Premium PowerPoint Presentation. Rigging Review
|
|
- Constance Cameron
- 6 years ago
- Views:
Transcription
1 Premium PowerPoint Presentation Rigging Review
2 Chapter 1 Hoisting Safety Review: What about the CG Symmetrical vs. Asymmetrical Balanced and Unbalanced Lifting Lug Hooks Angle Deformation Safety Gates
3 Chapter 1 Hoisting Safety Review: Shackles angle and tightening Master Link When do you need a Tag Line How high to hoist a load Twisted Rope - advantage disadvantage Plaited Rope Braided Rope - advantage disadvantage Single, Double
4 Chapter 1 Hoisting Safety Review: When Need: Signal Person Engineer Signals Slings / Sling Forces Bridle Basket Choker Vertical
5 Chapter 1 Hoisting Safety Review: Spreader Bars Fiber Rope Fiber, Yarn, Strand, Rope What causes Loss of Strength % of loss = 95% / 65% / 50% Whipping vs. Seizing Special Handling Knot vs. Hitch
6 Chapter 1 Hoisting Safety Review: SWLL, WLL, SLL, Working Load, Operating Tension, Normal Working Load Breaking Strength, Tensile Strength, Ultimate Strength Safety Factor 5 Personnel SF of 10
7 Chapter 1 Hoisting Safety Review: Chain More flexible More durable More impact resistant 3-5x Wire Rope Measure Wear at ends Deformation What Grade for overhead hoisting?
8 Chapter 1 Hoisting Safety Review: Crane Types JIB Tower Gantry Mobile vs Stationary Overhead All Types of Sling Damage Storage and Care of equipment
9 Chapter 1 Hoisting Safety Review: Fiber Slings Tagged Yarn Color & Warning Indicator Round Slings Color Identifier Does not require a date on the tag Parts of a sling: Body, length, splice, and Loop Eyes
10 Chapter 1 Hoisting Safety Review: Wire Rope Check Diameter at High points Watch for Damage Rust Kinks Bird caging Broken strands Inspect and tag & take out of service if any equipment is damaged.
11 Chapter 1 Hoisting Safety Review: Block and Tackle Types of Blocks crane, snatch, gin, crane What is Reeving Lead Line (Fall Line) Parts of Line (Load Lines) Parts and Sheaves Weight Distribution Pulley Friction / Bend Ratio Angle of Lead Line to Load Lines changes the SWLL
12 Chapter 1 Hoisting Safety Review: Hoist Mechanisms Takes the place of YOU pulling on the Lean line. Lifting Plans and Pre-Lift meetings. How know weight of load? Lifting Charts Heating metals can take out the original temper or heat treatment. Do not heat or weld on rigging equipment.
13 Chapter 1 Hoisting Safety Equipment Inspections Initial Periodic Frequent
14 Fiber Rope Rope Characteristics Guidelines for Maintaining Rope Store rope properly Dry rope properly after wetting Be careful with rotation resistand ropes Keep ropes clean Do not use frozen ropes Protect rope from chemicals Avoid kinks Do not overload ropes Do not use in wire rope blocks Avoid sharp angles or bends Reverse rope ends periodically Do no treat your rope Reeve ropes correctly Splice correctly Avoid sudden jerks or strains Avoid mud, sand, and grit 14
15 Slings and Chains Synthetic Web Slings Follow the capacities specified by your manufacturer. Sling capacities vary from manufacturer to manufacturer, and from this table. *Remember within 5 of Vertical 15
16 Slings and Chains Inspecting Chains Grad 8/80 or 10/100 A good inspection plan follows these principles: Under no circumstances is a chain to be used for hoisting purposes unless it has been closely examined for defects or wear. Inspect chains used regularly on a link-by-link basis at least once a month by a competent inspector. Deformation is a sign of excessive loading and possible failure 16
17 Rigging Hardware Inspecting Hooks Inspect hooks for: Wear, cracks, or severe corrosion Gates present and functional No Welding on hooks Any bending or twisting Throat openings of more than 5% or showing 10% wear If any of these conditions exist, destroy the hook. 17
18 Hook Loading 18
19 Working Load Limits Rigging Hardware The safe area for hook loading is shown below. 19
20 Rigging Hardware Attaching a Hook to a Pole When attaching a hook to a pole or other object, have the back of the hook toward the pole. 20
21 Synthetic Sling Shackles Shackle Types 21
22 Rigging Hardware Shackle Safety When Lifting With Shackles: Place the shackle pin in the hook, centered on the pin. Run the load line through the shank of the shackle, not the pin. Arrange the lift so the shackle is not pulled at an angle. Remember Pin in the Eye, Let it Fly 22
23 Rigging Hardware Shackle Safety When Lifting with Shackles: The safe area for shackle loading 23
24 Rigging Hardware Remember load weight and balance tips to the heavy end Symmetrical vs Asymmetrical Rigging Where do you find the weight Manufacturer Docs - Name Plate Shipping paperwork - Experience Estimation 24
25 Shackle Safety Rigging Hardware Unsafe screw pin shackle use. 25
26 Rigging Hardware Shackle Safety Unsafe screw pin shackle use. A shackle is a better choice below. 26
27 Rigging Hardware Eye Bolts Preferred Shoulder Type Eye Bolt Eye bolts may be attached directly to the load or to a bar lifting the load. Eye bolts can then be used with shackles or hooks to lift the load. Eye bolts and shackles have a better bearing surface and place less strain on the cable or sling. Apply loading in the plane of the eye so the bolts do not bend sideways. Eye bolts are measured by thread size. 27
28 Rigging Hardware Eye Bolts Correct and incorrect use of eye bolts. 28
29 Rigging Hardware Eye Bolts Right and wrong orientation of eye bolts. 29
30 Rigging Hardware Eye Bolts Right and wrong use of shoulder type eye bolts 30
31 Rigging Hardware Eye Bolts Right and wrong method to avoid excess strain on slings. 31
32 The standing block is under a greater force than just the load weight. The number of parts and the angle of lead-line affect the total block loading.
