Anchors that can be used for a lifeline in a grain bin. or Ladder do not make good anchors!
|
|
- Paulina Barrett
- 5 years ago
- Views:
Transcription
1 Anchors that can be used for a lifeline in a grain bin. or Ladder do not make good anchors!
2 Definitions: Carabiner 1 Webbing attachment hardware with double locking action rated at 4,000 pounds 8 mm Accessory cord rated at 3,600 pounds Forged eye bolt Welded eye bolt rated eyebolt welded eye bolt have less strength
3 Water knot only appropriate knot to use with webbing Bin stiffener internal or external vertical support in a bin Fisherman knot customary knot for use on accessory cord Bolt hangers attachment hardware rated for 24kn
4 Pre tied tying a rope before entering a bin is easier and quicker. Sling a loop made by tying the ends of a rope together Equalized attached in a way to spread the load on two or more points 19 gage bin sheet about the lightest gage sheet used in grain bins.
5 Ladder bracket the bracket that is bolted to the grain bin sheet. Ladder rung the part of the ladder you hold with your hands or step on with your feet Ladder sides Vertical sides of the ladder that rungs are attached to. Girth hitch a knot to attach a sling to an object.
6 Anchors with 1800 pound or 3600 pound rating.
7 Tag 9, a 3600 pound rated anchor: Purple webbing attached to a angle iron welded to a plate that is attached to the bin sheet by four 5/16 grade 5 bolts. The sheet is about 10 inches square with the bolts holes drilled in the peak of the corrugation and an identical sheet on the outside.
8 Top plate is the outside of the bin sheet on the previous slide. Tag 9. Lower two pipes and nuts are the outer side of the bin sheet on the next two slides for Tag 10 and Tag 17.
9 Tag 10, a 3600 pound rated anchor: Purple webbing attached to a forged ¾ eye bolt that is installed through the peak of the corrugation in the bin sheet. The back side of the sheet has a 2 pipe that is 4 long and secured by a nut (see previous slide).
10 Tag 17, an 1800 pound anchor rating: Yellow webbing attached to a ½ stainless welded eye bolt that is installed through the peak of the corrugation in the bin sheet. The back side of the sheet has a 2 pipe that is 4 long and secured by a nut (see previous slides).
11 3600 pound rated anchor: The carabiner is attached to a 3/16 plate through a ¾ hole that has 1/2 of steel from the hole to the plate edge. The plate is bolted to the side of the bin stiffener with four ¼inch or 5/16 grade 5 bolts.
12 Tag 2, 1800 pound rated anchor: A yellow green 1 webbing that is wrapped around the stiffener and the ends are tied together with a water knot..
13 Tag 1, an 1800 pound rated anchor: A blue 1 webbing sling that was pre tied by a water knot and wrapped around the bin stiffener and attached with a carabiner.
14 Tag 3, an 1800 pound rated anchor: An olive green 1 webbing that is wrapped around the stiffener twice and the ends are tied together with a water knot.
15 Tag 12, an 1800 pound rated anchor: An orange 8mm accessory cord that was pre tied by a fisherman knot into a sling. The sling is attached with carabiners to bolt hangers that are bolted to bin sheet bolts that each go through two bin sheets. A carabiner is used to equalize the anchor points.
16 Tag 22, 1800 pound anchor rated: A 3/16 diameter wire rope connected into a sling. It is wrapped around a stiffener and the loops attached by a carabiner.
17 Tag 23, a 3600 pound rated anchor: An orange 1 webbing sling that was pre tied by a water knot. Webbing is wrapped around two bin stiffener and attached and equalized with a carabiner.
18 Tag 23, a 3600 pound rated anchor: A yellow 1 webbing sling that was pre tied by a water knot and wrapped around the an angle iron that is bolted to the bin sheet splice with four bolts. Webbing is attached with a carabiner
19 Tag 18, an 1800 pound rated anchor: An olive green 1 webbing sling that was pre tied by a water knot and wrapped around an angle iron that is bolted to the bin sheet splice with three bolts. Webbing is attached with a carabiner.
20 Tag 13, a 3600 pound rated anchor: This anchor is made by Climbtech and designed for an emergency anchor. The toggle is inserted in the hole
21 Instillation is made by drilling a 7/8 hole through a bin sheet that is 19 gage or heavier. The toggle is inserted in the hole and by pushing the cable the toggle is rotated 90 degrees
22 The toggle is inserted in the hole and by pushing the cable the toggle is rotated 90 degrees and seats in the dish in the corrugated bin sheet. Tag 13, a 3600 pound rated anchor:
23 The following anchor points are not rated for lifeline use. The problem with each anchor is underlined
24
25 Tag 24, no rating: A yellow junk rope
26 Tag 4, no rating: A olive green 1 webbing that is wrapped around a ladder bracket
27 Tag 19, no rating: A red 1 webbing sling that is wrapped around two ladder bracket s
28 Tag 5, no rating: An olive green 1 webbing wrapped around three ladder rungs the ends are tied with a water knot.
29 The webbing is attached and equalized with a carabiner. Tag 5, no rating:
30 Tag 6, no rating: A red 1 webbing that is wrapped around two ladder sides
31 Tag 8, no rating: A purple 8mm accessory cord that is wrapped around a ladder bracket The ends of the cord are tied together with a fisherman knot.
