SAFETY DATA SHEET Mold Armor Mold Remover & Disinfectant 1. PRODUCT AND COMPANY IDENTIFICATION

Transcription

1 1. PRODUCT AND COMPANY IDENTIFICATION Product Name: Manufacturer Information: Company Name: Mason Chemical Company Emergency Contact: 721 W. Algonquin Rd. Arlington Heights, IL 65 Chemtrec (8) Information: Product or Company Information (847) Supplier Name and Address: Company Name: W. M. Barr 215 Channel Avenue Memphis, TN Web site address: Phone Number: (91)775-1 Emergency Contact: 3E 24 Hour Emergency Contact (8) Information: W.M. Barr Customer Service (8) Page: 1 Product Category: Intended Use: Synonyms: Additional Information GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: Hazard Rating System: HMIS: Potential Health Effects (Acute and Chronic): Quaternary Ammonium Compound RTU Disinfectant/Sanitizer FG55, FG551, FG552 EPA No None 2. HAZARDS IDENTIFICATION HEALTH FLAMMABILITY PHYSICAL PPE 1 A Flammability Health NFPA: 1 Instability Special Hazard Skin: May be mildly irritating. Very large exposure may be harmful. Eyes: May cause irritation. Inhalation: Mists and vapors may be mildly irritating to the throat and respiratory tract. Ingestion: Harmful if swallowed. Chronic: None

2 3. COMPOSITION/INFORMATION ON INGREDIENTS Page: 2 CAS # Hazardous Components (Chemical Name) Concentration RTECS # compounds,benzyl-c12-16-alkyldimethyl, chlorides Decanaminium, N,N-Dimethyl-N-octyl-, chloride <.1 % UZ2995 <.1 % HD Octanaminium, N,N-Dimethyl-N-octyl-, chloride <.1 % RG Decanaminium, N-Decyl-N,N-dimethyl-, chloride <.1 % BP Ethyl alcohol {Ethanol} <2. PPM KQ63 4. FIRST AID MEASURES Emergency and First Aid Procedures: Eyes: Hold eye open and rinse slowly and gently with water for 15-2 minutes. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eyes. If irritation persists, get medical attention. Skin: Flush immediately with plenty of water. If irritation persists, get medical attention. Inhalation: If breathing is affected, remove to fresh air. Get medical attention. Ingestion: Immediately drink one cupful of water or milk. Get medical attention. Aggravated Medical Conditions: Persons with pre-existing skin disorders may be more susceptible to irritating effects 5. FIRE FIGHTING MEASURES Flash Pt: > 12. C Method Used: Cleveland Closed Cup Explosive Limits: LEL: UEL: Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: Suitable Extinguishing Media:Use any agent appropriate for surrounding fire. Firefighters should wear full protective clothing including self-contained breathing apparatus. Cool fire exposed containers with spray. 6. ACCIDENTAL RELEASE MEASURES Steps To Be Taken In Case Material Is Released Or Spilled: Emergency Action: Isolate spill or leak area immediately. Keep unauthorized personnel away. Stay upwind. Spill Cleanup: Ventilate closed spaces before entering. Floor will be slippery. Do not touch or walk through spilled material. Stop leak if you can do it without risk. A vapor suppressing foam may be used to reduce vapors. Prevent entry into waterways, sewers, basements or confined areas. Absorb or cover with dry earth, sand or other non-combustible material and transfer to containers. Large Spills: Dike far ahead of liquid spill for later disposal.