33 Blocks Shackles are recommended as standing block fittings because they are stronger than hooks. Lead line should come from the center of the block. When the two blocks have an equal number of sheaves, the becket should be on the upper (standing) block. When the two blocks have unequal numbers of sheaves, the becket should be on the block having the least number of sheaves. 33
34 Blocks Maintenance and Care of Blocks Before use, blocks should be thoroughly inspected for: Wear in the pins or axles, rope grooves, side plates, and fittings. Misalignment or wobble in the sheaves. Loose bolts, nuts, or other locking hardware. 34
35 Chapter 1 Hoisting Safety Anything to add
Basic Rigging And Wire Rope
Basic Rigging And Wire Rope Presented By Master Builders of Iowa Basic Rigging and Wire Rope Topics Four Commandments of Rigging Sling Angles Types Of Hitches Types Of Slings Types Of Rigging Devices OSHA
More informationHeavy Equipment Technician Rigging
1. What is SWL? a. Single weight of load b. Second weakest location c. Working load limit Heavy Equipment Technician IP Red Seal Practice Exam d. Abbreviation for swivel Heavy Equipment Technician Rigging
More informationReferences: EM Section 15 OSHA UFGS
References: EM 385-1-1 Section 15 OSHA 1926.251 UFGS 01 35-26 Rigging Safety Rigging equipment shall be inspected as specified by the manufacturer, by a Competent Person, before use on each shift and as
More informationMATERIAL HANDLING - FIELD RIGGING SAFETY PROGRAM
Title: Material Handling - Rigging Effective Date: 12/4/2014 Control Number: THG_0049 Revision Number: 1 Date: 10/23/2015 Annual Review Completed: 5/13/2015 MATERIAL HANDLING - FIELD RIGGING SAFETY PROGRAM
More informationCrane & Rigging Brain Teasers
Crane & Rigging Brain Teasers Host: Mike Parnell President/CEO, ITI ASME B30 Vice Chair (Cranes & Rigging) ASME P30 Chair (Lift Planning) The views expressed in this presentation are that of ITI and are
More informationGENERAL GUIDELINES FOR PROPER RIGGING PRACTICES AND INSPECTION & REMOVAL CRITERIA FOR SLINGS PER OSHA
GENERAL GUIDELINES FOR PROPER RIGGING PRACTICES AND INSPECTION & REMOVAL CRITERIA FOR SLINGS PER OSHA 1910.184 SAFE OPERATING PRACTICES -.Whenever any sling is used, the following practices shall be observed:
More informationManaging Mobile Crane Hazards. Paul Satti Construction Safety Council. Hazards of Working Around Cranes. Key Concepts:
Managing Mobile Crane Hazards Paul Satti Construction Safety Council Hazards of Working Around Cranes Key Concepts: Electrocution Hazards Caught-In, Compressed or Crushing Hazards Struck-By Hazards Other
More informationProof load is the load applied in performance of a proof test. Proof test is a nondestructive tension test performed by the sling manufacturer or an
1910.184 Slings (a) Scope. This section applies to slings used in conjunction with other material handling equipment for the movement of material by hoisting, in employments covered by this part. The types
More informationBuckingham Mfg. Co., Inc. OX BLOCK TM Instructions and Warnings
OVERVIEW The Buckingham OX BLOCK is a rope snatch block with an integrated friction bar used for lowering loads, snubbing loads, and raising loads. It allows the rigging professional to handle loads with
More informationSECTION 15 RIGGING. b. Defective rigging shall be removed from service.