32 Tag 20, no rating: olive green 1 webbing that is wrapped around two ladder brackets
33 Tag 11, no rating: A red 8mm accessory cord wrapped around a ladder bracket twice
34 Tag 21, no rating: A red 1 webbing that is wrapped around two ladder side brackets
35 Tag 7, No Rating Red accessory cord attached to a ladder rung with a girth hitch. The sling is pre tied by a fisherman knot
36 Tag 24, No Rating Junk Rope tied around a bin stiffener and tied with a junk knot.
37 lifeline component and costs for every bin item number cost total economical best knot passing pulley attachment bracket for pulley to bin (guesstimate) anchor for entry point clothes line to install lifeline (diameter of bin) Total economical best
38 lifeline component costs of portable equipment item number cost total economical best either/ carabiners NFPA and ANSI or carabiners 24 kn either/ belay device or double prusic either/ lifeline, rescue 200 feet or lifeline, 7/16 static, 150 feet either/ harness or harness, rescue or rope access both webbing (20 feet) Total
39 The anchors have been evaluated by a structural engineer. We asked him if each anchor was able to support 1800 pounds or 3600 pounds. A safety factor of 2.5 was used. The anchors that did not meet 1800 pound rating are list as not rated. The current ASABE requires a lifeline to have an 1800 pound anchor so we chose this as our minimum anchor. will soon have more information on anchors and a complete lifeline for grain bin entry. This will have been accepted by OSHA for training on bin entry. OSHA requires a lifeline for grain bin entry.
40 The use of the subject anchor point fixtures described in this report is limited to WGM facilities. Installation of the anchor point fixtures is limited to WGM personnel trained in bin entry techniques including the proper installation and rigging of the anchor point fixture being used. No liability is assumed for the use or misuse of the information contained in this report by other parties. For more information contact Lynn McClure at Or the Grain Handling Safety Coalition at
Security and confidence at height.
A Security and confidence at height. Vertical Systems DISTRIBUTED BY M DBI-SALA Vertical Systems are designed to complement your ability to work while meeting all applicable OSHA and ANSI standards. Vertical
More informationa WOW Lab Prep Instructions
Pulleys and Mechanical Advantage A major step in the prep of this activity is choosing a good location. A key feature is an easily accessible top anchor. Some examples of good anchors are a solid tree
More information, Mountaineers Books; 2nd edition, National Ski Patrol
, Mountaineers Books; 2nd edition, National Ski Patrol Knot Tying Objective: The certified candidate will demonstrate the ability to tie the following knots. FIGURE 8 FOLLOW THOUGH: Used for attaching
More informationLOW ANGLE ROPE RESCUE OPERATIONAL
Scope: This chapter serves as an introduction to anchor systems. Terminal Learning Objective (TLO): At the end of this chapter, the student will be aware of anchor selection and anchor system construction.
More informationInstructor Guide. Session Reference: 1. Topic: Ropes, Knots, and Rigging. Level of Instruction: Time Required: Three Hours
Rescue Refresher Instructor Guide Session Reference: 1 Topic: Ropes, Knots, and Rigging Level of Instruction: Time Required: Three Hours Materials: 25 foot length of rope for each student webbing, harnesses,
More informationCATALOG INDEX. Removable Anchors. Toggle Anchors. I-Beam Anchors. Steel Slings. MegaSwivel Family. Swivel Kits. Mining Anchors.
2015 CATALOG CATALOG INDEX Removable Anchors P3 Toggle Anchors P6 I-Beam Anchors P7 Steel Slings P11 MegaSwivel Family P13 Swivel Kits P14 Mining Anchors P22 Ladder Rescue Kit P19 Contact P21 REMOVABLE
More informationRESCUE TECHNICIAN KNOT GUIDE
RESCUE TECHNICIAN KNOT GUIDE RESCUE TECHNICIAN - BASIC September 20, 2014 8AM-5PM - Location T.B.A September 27, 2014 8AM-5PM - Location T.B.A October 11, 2014 8AM-5PM - Location T.B.A This Class is an
More informationHARDWARE Ascenders. Rope Grabs Descenders Snaps Carabiners Links
HARDWARE Ascenders Rope Grabs Descenders Snaps Carabiners Links Ascenders KONG Twin Ascender Aluminum color anodized WLL: 100 grams Rope Diameter: 8-13mm Weight: 17.5oz (496g) Dimensions: 207mm x 162mm
More informationStand-N-Fish FULL DETAIL INSTALLATION INSTRUCTIONS
1 Stand-N-Fish FULL DETAIL INSTALLATION INSTRUCTIONS Thank you for purchasing the incredible new Stand-N-Fish Kayak Fishing System. Once installed on your kayak the Stand-N-Fish will take your kayak fishing
More informationRANDALL S ADVENTURE TRAINING BASIC SINGLE ROPE TECHNIQUES
BASIC SINGLE ROPE TECHNIQUES SINGLE ROPE TECHNIQUES An introductory course in the use of single rope techniques (SRT) for rappelling and ascending in a wilderness environment. This is a basic outline for
More informationKnots for Cavers Knots, Hitches, Bends, and Splices Step By Step Instructions For tying knots for Caving
Knots for Cavers Knots, Hitches, Bends, and Splices Step By Step Instructions For tying knots for Caving Knot Requirements by Slide Edge Color Required Knots Additional Knots Credits The photography and
More informationII-28 STOKES BASKET OPERATIONS
1 II-28 STOKES BASKET OPERATIONS Anchor Slings- (2) high strength nylon webbing straps with D-rings on both ends used to set an anchor. Max working load of 10,000 lbs. Bight- Element of knot formed by
More informationMade in the USA. For Fall Protection Only. SafeLok Part Description
Operations and Instruction Manual SafeLok Anchorage - Model # 4011 IM-0051 REV A Portable Concrete and Steel Anchorage Connector ANSI Z359.1-07 5,000 lbs / 22kn Made in the USA The 3/4 Fall Protection
More informationLOW ANGLE ROPE RESCUE OPERATIONAL
Scope: This chapter serves as an introduction to system attachments and fall restraint. Terminal Learning Objective (TLO): At the end of this chapter, the student will be aware of several methods of system
More informationDeluxe Gourd Racks I D E G A. Parts List. Shown above are parts for the two-level, Deluxe Gourd Rack (DGR 12V)with 12 arms for vertically hung gourds.
Deluxe Gourd Racks H F K I D E J C G A Shown above are parts for the two-level, Deluxe Gourd Rack (DGR V)with arms for vertically hung gourds. Parts List Code Quantity A B C D E F G H I J 6, or 4 6, or
More informationRIGGERS SAFETY SAFETY IS IN THE DETAILS FULL LINE CATALOG
RIGGERS SAFETY SAFETY IS IN THE DETAILS FULL LINE CATALOG Riggers Safety is a California-based manufacturer of Personal Fall Arrest Systems (PFAS) and Fall Prevention Products. Our automated manufacturing
More informationSECURITY AND CONFIDENCE AT HEIGHT
Detachable Cable Sleeve SECURITY AND CONFIDENCE AT HEIGHT THE ULTIMATE IN FALL PROTECTION THE DANGERS OF WORKING AT HEIGHT Every day, workers around the world climb ladders to great heights to get their
More informationSerial Number: Lot Number: Purchase Date: General Factors Accepted / Rejected Supportive Details or Comments. Accepted Rejected.
Full Body Harness Harness Model: General Factors / Supportive Details or Comments 1.) Hardware: (includes D-rings, buckles, keepers, and back pads) Inspect for damage, distortion, sharp edges, burrs, cracks
More informationB O N N E V I L L E C O U N T Y S H E R I F F S SEARCH & RESCUE
TECHNICAL ROPE RESCUE QUICK REFERENCE Version 1.2 as of February 13, 2010 Technical rope rescue work is inherently dangerous. Risk is reduced by having the proper training and equipment, which allows employment
More informationRIGGERS SAFETY SAFETY IS IN THE DETAILS FULL LINE CATALOG
RIGGERS SAFETY SAFETY IS IN THE DETAILS FULL LINE CATALOG Riggers Safety is a California-based manufacturer of Personal Fall Arrest Systems (PFAS) and Fall Prevention Products. Our automated manufacturing
More informationTRAVSMART permanent single-cable horizontal lifeline system
The Travsmart single-line system provides a smooth travel. It allows the traveler to move freely over the intermediate anchors, minimizing wear and eliminating user assistance. The user s hands remain
More informationObjectives (1 of 3) List at least two types of materials and designs used in rope manufacture. Define and describe the following: Dynamic rope Static
Chapter 16 Rescue Objectives (1 of 3) List at least two types of materials and designs used in rope manufacture. Define and describe the following: Dynamic rope Static rope Webbing List at least five rules
More informationTower Accessories & Hardware
Safety-Climb Cable System for Climbing Ladder These Safety-Climb Cable products clamp to climbing ladder rungs up to 1-1/4" (32 mm) in diameter. The products meet or exceed OSH requirements for climbing
More information8-20 Place edge protection to protect rope and webbing.
8-20 Place edge protection to protect rope and webbing. NOTE: All personnel working near an edge must take fall protection precautions as required by the AHJ. Edge personnel must place the edge protection,
More informationGeneral Rescuer Task Book
General Rescuer Task Book Course Dates: Students Name: Lead Instructor: General Rescuer Course Course Completion At the end of the course, the Lead Instructor will fill out the information below to document
More informationTripod. System. User Instructions. 3M Occupational Health and Environmental Safety. Fall Protection Equipment
3M Occupational Health and Environmental Safety Fall Protection Equipment Tripod System User Instructions User Instructions for the 3M TM Tripod System. Important: Keep these User Instructions for reference.
More informationUSER INSTRUCTIONS. Complies with ANSI Z359.1, ANSI Z359.4 standards and OSHA 29 CFR 1910 and 1926 regulations.
FALL PROTECTION USER INSTRUCTIONS TRIPOD SYSTEM Complies with ANSI Z359.1, ANSI Z359.4 standards and OSHA 29 CFR 1910 and 1926 regulations. Models: T100009, T210030B, T210060B, T210100B, T510000B, T510045,
More information2015 FALL PROTECTION & ROPE ACCESS CATALOG CLIMBTECH.COM THE ANCHORING EXPERTS IN SAFETY & ACCESS
2015 FALL PROTECTION & ROPE ACCESS CATALOG CLIMBTECH.COM THE ANCHORING EXPERTS IN SAFETY & ACCESS ABOUT US ClimbTech: The Anchoring Innovators for Fall Protection, Rope Access, Confined Space, Work-at-
More information2016 Product Price List
Bridges Canopy Tours Equipment Rigging Tree Houses ZipLine EcoTram Inspections 2016 Product Price List Device 2 (41 ft) 40052401 US$2,195.00 Device 2 (24.6 ft) 40051501 US$2,195.00 Device XL 40052501 US$2,495.00
More informationFall Protection Checklist. Guardrail System
Fall Protection Checklist Location/Department: Date of Inspection: Inspectors: Corrective Actions: Work order/memos were issued: Yes No Date issued: In accordance with the MIOSHA and OSHA standards the
More informationCORPORATE SAFETY MANUAL
CORPORATE SAFETY MANUAL Procedure No. 32-0 Revision: Date: May 2005 Total Pages: 10 PURPOSE To provide general guidelines for the inspection of all ropes, chains, cables, slings, etc. used for personnel
More informationWilson County Emergency Management Agency 110 Oak Street Lebanon, Tennessee 37087
SOG Name: High Angle & Rope Rescue SOG Number: 403.09 Effective Date: February 2, 2015 Approved: Joey Cooper, Director Reviewed: Scope The purpose of this procedure is to establish guidelines for conducting
More informationVertical Lifeline. Ladder Climb. User Instructions. 3M Occupational Health and Environmental Safety. Fall Protection Equipment
3M Occupational Health and Environmental Safety Fall Protection Equipment Ladder Climb Vertical Lifeline User Instructions User Instructions for the 3M TM Ladder Climb Vertical Lifeline System. Important:
More informationInstallation Guide Wall Mounted Angled Flagpole
Installation Guide 1.5m - 4m Angled Flagpole Dimensions Flagpole Dimensions Wall Bracket Dimensions 2m Aluminium 76mm Glassfibre 114.3mm angle from vertical 2000mm 250mm 300mm 1715mm Backplate thickness
More informationROOF ANCHOR / D-RING ANCHOR PLATE
RIGGERS SAFETY Riggers Safety LLC. 267 Winfield Cr. Corona, CA 92880. 951 371 8586. www.riggerssafety.com Use and Safety Manual ROOF ANCHOR / D-RING ANCHOR PLATE Table of Contents WARNINGS 3 Definitions
More informationAirwalker. Installation and Safety Information. Stretch Products for Dance, Therapy, Education, and Fitness
Airwalker Installation and Safety Information Stretch Products for Dance, Therapy, Education, and Fitness www.dyenamicmovement.com Airwalker is a Registered Trademark of Dye namic Movement Products, Inc.
