MANUAL/ELECTRIC PORTABLE PATIENT LIFT and SLINGS OWNER'S INSTALLATION AND OPERATING INSTRUCTIONS

Transcription

1 MU/ PB P F and G W' D PG U

2 P P P WG D P H QUPM WHU F DG D UDDG H MU. F YU UB UDD H WG, U D U; HH PF (D-HP) BF MPG U H QUPM - HW JUY DMG MY U. D FQUY F Most electronic equipment is influenced by adio Frequency nterference (F). U should be exercised with regard to the use of portable communication equipment in the area around such equipment. f F causes erratic behavior, PUH the MGY P BU DW (ê) MMD- Y. D disengage the mergency top Button while transmission is in progress. M Maintenance MU be performed Y by qualified personnel. WG notices as used in this manual apply to hazards or unsafe practices which could result in serious bodily harm. U notices as used in this manual apply to hazards or unsafe practices which could result in minor personal injury or property damage. highlight procedures and contain information which assist the operator in understanding the information contained in this manual. he information contained in this document is subject to change without notice. V H U D KP WH P F M. 2

3 B F P... 2 FY UMMY... 4 PF... 5 FU... 6 HDG PDU... 8 hipping and ransportation nstructions... 8 Unpacking... 8 nspection... 8 torage... 8 MBY... 9 ssembly of the Patient ift... 9 Unpacking the Patient ift... 9 ssembling the Mast to the Base... 9 ssembling the Manual/Hydraulic Pump to the Boom ssembling the lectric ctuator to the Boom hifter Handle nstallation V FM MU F Disassembly/ssembly emoving the Manual/Hydraulic Pump ssembly ssembly of the lectric ctuator ttaching the ontrol Box to the Mast Battery harging P U G Model o Hammock and Model o Hammock w/ommode pening Fabric Body Positioning the Model o Hammock or Model o Hammock w/ommode pening Positioning the Patient on the ling with or without ommode pening MD UV DU G Positioning the Patient in the Model o Universal Deluxe ling P perating the Patient ift o lose/pen the egs of the Base ssembly aising/owering Manual/Hydraulic ift aising the ift owering the ift B F 3 P (ont.) aising/owering lectric ift aising the ift owering the ift FG H P ttaching the lings to the Patient ift ifting/moving the Patient FG P F U F H BHM F ransferring Patient for Use of a ommode hair or tandard ommode ransferring to a ommode hair ransferring to a tandard ommode ransferring to a Bathing Unit FG WHH FG FM WHH FG FM WHH UBHG M FY P HK D M F YU P F ubrication Wear and Damage leaning Manual/Hydraulic Pump Manual/Hydraulic Pump or lectric ctuator eplacement wivel Bar eplacement Base djustment hifter Handle djustment asters ear aster eplacement Front aster eplacement Front aster Housing emoval nvacare 9833 Weight Module (Digital cale) MD WY B F

4 FY UMMY F Y U M M Y FY UMMY WG heck all parts for shipping damage before using. n case of damage, D use the equipment. ontact the Dealer for further instructions. he nvacare patient lift is a transport device. t is intended to transfer an individual from one resting surface to another (such as a bed to a wheelchair). Moving a person suspended in a sling over Y distance is recommended. D attempt any transfer without approval of the patient s physician, nurse or medical assistant. horoughly read the instructions in this wner s Manual, observe a trained team of experts perform the lifting procedures and then perform the entire lift procedure several times with proper supervision and a capable individual acting as a patient. Use common sense in all lifts. pecial care MU B taken with people with disabilities who cannot cooperate while being lifted. Use restraint straps if necessary. nvacare slings and patient lift accessories are specifically designed to be used in conjunction with nvacare patient lifts. lings and accessories designed by other manufacturers are not to be utilized as a component of nvacare s patient lift system. Use of these products is prohibited and will void nvacare s patient lift warranty. Use only genuine nvacare slings and lift accessories to maintain patient safety and product utility. Use a sling that is recommended by the individual s doctor, nurse or medical assistant for the comfort and safety of the individual being lifted. D use any kind of plastic back incontinence pad or seating cushion between the patient and sling material that may cause the patient to slide out of the sling during transferring. When using an adjustable base lift, the legs MU B in the maximum PD/KD position BF lifting the patient. Before transferring a patient from a stationary object (wheelchair, commode or bed), slightly raise the patient off the stationary object and check that all sling attachments are secure. f any attachment is not correct, lower the patient and correct the problem, then raise the patient and check again. During transfer, with patient suspended in a sling attached to the lift, D roll caster base over objects such as carpet, raised carpet bindings, door frames, or any uneven surfaces or obstacles that would create an imbalance of the patient lift and could cause the patient lift to tip over. Use steering handles on the mast at times to push or pull the patient lift. nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. fter the first 12 months of operation, inspect the swivel bar and the eye of the boom (to which it attaches) for wear. f the metal is worn, the parts MU be replaced. Make this inspection every three (3) months thereafter. he hydraulic/electric pump is sealed at the factory and if service is required, the pump unit MU B returned to the factory for repair. D attempt to open the hydraulic/electric pump or obtain local service as this will VD the warranty and may result in damage and a costly repair. onsult your Dealer or nvacare for further information. asters and axle bolts require inspection every six (6) months to check for tightness and wear. egular maintenance of patient lifts and accessories is necessary to assure proper operation. D exceed maximum weight limitation of the patient lift. he suggested weight limitation will vary from 300 lbs. for the lectric ift to 375 lbs. for the Manual (Hydraulic) ift depending on the type of patient lift purchased. 4

5 PF PF Height at ling Hook-up- M.: Height at ling Hook-up- M.: Base Width P: Base Width D: Base Height (learance): Base ength: aster ize (F/): Folded Height: ling ptions: 9700 Manual / Hydraulic 67.5-inches 18.5-inches 42.0-inches 24.5-inches 3.5-inches 42.0-inches 2.0-inches/5.0-inches 16.5-inches 3-tyles 9701 lectric 66-inches 17-inches 42.0-inches 24.5-inches 3.5-inches 42.0-inches 2.0-inches/5.0-inches 16.5-inches 3-tyles P F Weight apacity: 375 lbs. 300 lbs. Weight arton: 96 lbs. 92 lbs. Weight U of arton: 78 lbs. 79 lbs. Battery: / 2-12V echargeable ealed harger nput: / 120V harger utput: / 24V D ccessories: Digital cale, Quick Fold Kit Digital cale, Quick Fold Kit udible ow Battery larm: / When echarging eeded Motor afety Devices: / utomatic top Button * pprox. ifts per harge: / 60 to 100 Warranty Pump/lectronics: 1 Year 1 Year : 9700K lectric onversion Kit has the same specifications as Kit includes actuator, battery with bracket, remote control unit, recharging unit and attachment hardware. * Varies dependent upon load and stroke G Universal Deluxe Hammock Hammock Padded w/ommode verall ength: 25-inches Back 50-inches 50-inches 27-inches eg verall Width: 41-inches 40-inches 40-inches ommode pening: / / 6-inches Wide x 12-inches ong ccessories: 9732 Digital cale Bracket Y asy-tore Kit (Pin and ing ssembly for quickly Disassembling ift WHU ools). 5

6 FU FU MU / HYDU F (FGU 1) F (FGU 2) F U Manual / Hydraulic weight limitation is 375 lbs. Mast bolts into base. an be separated for storage. peration optimizes lift capabilities. equires less physical effort for raising patient. ffset mast and boom style provides better lift path. Maximizes full travel range. Pump handle can rotate from side-to-side for convenience of assistant. ange: inches of range allows the patient to be picked up from a lying position on floor. Boom lectric lift weight limitation is 300 lbs. Mast bolts into base. an be separated for storage. peration optimizes lift capabilities. equires less physical effort for raising patient. ffset mast and boom style provides better lift path. Maximizes full travel range. Hand control with elongated cord for convenience of assistant. ange: inches of range allows the patient to be picked up from a lying position on floor. wivel Bar Mast Hydraulic Pump ontrol Valve ling old eparately Boom hifter Handle Pump Handle Mast Hand ontrol wivel Bar astered Base ontrol Box lectric ctuator FGU 1 - MU/HYDU F hifter Handle astered Base 6 FGU 2 - F

7 FU P G WG Use a sling that is recommended by the individual s doctor, nurse or medical assistant for the comfort and safety of the individual being lifted. Patient slings work in conjunction with lifts to support the patient during lifting and transferring procedures. lings attach to the lift by using the sewn-in hook-on points. lings are adjustable. ach sling offers reinforcing at each hook-on point to ensure patient safety. ach sling is constructed of durable materials which resist deterioration from exposure to moisture or laundering. FU (ont.) Model o Universal Deluxe ling (FGU 4) Divided leg design is best suited for high level spinal cord injuries or patients which sling removal is more difficult. upport ranges from the upper back to beneath the thighs. an be positioned with patient seated. Greatly simplifies the use of restroom facilities. F U Model o Hammock and Model o Hammock w/ommode pening (FGU 3) : Both slings have a headrest. he one-piece contour slings can be used on heavy or light patients. upports patient from head to the knees. Used for weighing, transferring or to simplify the use of restroom facilities. FGU 4 - MD UV DU G Model 9833 Weight Module (Digital cale) and dapter Bracket 375 lbs. apacity ccurate within 0.25 grams Measures 4.5-inches (Height) : efer to ccessories ection in the back of this manual for correct operation of the Model 9833 Digital cale. Model o Model o FGU 3 - MD HMMK D MD HMMK w/mmd PG G 7

8 HDG PDU H D G P D U HPPG D P U (FGU 1) f the Patient ift is to be reshipped by common carrier, it should be packed in the same carton. xtra cartons are available from nvacare. Unpacking 1. heck for any obvious damage to the carton or its contents. f damage is evident, notify your nvacare Dealer/arrier. 2. emove all loose packing from the carton. 3. arefully remove all the components from the carton. HDG PDU : Unless the Patient ift is to be used immediately, retain boxes, containers and packing material for use in storing until use of the patient lift is required. nspection 1. xamine exterior of the Patient ift for nicks, dents, scratches or damages. nspect all components. torage 1. tore the packaged Patient ift in a dry area. 2. D place other objects on top of the packaged Patient ift. FGU 1 - HPPG D P 8

9 MBY MBY F H P F MBY WG Use Y nvacare parts in the assembly of this patient lift. he base legs, the mast, boom, pump assembly and the swivel bar are manufactured to specifications that assure correct alignment of all parts for safe functional operation. Unpacking the Patient ift 1. Unpack the components from the shipping carton. 2. ut the tie-wraps that secure swivel bar to the base and the pump assembly to the mast (FGU 1). ie-wrap FGU 1 - UPKG H P F ssembling the Mast to the Base 1. ock casters (FGU 2). K UK FGU 3 - MVG PV B : he connection between the mast and the base should be cleaned and coated with petroleum jelly prior to assembly. 3. Position the mast bushings into the U-shaped cut-out of the base while pushing the mast into an upright position (FGU 4). 4. nsert pivot bolt with washers through the base and mast bushing. ecure with nut (FGU 4). 5. lign adjustment knob flush with the lip of the U-shaped cut-out of the base (FGU 4). : his will prevent the mast from disengaging from the base. WG he mast may be removed from the base for storage or transporting. ach time the mast is removed and returned to the base, the mast MU be properly secured to the base assembly. djustment Knob U-shaped cut-outs M B Y Mast Bushing FGU 2 - KG H 2. emove the covers, pivot bolt, nut and washers, located at the base of the mast (FGU 3). 9 FGU 4 - UG M B

10 MBY M B Y ssembling the Manual / Hydraulic Pump to the Boom (FGU 5) 1. emove the covers, bolt, and nut from the mounting bracket on the boom assembly. 2. Unpack the plastic bushing from the patient lift carton. 3. ift-up on the boom and place it on your left shoulder. 4. et the hydraulic pump rest on the right-side of your chest and rotate the shaft extension of the hydraulic pump assembly until it lines-up with the mounting bracket holes in the boom assembly. 5. urn the plastic bushing 90 o and place over the shaft extension of the hydraulic pump. Mounting Bracket MBY (ont.) WG here are two (2) silver plugs in the mounting holes next to the hydraulic pump mounting bracket on the boom. D remove these silver plugs and use these holes at anytime or injury to the patient and/or assistant may occur (FGU 5). 6. lign the holes of the boom assembly mounting bracket with those of the hydraulic pump and insert the bolt. ecure with nut. : Be sure that the bolt is completely through the holes of the boom assembly mounting bracket and the manual / hydraulic pump assembly. he boom assembly will pivot easily if the mounting hardware is aligned properly when the boom assembly is secured to the mast. U D overtighten the nut and bolt and bend the mounting bracket. WG D use for mounting. Plastic Bushing : urn 90 o. Mounting Bracket FGU 5 - MBG H MU / HYDU PUMP H BM ssembling the lectric ctuator to the Boom (FGU 6) 1. emove the covers, bolt, and nut from the mounting bracket on the boom assembly. 2. Unpack the plastic bushing from the patient lift carton. 3. ift-up on the boom and place it on your left shoulder. : he bottom of the electric actuator assembly will already be assembled to the mast mounting bracket. 4. et the actuator rest on your right-side of your chest and rotate the shaft extension of the actuator assembly until it lines-up with the mounting holes in the boom assembly. 5. Place the plastic bushing over the shaft extension of the actuator. 10

11 MBY WG here are two (2) silver plugs in the mounting holes next to the actuator mounting bracket on the boom. D remove these silver plugs and use these holes at anytime or injury to the patient and/or assistant may occur (FGU 6). 6. lign the holes of the boom assembly mounting bracket with those of the actuator and insert the bolt. ecure with nut. WG D use for mounting. MBY (ont.) : Be sure that the bolt is completely through the holes of the boom assembly mounting bracket and the actuator assembly. he boom assembly will pivot easily if the mounting hardware is aligned properly when the boom assembly is secured to the mast. U D overtighten the nut and bolt and bend the mounting bracket. M B Y Plastic Bushing Mounting Bracket ctuator ssembly : he bottom of the actuator assembly will already be assembled to the mast mounting bracket. FGU 6 - MBG H U H BM hifter Handle nstallation (FGU 7) 1. emove the shifter handle from the packaging carton. 2. Press down on the release button on the shifter handle mounting tube and insert the shifter handle over the release button until the shifter handle locks in place. (Button MU be protruding from the opening in the shifter handle (FGU 7). hifter Handle elease Button 11 FGU 7 - HF HD

12 V FM MU F V FM MU F V DMBY / MBY emoving the Manual / Hydraulic Pump ssembly (FGU 1) 1. aise the lift so the boom is resting on your left shoulder. 2. emove the covers, bolt, nut and plastic bushing from the hydraulic pump mounting bracket on the boom assembly. 3. ower the boom and pump assemblies until they rest on the floor. 4. emove the covers, bolt, nut, washers and spacer from the mounting bracket on the mast assembly. Mast Boom Plastic Bushing 4. Place the plastic bushing over the shaft extension of the electric actuator. WG here are two (2) silver plugs in the mounting holes next to the electric actuator mounting bracket on the boom. D remove these silver plugs and use these holes at anytime or injury to the patient and/or assistant may occur (FGU 2). 5. lign the holes of the boom assembly mounting bracket with those of the electric actuator and insert the bolt. ecure with nut. : Be sure that the bolt is completely through the holes of the boom assembly mounting bracket and the actuator assembly. he boom assembly will pivot easily if the mounting hardware is aligned properly when the boom assembly is secured to the mast. U D overtighten the nut and bolt and bend the mounting bracket. WG D use for mounting. FGU 1 - MVG H MU / HYDU PUMP MBY Boom ssembly of the lectric ctuator (FGU 2) 1. With the boom resting on the ground, attach the bottom part of the actuator assembly to the mast mounting bracket using bolt, washers, spacer, nut and covers. 2. ift-up on the boom and place it on your left shoulder. 3. et the actuator rest on the right-side of your chest and rotate the shaft extension of the actuator assembly until it lines-up with the mounting bracket holes in the boom assembly. 12 Mast Plastic Bushing FGU 2 - MBY F H U

13 V FM MU F V FM MU F ttaching the ontrol Box to the Mast (FGU 3) : When positioning the control box on the mast, make sure there is enough clearance between the mergency top Button and the bottom of the steering handle to be able toengage and disengage the mergency top Button. 1. tanding behind the lift, hold the control box against the right-side of the mast. 2. Place the U-bolts around the left-side of the mast and through the control box mounting holes. 3. ecure with washers and nuts. 4. Plug the cables from the actuator assembly and hand control into the control box. teering Handle mergency top Button Battery harging WG V use or move the patient lift while battery is being charged. : nsure batteries are regularly charged, preferably VY GH. his will prolong their life and maintain peak performance. he battery charger is fully automatic and can be connected to the lift at any time, H H WH F U. t is recommended that the lift charging take place in a well ventilated dry room. his should be VY GH and/or when the audible alarm sounds during operation. he battery charger has a round output plug which is plugged into the patient lift hand-control. he D emergency stop button, mounted on the top of control box MU be DGGD (rotated KW until fully out) during charging (FGU 4). Disengage (otate lockwise) ngage (Push Down) V mergency top Button From Hand ontrol From lectric ctuator FGU 3 - HG H B H M 13 FGU 4 - DGGG H MGY P BU U t is important to ensure that both input and output plugs are correctly inserted before connection of power. f the patient lift is charged with any other type of charger, it is possible to irreparably damage the batteries. he charger automatically stops charging when the batteries are fully charged; therefore, it is perfectly safe to leave the patient lift on charge whenever it is not being used to ensure peak performance.

14 14

15 -P U G MD HMMK D MD HMMK W/MMD PG (FGU 1) nvacare slings are designed specifically for use with nvacare Patient ifts and made to support the patient during lift and transfer procedures. lings attach to the lift with color coded straps for easy positioning. he slings are reinforced at all points of attachment for safety. he fabrics used in these slings are of very durable materials that resist deterioration from exposure to moisture and laundering. his design will accommodate patients of heavy or light weight with full support from the head to the knees. t is particularly good for users with only moderate upper body strength, for bathing or for those remaining in the sling for extended periods of time. - P U G Body lings may be ordered at the time of purchase with a commode opening in the seat section for use over a toilet or a commode chair. lings are constructed with a high back section that provides additional support for the head and neck. Model o Model o U G Fabric he outer side has a reinforced "grab handle" for assistance in positioning the patient in a wheelchair, commode, etc. he edging is soft yet durable with extra reinforced stitching for safety. : lways place the sling under the patient with the handle away from the patient. : aundering should always be done with dark colors. efer to tagged washing instructions on the sling. pen mesh polyester fabric is an exceptional material that provides safety and comfort for the patient. he open mesh weave of the fabric is dyed blue or teal, preshrunk, and durable for use and laundering. t provides considerable traction to resist slipping and sliding during use. FGU 1 - MD HMMK D MD HMMK w/mmd PG G 15

16 -P U G U G Positioning the Model o Hammock or Model o Hammock w/ommode pening (FGU 2) 1. Position the patient in the center of the bed and laying flat on his/her back. 2. Fold the sling in half (length-wise) and place the sling beside the patient. : he closed-end or commode opening of the sling with positioning handle should be facing the patient when folded. Positioning Handle -P U G (ont.) op dge of ling ling Hooks ommode pening 3. he top edge of the sling fabric should be slightly above the patient's head. 4. he bottom edge of the sling fabric should then be a few inches above the back of the patient s knees. : nvacare recommends that two (2) assistants (ne [1] on each side of the bed) be used when positioning the patient on a sling. he bed rails may also be raised to minimize patient movement. 5. With one (1) assistant holding the patient, the second assistant pushes the folded sling under the patient without rolling him/her over. Positioning the Patient on the ling with or without ommode pening : Use the following method to easily move the patient and avoid strain to yourself. 1. f the patient is to roll to their F-D, then elevate the patient s GH K until the right foot is flat on the bed (FGU 3). ling Hooks Bottom dge of ling FGU 2 - PG H G 16 FGU 3 - G P H/H D

17 -P U G : nvacare recommends that two (2) assistants (ne [1] on each side of the bed) be used when positioning the patient onto a sling. -P U G (ont.) 2. With an assistant on each side of the bed and up against the mattress, the assistant on the left-hand side of the bed will position his/her GH-HD on the elevated K and his/her F-HD under the patient s GH HUD, slowly push on the knee and assist with a slight lift of the shoulder. he patient will easily roll onto their side (FGU 3). 3. With the patient on their side, push the fabrics of the seat and back gently under them (FGU 3). : he patient s head should be positioned in the headrest just below the top edge for maximum comfort and the lower edge of the seat section positioned a few inches above the back of the patient s knees (FGU 2). 4. oll the patient on to his/her back (FGU 4). : ssistants will reverse roles. 5. fter the patient has been positioned once again on his/her back, you now need to roll the patient to their GH-D (facing the assistant on the F). 6. With an assistant on each side of the bed and up against the mattress, the assistant on the right-hand side of the bed will elevate the F K and position his/her F-HD on the elevated K and his/her GH-HD under the patient s F HUD, slowly push on the knee and assist with a slight lift of the shoulder and the patient will easily roll onto their side (FGU 4). 7. Pull the fabrics of the seat and back across the mattress until they are smooth (FGU 4). 8. oll the patient onto their back and they should be approximately centered on the sling section (FGU 4). 9. ttach the sling to the hooks of the swivel bar. efer to ttaching the lings to the Patient ift in FG H P ection of this manual. 17 FGU 4 - G P H/H PP D D BK U G

18 UV DU G U V D U G MD UV DU G (FGU 1 and 1B) Positioning the Patient in the Model o Universal Deluxe ling : Headrest is not available on the Model o Universal Deluxe ling. : nvacare recommends that two (2) assistants (one [1] in front and one [1] in back of the wheelchair) be used when positioning the patient in the universal deluxe sling. : Use the following method to easily move the patient and avoid strain to yourself. WG f the patient is in a wheelchair, secure the wheel locks in place to prevent the chair from moving forward or backwards. 1. he rear wheel locks of the wheelchair are locked to prevent movement of the chair. 2. With the patient sitting in a chair one (1) assistant in the front and the other assistant in the back, lean the patient forward. : he front assistant will be supporting the weight of the patient. 3. Place the universal deluxe sling behind the patient (with "grab handle" on the outside) and bring the flaps out alongside the patient s legs. : he back of the universal deluxe sling should be parallel to the patient s upper arms and be positioned between the top of the patient s back and the top of the chair back. 4. With the back of the sling positioned properly, push the edges of the commode opening under the patient s buttocks. 5. ean the patient back into the chair with the assistant in the rear supporting his/her weight. 6. ift the patient s legs (one at a time) and reach under the patient s leg and pull until the front of the sling is behind the patient s knees (about three [3] inches) and the back of the sling remains in position. : he straps may be crossed BW or UDH the patient's legs. UV DU G ttach the sling to the swivel bar. efer to ttaching the lings to the Patient ift in FG H P ection of this manual. FGU 1 - PG H P H MD UV DU G

19 UV DU G UV DU G (ont.) U V D U G Between Underneath FGU 1B - PG H P H MD UV DU G 19

20 P P P PG H P F (FGU 1) o lose/pen the egs of the Base ssembly he shifter handle is used to open or close the legs of the base for stability when lifting a patient. WG he operation of the patient lift is an easy and safe procedure. D attempt any transfer without approval of the patient s physician, nurse or medical assistant. horoughly read the instructions in this wner s Manual, observe a trained team of experts performing the lifting procedures and then perform the entire lift procedure several times with proper supervision and a capable individual acting as a patient. Y operate this lift with the legs in MMUM P P and KD in place. he base legs MU be locked in the open position at all times for stability and patient safety when lifting and transferring a patient. 1. tand at the rear of the patient lift and grasp the shifter handle with one (1) hand and place the opposite hand on the steering handle of the mast for balance. : he shifter handle MU lock into its mounting slot to lock the legs in the full open or closes position. WG f the shifter handle is positioned completely into its mounting slot, D use the patient lift until shifter handle is properly seated and the legs of the patient lift KD in place or injury and/or damage may occur.. 2. Push the shifter handle U and away from the patient lift and then to your F until it K in the notch of the bracket. P. 3. Push the shifter handle U and away from the patient lift and then to your GH until it K in the notch of the bracket. P FGU 1- /P H G F H B MBY aising/owering Manual/Hydraulic ift WG nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. here are two (2) controls on the pump assembly: a. he control valve b. he pump handle G H F (FGU 2). he control valve MU be in the closed position (turn control valve clockwise until tight) to move the pump handle up and down and elevate the boom and the patient. 20

21 P P (ont.) WHU P ontrol Valve : urn clockwise to close. Pump Handle FGU 3B - WG H MU / HYDU P F aising/owering lectric ift (FGU 4) P FGU 2 - G H HYDU P F WG H F (FGU 3). he control handle MU be in the P position (control valve turned counterclockwise) to lower the boom and the patient. he rate of descent can be controlled by varying the amount that the control valve is opened. : safety gate is part of the hydraulic system that maintains a W maximum descent rate. 1. WH the patient in a sling, turn the control valve 1/4-turn counterclockwise. 2. WHU the patient in a sling, turn the control valve counterclockwise completely and pull DW on the boom. WG nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. G H F. Press the UP (é) button to raise the boom and the patient lift. WG H F. Press the DW (ê) button to lower the boom and the patient. WH P FGU 3 - WG H MU / HYDU P F 21 FGU 4 - G/WG H P F

22 FG H P F G P HG H G H P F (FGU 1) : efer to P F FY UMMY in the front of this manual before proceeding further and observe all WG indicated. WG Before lifting or transferring the patient, the base legs MU be KD in the P position for optimum stability and safety. : Before positioning the legs of the patient lift under the bed, make sure that the area is clear of any obstructions. 1. With the legs of the base P and KD, use the steering handle to push the patient lift underneath the bed. 2. ower the patient lift for easy attachment of the sling. FG H P U When connecting the sling to the patient lift, the shortest of the straps MU be at the back of the patient for support. Using the long section will leave little or no support for the patient's back. he loops of the sling are color coded and can be used to place the patient in various positions. he colors make it easy to connect both sides of the sling equally. Make sure that there is sufficient head support when lifting a patient. 3. Place the straps of the sling over the hooks of the swivel bar. Match the corresponding colors on each side of the sling for an even lift of the patient (FGU 1). : Model o Hammock and Model o Hammock w/ommode have four (4) sling straps while Model o Universal Deluxe ling has six (6) sling straps. UV DU G W/U HD WH MMD PG ( [6] P) olor oded traps HMMK G WH WHU MMD PG (FU [4] P Y) FGU 1 - HG H G H P F 22 olor oded traps

23 FG H P FG / MVG H P : D engage the rear locking casters when patient is in the lift. 1. Pump the lift handle or press the UP (é) button to raise the patient above the bed. he patient should be elevated high enough to clear the bed with their weight fully supported by the lift. : n manual / hydraulic lift, the boom will stay in position until the control valve is opened. n the electric lift, the boom will stay in position until the DW (ê) button is pressed. 2. When the patient is lifted from the bed (with the patient s head supported by the sling and/or an assistant), he/she will be raised to a sitting position (FGU 2). FG H P (ont.) WG When elevated a few inches off the surface of the bed and before moving the patient, check again to make sure that the sling is properly connected to the hooks of the swivel bar. f any attachments are properly in place, lower the patient back onto the bed and correct this problem. djustments for safety and comfort should be made before moving the patient. Patient s arms should be inside of the straps. nvacare slings are made specifically for use with nvacare Patient ifts. For the safety of the patient, D intermix slings and patient lifts of different manufacturers. Warranty will be voided. 3. When patient is clear of the bed surface, swing their feet off the bed (FGU 3). 4. Using the steering handles, move the lift away from the bed. F G P FGU 2 - FG H P FGU 3 - MVG H P 23

24 FG H P F G P 5. When moving the patient lift away from the bed, turn patient so that he/she faces assistant operating the patient lift (FGU 4). 6. Press the DW (ê) button (electric) or open control valve (manual / hydraulic) lowering patient so that his feet rest on the base of the lift, straddling the mast. lose control valve. : he lower center of gravity provides stability making the patient feel more secure and the lift easier to move. 7. Pull the patient lift away from the bed and push from behind with both hands firmly on the push handle. FG H P (ont.) FGU 4 - MVG H P F WY FM H BD 24

25 FG P F U F H BHM F FG P F U F H BHM F FG P F U F MMD H DD MMD he slings with commode openings are designed to be used with either a commode chair or standard commode. : nvacare recommends that the sling remain connected to the swivel bar hooks during the patient s use of either the commode chair or standard commode. WG When elevated a few inches off the surface of the commode chair or standard commode and before moving the patient, check again to make sure that the sling is properly connected to the swivel bar hooks. f the sling attachments are properly in place, lower the patient back onto the commode chair or standard commode to correct this problem. djustments for safety and comfort should be made before moving the patient. Patient s arms should be inside of the straps. nvacare slings are made specifically for use with nvacare Patient ifts. For the safety of the patient, D intermix slings and patient lifts of different manufacturers. Warranty will be voided. nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. ransferring to a ommode hair (FGU 1) 1. o lift the patient from the bed, follow the procedures concerning lifting the patient, operation and sling attachment. 2. he patient should be elevated high enough to clear the commode chair arms and their weight supported by the patient lift With the help of both assistants, guide the patient onto the commode chair. 4. ower the patient onto the commode chair leaving the sling attached to the swivel bar hooks. 5. When complete, recheck for correct attachment and then raise the patient off of the commode chair. 6. When patient is clear of the commode surface (using the steering handles), move the lift away from the commode chair. 7. o return patient to bed, reverse procedures concerning lifting the patient, operation and sling attachment. 8. o return or place patient in a wheelchair, refer to FG WHH. FGU 1 - FG MMD H B H M

26 FG P F U F H BHM F B H M FG P F U F H BHM F ransferring to a tandard ommode : he patient MU be transferred to a WHH and transported to the bathroom facilities before using the patient lift again to position the patient on a standard commode. efer to FG WHH in this manual. fter this has been accomplished refer to the following: 1. o lift the patient from the bed, follow the procedures concerning lifting the patient, operation and sling attachment. 2. he patient should be elevated high enough to clear the standard commode and their weight supported by the patient lift. 3. With the help of both assistants, guide the patient onto the standard commode. 4. ower the patient onto the standard commode leaving the sling attached to the swivel bar hooks. 5. When complete, recheck for correct attachment and then raise the patient off of the standard commode. 6. When patient is clear of the standard commode surface (using the steering handles), move the lift away from the standard commode. 7. o return or place patient in a wheelchair, refer to FG WHH. 8. o return patient to bed, reverse procedures concerning lifting the patient, operation and sling attachment. FG BHG U WG When elevated a few inches off the surface of the bed and before moving the patient, check again to make sure that the sling is properly connected to the swivel bar hooks. f any attachments are properly in place, lower the patient completely to correct this problem. djustments for safety and comfort should be made before moving the patient. Patient's arms should be inside of the straps. nvacare slings are made specifically for use with nvacare Patient ifts. For the safety of the patient, D intermix slings and patient lifts of different manufacturers. Warranty will be voided. nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. : here are many portable bathing apparatuses; this is an example of one. efer to your particular portable bath instructions and use them in conjunction with this wner s Manual. 1. o remove the patient from the bed, observe procedures concerning sling attachment, operation and lifting the patient. 2. he patient should be elevated high enough to clear the bed and be able to slide the portable bath tub under the patient. 3. ower the patient into the portable bath tub. 4. Detach the sling from the swivel bar hooks and attach the portable bath tub straps to the patient lift. 5. Using the lift, raise the sides of the portable bath tub. 6. Bathe patient. 7. everse procedures to return patient to bed. 26

