Safety Data Sheet SILANCOLOR PRIMER

Transcription

1 dated 30/11/2012, version 1 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Trade name: 1.2. Relevant identified uses of the substance or mixture and uses advised against Silicon based primer in water dispersion Uses advised against: == 1.3. Details of the supplier of the safety data sheet Supplier: MAPEI S.p.A. -Via Cafiero 22 - Milan -ITALY Competent person responsible for the safety data sheet: sicurezza@mapei.it 1.4. Emergency telephone number MAPEI S.p.A. - Tel. +(39) (office hours) Poison Centre - Ospedale di Niguarda - Milan - Tel. +39/02/ SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Directive criteria, 67/548/CE, 1999/45/EC and following amendments thereof: Properties / Symbols: This product is not a hazardous article and need not be labelled according to EC Directive 67/548, 99/45 as amended. Adverse physicochemical, human health and environmental effects: other hazards 2.2. Label elements Special Provisions: Safety data sheet available for professional user on request. Special provisions according to Annex XVII of REACH and subsequent amendments: 2.3. Other hazards vpvb Substances: - PBT Substances: Other Hazards: other hazards SECTION 3: Composition/information on ingredients 3.1. Substances 3.2. Mixtures Hazardous components within the meaning of EEC directive 67/548 and CLP regulation and corresponding classification: SECTION 4: First aid measures Page n. 1 of 7

2 4.1. Description of first aid measures In case of skin contact: Wash with plenty of water and soap. In case of eyes contact: In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. Wash immediately with water for at least 10 minutes. In case of Ingestion: A suspension of activated charcoal in water, or petrolium jelly may be administered. Wash the mouth thoroughly and drink plenty of water. In case of disease consult a physician immediately and present this safety-data sheet. In case of Inhalation: Remove casualty to fresh air and keep warm and at rest Most important symptoms and effects, both acute and delayed specific hazards are encountered under normal product use Indication of any immediate medical attention and special treatment needed Treatment: (see paragraph 4.1) SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media: in particular. Extinguishing media which must not be used for safety reasons: in particular Special hazards arising from the substance or mixture The product does not present a fire hazard Do not inhale explosion and combustion gases. Burning produces heavy smoke. The original ingredients or unidentified toxic and/or irritant compounds may be present in the combustion fumes Advice for firefighters Use suitable breathing apparatus. Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Move undamaged containers from immediate hazard area if it can be done safely. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Wear personal protection equipment. Remove persons to safety. See protective measures under point 7 and Environmental precautions Limit leakages with earth or sand. Do not allow to enter into soil/subsoil. Do not allow to enter into surface water or drains. In case of gas escape or of entry into waterways, soil or drains, inform the responsible authorities Methods and material for containment and cleaning up Suitable material for taking up: absorbing material, organic, sand Wash with plenty of water. Retain contaminated washing water and dispose it Reference to other sections See also section 8 and 13 SECTION 7: Handling and storage Page n. 2 of 7

3 7.1. Precautions for safe handling Avoid contact with skin and eyes, inhaltion of vapours and mists. Do not eat or drink while working. See also section 8 for recomened protective equipment Conditions for safe storage, including any incompatibilities Keep away from food, drink and feed. Incompatible materials: in particular. Instructions as regards storage premises: Adequately ventilated premises. Store above 5 C Specific end use(s) in particular SECTION 8: Exposure controls/personal protection 8.1. Control parameters occupational exposure limit available DNEL Exposure Limit Values PNEC Exposure Limit Values 8.2. Exposure controls Eye protection: t needed for normal use. Anyway, operate according good working practices. Protection for skin: special precaution must be adopted for normal use. Protection for hands: The use of LLPDE (0,06 mm), nitrile (0,4) or butyl (0,5 mm) gloves is suggested. Latex gloves are not recommended. Respiratory protection: t needed for normal use. Personal Protective Equipment should comply with relevant CE standards (as EN 374 for gloves and EN 166 for goggles), correctly maintained and stored. Consult the supplier to check the suitability of equipment against specific chemicals and for user information. Thermal Hazards: Environmental exposure controls: SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Appearance: liquid Colour: opaco Odour: typical Odour threshold: ph: 8 Melting point / freezing point: == C Initial boiling point and boiling range: 100 C Solid/gas flammability: Page n. 3 of 7

4 Upper/lower flammability or explosive limits: Vapour density: Flash point: == C Evaporation rate: Vapour pressure: Relative density: 0,95-1,05 g/cm³ (23 C) Vapour density (air=1): Solubility in water: disperdibile Solubility in oil: == Viscosity: 20 mpa.s (23 C) Auto-ignition temperature: == C Explosion limits(by volume): == Decomposition temperature: Partition coefficient (n-octanol/water): Explosive properties: == Oxidizing properties: 9.2. Other information Miscibility: Fat Solubility: Conductivity: Substance Groups relevant properties SECTION 10: Stability and reactivity Reactivity Stable under normal conditions Chemical stability Stable under normal conditions Possibility of hazardous reactions Conditions to avoid Stable under normal conditions Incompatible materials in particular Hazardous decomposition products. SECTION 11: Toxicological information Information on toxicological effects Route(s) of entry: Ingestion: Yes Inhalation: Contact: Toxicological information related to the product: There is no toxicological data available on the mixture. Consider the individual concentration of each component to assess toxicological effects resulting from exposure to the mixture. Toxicological information of the mixture: Toxicological information of the main substances found in the mixture: Corrosive/Irritating Properties: Eye: The product can cause a temporary irritation by contact. Sensitizing Properties: effects are known. Page n. 4 of 7

