Material Safety Data Sheet

Transcription

1 Material Safety Data Sheet Revision Number: Issue date: 11/19/ PRODUCT AND COMPANY IDENTIFICATION Product name: Product type: MULTAN CR 10 IDH number: Region: United States Company address: Henkel Corporation Stephenson Highway Madison Heights, MI Contact information: Telephone: For Chemical Emergency: Call CHEMTREC at Internet: 2. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW HMIS: Physical state: liquid HEALTH: 1 Color: Amber FLAMMABILITY: 1 Odor: Petroleum PHYSICAL HAZARD: 0 Personal Protection: See MSDS Section 8 CAUTION: This product may cause eye and skin irritation. Excessive inhalation of this material causes headache, dizziness, nausea and incoordination. Relevant routes of exposure: Potential Health Effects Inhalation: Skin contact: Eye contact: Ingestion: Existing conditions aggravated by exposure: Excessive inhalation of this material causes headache, dizziness, nausea and incoordination. Prolonged and/or repeated skin contact with this product may cause irritation/dermatitis. This product may cause irritation to the eyes. Ingestion of this product may cause nausea, vomiting and diarrhea. Small amounts of this product, if aspirated into the lungs, may cause mild to severe pulmonary injury. Pre-existing skin, eye and respiratory allergies. This product is considered hazardous under 29 CFR (Hazard Communication). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Hazardous components CAS NUMBER % Petroleum distillates, solvent-refined heavy paraffinic Distillates (petroleum), solvent-refined light paraffinic Amine phosphate Proprietary FIRST AID MEASURES Inhalation: Skin contact: If mist or vapor of this product is inhaled, remove person immediately to fresh air. Seek medical attention if symptoms develop or persist. Immediately flush skin with plenty of water (using soap, if available). If symptoms develop and persist, get medical attention. Page 1 of 5

2 Eye contact: Ingestion: Notes to physician: In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. If symptoms develop and persist, get medical attention. DO NOT induce vomiting unless directed to do so by medical personnel. This material, if aspirated into the lungs, may cause chemical pneumonitis; treat the affected person appropriately. 5. FIRE FIGHTING MEASURES Flash point: Autoignition temperature: Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Extinguishing media: Special firefighting procedures: Unusual fire or explosion hazards: Hazardous combustion products: 199 C (390.2 F) HST-US N27F; Flash Fire Points By Cleveland Open Cup carbon dioxide, foam, powder, water spray jet, fine water spray Wear self-contained breathing apparatus and full protective clothing, such as turn-out gear. Upon decomposition, this product emits carbon monoxide, carbon dioxide and/or low molecular weight hydrocarbons. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Clean-up methods: Prevent further leakage or spillage if safe to do so. Wear suitable protective clothing, gloves and eye/face protection. Remove all sources of ignition. Absorb spill with inert material. Shovel material into appropriate container for disposal. Dispose of according to Federal, State and local governmental regulations. 7. HANDLING AND STORAGE Handling: Storage: Avoid contact with eyes, skin and clothing. Avoid breathing vapors or mists of this product. Remove all sources of ignition. Do not take internally. For industrial use only. Launder work clothes frequently. Keep container tightly closed and in a cool, well-ventilated place away from incompatible materials. Do not pressurize, cut, heat or weld containers. Empty product containers may contain product residue. Do not reuse empty containers. Manufacturer recommends storing above 4.4 ºC (40 ºF). Thaw and mix thoroughly if frozen. For information on product shelf life, please review labels on container or check the Technical Data Sheet. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Page 2 of 5

3 Hazardous components ACGIH TLV OSHA PEL AIHA WEEL OTHER Petroleum distillates, solvent-refined heavy paraffinic Distillates (petroleum), solvent-refined light paraffinic 5 mg/m3 TWA 10 mg/m3 STEL 5 mg/m3 TWA 10 mg/m3 STEL 500 ppm (2,000 mg/m3) TWA Amine phosphate Engineering controls: Respiratory protection: Eye/face protection: Skin protection: Provide local and general exhaust ventilation to effectively remove and prevent buildup of any vapors or mists generated from the handling of this product. If ventilation is not sufficient to effectively prevent buildup of aerosols, mists or vapors, appropriate NIOSH/MSHA respiratory protection must be provided. Respirators should be selected by and used under the direction of a trained health and safety professional following the requirements found in OSHA's respirator standard (29 CFR ) and ANSI's standard for respiratory protection (Z ). A written respiratory protection program, including provisions for medical certification, training, fit-testing, exposure assessments, maintenance, inspection, cleaning, and convenient, sanitary storage, must be implemented. For concentrations above the TLV and/or PEL but less than 10 times these limits, a NIOSH approved half-face piece respirator equipped with vapor cartridges may be used. For concentrations greater than 10 times the TLV and/or PEL, consult the NIOSH respirator decision logic found in Publication No or ANSI Z Warning! Air-purifying respirators do not protect workers in oxygen-deficient atmospheres. Wear safety glasses; chemical goggles (if splashing is possible). Chemical resistant, impermeable gloves. Gloves should be tested to determine suitability for prolonged contact. Suitable glove materials may include: PVC Coated Gloves. Polyvinyl alcohol gloves. The use of neoprene gloves is recommended. The use of nitrile-latex gloves is recommended. Use of impervious apron and boots are recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Color: Odor: Odor threshold: ph: Vapor pressure: Boiling point/range: Melting point/ range: Specific gravity: Vapor density: Flash point: Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Autoignition temperature: Evaporation rate: Solubility in water: Partition coefficient (n-octanol/water): VOC content: liquid Amber Petroleum 1 mm Hg none 500 F (260 C) none at 16 C (60.8 F) Not determined 199 C (390.2 F) HST-US N27F; Flash Fire Points By Cleveland Open Cup partially soluble Page 3 of 5

4 10. STABILITY AND REACTIVITY Stability: Hazardous reactions: Hazardous decomposition products: Incompatible materials: Conditions to avoid: Stable at normal conditions. Will not occur. Upon decomposition, this product emits carbon monoxide, carbon dioxide and/or low molecular weight hydrocarbons. This product may react with strong oxidizing agents. Keep away from heat, ignition sources and incompatible materials. 11. TOXICOLOGICAL INFORMATION Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) Petroleum distillates, solvent-refined heavy paraffinic Known carcinogen. Group 1 No Distillates (petroleum), solvent-refined light paraffinic Known carcinogen. Group 1 No Decanoic acid, mixed esters with octanoic acid and No No No Amine phosphate No No No Hazardous components Petroleum distillates, solvent-refined heavy paraffinic Distillates (petroleum), solvent-refined light paraffinic Amine phosphate Health Effects/Target Organs Irritant Irritant, Some evidence of carcinogenicity No Records Allergen, Irritant 12. ECOLOGICAL INFORMATION Ecological information: No data available. 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Hazardous waste number: Material, if discarded, is not expected to be a characteristic hazardous waste under RCRA. U.S. Department of Transportation Ground (49 CFR) International Air Transportation (ICAO/IATA) 14. TRANSPORT INFORMATION Page 4 of 5

5 Water Transportation (IMO/IMDG) 15. REGULATORY INFORMATION United States Regulatory Information TSCA 8 (b) Inventory Status: TSCA 12(b) Export Notification: CERCLA/SARA Section 302 EHS: CERCLA/SARA Section 311/312: CERCLA/SARA 313: California Proposition 65: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. above reporting de minimus above reporting de minimus Immediate Health above reporting de minimus No California Proposition 65 listed chemicals are known to be present. Canada Regulatory Information CEPA DSL/NDSL Status: WHMIS hazard class: All components are listed on or are exempt from listing on the Canadian Domestic Substances List. D.2.B 16. OTHER INFORMATION This material safety data sheet contains changes from the previous version in sections: Updated composition in Section 3. Prepared by: Regulatory Affairs DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of any kind, including lost profits. Page 5 of 5