Safety Data Sheet according to Federal Register / Vol. 77, No. 58 / Monday, March 26, 2012 / Rules and Regulations

Transcription

1 Revision date:03/05/2013 Supersedes:01/19/2011 Version: SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product form Substance name Product code : Substance : Blood Print Powder : BPD Relevant identified uses of the substance or mixture and uses advised against Use of the substance/preparation 1.3. Details of the supplier of the safety data sheet : Laboratory chemical SIRCHIE Finger Print Laboratories 100 Hunter Place Youngsville, NC - USA T ; F ; Emergency telephone number Emergency number : SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification (GHS-US) Skin Irrit. 2 Eye Irrit. 2A STOT SE 3 H315 H319 H Label elements GHS-US labeling Hazard pictograms (GHS-US) : Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) 2.3. Other hazards Other hazards not contributing to the classification 2.4. Unknown acute toxicity (GHS US) No data available GHS07 : Warning : H315 - Causes skin irritation H319 - Causes serious eye irritation H335 - May cause respiratory irritation : P261 - Avoid breathing dust. P264 - Wash all exposed skin thoroughly after handling. P271 - Use only outdoors or in a well-ventilated area P280 - Wear eye protection, protective gloves. P302+P352 - IF ON SKIN: Wash with plenty of soap and water P304+P340 - IF INHALED: Remove person to fresh air and keep comfortable for breathing P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P312 - Call a POISON CENTER/doctor/ /if you feel unwell P321 - Specific treatment (see information on this label) P332+P313 - If skin irritation occurs: Get medical advice/attention P337+P313 - If eye irritation persists: Get medical advice/attention P362 - Take off contaminated clothing P403+P233 - Store in a well-ventilated place. Keep container tightly closed P405 - Store locked up P501 - Dispose of contents/container to local/regional/national/international regulations. : None under normal conditions. 05/03/2013 EN (English US) 1/6

2 SECTION 3: Composition/information on ingredients 3.1. Substances Substance type Name CAS No. : EC no : EC index no : : Mono-constituent : Blood Print Powder Name Product identifier % Classification (GHS-US) 3,3',5,5'-tetramethylbenzidine (CAS No.) Skin Irrit. 2, H315 Eye Irrit. 2A, H319 STOT SE 3, H335 Full text of H-phrases: see section Mixtures Not applicable SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). : Assure fresh air breathing. Allow the victim to rest. : Remove affected clothing and wash all exposed skin area with mild soap and water, followed by warm water rinse. : Rinse immediately with plenty of water. Obtain medical attention if pain, blinking or redness persist. : Rinse mouth. Do NOT induce vomiting. Obtain emergency medical attention Most important symptoms and effects, both acute and delayed Symptoms/injuries : Not expected to present a significant hazard under anticipated conditions of normal use Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media : Foam. Dry powder. Carbon dioxide. Water spray. Sand. Unsuitable extinguishing media : Do not use a heavy water stream Special hazards arising from the substance or mixture Reactivity : No reactivity hazard other than the effects described in sub-sections below Advice for firefighters Firefighting instructions Protection during firefighting : Use water spray or fog for cooling exposed containers. Exercise caution when fighting any chemical fire. Avoid (reject) fire-fighting water to enter environment. : Do not enter fire area without proper protective equipment, including respiratory protection. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures For non-emergency personnel Emergency procedures For emergency responders Protective equipment Emergency procedures : Evacuate unnecessary personnel. : Equip cleanup crew with proper protection. : Ventilate area Environmental precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters Methods and material for containment and cleaning up Methods for cleaning up 6.4. Reference to other sections See Heading 8. Exposure controls and personal protection. : On land, sweep or shovel into suitable containers. Minimize generation of dust. Store away from other materials. 05/03/2013 EN (English US) 2/6

