AIRCRAFT ENGINES SERVICE LETTER SL SL SL-2ST-003

Transcription

1 AIRCRAFT ENGINES SERVICE LETTER LIST OF DOCUMENTATION FOR ROTAX 2-STROKE AIRCRAFT ENGINES AND ALL VERSIONS OF ENGINE TYPE 912/914 SL SL SL-2ST-003 Repeating symbols: Please, pay attention to the following symbols throughout the Service Bulletin emphasizing particular information. WARNING: Identifies an instruction, which if not followed, may cause serious injury or even death. ATTENTION:Denotes an instruction which if not followed, may severely damage the engine or could lead to suspension of warranty. NOTE: Information useful for better handling. 1) Planning information 1.1) Engines affected All versions of the engine type: all 2-stroke aircraft engines (Series/pre-series) all 2-stroke certified aircraft engines (Series/pre-series) 912 (Series/pre-series) 914 (Series/pre-series) 1.2) Concurrent ASB/SB/SI und SL none 1.3) Reason List of valid documentation according to JAR Instruction for continued airworthiness 1.4) Subject List of documentation for ROTAX 2-stroke aircraft engines and for all versions of ROTAX engine type 912/ ) Compliance RECOMMENDED For technical reasons we strongly advise to update the documentation to the latest revision in accordance with the enclosed list in the Appendix ) Approval not required d01166 JY 2000 Rev. 2 Copyright - ROTAX GmbH SL SL SL-2ST-003 page 1 of 2

2 2) Material Information none 3) Accomplishment / Instructions Incorporation / replacement of the respective documentation. 4) Appendix In the following tables (list of current documentation, Issue , page 1-19) all the effective documentation is listed in English for all the engine types as stated in the section 1.1) Engines affected. NOTE: Because of the multitude of documentation a continual updating of the tables is not planned. Updating will be effected with each new issue or revision but at least twice a year. The current documentation and tables are available from any authorized ROTAX distributor or at the ROTAX AIRCRAFT ENGINES Homepage. WARNING: Non-compliance with these recommendations could result in engine damage, personal injury or death! JY 2000 Rev. 2 Approval of translation to best knowledge and judgement - in any case the original text in German language and the metric units (SI-system) are authoritative. Copyright - ROTAX GmbH SL SL SL-2ST-003 page 2 of 2

3 Verzeichnis der gültigen Dokumentationen / List of current documentation Auswahlkriterien / Selection criteria: Sprache / Language = English Engine Type = Any Dokumenttyp / Document Type = Any Info Nr. / Info EM A, 912 F Overhaul Manual 912 A/F (only available for authorized distributors and overhaul facilities) EM A, 912 F Appendices to Overhaul Manual 912 A/F (only available for authorized distributors and overhaul facilities) IM n.a. Installation Manual 275 (not available - use german version) IM , 503, Installtion Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 IM n.a. Installation Manual (not available - use german version) IM , 503, Installtion Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 IM A, 535 B, 535 C n.a. Installation Manual 535 (Serie) - (not available - use german version) IM , 503, Installtion Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 IM A Installation Manual 912 A IM S Installation Manual 912 S IM F Installation Manual 912 F IM Installation Manual 912 IM F Installation Manual 914 F IPC n.a. Spare parts list for engine 185 IPC n.a. Spare parts list for engine 275 (Nr. 656) 1 von / of 19

4 Info IPC n.a. Spare parts list for engine 277 (Nr. 491) IPC n.a. Spare parts list for engine 377 (Nr. 624) IPC n.a. Spare parts list for engine 447 SCDI (Nr. 903) IPC n.a. Spare parts list for engine 462 (Nr. 660) IPC n.a. Spare parts list for engine 501 (Nr. 306) IPC Spare parts list for engine 503 DCDI (Nr. 973) IPC , 505 A n.a. parts list for engine type 505/505A (Nr. 744) IPC n.a. Spare parts list for engine 505 (Nr. 357) IPC A n.a. Spare parts list for engine 505 A (Nr. 805) IPC n.a. Spare parts list for engine 508 (Nr. 646) IPC n.a. Spare parts list for engine 532 (Nr. 648) IPC C n.a. Illustrated Parts Catalog 535 C (Nr. 645) IPC A, 535 B n.a. Illustrated Parts Catalog 535 A+B (Nr. 448) IPC n.a. Spare parts list for engine 582 DCDI (Nr. 837) IPC n.a. Spare parts list for engine 618 DCDI (Nr. 878) IPC n.a. Illustrated parts catalog 912 (No. 825) IPC A, 912 F, 912 S, 912, 912 S, 914 F, Illustrated parts catalog 912 A, F, S,, S / 914 F, IPC A, n.a. Illustrated parts catalog 912 (No. 700) IPC A, 912 F, 912 S, 912, 912 S, 914 F, 914 MM , 503, 582 MM , 503, Illustrated parts catalog 912 A, F, S,, S / 914 F, Maintenance Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod Maintenance Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 2 von / of 19

5 Info MM , 503, Maintenance Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 MM A Maintenance manual 912 A (except Chapter 12 - use MM 912 Serie p current issue) MM A, 912 F, 912 S, Maintenance manual 912 series 912, 912 S MM F Maintenance manual 912 F (except Chapter 12 - use MM 912 Serie p current issue) MM F Maintenance manual 914 F OM n.a. Operator's manual 275 OM n.a. Operators manual 277 OM , 503, Operator s Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 OM Operators manual 462 OM n.a. Operator s manual (not available - use german version) OM n.a. Operator's manual 501 OM , 503, Operator s Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 OM , 503, Operator s Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 OM n.a. Operator`s manual 505 with decompressor OM n.a. Operator`s manual 505 without decompressor OM A n.a. Operator`s manual 505 A with decompressor OM A n.a. Operators manual 505 A without decompressor OM n.a. Operators manual 508 OM n.a. Operators manual 532 OM A, 535 B n.a. Operator s manual 535 A (dual carburetor horizontal) Operator s manual 535 B (dual carburetor vertical) OM C n.a. Operator s manual 535 C (single carburetor) 3 von / of 19

6 Info OM , 503, Operator s Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 OM , 503, Operator s Manual 447 SCDI-503 DCDI-582 DCDI-582 DCDI mod.99 OM n.a. Operator s manual, ROTAX 618 OM n.a. Operator`s manual 642 OM A, 912 F, 912 S, Operator`s Manual 912 Series 912, 912 S OM F, Operator's manual 914 series RM n.a. Repair manual 275 RM n.a. Repair manual 277 RM , 447, n.a. Repair manual engine types CB RM , 447, n.a. Repair manual engine types CB RM , 532, Repair manual RM , 505, 505 A n.a. Repair manual 501/505 (Serie) RM , 447, n.a. Repair manual engine types CB RM , 505, 505 A n.a. Repair manual 501/505 (Serie) RM , 532, Repair manual RM A, 535 B, 535 C n.a. Repair manual 535 (Serie) RM , 532, Repair manual ** SB , 505, 505 A n.a. Piston pin bearing, conversion to reinforced design **(for 501 see SB ) ** SB , 505, 505 A n.a. TBO of ROTAX engine type 501, 505 and 505 A. **(for 501 see SB ) SB n.a. Studs (M8x177) connecting cylinders to crankcase (8x) 4 von / of 19

7 Info SB n.a. Conversion of engine types 505 into 505 A (type certificate data sheet TW 3/78, issue 5 SB , 505 A n.a. Check of ignition timing after exchange of an electronic box SB , 505 A n.a. Examination of the starter gear for cracks. SB , 505, 505 A n.a. Piston pin bearing, conversion to reinforced design **(for 501 see SB ) SB , 505 A n.a. Introduction of a new electronic box with a modified wiring on the stator plate. SB , 505, 505 A n.a. TBO of ROTAX engine type 501, 505 and 505 A. **(for 501 see SB ) SB , 505 A, 535 A, n.a. Magneto housing for ROTAX engine type and 535 (series). 535 B, 535 C SB , 505 A n.a. Magneto housing for ROTAX engine type 505 (series) SB A, 535 B n.a. Flywheel on drive side SB A, 535 B n.a. Coil brace connecting charging coil with lighting coil on armature plate assy. SB A, 535 B, 535 C n.a. Check of ignition timing after exchange of an electronic box. SB A, 535 B, 535 C n.a. Fixation of charging coil and lighting coil on armature plate assy. SB A, 535 B, 535 C n.a. Examination of the starter gear for cracks. SB A, 535 B, 535 C n.a. Introduction of a new electronic box with a modified wiring on the stator plate. SB , 505 A, 535 A, n.a. Magneto housing for ROTAX engine type and 535 (series). 535 B, 535 C SB A n.a. 912 A, Ignition unit with resistor spark plug SB A n.a. Ignition for ROTAX 912 A SB A n.a. Operators manual for ROTAX 912 A SB A n.a. TBO for ROTAX Motor Type 912 A (series) SB A n.a. Special inspection to increase the TBO for engine 912 A Serie SB A n.a. Grounding cable for electronic module of ROTAX Engine series Type 912 A SB A n.a. Ground connection for pick up wiring, ROTAX Engine Series Type 912 A SB A n.a. Electronic module with µ-filter, ROTAX Engine Series 912 A 5 von / of 19

