SECTION 1: Identification of the substance/mixture and of the company/undertaking

Transcription

1 Safety data sheet Page: 1/15 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Efka PB Relevant identified uses of the substance or mixture and uses advised against Relevant identified uses: process chemical 1.3. Details of the supplier of the safety data sheet Company: BASF SE Ludwigshafen GERMANY Regional Business Unit Dispersions and Resins Europe Telephone: address: 1.4. Emergency telephone number International emergency number: Telephone: SECTION 2: Hazards Identification 2.1. Classification of the substance or mixture According to Regulation (EC) No 1272/2008 [CLP] Asp. Tox. 1 Flam. Liq. 3

2 Page: 2/15 STOT SE 3 (Vapours may cause drowsiness and dizziness.) STOT SE 3 (irritating to respiratory system) Aquatic Chronic 3 H226, H304, H336, H335, H412 For the classifications not written out in full in this section the full text can be found in section Label elements According to Regulation (EC) No 1272/2008 [CLP] Pictogram: Signal Word: Danger Hazard Statement: H226 H304 H336 H335 H412 Flammable liquid and vapour. May be fatal if swallowed and enters airways. May cause drowsiness or dizziness. May cause respiratory irritation. Harmful to aquatic life with long lasting effects. Precautionary Statements (Prevention): P271 Use only outdoors or in a well-ventilated area. P210 Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. P280 Wear protective gloves and eye/face protection. P273 Avoid release to the environment. P261 Avoid breathing dust/fume/gas/mist/vapours/spray. P243 Take action to prevent static discharges. P241 Use explosion-proof electrical/ventilating/lighting/equipment. P240 Ground and bond container and receiving equipment. P242 Use only non-sparking tools. Precautionary Statements (Response):

3 Page: 3/15 P312 Call a POISON CENTER or doctor/physician if you feel unwell. P301 + P310 IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. P304 + P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing. P303 + P361 + P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. P331 Do NOT induce vomiting. P370 + P378 In case of fire: Use foam or dry powder for extinction. Precautionary Statements (Storage): P233 Keep container tightly closed. P403 + P235 Store in a well-ventilated place. Keep cool. P405 Store locked up. Precautionary Statements (Disposal): P501 Dispose of contents/container to hazardous or special waste collection point. Labeling of special preparations (GHS): EUH066: Repeated exposure may cause skin dryness or cracking. According to Regulation (EC) No 1272/2008 [CLP] EUH208: May produce an allergic reaction. Contains: 2-butanone oxime; ethyl methyl ketoxime; ethyl methyl ketone oxime According to Regulation (EC) No 1272/2008 [CLP] Hazard determining component(s) for labelling: Naphtha (petroleum), hydrotreated light; Low boiling point hydrogen treated naphtha, Solvent naphtha (petroleum), light arom.; Low boiling point naphtha - unspecified 2.3. Other hazards According to Regulation (EC) No 1272/2008 [CLP] No specific dangers known, if the regulations/notes for storage and handling are considered. SECTION 3: Composition/Information on Ingredients 3.1. Substances Not applicable 3.2. Mixtures Chemical nature

4 Page: 4/15 Solution based on: defoamer, aromatic hydrocarbons, aliphatic hydrocarbon Hazardous ingredients (GHS) according to Regulation (EC) No. 1272/ butanone oxime; ethyl methyl ketoxime; ethyl methyl ketone oxime Content (W/W): >= 0.3 % - < 1 % Acute Tox. 4 (dermal) CAS Number: Eye Dam./Irrit. 1 EC-Number: Skin Sens. 1 INDEX-Number: Carc. 2 H318, H312, H317, H351 Hydrocarbons, C9-C10, n-alkanes, isoalkanes, cyclics, < 2% aromatics Content (W/W): >= 30 % - <= 50 % Asp. Tox. 1 EC-Number: Flam. Liq. 3 REACH registration number: 01- STOT SE 3 (drowsiness and dizziness) Aquatic Chronic 3 INDEX-Number: H226, H304, H336, H412 EUH066 Hydrocarbons, C9, aromatics Content (W/W): >= 20 % - < 25 % REACH registration number: Asp. Tox. 1 Flam. Liq. 3 STOT SE 3 (drowsiness and dizziness) STOT SE 3 (irr. to respiratory syst.) Aquatic Chronic 2 H226, H304, H336, H335, H411 EUH066 For the classifications not written out in full in this section, including the hazard classes and the hazard statements, the full text is listed in section 16. SECTION 4: First-Aid Measures 4.1. Description of first aid measures Immediately remove contaminated clothing. If inhaled: If difficulties occur after vapour/aerosol has been inhaled, remove to fresh air and seek medical attention. On skin contact: Wash thoroughly with soap and water. On contact with eyes: Wash affected eyes for at least 15 minutes under running water with eyelids held open.

