SAFETY DATA SHEET DAC Product and Company Identification. 2. Hazards Identification

Transcription

1 Page: Printed: 04/3/206 Revision: 0/3/205 Product Code: Product Name: Company Name:. Product and Company Identification DAC 20 Casco Products Company, Inc. P.O. Drawer 850 Brookhaven, MS address: Emergency Contact: Chemtrec (800) Casco (60) Information: Casco (60) Skin Corrosion/Irritation, Category B Aquatic Toxicity (Acute), Category 2. Hazards Identification GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: Potential Health Effects (Acute and Chronic): Inhalation: Skin Contact: Eye Contact: Ingestion: Danger H34: Causes severe skin burns and eye damage. H400: Very toxic to aquatic life. P260: Do not breathe {dust/fume/gas/mist/vapors/spray}. P264: Wash {hands} thoroughly after handling. P273: Avoid release to the environment. P280: Wear {protective gloves/protective clothing/eye protection/face protection}. P : IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P : IF ON SKIN (or hair): Remove/take off immediately all contaminated clothing. Rinse skin with water/shower. P : IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P30: Immediately call a POISON CENTER or doctor/physician. P32: Specific treatment {see... on this label}. P363: Wash contaminated clothing before reuse. P39: Collect spillage. P405: Store locked up. P50: Dispose of contents/container according to Federal, State and Local regulations. Skin: Causes corrosive burns. Brief exposures may cause irritation and defatting of the skin. Eyes: Causes burns and may result in permanent injury to eyes including blindness. Inhalation: Mists and vapors can irritate the throat and respiratory tract. High vapor concentrations may cause central nervous system effects. May be fatal if inhaled. Symptoms may include headaches, dizziness, and drowsiness. Ingestion: Ingestion can cause gastrointestinal irritation, nausea, vomiting and diarrhea. May irritate the throat and respiratory tract. High vapor concentrations may cause central nervous system effects. Causes corrosive burns. Brief exposures may cause irritation and defatting of the skin. Causes burns and may result in permanent injury to eyes including blindness. Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea.

2 Page: 2 Printed: 04/3/206 Revision: 0/3/205 Medical Conditions Generally Asthma Aggravated By Exposure: Pregnant women should avoid all chemical exposures. 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) Concentration Quaternary ammonium compounds,benzyl-c2-8-alkyldimethyl, chlorides C2-4-alkyl.(.(ethylphenyl)m ~0.0 % ~0.0 % Ethyl alcohol <.0 % Water ~79.0 % Emergency and First Aid Procedures: 4. First Aid Measures In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: If symptoms are experienced, move victim to fresh air. If person is not breathing, call 9 or an ambulance, then give artificial respiration, preferably mouth to mouth if possible. Call a poison control center or Doctor for further treatment advice. Take off contaminated clothing. Rinse skin immediately with plenty of water for 5-20 minutes. Call a poison control center or Doctor for treatment advice. Immediately flush with water for at least 5 minutes, while holding eyelids open. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye. Seek medical attention at once. Call a poison control center or Doctor immediately for treatment advice. Have a person sip a glass of water if able to swallow. Do not induce vomiting unless told to do so by a poison control center or Doctor. Do not give anything by mouth to an unconscious person. Skin: Burning and irritation. Eyes: Burning, watering, irritation, cloudy and difficulty seeing. Inhalation: Irritation, sneezing, coughing up to difficulty breathing. Ingestion: Gastrointestinal irritation, nausea, vomiting and diarrhea. 5. Fire Fighting Measures Flash Pt: > F Method Used: Pensky-Marten Closed Cup Explosive Limits: LEL: UEL: Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: Suitable Extinguishing Media: Dry chemical, foam, carbon dioxide or water fog. Solid water streams may spread burning liquids. Hazardous Combustion Products: Firefighters should wear full protective clothing including self-contained breathing apparatus. Cool fire exposed containers with spray. Irritating and toxic gases or fumes may be released during a fire.