27 FG WHH FG WHH (FGU 1) : o position an individual in a sling, follow the procedures concerning lifting the patient, operation and sling attachments. : nvacare recommends that two (2) assistants be used when transferring a patient to a wheelchair. WG When elevated a few inches off a seating surface and before moving the patient, check again to make sure that the sling is properly connected. f any attachments are properly in place, lower the patient completely to correct this problem. djustments for safety and comfort should be made before moving the patient. Patient s arms should be inside of the straps. nvacare slings are made specifically for use with nvacare Patient ifts. For the safety of the patient, D intermix slings and patient lifts of different manufacturers. Warranty will be voided. nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. FG WHH 6. With one (1) assistant behind the chair and the other operating the patient lift, the assistant behind the chair will pull back on the "grab handle" or sides of the sling to seat the patient well into the back of the chair. his will maintain a good center of balance and prevent the chair from tipping forward. 7. he sling is left in place. 8. o return to the seating surface, reverse procedures concerning lifting the patient, operation and sling attachments. WG Be sure to check the sling attachments each time the sling is removed and replaced, to ensure that it is properly attached before the patient is removed from the bed or chair. F W H H 1. he legs of the lift (w/patient) are in the opened position. 2. he wheelchair is moved into position. WG Wheelchair wheel locks MU be in a locked position before lowering the patient into the wheelchair for transport. 3. he rear wheel locks of the wheelchair are locked to prevent movement of the chair. 4. he patient is positioned over the seat with their back against the back of the chair. 5. Begin to lower the patient either by opening the control valve or by pressing the DW (ê) button. 27 FGU 1 - FG WHH

28 FG FM WHH F FG FM WHH FG FM WHH (FGU 1 D 1B) : nvacare recommends that two (2) assistants be used when transferring a patient from a wheelchair to a car. WG When elevated a few inches off the seating surface of the wheelchair and before moving the patient, check again to make sure that the sling is properly connected to swivel bar hooks. f any attachments are properly in place, lower the patient completely to correct this problem. djustments for safety and comfort should be made before moving the patient. Patient s arms should be inside of the straps. nvacare slings are made specifically for use with nvacare Patient ifts. For the safety of the patient, D intermix slings and patient lifts of different manufacturers. Warranty will be voided. nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. ransfer to a car is easily accomplished with the use of nvacare s patient lifts and slings. he transfer to a car should be made on a level driveway or surface. : Before lifting the patient from the chair, make sure to shorten the distance between the patient and the boom. his will make the transfer into the seat of the car easier. : ttendants should practice "Good Body Mechanics" when positioning patient onto any seating surface. 1. he rear wheel locks of the wheelchair are locked to prevent movement of the chair. 2. ttach the sling to the swivel bar hooks. 3. ift the patient from the wheelchair. 28 FGU 1 - FG FM WHH

29 FG FM WHH FG FM WHH 4. he lift is moved, by the steering handles, to a position close to the doorway of the car. 5. ower the boom of the lift until the hooks of the swivel bar are even with the roof of the car. 6. s one (1) assistant pushes the patient into the car by his knees until he/she is positioned over the seat of the car, the other assistant lowers the boom. s the boom is being lowered, the first assistant is not only pushing but turning the patient so he/she is positioned facing the front of the car. 7. he patient will come to rest on the seat of the car. 8. While one (1) assistant is holding the patient, the other assistant removes the straps from the swivel bar and slides the patient lift out of the way. 9. he sling may be left under the patient or removed. 10. he mast, boom and pump assembly may be removed from the base and transported in the car. : f the patient lift and wheelchair are both packed in the trunk of the car, care should be taken not to damage the spokes of the wheelchair on the patient lift. F FGU 1B - FG FM WHH 29