5 Page: 5/15 On ingestion: Rinse mouth immediately and then drink plenty of water, seek medical attention Most important symptoms and effects, both acute and delayed Symptoms: The most important known symptoms and effects are described in the labelling (see section 2) and/or in section 11., Further important symptoms and effects are so far not known Indication of any immediate medical attention and special treatment needed Treatment: Treat according to symptoms (decontamination, vital functions), no known specific antidote, administer corticosteroid dose aerosol to prevent pulmonary odema. SECTION 5: Fire-Fighting Measures 5.1. Extinguishing media Suitable extinguishing media: dry powder, foam 5.2. Special hazards arising from the substance or mixture harmful vapours Evolution of fumes/fog. The substances/groups of substances mentioned can be released in case of fire Advice for fire-fighters Special protective equipment: Wear a self-contained breathing apparatus. Further information: The degree of risk is governed by the burning substance and the fire conditions. Contaminated extinguishing water must be disposed of in accordance with official regulations. SECTION 6: Accidental Release Measures 6.1. Personal precautions, protective equipment and emergency procedures Use personal protective clothing. Breathing protection required Environmental precautions Contain contaminated water/firefighting water. Do not discharge into drains/surface waters/groundwater Methods and material for containment and cleaning up For large amounts: Pump off product. For residues: Pick up with suitable absorbent material. Dispose of absorbed material in accordance with regulations Reference to other sections

6 Page: 6/15 Information regarding exposure controls/personal protection and disposal considerations can be found in section 8 and 13. SECTION 7: Handling and Storage 7.1. Precautions for safe handling Ensure thorough ventilation of stores and work areas. Protection against fire and explosion: Sources of ignition should be kept well clear. Take precautionary measures against static discharges. If delivered in plastic packing, highest permissable emptying temperature is 5 Kelvin below the flash point Conditions for safe storage, including any incompatibilities Further information on storage conditions: Keep container tightly closed and in a cool place Specific end use(s) For the relevant identified use(s) listed in Section 1 the advice mentioned in this section 7 is to be observed. SECTION 8: Exposure Controls/Personal Protection 8.1. Control parameters Components with occupational exposure limits : Solvent naphtha (petroleum), light arom.; Low boiling point naphtha - unspecified Components with DNEL : Solvent naphtha (petroleum), light arom.; Low boiling point naphtha - unspecified worker: Long-term exposure- systemic effects, Inhalation: ppm consumer: Long-term exposure- systemic effects, Inhalation: 179 mg/m Exposure controls Personal protective equipment Respiratory protection: Suitable respiratory protection for higher concentrations or long-term effect: Gas filter for gases/vapours of organic compounds (boiling point >65 C, e. g. EN Type A) Hand protection: Chemical resistant protective gloves (EN 374) Suitable materials also with prolonged, direct contact (Recommended: Protective index 6, corresponding > 480 minutes of permeation time according to EN 374): fluoroelastomer (FKM) mm coating thickness Polyethylene-Laminate (PE laminate) - ca. 0.1 mm coating thickness

7 Page: 7/15 Suitable materials for short-term contact (recommended: At least protective index 2, corresponding > 30 minutes of permeation time according to EN 374) nitrile rubber (NBR) mm coating thickness Supplementary note: The specifications are based on tests, literature data and information of glove manufacturers or are derived from similar substances by analogy. Due to many conditions (e.g. temperature) it must be considered, that the practical usage of a chemical-protective glove in practice may be much shorter than the permeation time determined through testing. Manufacturer's directions for use should be observed because of great diversity of types. Eye protection: Safety glasses with side-shields (frame goggles) (e.g. EN 166) Body protection: Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting boots, chemical-protection suit (according to EN in case of splashes or EN ISO in case of dust). General safety and hygiene measures Handle in accordance with good industrial hygiene and safety practice. Wearing of closed work clothing is required additionally to the stated personal protection equipment. SECTION 9: Physical and Chemical Properties 9.1. Information on basic physical and chemical properties Form: Colour: Odour: Odour threshold: liquid colourless characteristic Not determined due to potential health hazard by inhalation. ph value: not determined Freezing point: not determined Boiling range: not determined Flash point: 26 C Information on: Naphtha (petroleum), hydrotreated light Flash point: 27 C Evaporation rate: not determined Flammability: Flammable. Lower explosion limit: 0.6 %(V) Upper explosion limit: 8.0 %(V) Ignition temperature: not determined

