SAFETY DATA SHEET Acc. to EU Rule: RL 2001/58/EG Disinfectant Concentrate EM-200

Transcription

1 Page: 1 of 1 1. NAME- / PREPARATION / COMPANY Name EM Application Manufacturer Supplier Internet Disinfection for instruments Dr. Schumacher GmbH EMAG AG Gerauer Strasse 34 D Mörfelden Tel : / Fax : service@emag-germany.de 2. COMPOSITION / INFORMATION ABOUT INGREDIENTS Chemical Characterisation Aqueous preparation with detergents and solvents Dangerous ingredients. CAS-Nr. EG-Nr. Bezeichnung [Gew-%] Einstufung - Alkylpropylendiamin-1,5-bis-guanidiniumacetat < 5 R10, Xn R22, C R34, N R50 Alcoholethoxylate < 10 Xn R22; Xi R N,N,-Didecyl-N-methyl-poly(oxyethyl) < 10 Xn R22, C R34, N R50 ammoniumpropionat 3. POSSIBLE DANGERS wording of R R34 causes chemical burn 4. FIRST AID MEASURES General directions After inhalation After skin contact After eye contact After swallow Remove dirty or moist clothes immediately. In case of discomfort contact doctor immediately. After inhalation of vapors or decomposition materials in case of accident go to fresh air. When discomfort remains contact doctor. Immediately to be washed with soap and plenty of water. In case of permanent skin irritation go to doctor. Immediately to be washed with plenty of water even under eyelid - for min. 15 minutes. Contact doctor immediately. Do not cause regurgitation. Contact doctor. Attention: In case of regurgitation high danger of choking by foamy ingredients. Rinse mouth. Drink some glasses of water. The question of whether or not regurgitation should be initiated can only be answered by the doctor. 1

2 Page: 2 of 2 5. MEASURES TO CONTROL FIRE Appropriate extinguishing agents Non suitable extinguishing agents Special danger in case of fire Protective clothing Additional information Extinguish measures to be adjusted to ambient fire. Product itself does not burn. Solid water jet (by safety reasons). In case of fire carbon monoxide (CO), carbon dioxide and njtrotic gases (NOx) may be released Self contained breathing apparatus to be used. Cool container with water spray jet. 6. MEASURES IN CASE OF UNINTENTIONAL RELEASE Person related precautions Environment protection measures Procedures for cleaning In case of vapours use breathing apparatus. Take care of appropriate air ventilation. Use personal protective clothing. Don`t lead into surface or ground water or canalisation. To be fixed with liquid soaking material (i.e. sand, silica gel, acid / universal bonding agents). Use shovel to put into appropriate container for disposal. Additional information - 7. HANDLING AND STORAGE Direction for safe handling Direction for fire and explosion protection Storage Information about storage conditions Storage class Contact with mouth, eyes, skin and clothes to be avoided. To be used only in rooms with sufficient air ventilation. Containers to be kept closed. No special fire protection measures required. Keep container firmly closed and store in well ventilated dry place. Do not use container made of metal. Do not store together with oxydation agents. Keep away from food, beverages and animal feed. 8 (VCI Kzpt.) 2

3 Page: 3 of 3 8. EXPOSITION LIMITS AND PERSONAL PROTECTION CLOTHES General protection measures Breathing protection Hand guard Eye protection Body protection Hygiene measures Sufficient air ventilation especially in closed rooms. If air ventilation is not sufficient use breathing apparatus (gas filter type A). Rubber or plastic gloves. This advise is exclusively based on the chemical compatibility and the test acc. to EN 374 under laboratory conditions. Depending on application other conditions may apply. Therefore additional advise of the glove supplier are to be watched. Protective goggles with side protection, eye wash bottle with clean water Long arm working clothes. Wash hands after rests and immediately after usage of the product. During work do not eat, drink or smoke. Remove dirty or moist clothing immediately. Avoid contact with skin, eyes and clothing. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Form : Liquid Colour : Blue / green Aroma : Perfumed ph Value (at delivery) Approx. 9 Boiling Point / Boiling Range Approx C Flash Point - Explosion Risk - Fire Boosting Properties - Vapor Pressure - Relative Density Solubility in Water Viscosity 1 g/ml (+20 C) mixable (+20 C) Approx. 20 mpa*s 3