5 Cancerogenic Effects: effects are known. Mutagenic Effects: effects are known. Teratogenic Effects: effects are known. If not differently specified, the information required in Regulation 453/2010/EC listed below must be considered as : a) acute toxicity; b) skin corrosion/irritation; c) serious eye damage/irritation; d) respiratory or skin sensitisation; e) germ cell mutagenicity; f) carcinogenicity; g) reproductive toxicity; h) STOT-single exposure; i) STOT-repeated exposure; j) aspiration hazard. SECTION 12: Ecological information Toxicity t available data on the mixture Aquatic toxicity: the preparation is not to be considered toxic to the aquatic environment based on components. LC50>100mg/l - aquatic species (calculated data following 1999/45/EC Directive). Adopt good industrial practices, so that the product is not released into the environment Persistence and degradability Bioaccumulative potential Mobility in soil Results of PBT and vpvb assessment vpvb Substances: - PBT Substances: Other adverse effects t available data on the mixture SECTION 13: Disposal considerations Waste treatment methods Recover if possible. In so doing, comply with the local and national regulations currently in force. 91/156/EEC, 91/689/EEC, 94/62/EC and subsequent amendments. Disposal of hardened product (EC waste code) : Disposal of not hardened product (EC waste code) : The suggested European waste code is just based on the composition of the product. According to the specific process or application field a different waste code may be necessary. SECTION 14: Transport information UN number UN Number: == UN proper shipping name Transport hazard class(es) Page n. 5 of 7 Rail/Road(RID/ADR): no dangerous good

6 ADR-Upper number: NA Air (ICAO/IATA): no dangerous good Sea (IMO/IMDG): no dangerous good Packing group Environmental hazards ADR Enverinmental Pollutant: Marine pollutant: Special precautions for user Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code SECTION 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Dir. 67/548/EEC (Classification, packaging and labelling of dangerous substances) Dir. 99/45/EC (Classification, packaging and labelling of dangerous preparations) Dir. 98/24/EC (Risks related to chemical agents at work) Dir. 2000/39/EC (Occupational exposure limit values) Dir. 2006/8/EC Regulation (EC) n. 1907/2006 (REACH) Regulation (EC) n. 1272/2008 (CLP) Regulation (EC) n. 790/2009 (ATP 1 CLP) Regulation (EU) n. 453/2010 (Annex I) Restrictions related to the product or the substances contained according to Annex XVII Regulation (EC) 1907/2006 (REACH) and subsequent modifications: REACH Regulation (1907/2006) REACH Regulatio n 1907/2006 (REACH) Art. 59 (Su bstances in Candidate List ): CLP Regulation n 1272/2008 (CLP) and s.m.i. Directive n 1999/45/CE (Dangerous Preparation) an d s.m.i. Directive n 67/548/CEE (Substances) and s.m.i. Directive 2000/39/CE and s.m.i. (Professional threshold limit) Directive 105/2003/CE (Seveso III): ADR Agreement IMDG Code IATA Regulation Wassergefährdungsklasse: VOC (2004/42/EC) : 5 g/l Page n. 6 of 7

7 15.2. Chemical safety assessment SECTION 16: Other information This safety data sheet has been completely updated in compliance to Regulation 453/2010/EU. This document was prepared by a competent person who has received appropriate training. Main bibliographic sources: NIOSH - Registry of toxic effects of chemical substances ECDIN - Environmental Chemicals Data and Information Network - Joint Research Centre, Commission of the European Communities SAX'S - Dangerous properties of industrial materials Istituto Superiore di Sanità - Inventario Nazionale Sostanze Chimiche The information contained herein is based on our state of knowledge at the above-specified date. It refers solely to the product indicated and constitutes no guarantee of particular quality. This MSDS cancels and replaces any preceding release. ADR: CAS: CLP: DNEL: EINECS: GefStoffVO: GHS: IATA: IATA-DGR: ICAO: ICAO-TI: IMDG: INCI: KSt: LC50: LD50: LTE: PNEC: RID: STE: STEL: STOT: TLV: TWA OEL: VLE: WGK: : N.D.: European Agreement concerning the International Carriage of Dangerous Goods by Road. Chemical Abstracts Service (division of the American Chemical Society). Classification, Labeling, Packaging. Derived Effect Level. European Inventory of Existing Commercial Chemical Substances. Ordinance on Hazardous Substances, Germany. Globally Harmonized System of Classification and Labeling of Chemicals. International Air Transport Association. Dangerous Goods Regulation by the International Air Transport Association (IATA). International Civil Aviation Organization. Technical Instructions by the International Civil Aviation Organization (ICAO). International Maritime Code for Dangerous Goods. International menclature of Cosmetic Ingredients. Explosion coefficient. Lethal concentration, for 50 percent of test population. Lethal dose, for 50 percent of test population. Long-term exposure. Predicted Effect Concentration. Regulation Concerning the International Transport of Dangerous Goods by Rail. Short-term exposure. Short Term Exposure limit. Specific Target Organ Toxicity. Threshold Limiting Value. Threshold Limit Value for the Time Weighted Average 8 hour day. (ACGIH Standard). European threshold limit value Threshold Limiting Value. German Water Hazard Class. Page n. 7 of 7