3 Page: 3 Printed: 04/3/206 Revision: 0/3/ Accidental Release Measures Environmental Precautions: Steps To Be Taken In Case Material Is Released Or Spilled: Dike far ahead of liquid spill for later disposal. Water spray may reduce vapor but will increase foaming. Isolate spill or leak area immediately. Keep unauthorized personnel away. Stay upwind. Keep out of low areas where vapors may accumulate. Eliminate all ignition sources. 7. Handling and Storage Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Avoid contact with skin and eyes. Use good personal hygiene practices. Wash hands before eating, drinking, smoking, or using toilet facilities. Wash thoroughly after work using soap and water. Keep container tightly closed in a cool, well-ventilated place. Keep from freezing. Do not handle or store near an open flame, heat or other sources of ignition. Prevent electrostatic charge buildup by using common bonding and grounding techniques. 8. Exposure Controls/Personal Protection CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits Quaternary ammonium compounds,benzyl-c2-8-alkyldimeth yl, chlorides C2-4-alkyl.(.(ethylphenyl)m Ethyl alcohol PEL: 000 ppm TLV: 000 ppm STEL: 000 ppm Water Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): If exposure limits are exceeded or if irritation is experienced, NIOSH approved respiratory protection should be worn. Wear chemical goggles. Use face shield if splashing is possible. Nitrile, neoprene or rubber gloves Eye wash fountain and emergency showers are recommended. Clothing and/or aprons impervious to chemicals. 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: ph: Melting Point: Boiling Point: Flash Pt: > F Method Used: Pensky-Marten Closed Cup Evaporation Rate: Flammability (solid, gas): Appearance: Clear Colourless Straw-colored Liquid Odor: Benzaldehyde-like odor Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = ):

4 Page: 4 Printed: 04/3/206 Revision: 0/3/205 Specific Gravity (Water = ): Solubility in Water: Octanol/Water Partition Coefficient: Autoignition Pt: ~ For 0% Aq. Decomposition Temperature: Viscosity: Stability: Conditions To Avoid - Instability: Incompatibility - Materials To Avoid: Hazardous Decomposition or Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: Toxicological Information: Carcinogenicity: Waste Disposal Method: LAND TRANSPORT (US DOT): 0. Stability and Reactivity Unstable [ ] Stable [ X ] Keep away from heat and strong oxidizers. Strong oxidizing agents and reducing agents. Carbon monoxide, cardon dioxide and toxic hydrogen chloride vapors. Will occur [ ] Will not occur [ X ] Will not occur. Toxicological Information NTP? No IARC Monographs? No OSHA Regulated? No 2. Ecological Information 3. Disposal Considerations According to Federal, State and local regulations. 4. Transport Information DOT Proper Shipping Name: Disinfectants Liquid Corrosive, NOS (Quaternary Ammonia Compound), 8, UN903, PG III DOT Hazard Class: 8 CORROSIVE UN/NA Number: UN903 Packing Group: III Precautionary Label: Corrosive CAS # Hazardous Components (Chemical Name) 5. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 986) Lists Quaternary ammonium compounds,benzyl-c2-8-alkyldimethyl, chlorides C2-4-alkyl.(.(ethylphenyl)m S. 302 (EHS) S. 304 RQ S. 33 (TRI) No No No No No No

5 Page: 5 Printed: 04/3/206 Revision: 0/3/ Ethyl alcohol No No No Water No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 3/32 as indicated: [X] Yes [ ] No Acute (immediate) Health Hazard [ ] Yes [X] No Chronic (delayed) Health Hazard [ ] Yes [X] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard Revision Date: Hazard Rating System: HMIS: 0/3/ Other Information HEALTH FLAMMABILITY PHYSICAL PPE npqr Flammability Health NFPA: COR Instability Special Hazard Additional Information About This Product: Company Policy or Disclaimer: