat from fires should be cooled with water fog to prevent vapor pressure buildup which could result in container rupture. The flash point of this product is over 100 degrees F. If heated, vapors may form which are heavier than air and may travel along the ground. Such vapors may be ignited by pilot lights, sparks, or open flames. FLAMMABLE LIMITS IN AIR VOLUME %: Lower 1.0% Upper: No Data SECTION V HEALTH HAZARD DATA PRINCIPLE ROUTES OF EXPOSURE: CONTACT WITH EYES: CONTACT WITH SKIN: SKIN ABSORPTION: INHALATION: INGESTION: HEALTH EFFECT OR RISKS FROM EXPOSURE: Skin, ingestion, inhalation Irritation, redness, tearing, blurred vision Prolonged or repeated liquid contact may result in drying of the skin, which may result in skin irritation. No data Excessive inhalation of vapors can cause nasal and respiratory irritation, dizziness, weakness, fatigue, nausea, headache, possible unconsciousness. Ingestion of product may result in vomiting; aspiration of vomitus into the lungs must be avoided as even small quantities may result in aspiration pneumonitis, as evidenced by coughing. No additional data 2

3 MATERIAL SAFETY DATA SHEET SECTION V (Cont'd) EMERGENCY AND FIRST AID PROCEDURES EYES: SKIN: INHALATION: INGESTION: MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: RECOMMENDATIONS TO PHYSICIAN: Flush eyes with plenty of water for 15 minutes while holding eyelids open. Seek medical attention. Remove contaminated clothing. Flush skin with water. Follow by washing with soap and water. If irritation occurs seek medical attention. If discomfort is experienced, remove to fresh air. If breathing is difficult, give oxygen and call physician. If breathing stops, begin artificial respiration; immediately seek medical attention. DO NOT INDUCE VOMITING. If vomiting occurs spontaneously, keep head below hip to prevent aspiration of liquid into lungs. Wash out mouth area and give moderate amounts of fluid to dilute. Don't give anything by mouth if patient is unconscious. Get medical attention immediately. As with any chemical, this product may aggravate allergic conditions in sensitive people. Ingestion of this product or subsequent vomiting can result in aspiration of light hydrocarbon liquid which can cause pneumonitis. Treatment of overexposure should be directed at the control of symptoms and the clinical condition. SECTION VI TOXICITY DATA SUSPECTED CANCER AGENT? Mixture is not considered a carcinogen by IRAC or NNTP. This mixture is reasonably believed not to contain any toxic chemicals in quantities subject to reporting requirement of SARA (1986, Section 313, Title111) and 40 CFR 372. SECTION VII REACTIVITY DATA STABILITY: Stable CONDITIONS TO AVOID: Heat, temperature extremes, flames, ignition sources MATERIALS TO AVOID: HAZARDOUS DECOMPOSITION PRODUCTS: HAZARDOUS POLYMERIZATION: Strong oxidizers, some plastics, reactive metals and some rubber products. Carbon oxides. Will not occur 3

4 MATRIAL SAFETY DATA SHEET SECTION VIII WARNING: SMALL SPILLS: WASTE DISPOSAL METHOD: SPILL OR LEAK PROCEDURES COMBUSTIBLE: Eliminate all ignition sources. The floor surface may be slippery. Use care walking, working and standing. Mop up and rinse area. Place excess spilled liquid into non-leaking containers for proper disposal. Incinerate liquid landfill contaminated absorbant. Avoid land filling liquids. Small amount of spilled material may be disposed of by allowing to evaporate in a well ventilated area. Dispose of wastes in accordance with Federal, State and Local regulations. SECTION IX TRANSPORT INFORMATION PROPER SHIPPING NAME: Non-Regulated HAZARD CLASS: Non-hazardous by CFR UN NUMBER: None This product IS NOT DOT regulated SECTION X SPECIAL PROTECTION INFORMATION VENTILATION AND ENGINEERING CONTROLS: In confined areas provide adequate ventilation to lower the concentration of excessive mists, vapors, or sprayed material. PROTECTIVE GLOVES: EYE PROTECTION: WORK PRACTICE: OTHER HANDLING AND STORAGE REQUIREMENTS: PROTECTIVE MEASURES DURING MAINTENANCE OF CONTAMINATE EQUIPMENT: During prolonged use, nitrile or butyl rubber gloves will decrease skin dryness and irritation. Protective eyewear may be used if there is risk of sprayed product coming into contact with eyes. All food should be kept in a separate area, away from the working location. After use, hands should be washed. All hazard precautions given in data sheet must be observed. Prolonged skin and inhalation contact should be avoided. Store in original container in a cool dry area away from other chemicals and food preparations. If possible, service equipment in well ventilated area. Use all proper safety procedures and exercise cuation. Plan maintenance to minimize exposure. 4

5 MATERIAL SAFETY DATE SHEET SECTION IX (Cont'd) PRECAUTIONARY STATEMENTS: CAUTION: KEEP OUT OF REACH OF CHILDREN SPECIAL PRECAUTIONS Do not get in eyes, on skin or on clothing. Do not take internally. Avoid breathing vapors. If eyes are contacted, irrigate eyes for 15 minutes. Seek medical attention if irritation persists. If skin is contacted wash with water. If discomfort is experienced after prolonged exposure to mists/vapors, remove to fresh air. Seek medical attention if discomfort persists. If ingested, DO NOT induce vomiting. Give moderate amounts of water or milk. If vomiting occurs spontaneously keep the victim's head below the hips to prevent aspiration of the compound into the lungs. WORK/HYGIENIC PRACTICES: The recommendations described herein are intended to provide general guidance for minimizing exposure and potential risk when handling this product. Because such conditions will vary depending with each possible application, specific safe handling procedures should be developed by persons knowledgeable of the intended use conditions and equipment. DISCLAIMER PERFECTDATA expressly disclaims all express or implied warranties for merchantability and fitness for a particular purpose, with respect to the product or information provided herein. All information appearing herein is based upon data obtained form the manufacturer and/or recognized technical sources.. While the information is believed to be accurate, PERFECTDATA makes no representations as to its accuracy or sufficiency. Conditions of use are beyond PERFECTDATA's control and therefore users are responsible to verify this data under their own operation conditions to determine whether the product is suitable for their particular purposes and they assume all risks of their use, handling and disposal of the product, or from the publication, or use of, or reliance upon, information contained herein. This information relates only to the product designated here and does not relate to its use in combination with any other material or in any other process. 5