Section 1. Identification of the substance/mixture and of the company/undertaking. Spray-Applied Fire Resistive Materials

Transcription

1 SAFETY DATA SHEET Issuing Date 30-Sep-2018 Revision Number 1 Section 1. Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product Name ISOLATEK Type M-II 1.2. Relevant identified uses of the substance or mixture and uses advised against Recommended Use Spray-Applied Fire Resistive Materials Uses advised against Do not use this product for any use other than intended Details of the supplier of the safety data sheet Company United States Mineral Products Company dba Isolatek International 41 Furnace Street Stanhope, NJ Toll Free: For further information, please contact Address REACH@Isolatek.com 1.4. Emergency telephone number Emergency Telephone Number Europe Chemtrec Classification of the substance or mixture Physical Hazards None Section 2. Hazards identification REGULATION (EC) No 1272/2008 Skin Corrosion/Irritation Category 2 Serious Eye Damage/Eye Irritation Category 1 Skin Sensitization Sub-category 1B Specific Target Organ Systemic Toxicity (Single Exposure) Category Label Elements Signal Word Danger Hazard Statements H315 - Causes skin irritation H317 - May cause an allergic skin reaction H318 - Causes serious eye damage H335 - May cause respiratory irritation Page 1 / 8

2 Precautionary Statements - EU ( 28, 1272/2008) P305 + P351 + P338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P310 - Immediately call a POISON CENTER or doctor/ physician P280 - Wear eye protection/ face protection Precautionary Statements P264 - Wash face, hands and any exposed skin thoroughly after handling P332 + P313 - If skin irritation occurs: Get medical advice/ attention P362 - Take off contaminated clothing and wash before reuse P305 + P351 + P338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P310 - Immediately call a POISON CENTER or doctor/ physician P272 - Contaminated work clothing should not be allowed out of the workplace P302 + P352 - IF ON SKIN: Wash with plenty of soap and water P333 + P313 - If skin irritation or rash occurs: Get medical advice/ attention P363 - Wash contaminated clothing before reuse P261 - Avoid breathing dust/ fume/ gas/ mist/ vapors/ spray P271 - Use only outdoors or in a well-ventilated area P403 + P233 - Store in a well-ventilated place. Keep container tightly closed P405 - Store locked up P501 - Dispose of contents/container in accordance with local regulations Other information 3.1. Substances Section 3. Composition/information on ingredients Chemical Name EC-No CAS-No Weight % EU - GHS Substance Classification Skin Corros. 2 (H315) Skin Sens. 1B (H317) Eye Dam. 1 (H318) STOT SE 3 (H335) For the full text of the H-Statements mentioned in this Section, see Section 16 REACH No. No data available Note This product does not contain candidate substances of very high concern at a concentration >=0.1% (Regulation (EC) No. 1907/2006 (REACH), Article 59) The above products are compliant to REACH registration obligations; Registration number(s) may not be provided because substance(s) are exempted, not yet registered under REACH or are registered under another regulatory process (biocide uses, plant protection, etc.) of first-aid measures Section 4. First aid measures Eye Contact Skin Contact Ingestion Inhalation Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Immediate medical attention is required. Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes. If skin irritation or rash occurs: Get medical advice/attention. Clean mouth with water and afterwards drink plenty of water. Move to fresh air. Page 2 / 8

3 Protection of First-aiders Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves Most important symptoms and effects, both acute and delayed Most Important Symptoms/Effects Indication of immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. Section 5. Fire-fighting measures 5.1. Extinguishing media Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Extinguishing media which must not be used for safety reasons Special hazards arising from the substance or mixture Special exposure hazards arising from the substance or preparation itself, combustion products, resulting gases None in particular Advice for firefighters Special protective equipment for fire-fighters As in any fire, wear self-contained breathing apparatus and full protective gear. Section 6. Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Avoid contact with the skin and the eyes. Ensure adequate ventilation. Advice for emergency responders Wear personal protective equipment. For personal protection see section Environmental precautions Prevent further spillage if safe to do so Methods and materials for containment and cleaning up Pick up and transfer to properly labeled containers Reference to other sections For additional information see: Section 8: Exposure controls/personal protection Section 12: Ecological Information Section 13: Disposal considerations Section 7. Handling and storage 7.1. Precautions for Safe Handling Handling Ensure adequate ventilation. Wear personal protective equipment. Hygiene Measures Handle in accordance with good industrial hygiene and safety practice. Page 3 / 8