8 Info SB A n.a. Contamination of carburetors, ROTAX 912 A (series) SB A, 912 F n.a. Fitting of a carburetor support, ROTAX 912 A/F (series) SB A, 912 F n.a. Use of an adapted propeller governor on Rotax engine type 912 A3 and 912 F3 SB A n.a. Modification on ROTAX 912 A4 SB A, 912 F 0 0. n.a. Motor oil for ROTAX 912 Series, replaced by SI latest revision SB A, 912 F n.a. 1200h-TBO for ROTAX engine Type 912 A (series) and 912 F (series) SB A, 912 F n.a. Replacement of rocker arms on ROTAX 912 A/F (series) SB A n.a. External alternator for engine type 912, model A2, A3 and A4 SB A, 912 F, 914 F n.a. Oil filter for ROTAX 912 A and F (series) and 914 F (series). **(for 914 see SB ) SB A n.a. Cam shaft check engine type ROTAX 912 A (series) SB A n.a. Propeller gear box for ROTAX 912 A3 SB A, 912 F n.a. Fuel pump for ROTAX 912 F and 912 A (series) SB F n.a. Operator's manual for ROTAX 912 F (series) rev. 1 and 2 SB A, 912 F, 912 S n.a. intentionally obmitted SB A, 912 F n.a. Inspection of the fuel pump kit, part SB A, 912 F n.a. Installation of propeller governor McCauley Propellerregler DCFU290D17B/T1 SB A, 912 F n.a. Installation of propeller governor McCauley Propellerregler DCFU290D17B/T2 SB A, 912 F, 914 F n.a. Checking and replacement of stator assy. SB , 912 S, n.a. Checking and replacement of stator assy. SB A, 912 F, 914 F n.a. Checking or replacement of the propeller gearbox for all versions of the Rotax engine type 912 and 914 SB , n.a. Checking or replacement of the propeller gearbox for all versions of the Rotax engine type 912 and 914 ** SB A, 912 F, 914 F n.a. Oil filter for ROTAX 912 A and F (series) and 914 F (series). **(for 914 see SB ) SB F n.a. Use of an adapted propeller governor on engine type ROTAX 914 F3 6 von / of 19

9 Info SB F n.a. Modification of engine type ROTAX 914 F3 SB F n.a. Calibration of the mixture enrichment jet of engine type ROTAX 914 F (series) SB F n.a. Checking of the banjo bolt in the pressure oil line of turbo charger for ROTAX 914 (series) SB F n.a. Introduction of a turbo charger with a modified wastegate on Rotax 914 SB F n.a. ROTAX engine type 914 F (series), check / replacement of the turbo oil pressure line and pipe clamps SB F n.a. ROTAX engine type 914 F (series) check / replacement of the wastegate servo cable SB F n.a. Installation of propeller governor McCauley Propellerregler DCFU290D17B/T2 SB A, 912 F, 914 F n.a. Checking or replacement of the propeller gearbox for all versions of the Rotax engine type 912 and 914 SB , n.a. Checking or replacement of the propeller gearbox for all versions of the Rotax engine type 912 and 914 SB F, n.a. intentionally obmitted SB F n.a. ROTAX engine series type 914 F, verification of the wiring harness SB F n.a. Turbocharge control unit (TCU) with software level according to RTCA DO 178 B, for engine Type 914 F (series) SB A, 912 F, 914 F n.a. Checking and replacement of stator assy. SB , 912 S, n.a. Checking and replacement of stator assy. SI-2ST , n.a. Installation instructions for the new design piston for 582 with mono hook piston pin circlip grooves SI-2ST , n.a. Change of the exhaust gasket on engine type 582 mod. 90/99 und type 618 SI n.a. -Propeller-Gear 277 SI , 447, 462, 503, n.a. -Propeller-Gear SI , 377, n.a. Ignition Voltage, 462, 503, 532 SI n.a. -Propeller-Gear von / of 19