SECTION 15 RIGGING 15.A GENERAL 15.A.01 Inspection and use. a. Rigging equipment shall be inspected as specified by the manufacturer, by a Competent Person, before use on each shift and as necessary during
More informationCORPORATE SAFETY MANUAL
CORPORATE SAFETY MANUAL Procedure No. 32-0 Revision: Date: May 2005 Total Pages: 10 PURPOSE To provide general guidelines for the inspection of all ropes, chains, cables, slings, etc. used for personnel
More informationBuckingham Mfg. Co., Inc. OX BLOCK TM Instructions and Warnings
OVERVIEW The Buckingham OX BLOCK is a rope snatch block with an integrated friction bar used for lowering loads, snubbing loads, and raising loads. It allows the rigging professional to handle loads with
More informationBANKSMAN / SLINGER. 1. What is the smallest size diameter of synthetic rope allowed for use as a hand held tagline?
BANKSMAN / SLINGER 1. What is the smallest size diameter of synthetic rope allowed for use as a hand held tagline? A. 16mm B. 10mm C. 12mm 2. What is the maximum temperature that a webbing sling can be
More information1.0 Purpose: To provide guidelines for selection, usage, inspection and rejection of rigging equipment
Orignal Issue Date : 28-10-10 Date of Revision: Page- - 1-1.0 Purpose: To provide guidelines for selection, usage, inspection and rejection of rigging equipment (Slings & Ropes) 2.0 Reference: 3.0 Associated
More informationSlings Steel Chain, Wire Rope and Metal Mesh
Optional Information Name of School: Date of Inspection: Vocational Program/Course/Room: Signature of Inspector: Slings Steel Chain, Wire Rope and Metal Mesh Self Inspection Checklist Guidelines: This
More informationoperation WARNING! Operator must read and understand instructions here and on sling prior to use.
SLINGS S-17880, S-17881 S-17882, S-17883 S-17884, S-17885 operation WARNING! Operator must read and understand instructions here and on sling prior to use. Safe Operating Practices Inspect slings prior
More informationOMG Southeast & Southwest RIGGING SAFETY PROGRAM (29 CFR Part , , , , , & ANSI B30.5, ANSI B30.
OMG Southeast & Southwest RIGGING SAFETY PROGRAM (29 CFR Part 1926.251, 1926.550, 1910.180, 1910.184, 1910.330, & ANSI B30.5, ANSI B30.8) Nearly every project is required to perform some type of rigging
More informationRigging Safety. 1 Copyright 2014 by PEC Safety Management, Inc. PPT-SM-RIGGING 2014
Rigging Safety 1 Copyright by PEC Safety Management, Inc. Rigger Role Assist the crane operator by properly attaching and detaching loads the crane Know how to safely connect and disconnect loads Discuss
More informationSection 15 TABLE OF CONTENTS Rigging. 15.A General B Personnel Qualifications
Section 15 TABLE OF CONTENTS Rigging Section: Page 15.A General... 15-1 15.B Personnel Qualifications... 15-2 15.C Multiple Lift Rigging (MLR) ( Christmas Tree Rigging )... 15-3 15.D Slings... 15-5 15.E
More informationCare, Use and Inspection
Care, Use and Inspection of Synthetic Web Slings Safety is the paramount consideration involved in the use of any web sling. This standard does not purport to address all safety concerns, if any, associated
More informationHealth & Safety Policy and Procedures Manual SECTION 25 RIGGING AND HOISTING EQUIPMENT
SECTION 25 RIGGING AND HOISTING EQUIPMENT 1. RIGGING AND HOISTING: These rules apply to all Maul Electric, Inc. employees and subcontractors. Note: Maul Electric, Inc. employees will utilize mechanical
More informationBC Shackle. Made in the China. Alloy Steel Anchor Shackle. Instructions for handling and use - Please read in full before using this device
BC Shackle Made in the China Alloy Steel Anchor Shackle Instructions for handling and use - Please read in full before using this device Index 1.) Introduction 2.) Warnings / General Use Guidelines 3.)