More informationInstructions for the following series products:
Instructions for the following series products: U-Bolt Roof Anchors (See back page for specific model numbers.) User Instruction Manual U-bolt Roof Anchor This manual is intended to be used as part of
More information3/8" Safety Cable Systems
3/8" Safety Cable Systems Ladder-Mount 3/8" Cable System (No Slider) Kits include appropriate length of aircraft cable, top and bottom support brackets, 12" tensioning turnbuckle, tension spring, and all
More informationPulley-carabiner that facilitates installation of the rope when pulley is connected to the anchor
Petzl Rollclip Pulley-carabiner that facilitates installation of the rope when pulley is connected to the anchor ROLLCLIP A is a pulley-carabiner with a gate opening on the pulley side that facilitates
More informationVisual unlocked indicator
82 Hydrokarst, Voreppe, Isére France Lafouche To meet the many different needs encountered in the field, there exists a wide selection of connectors. Each product is designed for a specific use based on
More informationAerial Litter Basket Set-Up
The following information is also based upon the manufactures recommendations of proper aerial stokes set-up procedures, and the teachings of aerial dynamics. Any deviation in setup procedures could possibly
More informationPremium PowerPoint Presentation. Rigging Review
Premium PowerPoint Presentation Rigging Review Chapter 1 Hoisting Safety Review: What about the CG Symmetrical vs. Asymmetrical Balanced and Unbalanced Lifting Lug Hooks Angle Deformation Safety Gates
More informationQUALITY ALUMINUM BOAT LIFTS, INC. INSTRUCTIONS. Dominator Lake Lift
INSTRUCTIONS Dominator Lake Lift PHONE:251-986-3882 * FAX:251-986-3136 QABLDOMINATORINST.2014 P a g e 1 Quality Aluminum Boat Lifts, INC. Installation Instructions: Dominator Lake Lift Thank you for your
More informationCOMPACT. VERSATILE. SAFE.
NANO-LOK SELF RETRACTING LIFELINES ONLY 1.6 POUNDS! COMPACT. VERSATILE. SAFE. REPLACE YOUR LANYARD TO REDUCE FALL DISTANCE AND IMPROVE SAFETY. Model Shown 3101211 THE ULTIMATE IN FALL PROTECTION PRODUCT
More informationUser Instructions 1790 Rail Anchor
User Instructions 1790 Rail Anchor This document is intended to meet the Manufacturer s Instruction requirements as stated by ANSI Z359.1, and should be used as part of an employee training program as
More informationPrice List January SECUROPE Life Line
4, rue des Etangs L-7303 Steinsel email :marketing@fallprotec.com Fax : +352 26 36 08 41 Tel : +352 26 55 09 30 Price List January 2009 SECUROPE Life Line Code N Quantity for 1 system Designation Unit
More information2010 International Snow Science Workshop
HOW TO TURN A KIDS BIKE INTO A BOMB TRAM FOR AVALANCHE CONTROL WORK David Immeker* Heavenly Mountain Resort Professional Ski Patrol, South Lake Tahoe, California ABSTRACT: Bomb trams have been used for
More informationDBI-SALA CONFINED SPACE ENTRY, RESCUE & DESCENT EQUIPMENT. Reliability When You Need It the Most
DBI-SALA CONFINED SPACE ENTRY, RESCUE & DESCENT EQUIPMENT Reliability When You Need It the Most When it comes to rescue, it is essential that equipment operates perfectly...and fast. DBI-SALA has developed
More informationSKED-EVAC Tripod Instructions
Skedco, Inc. Web Site: http://www.skedco.com E-mail: skedco@skedco.com P.O. Box 3390 Tualatin, Oregon 97062 USA Phone (503) 691-7909 FAX (503) 691-7973 SKED-EVAC Tripod Instructions FEATURES The Sked-Evac
More information3/4 SafeClaw Anchorage Connectors
Operations and Instruction Manual Model #4075 Portable Concrete Anchorage Connector ANSI Z359.1-07 5,000 lbs / 22kn OHSA 1910.66 & 1926.502 Effective: 01/2012 Expires: 01/2022 IM-0049 REVA 3/4 SafeClaw
More informationMSA Confined Space Entry Equipment
MSA Confined Space Entry Equipment Because every life has a purpose... MSA Confined Space Entry Equipment MSA XTIRPA Manhole Guard System Use for confined space vertical entry and fall protection when
More informationTime: 3.0 hours Teaching and Learning Domain: Cognitive and Psychomotor
Construction of Rigging Systems Refresher Teaching and Learning Aids Projection Screen and PowerPoint System Whiteboard or easel pad and markers Rope Kits Time: 3.0 hours Teaching and Learning Domain:
More informationLAD-SAF LAD-SAF VERTICAL SAFETY SYSTEM THE ULTIMATE IN FALL PROTECTION
LAD-SAF VERTICAL SAFETY SYSTEM THE ULTIMATE IN FALL PROTECTION CONTENTS Product Overview 2 Working Safely at Height 2 Features & Benefits 3 Lad-Saf X2 Detachable Cable Traveller 4-5 Typical System Configurations
More informationUser Instructions 1789 Parapet Wall Anchor
User Instructions 1789 Parapet Wall Anchor This manual is intended to meet the Manufacturer Instructions as required by ANSI Z359.1 and should be used as part of an employee training program as required
More information1 SafeClaw Anchorage Connectors
Operations and Instruction Manual Model #4077 Portable Concrete Anchorage Connector ANSI Z359.1 10,000 lbs / 44kn OHSA 1910.66 & 1926.502 Effective: 01/2012 Expires: 01/2022 IM-0050 REVA 1 SafeClaw Anchorage
More informationOPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: SWY100N
OPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: SWY100N IMPORTANT!!! ALL PERSONS USING THIS EQUIPMENT MUST READ AND UNDERSTAND ALL INSTRUCTIONS. FAILURE TO DO SO MAY RESULT IN SERIOUS INJURY OR DEATH.