10 Info SI , 377, 447, 462, 503, 508, 532 SI , 377, 447, 462, 503, 508, n.a. Possible causes for piston seizures or holes in pistons n.a. -Reduction gear box SI , 377, n.a. Ultralight engines-unexpected engine stops, 462, 503, 508, 532, 582 SI , 377, n.a. Engine-Instruments, 462, 503, 508, 532, 582 SI , 377, n.a. Fuel consumption, 2-stroke -Engine, 462, 503, 508, 532, 582 SI , 377, n.a. Influence of ambient air temperature and barometric pressure on engine performance and carb calibration, 462, 503, 508, 532, 582 SI n.a FREE AIR Version SI , 447, n.a. Exhaust systems for , 532 SI , 377, n.a. Rectifier regulator, 462, 503, 532 SI , 447, n.a. Gearbox fixation on -engines type 377 to 532, 503, 532 SI n.a. Fan drive of engine Type 503 SI , 447, 503, n.a. Matching a propeller to ROTAX -Engines. 8 von / of 19

11 Info SI , 377, 447, 462, 503, 508, 532, n.a. Use of tool for cageless piston pin needle bearing SI n.a. Starter gear - electric starter, magneto side, on engine 582 SI , n.a. Disturbance of tachometer for 503 C.D.I. and 582 with DUCATI ignition unit SI , n.a. Rotary valve shaft sealing for ROTAX 532 and 582 SI , 582, n.a. Tightening torque increase on "C" gearboxes for -engines. SI , 377, 447, 462, 503, 508, 532, 582, n.a. Daily and Pre-Flight-Check - Maintenance plan for all ROTAX engines SI , Wiring diagr. for 447 SCDI and 508 SCDI in conj. with electr. tachometer SI , 377, 447, 462, 503, 508, 532, 582, 618 SI , 377, 447, 462, 503, 508, 532, 582, n.a. Safety-check of the BING-carburetors used in all ROTAX -engines Installation Instructions for ROTAX -engines SI A, n.a. Water distributor for ROTAX 912 A and 912 SI , 377, 447, 462, 503, 508, 532, 582, 618, n.a. Propeller mass moment of inertia SI n.a Valve Cover Attachment SI A, n.a. Coolant expansion tank ROTAX 912 (only available in german language) SI n.a. ROTAX 582 DCDI - making of pick-up 9 von / of 19

12 Info SI n.a. Crankcase modifications - ROTAX 582 DCDI SI n.a. ROTAX 582 carb adapter SI n.a. Revolution counter for ROTAX 447 SCDI SI n.a. Assembly instructions for ROTAX 618 water pump cover SI A, n.a. Electronic-box for ROTAX 912 A + SI A, n.a. Sensor and gauge for oil pressure indication-rotax 912 SI , 377, n.a. Carburetor icing on -engines, 462, 503, 508, 532, 582, 618, 912, 914 SI A, n.a. Banjo Bolt ROTAX 912 SI , 377, 447, 462, 503, 508, 532, 582, n.a. Incorrect Model fuel pumps without bleed hole, ROTAX 2-cycle engines SI n.a. ROTAX 582 crankshaft SI n.a. Attaching of water pump housing on ROTAX 582 SI , 532, n.a. Installation Instruction of Reduction gear box type "C " and "CL", 618 SI , 532, n.a. Installation Instruction of Reduction gear box type "E " and "EL", 618 SI n.a. Subsequent install. or retrofit of an oil-pump for separate oil Lubrication SI , 377, 447, 462, 503, 508, 532, 582, n.a. Using auto fuel in ROTAX two cycle aircraft engine 10 von / of 19