More informationFor Review Only No Copying No Saving No Lending No Posting Online
The following copyrighted samples are provided as a service for your review only. Copying, saving, lending, posting online or any general use of these files other than for the purpose provided is unlawful
More informationM S I C R A N E S C A L E
2 M E A S U R E M E N T S Y S T E M S I N T E R N A T I O N A L Table of Contents Forward...3 Safe Operating Guidelines...4 Operating Suggestions...4 Handling Hoist Motion...4 Safe Loading and Rigging
More informationHeavy Equipment & Rigging Specialist Training
Heavy Equipment & Rigging Specialist Training Module 1 Unit 4: Intro to Rigging May08 1 Key Points Review of Exercise Goals Discuss Rigging Components Language of Crane Signals Review Anchor Installation
More informationWEB SLING BASICS AND HOW TO ORDER WEB SLINGS
27 WEB SLING BASICS AND HOW TO ORDER WEB SLINGS TYPE I Web sling made with a triangle fitting on one end and a slotted triangle choker fitting on the other end. It can be used in a vertical, basket or
More informationDEPARTMENT OF LICENSING AND REGULATORY AFFAIRS DIRECTOR'S OFFICE GENERAL INDUSTRY SAFETY STANDARDS PART 49. SLINGS
DEPARTMENT OF LICENSING AND REGULATORY AFFAIRS DIRECTOR'S OFFICE GENERAL INDUSTRY SAFETY STANDARDS (By authority conferred on the director of the department of licensing and regulatory affairs by sections
More informationWorker s Safety Handbook for Rigger and Signalman
Worker s Safety Handbook for Rigger and Signalman Contents Preface 3 Proper Attire for Rigger and Signalman 4 Roles and Responsibilities of a Rigger 5 Good and Bad Rigging Practices 12 Inspection of Hooks
More information8012, 8018 & ,000 LB. CAPACITY HOOK-TYPE CABLE SHEAVES
OPERATION, SERVICE AND PARTS INSTRUCTION MANUAL 80, 808 & 804 8,000 LB. CAPACITY HOOK-TYPE CABLE SHEAVES Read and understand this material before operating or servicing this sheave. Failure to understand
More information"RIGGING SAFETY IN CONSTRUCTION ENVIRONMENTS"
PRESENTER'S GUIDE "RIGGING SAFETY IN CONSTRUCTION ENVIRONMENTS" Part of the "CONSTRUCTION SAFETY KIT" Series Quality Safety and Health Products, for Today...and Tomorrow OUTLINE OF MAJOR PROGRAM POINTS
More informationPURPOSE: The purpose of this Operating Policy/Procedure (OP) is to ensure that material handling devices are used correctly and safely.
[Date changed posted 10/3/17 (replaces 10/31/12 edition)] Operating Policy and Procedure : Material Handling Devices DATE: October 3, 2017 PURPOSE: The purpose of this Operating Policy/Procedure (OP) is
More informationRigging Safety 16 Hour (API RP 2D 7 th Edition) Course Outline
Rigging Safety 16 Hour (API RP 2D 7 th Edition) Course Outline Prerequisites: This course shall have no formal pre-requisite. The individual should have no history of a disabling medical condition, which
More informationDonaghys Winch Ropes. Handling & Installation Guide
Donaghys Winch Ropes Handling & Installation Guide September 2015 Choosing the right rope for the job It is important to choose the right rope for the job. Donaghys specialise in custom designing ropes
More informationLift-All Wire Rope & Slings
WIRE ROPE AND SLING BASICS Lift-All & Slings Two major and opposing characteristics of wire rope slings are flexibility and resistance to abrasion. To a great extent, these traits are a direct function
More informationHOW TO PREPARE FOR THE LEVEL A CRANESAFE CERTIFICATION ASSESSMENT
HOW TO PREPARE FOR THE LEVEL A CRANESAFE ASSESSMENT Prepare for your assessment! Our website contains all the information you need for a successful assessment. Our goal is to find you competent on the
More informationUSER S GUIDE LIFTING TERMINOLOGY
USER S GUIDE LIFTING API RP2D Version (06/06) REFER TO API RP2D FOR FULL DETAILS RISK MANAGEMENT DEFINITION COMPREHENSIVE SET OF ACTIONS THAT REDUCES THE RISK OF A PROBLEM, A FAILURE, AN ACCIDENT Quality
More informationThis training session focuses on safe rigging for crane and derrick operations at construction sites. A critical job for the safety of any crane or
This training session focuses on safe rigging for crane and derrick operations at construction sites. A critical job for the safety of any crane or derrick operation is rigging the load. A poor rigging
More informationBritish Columbia Carpenter Apprenticeship Program
British Columbia Carpenter Apprenticeship Program Level 2 Line E Competency E-3 Use Hoisting Equipment 7960003554 Ordering Crown Publications, Queen s Printer PO Box 9452 Stn Prov Govt 563 Superior St.