4 7.2. Conditions for safe storage, including any incompatibilities Keep container tightly closed in a dry and well-ventilated place. Protect from moisture. Once container is opened, use entire contents at once Specific end use(s) Exposure Scenario. Other Guidelines Control parameters Exposure Limits Section 8. Exposure controls/personal protection Chemical Name EU Austria Belgium Cyprus Denmark TWA: 5 mg/m 3 TWA: 10 mg/m 3 Chemical Name Finland France Germany Gibraltar Greece TWA: 5 mg/m 3 TWA: 1 mg/m 3 TWA: Ceiling / : Carc* Repr* Sen* Chemical Name Ireland Italy Lithuania Luxembourg Malta TWA: 1 mg/m 3 STEL: 3 mg/m 3 Chemical Name The Netherlands Norway Poland Portugal Spain TWA: 6.0 mg/m 3 TWA: 2.0 mg/m 3 TWA: 4 mg/m 3 Chemical Name Switzerland Sweden The United Kingdom TWA: 5 mg/m 3 Sen* TWA: 10 mg/m 3 TWA: 4 mg/m 3 STEL: 30 mg/m 3 STEL: 12 mg/m 3 Biological occupational exposure limits This product, as supplied, does not contain any hazardous materials with biological limits established by the region specific regulatory bodies Derived No Effect Level Predicted No Effect Concentration (PNEC) Exposure controls Engineering Measures Personal protective equipment Eye Protection Ensure adequate ventilation, especially in confined areas. Personal protection equipment should be chosen according to the CEN standards Safety glasses with side-shields. Page 4 / 8

5 Skin and Body Protection Long sleeved clothing. Hand Protection Respiratory Protection Protective gloves. When workers are facing concentrations above the exposure limit they must use appropriate certified respirators. Environmental Exposure Controls. 9.1 Information on basic physical and chemical properties Section 9. Physical and chemical properties Physical State Odor Solid, Powder Low Appearance Odor Threshold Grey No data available. Property Values Remarks/ - Method ph 10 - < 20 C Melting Point/Range > 981 C None known Boiling Point/Boiling Range No data available None known Flash Point None known Evaporation rate No data available None known Flammability (solid, gas) No data available None known Flammability Limits in Air No data available None known Vapor Pressure No data available. None known Vapor Density No data available. None known Relative Density No data available None known Water Solubility No data available None known Solubility in other solvents No data available None known Partition coefficient: n-octanol/waterno data available None known Autoignition Temperature No data available None known Decomposition Temperature No data available None known Viscosity No data available None known Explosive Properties Oxidizing Properties 9.2. Other information VOC Content (%) Section 10. Stability and reactivity Reactivity No data available Chemical stability Stable under normal conditions. Page 5 / 8

6 10.3. Possibility of hazardous reactions Conditions to avoid None known based on information supplied Incompatible materials Hazardous decomposition products None under normal use Information on toxicological effects Section 11. Toxicological information Acute Toxicity Product Information Inhalation Eye Contact Skin Contact Ingestion Respiratory or Skin Sensitization Mutagenic Effects Carcinogenic Effects Reproductive Toxicity Developmental Toxicity STOT - single exposure STOT - repeated exposure Aspiration Hazard Product does not present an acute toxicity hazard based on known or supplied information. May cause irritation of respiratory tract. Based on components:. Causes serious eye damage. Based on components:. Irritating to skin. There is no data available for this product. May cause sensitization by skin contact. May cause respiratory irritation.. Section 12. Ecological information Toxicity Ecotoxicity Effects The environmental impact of this product has not been fully investigated Persistence and degradability Bioaccumulative potential Mobility in soil Results of PBT and vpvb assessment Page 6 / 8

7 12.6. Other adverse effects This product does not contain any known or suspected endocrine disruptors Waste treatment methods Section 13. Disposal considerations Waste from Residues / Unused Products Contaminated Packaging Dispose of in accordance with local regulations. Dispose of in accordance with local regulations. Section 14. Transport information IMDG/IMO Proper Shipping Name Not regulated Marine Pollutant None Transport in bulk according. to Annex II of MARPOL 73/78 and the IBC Code RID Proper Shipping Name Not regulated Environmental hazard None ADR Proper Shipping Name Not regulated Environmental hazard None ICAO Proper shipping name Not regulated Environmental hazard None IATA Page 7 / 8

8 14.2. Proper Shipping Name Not regulated Environmental hazard None Section 15. Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Candidate List of Substances of Very High Concern for Authorization No substances listed at 0.1% or greater Chemical Safety Assessment Section 16. Other information Full text of H-Statements referred to under sections 2 and 3 H315 - Causes skin irritation H317 - May cause an allergic skin reaction H318 - Causes serious eye damage H335 - May cause respiratory irritation Key or legend to abbreviations and acronyms EU - European Union CAS #: Chemical Abstract Services Number VOC: Volatile Organic Compound Key literature references and sources for data Supplier Safety Data Sheets Data from internal and external sources Issuing Date Revision Date Revision Note 30-Sep Oct-2018 Update to Format. This safety data sheet complies with the requirements of Commission Regulation (EU) 2015/830 of 28 May 2015 amending Regulation (EC) No. 1907/2006 Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet Page 8 / 8