8 Page: 8/15 Vapour pressure: 10.0 hpa Density: (20 C) g/cm3 (20 C) Relative density: (20 C) Relative vapour density (air): not determined Solubility in water: immiscible Partitioning coefficient n-octanol/water (log Kow): not applicable for mixtures Self ignition: Temperature: 240 C not self-igniting Thermal decomposition: not determined Viscosity, dynamic: 15 mpa.s (40 C) Explosion hazard: not explosive Fire promoting properties: not fire-propagating (BASF method) 9.2. Other information Hygroscopy: Surface tension: Grain size distribution: Non-hygroscopic The substance / product is marketed or used in a non solid or granular form. SECTION 10: Stability and Reactivity Reactivity No hazardous reactions if stored and handled as prescribed/indicated Chemical stability The product is stable if stored and handled as prescribed/indicated Possibility of hazardous reactions No hazardous reactions when stored and handled according to instructions Conditions to avoid Avoid all sources of ignition: heat, sparks, open flame. Avoid electro-static charge. Avoid electrostatic discharge Incompatible materials Substances to avoid: strong oxidizing agents, strong bases, strong acids

9 Page: 9/ Hazardous decomposition products Hazardous decomposition products: No hazardous decomposition products if stored and handled as prescribed/indicated. SECTION 11: Toxicological Information Information on toxicological effects Acute toxicity Experimental/calculated data: LD50 rat (oral): > 5,000 mg/kg LC50 rat (by inhalation): > 20 mg/l 4 h LD50 rabbit (dermal): > 5,000 mg/kg Irritation Assessment of irritating effects: Irritating to respiratory system. The product has not been tested. The statement has been derived from the properties of the Experimental/calculated data: Skin corrosion/irritation: non-irritant Serious eye damage/irritation: non-irritant Respiratory/Skin sensitization Experimental/calculated data: other other: Non-sensitizing. Germ cell mutagenicity

10 Page: 10/15 Assessment of mutagenicity: No data available concerning mutagenic effects. Carcinogenicity Assessment of carcinogenicity: Reproductive toxicity Assessment of reproduction toxicity: Developmental toxicity Assessment of teratogenicity: Specific target organ toxicity (single exposure) Assessment of STOT single: A single exposure may have relevant toxic effects on organs named in section 2 of this safety data sheet. Remarks: The product has not been tested. The statement has been derived from the properties of the Repeated dose toxicity and Specific target organ toxicity (repeated exposure) Assessment of repeated dose toxicity: Aspiration hazard Aspiration hazard SECTION 12: Ecological Information Toxicity Toxicity to fish: LC50 > mg/l Aquatic invertebrates: EC50 (48 h) > mg/l, Daphnia magna

11 Page: 11/15 Aquatic plants: EC50 (72 h) > mg/l Microorganisms/Effect on activated sludge: Chronic toxicity to fish: Chronic toxicity to aquatic invertebrates: Assessment of terrestrial toxicity: No data available concerning terrestrial toxicity Persistence and degradability Assessment biodegradation and elimination (H2O): Not readily biodegradable (by OECD criteria). The product has not been tested. The statement has been derived from the properties of the Bioaccumulative potential Assessment bioaccumulation potential: Accumulation in organisms is expected Mobility in soil Assessment transport between environmental compartments: Volatility: Results of PBT and vpvb assessment According to Annex XIII of Regulation (EC) No.1907/2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH): The product does not contain a substance fulfilling the PBT (persistent/bioaccumulative/toxic) criteria or the vpvb (very persistent/very bioaccumulative) criteria Other adverse effects The product does not contain substances that are listed in Annex I of Regulation (EC) 2037/2000 on substances that deplete the ozone layer Additional information