13 Info SI , 377, 447, 462, 503, 508, 532, 582, n.a. ROTAX two-cycle aircraft engines crankshaft failures, piston seizures SI , 503, n.a. DUCATI rev. counter, 532, 582, 618 SI , 377, n.a. Weight, centre of gravity and moments of inertia of ROTAX -engines, 462, 503, 508, 532, 582, 618 SI n.a. Grounding cable for electronic module for ROTAX 912 SI n.a. Cylinder and Piston for ROTAX 582 DCDI SI A, n.a. Lubrication system for all ROTAX 912 SI A, 912 F, 912 S, 912, 912 S SI , 377, 447, 462, 503, 508, 532, 582, n.a. 912 Carburetor fixation n.a. supply scope of ROTAX crankshafts SI n.a. TBO for ROTAX engine type 912 -series SI n.a. Special inspection to increase the TBO for engine type 912 SI n.a. Ground connection for pick-up wiring, ROTAX engine Series Type 912 SI n.a. Contamination of carburetors, ROTAX-series 912 SI A, n.a. Cracks in the carburetor flange, engine series type 912 SI A, 912 F, n.a. Floats with a new shape, engine Series Type 912 SI n.a. External alternator for engine series type 912, Mod. 94 SI n.a. External alternator for engine series type 912, Mod. 89 and von / of 19

14 Info SI n.a. Fitting of a carburetor support, Rotax Series 912 SI A, n.a. Rectifier regulator, Rotax Series 912 SI , 532, n.a. Rotary valve shaft seal leakage at Rotax engine type 462 / 532 / 582 and 618, 618 SI , n.a. Cracks in the carburetor socket, ROTAX 447 and 503 SI , 582, n.a. Modifications on reduction gearbox C" and "E" SI n.a. Replacement of rocker arms on ROTAX 912 (series) SI n.a. Installation of oversize pistons, ROTAX 618 SI n.a. ROTAX 914 exchange of the oilpump housing SI , 377, 447, 503, 532, 582, 618 SI , 377, 447, 503, 532, 582, n.a. Piston pin circlip installation (2-stroke -engines) n.a. Engine preservation for 2-stroke- - engines SI A, 912 F, n.a. Oil filter ROTAX 912 / 914 engine, 914 F, 914 SI A, 912 F, n.a. Install. instructions of ROTAX rev-counter (part ) for ROTAX 912/914, 914 F, 914 SI n.a. Camshaft check on ROTAX engine Type 912 (series) SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912, 914 F, n.a. Coolant (antifreeze) mixtures - ROTAX engines 912/914 (series) n.a. Rotax engine type 912 / 914 (series), Venting of lubrication system n.a. Exhaust flange of ROTAX engines 912/914 (series) 12 von / of 19

15 Info SI A, 912 F, n.a. Friction torque check of Rotax 912/914 with slipper clutch installed, 914 F, 914 SI n.a. Calibration of the mixture enrichment jet of ROTAX 914 (series) SI n.a. Exchange of piston pins, ROTAX 503 SI F, n.a. Adjustment or verification of the wastegate position on ROTAX 914 SI n.a. Checking of the banjo bolt in the pressure oil line of turbo charger for ROTAX engine Type 914 (series) SI n.a. Introduction of a turbo charger with a modified wastegate on Rotax 914 SI n.a. Introduction of the single valve spring arrangement on Rotax engine type 912 and 914 (series) SI n.a. Spark plugs for ROTAX engines 912/914 (series) SI n.a. Introduction of a modified oil pressure sensor 912/914 SI , 377, 447, 503, 532, 582, n.a. Introduction of resistance spark plugs for Rotax 2-stroke engines SI A, 912 F, 912 S, n.a. Selection of Motor Oil and General Operating Tips for Rotax engines Type 912 and 914 (series) 912, 912 S, 914 F, 914 SI n.a. Version without intake silencer 618 SI , 377, 447, 503, 532, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912, 914 F, n.a. New flydat configuration for Rotax and aircraft engines n.a. Introduction of the mono hook circlip at ROTAX 912 and 914 series, R n.a. Pressure oil line for hydraulic governor 912/ von / of 19