More informationTroyer s Gourd Rack 8 unit F R H O P
B E A D I M-N L Vertical Parts F R H O P Horizontal Parts C G J Updated 11/16 Parts List A: Top of Pole B: Bottom of Pole C: 48 Ground Stake D: Top Perch rods 48 long E: Hub F: Rope Winder w/ attached
More informationFor Review Only No Copying No Saving No Lending No Posting Online
The following copyrighted samples are provided as a service for your review only. Copying, saving, lending, posting online or any general use of these files other than for the purpose provided is unlawful
More informationFall Protection for Compliance Workman : Quality, Comfort & Value
Fall Protection for Compliance Workman : Quality, Comfort & Value Fall Protection for Compliance Workman Full-Body Harnesses Quality, comfort, and value come together in the Workman line of products and
More informationUSER S INSTRUCTION MANUAL FOR THE INSTALLATION, OPERATION & MAINTENANCE OF THE GUARDIAN TEMPORARY HORIZONTAL LIFELINE SYSTEM
USER S INSTRUCTION MANUAL FOR THE INSTALLATION, OPERATION & MAINTENANCE OF THE GUARDIAN 04630 TEMPORARY HORIZONTAL LIFELINE SYSTEM 1 WARNING This is a design compatible component for a comprehensive Guardian
More informationOPE Training Seminar Agenda
OPE Training Seminar Agenda Basics -OSHA - Industry Symbols - A,B,C s - Types of OPE Systems - Selection of an OPE System - Inspection & Maintenance - Safety Tips (OSHA) OCCUPATION SAFETY AND HEALTH ADMINISTRATION
More informationINSTRUCTIONS FOR USER RBD - COMPACT RESCUE BELAY DEVICE
INSTRUCTIONS FOR USER RBD - COMPACT RESCUE BELAY DEVICE RESCUE BELAY DEVICE Code RBD-COMPACT USING THE RBD The RBD features an automatically engaged cam lock mechanism for rescue belay operations. The
More informationBasic Rigging Knots. Clove hitch: primarily used to secure branches which are being rigged. To secure this hitch from rolling
Clove hitch: primarily used to secure branches which are being rigged. To secure this hitch from rolling out under load during rigging, it is vital to secure the tail end of the rope around the standing
More information1. 2: 1 System ( YELLOW BAG ) made up of 200 feet of 9mm kernmantle rope, carabineers and a preset 2: 1 pulley system.
The Westbury Fire Department currently has two (2) pre-rigged mechanical advantage rope systems, each in pre-packed rope bags stored on both ladder trucks ( 962 and 963). 1. 2: 1 System ( YELLOW BAG )
More informationADVENTURE EDUCATION HIGH ROPES
ADVENTURE EDUCATION HIGH ROPES History and Overview Ropes courses could be found in the United States as early as the 1960s. Outward Bound was a leader in these types of adventure activities with their
More informationHealth & Safety Policy and Procedures Manual SECTION 25 RIGGING AND HOISTING EQUIPMENT
SECTION 25 RIGGING AND HOISTING EQUIPMENT 1. RIGGING AND HOISTING: These rules apply to all Maul Electric, Inc. employees and subcontractors. Note: Maul Electric, Inc. employees will utilize mechanical
More informationTHOR 10 HAMMER CAGE INSTRUCTIONS
75 " 7m 78 4" m 6" 8.8m 45 ".70m 4.9deg 6 4" 6m 44 4".67m 75 " 7m 9 4" 0m 44".m 497 4".64m The 70, Thor Hammer Cage, consists of four heavy duty aluminum net poles. The unique pole structure reduces the
More informationBuckingham Mfg. Co., Inc. OX BLOCK TM Instructions and Warnings
OVERVIEW The Buckingham OX BLOCK is a rope snatch block with an integrated friction bar used for lowering loads, snubbing loads, and raising loads. It allows the rigging professional to handle loads with
More informationCaving Knots. Prepared by CCPO S C Milton CSCA Technical Training Adviser
Nov 2001 Prepared by CCPO S C Milton CSCA Technical Training Adviser INTRODUCTION 1. This booklet provides information about knots used for caving. The "Basic knots" detailed within this booklet are taught
More informationInstallation, Operating, Inspection and Maintenance Instructions Ladder Climber s Safety System. Warning
OWNER'S MANUAL Installation, Operating, Inspection and Maintenance Instructions Ladder Climber s Safety System Model # s: 6000, 6001, 6010 Warning You must read and fully understand all instructions, or
More informationIMPORTANT: If you have questions on the use, care, or suitability of this equipment for your application, contact DBI/SALA.