3 SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling : Wash hands and other exposed areas with mild soap and water before eat, drink or smoke and when leaving work. Provide good ventilation in process area to prevent formation of vapor Conditions for safe storage, including any incompatibilities Storage conditions Incompatible products Incompatible materials 7.3. Specific end use(s) : Keep only in the original container in a cool, well ventilated place away from : Keep container closed when not in use. : Strong bases. strong acids. SECTION 8: Exposure controls/personal protection 8.1. Control parameters : Sources of ignition. Direct sunlight Exposure controls Personal protective equipment : Avoid all unnecessary exposure. Dust formation: dust mask. Gloves. Safety glasses. Hand protection Eye protection Respiratory protection : Wear protective gloves. : Chemical goggles or safety glasses. : Wear approved mask. : When using, do not eat, drink or smoke. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Solid Appearance : Powders. Color : White to light yellow. Odor : odorless. Odor threshold ph Relative evaporation rate (butyl acetate=1) Melting point Freezing point Boiling point Flash point Self ignition temperature Decomposition temperature Flammability (solid, gas) Vapor pressure Relative vapor density at 20 C Relative density Solubility : Soluble in water. Log Pow Log Kow Viscosity, kinematic Viscosity, dynamic Explosive properties Oxidizing properties Explosive limits /03/2013 EN (English US) 3/6

4 SECTION 10: Stability and reactivity Reactivity No reactivity hazard other than the effects described in sub-sections below Chemical stability Stable under recommended handling and storage conditions (see section 7) Possibility of hazardous reactions No reactivity hazard other than the effects described in sub-sections below Conditions to avoid Direct sunlight. Extremely high or low temperatures Incompatible materials strong acids. Strong bases Hazardous decomposition products fume. Carbon monoxide. Carbon dioxide. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Potential Adverse human health effects and symptoms : Not classified : Causes skin irritation. : Causes serious eye irritation. : Not classified : Not classified : May cause respiratory irritation. : Based on available data, the classification criteria are not met. SECTION 12: Ecological information Toxicity Persistence and degradability Blood Print Powder Persistence and degradability 3,3',5,5'-tetramethylbenzidine ( ) Persistence and degradability Bioaccumulative potential Blood Print Powder Bioaccumulative potential 3,3',5,5'-tetramethylbenzidine ( ) Bioaccumulative potential Not established. Biodegradability in water: no data available. Not established. No bioaccumulation data available Mobility in soil Other adverse effects : Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations : Dispose in a safe manner in accordance with local/national regulations. Ecology - waste materials : Avoid release to the environment. 05/03/2013 EN (English US) 4/6

5 SECTION 14: Transport information In accordance with ADR / RID / ADNR / IMDG / ICAO / IATA UN number Not applicable UN proper shipping name Not applicable Additional information : No supplementary information available. Overland transport Transport by sea Air transport SECTION 15: Regulatory information US Federal regulations Blood Print Powder Listed on SARA Section 313 (Specific toxic chemical listings) Listed on the United States TSCA (Toxic Substances Control Act) inventory International regulations CANADA EU-Regulations Classification according to Regulation (EC) No. 1272/2008 [CLP] Not classified Classification according to Directive 67/548/EEC or 1999/45/EC Not classified National regulations US State regulations 05/03/2013 EN (English US) 5/6

6 SECTION 16: Indication of changes : Revision - See : *. Data sources Training advice : REGULATION (EC) No 1272/2008 OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL of 16 December 2008 on classification, labeling and packaging of substances and mixtures, amending and repealing Directives 67/548/EEC and 1999/45/EC, and amending Regulation (EC) No 1907/2006. : Normal use of this product shall imply use in accordance with the instructions on the packaging. Keep in tightly closed container. Keep cool and dry. Avoid all ignition sources - heat, open flame, sparks. Avoid incompatible materials. Avoid dust creation and accumulation. Avoid inhalation and ingestion. Avoid contact with eyes. Wash thoroughly after handling. : This has been established in accordance with the applicable European Union legislation. Full text of H-phrases: see section 16: Eye Irrit. 2A Serious eye damage/eye irritation Category 2A Skin Irrit. 2 skin corrosion/irritation Category STOT SE 3 Specific target organ toxicity (single exposure) Category H315 Causes skin irritation H319 Causes serious eye irritation H335 May cause respiratory irritation NFPA health hazard NFPA fire hazard NFPA reactivity : 3 - Short exposure could cause serious temporary or residual injury even though prompt medical attention was given. : 1 - Must be preheated before ignition can occur. : 1 - Normally stable, but can become unstable at elevated temperatures and pressures or may react with water with some release of energy, but not violently. HMIS III Rating Health Flammability Physical Personal Protection : 3 Serious Hazard - Major injury likely unless prompt action is taken and medical treatment is given : 1 Slight Hazard : 1 Slight Hazard : E SDS US (GHS HazCom 2012) The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, expressed or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigation to determine the suitability of the information for their particular purposes. 05/03/2013 EN (English US) 6/6