4 Page: 4 of STABILITY AND REACTIVITY Conditions to be avoided Substances to be avoided Dangerous decomposition products Special remarks Do not overheat to avoid thermal decomposition Strong oxidation agents Carbon monoxide (CO), carbon dioxide (CO2), nitrical gases (NOx). No decomposition if stored and used conventional. 11. INFORMATION ABOUT TOXICOLOGY General Remarks Causes chemical burn 12. INFORMATION ABOUT ECOLOGY Information about disposal - Procedure - - Methods of analysis - - Degree of disposal > 90% according to WRMG - Valuation Bio-degradable Additional information May cause damage to waters. Don`t lead into surface water or canalisation. 13. INFORMATION ABOUT SEWAGE AND REFUSE DISPOSAL Important: Information given in this section is only Valid for the clean, not polluted product Disposal code : (EG) Disposal procedure for the product Uncleaned packages Recommended cleaning agent Name of Disposal: Disposal a.n.g. Reuse is favoured over disposal. Can be burned considering official regulations To be handed over to local re-use, recycling or disposal agents. Cleaned packages may be re-used if cleaned properly. Packages which can not be cleaned properly are to be treated like uncleaned packages. Water 4

5 Page: 5 of INFORMATION ABOUT TRANSPORTATION Land freight (ADR/RID/GGVS/GGVE) Designation of product DISINFECTANT, LIQUID, CORROSIVE, N.O.S. (didecylmethylpoly (oxyethyl)ammonium propionate) UN-No Class 8 PG III Danger class No. 80 Remarks LQ 7: composed packages: 5 l / 30 kg (gross); trays: 5 l / 20 kg (gross) Sea freight IMDG/GGV See Designation of product DISINFECTANT, LIQUID, CORROSIVE, N.O.S. (didecylmethylpoly(oxyethyl)ammonium propionate) UN-No Class 8 PG III Marine pollutant Remarks Air freight ICAO/IATA Designation of product No Limited quantities (Section 18): composed packages: 5 l / 30 kg (gross); Trays: 5 l / 20 kg (gross) DISINFECTANT, LIQUID, CORROSIVE, N.O.S. (didecylmethylpoly(oxyethyl)ammonium propionate,solution) UN/ID-No Class 8 PG III Remarks PAC 818 (5 L), CAC 820 (60 L) Further recommendations for transport Germany / Mailing: National: max. 500 ml per inner package, max. 2 l per mailing package; International: forbidden. 5

6 Page: 6 of SPECIFICATIONS Code letter / Indication of danger acc. to 67/548/EWG and 1999/45/EG C chemical burns R class S class R34 create chemical burns S26 in case of contact with eyes spring-clean immediately With water and contact doctor S35 Waste and container are assured to be disposed. S36/37/39 wear during work a suitable protective clothing, protective gloves and protective goggles / face mask S45 in case of accident or indisposition contact immediately a doctor (if possible present label of the bottle) S61 release to environment to be avoided. Special directions to be obtained, Safety Data Sheet to be contacted. Code letter / Indication of danger acc. to national specifications to be labelled with: N.N.-Didecyl-N-methyl-poly(oxyethyl)ammoniumpropionat 16. OTHER INFORMATION Sections changed in this edition - Wording of R class for ingredients mentioned in section 2 R10 - inflammable R22 harmful if swallowed R34 causes chemical burn R41 danger of serious eye damage R50 very toxic for water organisms Wording of S class for ingredients - mentioned in section 2 Sensitising materials - The information given in this safety data sheet are correct to our best knowledge at the time of issue. It shall provide you with information about the safe handling of the product regarding storage, use, transportation and sewage and refuse disposal. The information is not transferable to other products. If products specified in this safety data sheet are mixed or used with other materials, information of this safety data sheet can not be transferred unless explicitly mentioned. 6