User Instruction Manual Precast Concrete Beam Horizontal Lifeline System This manual is provided as the Manufacturer s Instructions, and should be used as part of an employee training program as required
More informationBuckingham Mfg. Co., Inc. OX BLOCK TM Instructions and Warnings
OVERVIEW The Buckingham OX BLOCK is a rope snatch block with an integrated friction bar used for lowering loads, snubbing loads, and raising loads. It allows the rigging professional to handle loads with
More informationAlternate Sked Lashing Methods From Roco Rescue. Approved by Skedco.
Presented by: Roco Rescue Roco Rescue, Inc. 12-11-12 Alternate Sked Lashing Methods From Roco Rescue. Approved by Skedco. Warning: Proper training is required prior to use of this or any other rescue equipment
More informationOPERATION AND INSTRUCTION MANUAL Beam Trolley Model: BTA012N
OPERATION AND INSTRUCTION MANUAL Beam Trolley Model: BTA012N WARNING: ALL PERSONS USING THIS EQUIPMENT MUST READ AND UNDERSTAND ALL INSTRUCTIONS. FAILURE TO DO SO MAY RESULT IN SERIOUS INJURY OR DEATH.
More informationRetractable. Dual Leg. User Instructions. 3M Occupational Health and Environmental Safety. Fall Protection Equipment
3M Occupational Health and Environmental Safety Fall Protection Equipment Dual Leg Retractable User Instructions User Instructions for the 3M TM Dual Leg Retractable Important: Keep these User Instructions
More informationEQUIPMENT COST REIMBURSEMENT PROCEDURES
Purpose: Scope: To describe the process for fire departments in the Technical High Angle Rope Rescue Program to be reimbursed for initial equipment purchase costs. This policy refers to the equipment purchase
More informationOPERATION AND INSTRUCTION MANUAL
OPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: SWS100N-316-CTS Patent US # 8,424,638 WARNING: ALL PERSONS USING THIS EQUIPMENT MUST READ AND UNDERSTAND ALL INSTRUCTIONS. FAILURE TO DO SO MAY RESULT
More informationWe put it all on the line, so you don t have to.
3M DBI-SALA 8 mm Permanent Horizontal Lifeline Systems We put it all on the line, so you don t have to. Smarter software. Stronger hardware. Easier installation. How do you improve on one of the best permanent
More informationKITSAP MOUNTAINEERS BASIC CLIMBING COURSE
Basic Rock & Glacier Climbing Course Kitsap Mountaineers KITSAP MOUNTAINEERS BASIC CLIMBING COURSE Class #2 and Field Trip #2 Kitsap Basic Climbing Course Class 5 and Field Trips 6 & 7-1 BASIC CLIMBING
More informationKnots, Hitches and Bends
Knots, Hitches and Bends It is hard to define clearly the terms knot, hitch and bend because their functions overlap. However, the terms may be generally defined as follows: Knots Hitches Bends Knots are
More informationOPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: SWY100N
OPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: SWY100N Patent # US 8,424,638 WARNING: ALL PERSONS USING THIS EQUIPMENT MUST READ AND UNDERSTAND ALL INSTRUCTIONS. FAILURE TO DO SO MAY RESULT IN SERIOUS
More informationDeveloped by Firefighter Ty Drage January NFPA 1670 Standard on Operations and Training for Technical Search and Rescue Incidents
Q UICK A CCESS K IT (1.1) Developed by Firefighter Ty Drage January 2011 NFPA 1670 Standard on Operations and Training for Technical Search and Rescue Incidents T ASK S KILL DESCRIPTION AND DETAIL Every
More informationSafe Work Practices (SWP) SWP (6) FALL PROTECTION PROGRAM
SWP (6) FALL PROTECTION PROGRAM The following information on Fall Protection has been based around the BC OHS Regulations, standards, policies and guidelines. Prior to starting work outside of BC, the
More informationGrain Bin Safety: Entrapment Prevention Kits
Grain Bin Safety: Entrapment Prevention Kits At SCAFCO Grain Systems Company, we are always focused on safety, which is why we are now offering grain entrapment prevention kits for all flat bottom bins
More informationOPERATION AND INSTRUCTION MANUAL
OPERATION AND INSTRUCTION MANUAL Dual Extension Swivel Anchor Model: SWD100N-036 WARNING: ALL PERSONS USING THIS EQUIPMENT MUST READ AND UNDERSTAND ALL INSTRUCTIONS. FAILURE TO DO SO MAY RESULT IN SERIOUS
More information1.3 LIMITATIONS: The following application limitations must be recognized and considered before using this product:
3965 Pepin Avenue Red Wing, MN 55066-1837 Toll Free: (800) 328-6146 Phone: (651) 388-8282 Fax: (651) 388-5065 www.protecta.com User Instruction Manual AJ720A Concrete Anchor This manual is intended to
More informationBasic Rigging And Wire Rope
Basic Rigging And Wire Rope Presented By Master Builders of Iowa Basic Rigging and Wire Rope Topics Four Commandments of Rigging Sling Angles Types Of Hitches Types Of Slings Types Of Rigging Devices OSHA
More informationAlpine WebLock 4.0. Made in the USA. 1-inch Slackline Webbing Anchor. Instructions for handling and use - Please read in full before using this device
Alpine WebLock 4.0 Made in the USA 1-inch Slackline Webbing Anchor Instructions for handling and use - Please read in full before using this device 1.) Introduction 2.) Warnings / General Use Guidelines
More informationOccupational Protective Equipment
Introduction One of the leading occupational dangers in today s workforce is the risk of death or injury due to falls. Falls from ladders, scaffolds, buildings, or other elevations have become the second
More information1.2 LIMITATIONS: Consider the following application limitations before using this equipment:
User Instruction Manual Standing Seam Roof Anchor This manual is intended to meet the Manufacturer s Instructions, and should be used as part of an employee training program as required by OSHA. Figure
More informationFigure 1 - Parts Identification. Copyright 2002, DB Industries, Inc.
User Instruction Manual Zorbit Energy Absorber Kits for Horizontal Lifeline Systems This manual is provided as the Maunfacturer s Instructions, and should be used as part of an employee training program
More informationESCONDIDO FIRE DEPT TRAINING MANUAL Section ENGINE MODULE Page 1 of 14 IRIC/RIC Downed Firefighter Removal Revised
ENGINE MODULE Page 1 of 14 DOWNED FIREFIGHTER REMOVAL Moving the Downed Firefighter: Carries and Drags The process of rescuing a downed firefighter can become extensive and may involve multiple decisions
More informationSAMPLE PAGE. Section 2... Wire Rope
Section 2...................................................... Wire Rope Never use any kind of clip to directly connect two straight lengths of wire rope to form a continuous piece. Do not make up slings
More informationDO NOT use any Alien Flier Zip Line Products or Accessories until you read and understand these SAFETY WARNINGS!
! WARNING DO NOT use any Alien Flier Zip Line Products or Accessories until you read and understand these SAFETY WARNINGS! A zip line can be very dangerous. Do not use this kit if you do not understand
More informationFewer parts. Fast installs. ANSI Compliant. 3M DBI-SALA Lad-Saf Flexible Cable Vertical Safety Systems
Fewer parts. Fast installs. ANSI Compliant. 3M DBI-SALA Lad-Saf Flexible Cable Vertical Safety Systems 3M DBI-SALA Lad-Saf Flexible Cable Vertical Safety Systems Adding or upgrading your vertical safety
More informationOPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: HD26248
OPERATION AND INSTRUCTION MANUAL Swivel Anchor Model: HD26248 IMPORTANT!!! ALL PERSONS USING THIS EQUIPMENT MUST READ AND UNDERSTAND ALL INSTRUCTIONS. FAILURE TO DO SO MAY RESULT IN SERIOUS INJURY OR DEATH.
More informationWorkman Confined Space Entry Kit
Workman Confined Space Entry Kit Because every life has a purpose... Workman Tripod The Workman Tripod Easy to Use. Durable. Versatile. The Workman Tripod is very easy to use. Simple setup makes the process
More informationMSA Latchways Ladder System
Systems overview 1 of 13 Important information Individuals or organisations carrying out the installation of a MSA Latchways ladder fall protection system shall read, understand and follow these instructions
More informationROPE RESCUE & RIGGING
ROPE RESCUE & RIGGING Field Guide Second Edition by Grant Prattley ROPE RESCUE & RIGGING Field Guide Second Edition 2016 Written and illustrated by Grant Prattley Copyright Over The Edge Rescue www.oterescue.com
More informationUser Instruction Manual Tripod Anchorage Connectors
User Instruction Manual Tripod Anchorage Connectors This manual is intended to meet the Manufacturer's Instructions as required by ANSI Z359.1 and ANSI A10.14, and should be used as part of an employee
More information