3 7. HANDLING AND STORAGE Page: 3 Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Handling Procedures: Avoid contact with skin and eyes. Use good personal hygiene practices. Wash hands before eating, drinking, smoking, or using toilet facilities. Wash thoroughly after work using soap and water. Keep the container tightly closed and in a cool, well-ventilated place. Keep from freezing. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits compounds,benzyl-c12-16-alkyldimeth yl, chlorides Decanaminium, N,N-Dimethyl-N-octyl-, chloride Octanaminium, N,N-Dimethyl-N-octyl-, chloride Decanaminium, N-Decyl-N,N-dimethyl-, chloride Ethyl alcohol {Ethanol} PEL: 1 ppm TLV: 1 ppm Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Work/Hygienic/Maintenance Practices: No special requirements under normal use conditions Handle in accordance with good industrial hygiene and safety practice Safety glasses with side-shields if splashing is likely Hand Protection Skin and body No special requirements under normal use conditions. No special requirements under normal use conditions No special ventilation requirements. General room ventilation is adequate. Eye wash fountain and emergency showers are recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: Clear, colorless to straw colored liquid with benzaldehyde (organic) odor. Melting Point: Boiling Point: Autoignition Pt: Flash Pt: > 12. C Method Used: Cleveland Closed Cup Explosive Limits: LEL: UEL: Specific Gravity (Water = 1): Density: 8.34 LB/GA

4 Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): Evaporation Rate: Solubility in Water: SAFETY DATA SHEET Viscosity:.955 cst ph: 7.99 Percent Volatile: Stability: Conditions To Avoid - Instability: Incompatibility - Materials To Avoid: 1. STABILITY AND REACTIVITY Unstable [ ] Stable [ X ] Keep away from strong oxidizing agents. Strong oxidizing agents, reducing agents. Hazardous Decomposition Or Carbon monoxide, carbon dioxide and toxic hydrogen chloride vapors. Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: Will occur [ ] Will not occur [ X ] Will not occur. 11. TOXICOLOGICAL INFORMATION Page: 4 Toxicological Information: Acute Oral LD5 > 5, mg/kg in rats Acute Dermal > 2, mg/kg in rats Primary Skin Not an irritant. Primary Eye Mildly irritating. 12. ECOLOGICAL INFORMATION General Ecological Information: Very Toxic to aquatic organisms Information available upon request. Please contact Mason Chemical Company Technical Service Department. This product is biodegradable 13. DISPOSAL CONSIDERATIONS Waste Disposal Method: Dispose in accordance with applicable local, state, and federal regulations.

5 LAND TRANSPORT (US DOT): CAS # DOT Proper Shipping Name: DOT Hazard Class: UN/NA Number: SAFETY DATA SHEET 14. TRANSPORT INFORMATION Not Regulated 15. REGULATORY INFORMATION EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists Hazardous Components (Chemical Name) compounds,benzyl-c12-16-alkyldimethyl, chlorides Decanaminium, N,N-Dimethyl-N-octyl-, chloride Page: 5 S. 32 (EHS) S. 34 RQ S. 313 (TRI) No No No No No No Octanaminium, N,N-Dimethyl-N-octyl-, chloride No No No Decanaminium, N-Decyl-N,N-dimethyl-, chloride No No No Ethyl alcohol {Ethanol} No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated: [X] Yes [ ] No Acute (immediate) Health Hazard [ ] Yes [X] No Chronic (delayed) Health Hazard [ ] Yes [X] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard Regulatory Information: TSCA Status While all ingredients are listed on the TSCA Chemical Inventory, this product is regulated as a pesticide under the Federal Insecticide, Fungicide and Rodenticide Act (FIFRA) and not subject to the TSCA Inventory rules for FIFRA uses. Revision Date: Additional Information About This Product: Company Policy or Disclaimer: Other Chemical Inventories All components of this product are listed on the following inventories: Canada (DSL), European Union, China, Korean and Philippines. One or more ingredients are not listed on the following inventories: Australia and Japan. 4/7/ OTHER INFORMATION The information contained herein is presented in good faith and believed to be accurate as of the effective date shown above. This information is furnished without warranty of any kind. Employers should use this information only as a supplement to other information gathered by them and must make independent determination of suitability and completeness of information from all sources to assure proper use of these materials and the safety and health of employees. Any use of this data and information must be determined by the user to be in accordance with applicable federal, state and local laws and regulations.