More informationSession Objectives. Business & Legal Reports, Inc. 1011
Crane Rigging Cranes are old devices the ancient Greeks and Romans designed cranes to lift and move heavy objects. Buildings such as the Roman Colosseum and the medieval cathedrals of Europe were built
More informationWinchline n a box WINCH LINE SELECTION GUIDE. Wire Rope Winchlines are superior to most other winchlines found in the market place due to the
Winchline n a box Wire Rope Winchlines are superior to most other winchlines found in the market place due to the eye) end terminations. Each eye is protected by a steel liner (thimble) to guard against
More informationSerial Number: Lot Number: Purchase Date: General Factors Accepted / Rejected Supportive Details or Comments. Accepted Rejected.
Full Body Harness Harness Model: General Factors / Supportive Details or Comments 1.) Hardware: (includes D-rings, buckles, keepers, and back pads) Inspect for damage, distortion, sharp edges, burrs, cracks
More informationFall Protection Checklist. Guardrail System
Fall Protection Checklist Location/Department: Date of Inspection: Inspectors: Corrective Actions: Work order/memos were issued: Yes No Date issued: In accordance with the MIOSHA and OSHA standards the
More informationWIRE ROPE AND SLING BASICS. Total. of Wires WIRE ROPE SLINGS. Use of EIP, IWRC rope gives 15% greater capacity than IP, IWRC ropes.
V WIRE ROPE AND SLING BASICS & Slings Two major and opposing characteristics of wire rope slings are flexibility and resistance to abrasion. To a great extent, these traits are a direct function of the
More informationNEVER EXCEED WORKING LOAD LIMITS PAGE
WIRE ROPE All wire rope is manufactured with three basic components: Wires, Strand and Core. Following is a description on the essential information required for ordering wire rope. DIAMETER Nominal Diameter
More informationTOWER INSPECTION REPORT
3010 S. Hwy 77, Suite 600 Waxahachie, Texas 75165 http://ctctower.com Office: 972/923-9504 Fax: 972/923-9619 TOWER INSPECTION REPORT PREPARED FOR MR. CUSTOMER 1,563 GUYED TOWER NEAR CITY, STATE JANUARY
More informationHoisting Equipment Cable puller & Accessories
Yale hoists and trolleys are not ed for Cable puller model Yaletrac Pulling force 800-3200 It has a light weight, compact, high tensile aluminium alloy housing with a large flat bottom surface for increased
More informationChapter 2 Rigging. Cutting Wire Rope. Anchoring Wire Rope to Drum. Winding Wire Rope Onto Drum
Chapter 2 Rigging Cutting Wire Rope The wire rope must be tightly seized on both sides of the point where the wire rope will be cut, as shown in Figure 2-1. Seize the wire rope with either seizing wire
More informationSeamanship. A braided line comprises a core of braided or stranded threads covered with a sheath. The center or core of the line gives strength.
Seamanship 1. Describe the life boat ropes. On a life boat, we rarely use the word rope but rather lines to describe all of the ropes. Moreover, each line has a specific name, such as the painter, halyard
More informationsteel wire rope slings and fittings
steel wire rope slings and fittings Steel Wire Rope Slings SNS7531 Working load limits using 6x19 or 6x36 IWR (1960mpa) SWR Ø nominal break load 1 Leg 2 Leg 3 and 4 Leg angle between the legs angle between
More informationWEBMASTER 00 SLINGS master 00 Polyester Slings Hardware Slings (TYPES U, AND ) Standard duty master 00 is designed for less frequent, light duty servi
Best in Abrasion Resistance Available in two strength classes, all Dura- slings feature premium abrasive resistant yarns covering all surfaces, for extended sling life and long term value. Dura- Features,
More informationFigure 1 - Parts Identification
Instructions for the following series products: Zorbit Energy Absorber Kits (See back page for specific model numbers.) User Instruction Manual Zorbit Energy Absorber Kits for Horizontal Lifeline Systems
More informationDrawing Showing the Component Parts of a Standard Steel Wire Rope
Drawing Showing the Component Parts of a Standard Steel Wire Rope Core wire Rope wire Strand Steel wire rope Core of natural or synthetic fibre or steel * *) The strands are wrapped around a core of fibre
More informationWarning CABLE REPLACEMENT INSTRUCTIONS. Questions? - Call Telpro Inc. Customer Service at or
CABLE REPLACEMENT INSTRUCTIONS Warning Read and follow these warnings and the instructions that follow. Failure to do so could result in serious property damage and/or serious bodily injury. BEFORE operating
More informationLifting Slings. Before equipment use, please read this operation manual carefully. Serial Number: Date Purchased:
Lifting Slings OPERATION MANUAL This operation manual is intended as an instruction manual for trained personnel who are in charge of installation, maintenance, repair etc. Before equipment use, please