30 FG FM WHH W H H FG FM WHH FG FM WHH (FGU 1) : nvacare recommends that two (2) assistants be used when transferring a patient from a wheelchair to a car. WG When elevated a few inches off the seat of the car and before moving the patient, check again to make sure that the sling is properly connected to the swivel bar hooks. f any attachments are properly in place, lower the patient completely to correct this problem. djustments for safety and comfort should be made before moving the patient. Patient s arms should be inside of the straps. nvacare slings are made specifically for use with nvacare Patient ifts. For the safety of the patient, D intermix slings and patient lifts of different manufacturers. Warranty will be voided. nvacare does recommend locking of the rear casters of the patient lift when lifting an individual. Doing so could cause the lift to tip and endanger the patient and assistants. nvacare D recommend that the rear casters be left UKD during lifting procedures to allow the patient lift to stabilize itself when the patient is initially lifted from a chair, bed or any stationary object. 6. he second assistant should pull the patient lift away from the car until the patient is completely clear of the door frame. 7. elease the patient back to his/her normal sitting position in the sling. 8. Position the wheelchair under the patient. 9. ngage the rear wheel locks of the wheelchair. WG Wheelchair wheel locks MU be in a locked position before lowering the patient into the wheelchair for transport. 10. ne (1) assistant will slowly lower the patient into the wheelchair while the other assistant guides him/her into the chair. : ne (1) assistant will support patient at all times. 1. With the first assistant supporting the patient, the second assistant then lowers the boom of the patient lift until the hooks of the swivel bar are even with the roof of the car. 2. ttach the sling to the swivel bar. 3. ift patient up off of seat until straps are taut. 4. urn patient with sling until legs are outside of car. : ttendants should practice "Good Body Mechanics" when positioning patient onto any seating surface. 5. ift up on legs with one (1) hand and tilt the patient s back with the other hand. 30 FGU 1 - FG FM WHH

31 UBHG YMPM FU U Patient ift feels loose. asters/brakes noisy or stiff. oisy or dry sound from pivots. il leaking from hydraulics. UBHG Foot pedal pressure loose. Fluff or debris in bearings. eeds lubrication. Hydraulic pump in need of service. efer to Foot Pedal djustment in the D M section in this manual. efer to asters in the D M section in this manual. efer to ubrication in the D M section in this manual. efer to Manual / Hydraulic or lectric ctuator eplacement in the D M section of this manual. ontact your Dealer. U B H G Manual / Hydraulic pump fails to lift when pumped. lectric actuator fails to lift when button is pressed. Handwheel not fully closed. Manual / Hydraulic pump in need of service. Hand-control or actuator connector loose. Batteries low. Push D mergency top Button down. lectric actuator in need of service. lose handwheel. efer to Manual / Hydraulic or lectric ctuator eplacement in the D M section of this manual. ontact your Dealer. heck connections. harge batteries. efer to Battery harging in the V FM MU - F section of this manual. otate clockwise to operate. efer to Manual / Hydraulic or lectric ctuator eplacement in the D M section of this manual. ontact your Dealer. : f problems are not remedied by the suggested means, please contact your Dealer or nvacare. 31

32 M FY P HK M FY P HK P H K M Y P/DJU MHY H B nspect for missing hardware. Base opens/closes with ease. nspect casters and axle bolts for tightness. nspect casters for smooth swivel and roll. pply a light grease to caster ball bearings. HF HD perates smoothly. ocks adjustable base whenever engaged. H M Mast should lock securely when assembled. nspect for bends or deflections. H BM heck all hardware and swivel bar supports. nspect for bends or deflections. nspect bolted joints of boom for wear. nspect to ensure that the boom is centered between the base legs. H WV B heck the hooks for wear or damage. heck sling hooks for wear or deflection. H PUMP MBY heck for leakage. nspect hardware on mast and boom. heck for wear or deflection of rod. (F DMGD, U FY). H PUMP HD heck for smooth operation. H VV pens and closes easily. G Whenever necessary. G D HDW HK G HM each time it is used to ensure proper connection and patient safety. nspect sling material for wear. nspect straps for wear. P/DJU PDY 32

33 D M F YU P F D M F YU P F D M F YU P F : Follow the maintenance procedures described in this manual to keep your patient lift in continuous service. he nvacare Patient ift is designed to provide a maximum of safe, efficient and satisfactory service with minimum care and maintenance. ll parts of the nvacare ift are made of the best grades of steel, but metal to metal contact will wear after considerable use. here is no adjustment or maintenance of either the casters or brakes, other than cleaning, lubrication and checking axle and swivel bolts for tightness. emove all debris, etc. from the wheel and swivel bearings. f any parts are worn, replace these parts immediately. f you question the safety of any part of the lift, contact your Dealer immediately and advise him/ her of your problem. ubrication (FGU 1) he nvacare lift is designed for minimum maintenance; however, a six (6) month check and lubrication should ensure continued safety and reliability. Keep lift and slings clean and in good working order. ny defect should be noted and reported to your dealer as soon as possible. he casters MU swivel and roll smoothly. light grease (waterproof auto lubricant) may be applied to the ball bearing swivel of the casters once a year. pply more frequently if the casters are exposed to extreme moist conditions. he connection between the mast and the base should be cleaned and coated with petroleum jelly prior to assembly. efer to lubrication diagram for lubrication points. ubricate all pivot points. Wipe all excess lubricant from lift surface. 1. wivel Bar 2. Boom Mounting Bracket 3. Boom / Mast Mount 4. Mast Mounting Bracket 5. Base / Mast Mount 6. ear asters 7. Front aster 8. Front aster Wear and Damage 7. FGU 1 - UB t is important to inspect all stressed parts, such as slings, spreader bar and any pivot for slings for signs of cracking, fraying, deformation or deterioration. eplace any defective parts immediately and ensure that the lift is not used until repairs are made. leaning he sling should be washed regularly in water temperature of 140 o F (60 o ) and a biological solution. soft cloth, dampened with water and a small amount of mild detergent, is all that is needed to clean the patient lift. he lift can be cleaned with non-abrasive cleaners. uto wax or furniture polish will help maintain the sparkling finish over a long period of time M