12 Page: 12/15 Add. remarks environm. fate & pathway: Treatment in biological waste water treatment plants has to be performed according to local and administrative regulations. Other ecotoxicological advice: The product has not been tested. The statements on ecotoxicology have been derived from the properties of the SECTION 13: Disposal Considerations Waste treatment methods Must be disposed of or incinerated in accordance with local regulations. Contaminated packaging: Uncontaminated packaging can be re-used. Packs that cannot be cleaned should be disposed of in the same manner as the contents. SECTION 14: Transport Information Land transport ADR UN number UN1866 UN proper shipping name: RESIN SOLUTION Transport hazard class(es): 3 Packing group: III Environmental hazards: no Special precautions for Tunnel code: D/E user: RID UN number UN1866 UN proper shipping name: RESIN SOLUTION Transport hazard class(es): 3 Packing group: III Environmental hazards: no Special precautions for None known user: Inland waterway transport ADN UN number UN1866

13 Page: 13/15 UN proper shipping name: RESIN SOLUTION Transport hazard class(es): 3 Packing group: III Environmental hazards: Special precautions for user: no None known Transport in inland waterway vessel Not evaluated Sea transport IMDG UN number: UN 1866 UN proper shipping name: RESIN SOLUTION Transport hazard class(es): 3 Packing group: III Environmental hazards: no Marine pollutant: NO Special precautions for None known user: Air transport IATA/ICAO UN number: UN 1866 UN proper shipping name: RESIN SOLUTION Transport hazard class(es): 3 Packing group: III Environmental hazards: No Mark as dangerous for the environment is needed Special precautions for None known user: UN number See corresponding entries for UN number for the respective regulations in the tables above UN proper shipping name See corresponding entries for UN proper shipping name for the respective regulations in the tables above Transport hazard class(es) See corresponding entries for Transport hazard class(es) for the respective regulations in the tables above.

14 Page: 14/ Packing group See corresponding entries for Packing group for the respective regulations in the tables above Environmental hazards See corresponding entries for Environmental hazards for the respective regulations in the tables above Special precautions for user See corresponding entries for Special precautions for user for the respective regulations in the tables above Transport in bulk according to Annex II of MARPOL and the IBC Code Regulation: Shipment approved: Pollution name: Pollution category: Ship Type: Not evaluated Not evaluated Not evaluated Not evaluated Not evaluated SECTION 15: Regulatory Information Safety, health and environmental regulations/legislation specific for the substance or mixture Prohibitions, Restrictions and Authorizations Annex XVII of Regulation (EC) No 1907/2006: Number on List: 3, 40 If other regulatory information applies that is not already provided elsewhere in this safety data sheet, then it is described in this subsection Chemical Safety Assessment Chemical Safety Assessment not yet performed due to registration timelines SECTION 16: Other Information Due to the merger of CIBA and BASF Group all Material Safety Data Sheets have been reassessed on the basis of consolidated information. This may have resulted in changes of the Material Safety Data Sheets. In case you have questions concerning such changes please contact us at the address mentioned in Section I. Full text of the classifications, including the hazard classes and the hazard statements, if mentioned in section 2 or 3: Asp. Tox. Aspiration hazard Flam. Liq. Flammable liquids STOT SE Specific target organ toxicity single exposure

15 Page: 15/15 Aquatic Chronic Hazardous to the aquatic environment - chronic Acute Tox. Acute toxicity Eye Dam./Irrit. Serious eye damage/eye irritation Skin Sens. Skin sensitization Carc. Carcinogenicity H226 Flammable liquid and vapour. H304 May be fatal if swallowed and enters airways. H336 May cause drowsiness or dizziness. H335 May cause respiratory irritation. H412 Harmful to aquatic life with long lasting effects. H318 Causes serious eye damage. H312 Harmful in contact with skin. H317 May cause an allergic skin reaction. H351 Suspected of causing cancer. H411 Toxic to aquatic life with long lasting effects. EUH066 Repeated exposure may cause skin dryness or cracking. The data contained in this safety data sheet are based on our current knowledge and experience and describe the product only with regard to safety requirements. This safety data sheet is neither a Certificate of Analysis (CoA) nor technical data sheet and shall not be mistaken for a specification agreement. Identified uses in this safety data sheet do neither represent an agreement on the corresponding contractual quality of the substance/mixture nor a contractually designated use. It is the responsibility of the recipient of the product to ensure any proprietary rights and existing laws and legislation are observed. Vertical lines in the left hand margin indicate an amendment from the previous version.