More informationUSER S GUIDE LIFTING
RISK MANAGEMENT DEFINITION COMPREHENSIVE SET OF ACTIONS THAT REDUCES THE RISK OF A PROBLEM, A FAILURE, AN ACCIDENT ASME B30.9 REQUIRES THAT SLING USERS SHALL BE TRAINED IN THE SELECTION, INSPECTION, CAUTIONS
More information20', 15', AND 12' BALL STOPS ASSEMBLY INSTRUCTIONS
20'-0" 15'-0" 1 739020 739020A 20' BALL STOP; STRAIGHT POLE 739015 739015A 15' BALL STOP; STRAIGHT POLE 739012 739012A 12' BALL STOP; STRAIGHT POLE Read all of the instructions before beginning. Make sure
More informationAn introduction to Rigging for Trail Work
An introduction to Rigging for Trail Work Give me a lever long enough and a prop strong enough, I can single handed move the world. Archimedes The purpose of this seminar is to provide a hands-on introduction
More informationSECTION 2. Wire Rope Slings & Bridles
SECTION Wire Rope Slings & Bridles All four of the Coordinated Wire Rope companies specialize in the fabrication of wire rope slings in many different sizes and configurations. The wire rope sling has
More informationSAMPLE PAGE. Section 2... Wire Rope
Section 2...................................................... Wire Rope Never use any kind of clip to directly connect two straight lengths of wire rope to form a continuous piece. Do not make up slings
More informationSling Safety. Construction Safety and Health Outreach Program. U.S. Department of Labor OSHA Office of Training and Education May 1996 INTRODUCTION
Construction Safety and Health Outreach Program U.S. Department of Labor OSHA Office of Training and Education May 1996 Sling Safety INTRODUCTION The ability to handle materials - to move them from one
More informationSeptember 27, DOE-RL-92-36, Hanford Site Hoisting and Rigging Manual. Wire Rope. Page 1 CONTENTS
Page 1 CONTENTS 8.0 WIRE ROPE...2 8.1 SCOPE...2 8.2 GENERAL REQUIREMENTS...2 8.2.1 Design Factors For s... 2 8.2.2 Rotation-Resistant Rope...3 8.2.3 Requirement for Independent Core...3 8.3 INSPECTION
More informationVersie Date: USAGE AND SAFETY MANUAL SPREADERBEAMS
USAGE AND SAFETY MANUAL SPREADERBEAMS 1. INTRODUCTION: The spreader system exists of modular traverses with possibility of different spans. Each spreaderbeam exists of two head section complete with shackles
More informationOPERATIONS MANUAL IMPORTANT SAFETY INFORMATION
OPERATIONS MANUAL IMPORTANT SAFETY INFORMATION Please read, understand and follow all safety information contained in these instructions prior to the use of this tool. Retain these instructions for further
More informationIntroduction: Materials needed to conduct this training: White board, black board or presentation tablets. Projector
1 Introduction: Materials needed to conduct this training: White board, black board or presentation tablets Projector Student Manuals printed out for each participant Notepad or scratch paper Calculator
More informationTULSA CHAIN.COM, LLC.
RECOMMENDED OPERATING, CARE AND INSPECTION MANUAL FOR SYNTHETIC POLYESTER ROUNDSLINGS WSTDA-RS-2 TM Web Sling & Tie Down Association 2005 $6.00 MANDATORY AND ADVISORY RULES Mandatory rules are characterized
More informationFigure 1 - Parts Identification. Copyright 2002, DB Industries, Inc.
User Instruction Manual Zorbit Energy Absorber Kits for Horizontal Lifeline Systems This manual is provided as the Maunfacturer s Instructions, and should be used as part of an employee training program
More informationRoughneck TM Mesh Slings
Roughneck TM Slings ROUGHNECK WIRE MESH SLINGS Widely used in metalworking shops and steel warehouses where loads are abrasive, hot or tend to cut web slings Features and Benefits Promotes Safety Steel
More informationObjectives (1 of 3) List at least two types of materials and designs used in rope manufacture. Define and describe the following: Dynamic rope Static
Chapter 16 Rescue Objectives (1 of 3) List at least two types of materials and designs used in rope manufacture. Define and describe the following: Dynamic rope Static rope Webbing List at least five rules
More informationMANITOWOC MODEL TON CAPACITY
LIFTING CHARTS - Crawler Cranes ANITOWOC ODEL - TON CAPACITY BOO RIGGING GUIDE ODEL # HEAVY LIFT BOO Table of Contents General... Assist Crane Requirements... Accessing Parts... Installation and Removal
More informationSLINGS, HOISTING & RIGGING
GENERAL REQUIREMENTS These requirements apply regarding the hazards associated with hoisting and rigging. Pre-shift Visual Inspection of Cranes Cranes being used in steel erection activities will be visually
More informationLiftAlloy Chain Slings
CHAIN SLING BASICS Slings Lift-All chain slings meet or exceed all OSHA, ASME B30.9 and NACM standards and regulations. chain slings, available in 80 for 7/8"- /4" and 00 for 7/32"-3/4", are recommended
More informationEssential Rig Tuning Guide The Ins and Outs of tuning your mast.
Essential Rig Tuning Guide The Ins and Outs of tuning your mast. Tuning Your Rig The main goal in tuning your mast is to achieve a spar that s straight. By doing this it will help you gain control of sail
More informationCrane Rental Heavy Machinery Moving Project Management
2 3 4 5 6 7 8 9 10 Link-Belt TG-2300B lifting crane capabilities - heavy duty boom Boom - tubular: 90" x 90" (2.29 x 2.29 m) with open throat top section, 2" (51 mm) diameter boom pendants. Mast - 43'
More informationWIRE ROPE PULLING MACHINE
WIRE ROPE PULLING MACHINE Spare parts list and exploded view Specifications Dimensions Item No. 0.8T 1.6T 3.2T 5.4T Rated Capacity kg 800 1600 3200 Rated Forward Handpower N 343 441 441 Rated Forward Travel
More informationVisit: 27
Visit: http://www.kwrs.com 7 SINGLE PART SLINGS Eyes are typically formed using a flemish eye splice. The ends are secured by pressing a metal sleeve over the ends of the strands of the splice. Pull follows
More informationLOAD CHARTS RT890E METRIC DIN / ISO / 75%
LOAD CHARTS RT89E METRIC DIN / ISO / 75% 232729 SERIAL NUMBER RT89E - S/N 232729 1 RT89E - S/N 232729 2 TABLE OF CONTENTS GENERAL NOTES...4 WEIGHT REDUCTIONS / LINE PULLS & REEVING INFO / RIGGING CHART
More informationCare and inspection of wire rope
Data Sheet 667 Reaf. 89 Rev. April 2016 Care and inspection of wire rope The applications of wire rope for crane hoists is an important tool and probably one of the least understood and most abused. 1.
More informationChapter 16 Workbook Questions
1. List four defects that might be found during rope inspection that would require a rope to be retired. a. b. c. d. cuts, excessive fraying, abrasions puffs, pulled or herniated fibers changes in diameter
More informationInstruction Sheet. Powered Cable Pullers CP800, CP8000, CP8000D CP8003, CP8006
Instruction Sheet Powered Cable Pullers CP800, CP8000, CP8000D CP8003, CP8006 IMPORTANT: RECEIVING INSTRUCTIONS Visually inspect all components for shipping damage. If any shipping damage is found, notify
More informationUSER INSTRUCTIONS. Complies with ANSI Z359.1, ANSI Z359.4 standards and OSHA 29 CFR 1910 and 1926 regulations.
FALL PROTECTION USER INSTRUCTIONS TRIPOD SYSTEM Complies with ANSI Z359.1, ANSI Z359.4 standards and OSHA 29 CFR 1910 and 1926 regulations. Models: T100009, T210030B, T210060B, T210100B, T510000B, T510045,
More informationLiftAlloy TM Chain Slings
LiftAlloy TM LiftAlloy CHAIN SLING BASICS Lift-All chain slings meet or exceed all OSHA, ASME B30.9 and NACM standards and regulations LiftAlloy chain slings, available in grade 00 for 7/32" through 3/4",
More informationSYNTHETIC, CHAIN & WIRE ROPE SLINGS
08 SYNTHETIC, CHAIN WIRE ROPE SLINGS 109 POLYESTER WEB SLINGS POLYESTER WEB SLINGS POLYESTER WEBBING BREAKING STRENGTH: 9,800LBS/INCH SAFETY FACTOR = 5:1. Easy use combined with industrial rigging for
More informationUser Instruction Manual For Davit Rescue System
Instructions for the following series products: Rescue Davit System Model numbers 8004000 and 8302500 User Instruction Manual For Davit Rescue System This manual should be used as part of an employee training
More informationLOAD CHARTS RT540E 85% STABILITY ON OUTRIGGERS 75% STABILITY ON RUBBER
LOAD CHARTS RT540E 85% STABILITY ON OUTRIGGERS 75% STABILITY ON RUBBER SERIAL NUMBER 1 2 TABLE OF CONTENTS GENERAL NOTES... 4 WT. REDUCTIONS / LINE PULLS & REEVING INFO / HOIST PERFORMANCE. 5 LIFTING AREA
More informationUSER S INSTRUCTION MANUAL FOR THE INSTALLATION, OPERATION & MAINTENANCE OF THE GUARDIAN TEMPORARY HORIZONTAL LIFELINE SYSTEM
USER S INSTRUCTION MANUAL FOR THE INSTALLATION, OPERATION & MAINTENANCE OF THE GUARDIAN 04630 TEMPORARY HORIZONTAL LIFELINE SYSTEM 1 WARNING This is a design compatible component for a comprehensive Guardian
More informationTransfer Chain (SA-1002) & Adjustable I-Beam Clamp (SA-1039 or SA-1040) Operating Instructions
Transfer Chain (SA-1002) & Adjustable I-Beam Clamp (SA-1039 or SA-1040) Operating Instructions SPIDER Page 1 of 8 702127 Rev A Using Transfer Chain with Adjustable I-Beam Clamp Safety Notes Do not use
More informationRelated Elevator Products
37 SECTION 2 - Elevator Products Reeving Splices Related Elevator Products Reeving Splice Specifications PIN # Wire Rope Size Units per Carton Wt. per Carton (Lbs) Length (IN) Color Code 1119100012 3/8
More informationVGD WIRE ROPE HARDWARE
VGD WIRE ROPE HARDWARE This is at your service Since 1960, Steel Ltd., a sister Company of Ringball Corporation, has been supplying specialty steels and steel products to North American Industries. By
More informationIMPORTANT: If you have questions on the use, care, or suitability of this equipment for your application, contact DBI/SALA.
User Instruction Manual Precast Concrete Beam Horizontal Lifeline System This manual is provided as the Manufacturer s Instructions, and should be used as part of an employee training program as required
More informationA & M Sales Offers a complete Line of Winch Line Rope. Bumper Mount Winch
a & m sales, inc. p.o. box 171 chagrin falls, ohio 22 () 78-18 A & M Sales Offers a complete Line of Winch Line Rope Bed Mount Winch Just give us a call and we can walk you through the process of ordering
More informationCable Grip Fitting Procedure General
Cable Grip Fitting Procedure General 1 Ensure the grip is labelled for the correct diameter range and working load limit. (unless otherwise labelled, WLL is one third of the UTS). 2 Always inspect the
More informationIRATA International code of practice for industrial rope access. Part 3: Informative annexes Annex H: Equipment inspection checklist
IRATA International code of practice for industrial rope access Part 3: Informative annexes Annex H: inspection checklist September 2013 The first edition of Annex H was published in December 2010. This
More informationLoad Ring bolted > VWBG < in pink
RUD-Art.-Nr.: 8503693-EN / 03.014 Load Ring bolted > VWBG < in pink EN Safety instructions This safety instruction/declaration has to be kept on file for the whole lifetime of the product. Translation
More informationTHOR 10 HAMMER CAGE INSTRUCTIONS
75 " 7m 78 4" m 6" 8.8m 45 ".70m 4.9deg 6 4" 6m 44 4".67m 75 " 7m 9 4" 0m 44".m 497 4".64m The 70, Thor Hammer Cage, consists of four heavy duty aluminum net poles. The unique pole structure reduces the
More informationTECH TIPS: ROPE DEFECTS
Hoist Ropes: Why must they be inspected? A hoist rope is not made to last forever. This is a useful fact, as the kinds of wear that appear on a rope can indicate areas of problems within an installation
More informationHARDWARE Ascenders. Rope Grabs Descenders Snaps Carabiners Links
HARDWARE Ascenders Rope Grabs Descenders Snaps Carabiners Links Ascenders KONG Twin Ascender Aluminum color anodized WLL: 100 grams Rope Diameter: 8-13mm Weight: 17.5oz (496g) Dimensions: 207mm x 162mm
More informationDusty residue when twisted open. Crushed, jammed, or flattened strands. Gaps between strands. Heat damage, torch burns, or electric arc strikes
CHAPTER 24 RIGGING 24 RIGGING Tradespeople who are not professional riggers must nonetheless rig loads at times on the job. Carpenters, for instance, are often involved not only in handling but in hoisting
More informationSQWUREL. Variable Friction Descender for Canyoneering
SQWUREL Variable Friction Descender for Canyoneering Made in UTAH, USA 7075 T6 Aluminum DIM: 6.539 x 3.781 x 0.375 Inches Weight: 4.4 Ounces Patent Pending Single Rope: 8mm - 11mm Double Rope: 8mm - 9mm
More informationGENERAL INFORMATION WIRE ROPE SLINGS
GENERAL INFORMATION NOMINAL SLING STRENGTH is based upon the nominal (catalog) rope strength of the wire rope used in the sling and other factors which affect the overall strength of the sling. These other
More informationPROCEDURES Power Lines
PROCEDURES Power Lines Crane contact with power lines is a major cause of serious injuries and fatalities involving those working with cranes. Overhead power lines must always be considered energized until
More information