16 Info SI A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Running modifications on Rotax engine type 912 and 914 (series) SI n.a. Appendix to the maintenance manual 912 A "Propeller gearbox without slipper clutch" SI A, 912 F, 912 S, n.a. ROTAX engine type 912 and 914 (series), Oil level check 912, 912 S, 914 F, 914 SI n.a. Fuel pump (pump with screw fittings) 912 (series) SI n.a. ROTAX engine type 914, check / replacement of the turbo oil pressure line and pipe clamps SI A, 912 F, n.a. cold start at 912 and 914 engines, 914 F, 914 SI F, n.a. ROTAX engine type 914 F (series) Replacement of the waste gate servo cable SI F, n.a. Acceptable cracks in the turbine housing of the turbo charger for engine 914 SI , 503, 532, 582, n.a. Amendment on propeller gearbox type "C" and "E" for two stroke engines SI n.a. ROTAX 503 DCDI (all versions), "B" type gearbox installation SI n.a. ROTAX engine series type 914, verification of the wiring harness SI A, 912 F, 912 S, n.a. Standardization of the crankcase for ROTAX engines 912 and , 912 S, 914 F, 914 SI n.a. Turbocharge control unit (TCU) with software level according to RTCA DO 178 B, for ROTAX engine Type 914 F (series) SI S, 912 S n.a. ROTAX engine Type 912 S/S, Oil consumption SI , 503, 582 SI A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Documentations for mod n.a. Illustrated Parts Catalog (IPC) for ROTAX engines 912 / 914 (series) 14 von / of 19

17 Info SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Installation of rotary water pump seal and water pump impeller n.a. Verification of the Lubrication system and replacement of the oi pressure spring for engine type 912 and n.a. Oil line connections with UNF-threads, ROTAX engine types 912/914 (series) n.a. Modified carburetor flange for Rotax engine type 912 (series) and Rotax engine type 914 (series) n.a. Lubrication system for all ROTAX engine type 912 (series) and 914 (series) n.a. Installation of rotary water pump seal and water pump impeller SI F, n.a. Optimizing of mixture distribution SI F, n.a. Check and lubrication of Wastegate, ROTAX engine types 914 (series) SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, 914 SI A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Verification of the Lubrication system and replacement of the oi pressure spring for engine type 912 and n.a. Oil line connections with UNF-threads, ROTAX engine types 912/914 (series) n.a. Modified carburetor flange for Rotax engine type 912 (series) and Rotax engine type 914 (series) n.a. Lubrication system for all ROTAX engine type 912 (series) and 914 (series) 15 von / of 19

18 Info SL-2ST , 377, 447, 462, 463, 501, 503, 505, 505 A, 508, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL-2ST , 377, 447, 462, 501, 503, 505, 505 A, 532, 535 A, 535 B, 535 C, 582, 618 SL-2ST , 275, 277, 377, 447, 462, 463, 501, 503, 505, 505 A, 508, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL-2ST , 447, 462, 501, 503, 505, 505 A, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Change of desig. of Tech. Bulletins and Service Information in acc. with the new ROTAX standard for ROTAX 2-stroke aircraft engines, ROTAX 912 (series) and ROTAX 914 (series) n.a. Documentations for ROTAX two stroke engines and certified two stroke engines n.a. List of documentation for ROTAX 2-Stroke Aircraft engines and all versions of engine Type 912 / n.a. Change of layout for: Alert Service Bulletin (ASB), Service Bulletins (SB), Service Instructions (SI) and Service Letters (SL) 16 von / of 19

19 Info SL , 377, 447, 462, 463, 501, 503, 505, 505 A, 508, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL , 275, 277, 377, 447, 462, 463, 501, 503, 505, 505 A, 508, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL A, 912 F, 912 S, 912, 912 S SL , 447, 462, 501, 503, 505, 505 A, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Change of desig. of Tech. Bulletins and Service Information in acc. with the new ROTAX standard for ROTAX 2-stroke aircraft engines, ROTAX 912 (series) and ROTAX 914 (series) n.a. Standardization of the reduction gearbox for Rotax 912/ n.a. List of documentation for ROTAX 2-Stroke Aircraft engines and all versions of engine Type 912 / n.a. Documentations for ROTAX engine type 912 (series) n.a. Change of layout for: Alert Service Bulletin (ASB), Service Bulletins (SB), Service Instructions (SI) and Service Letters (SL) 17 von / of 19

20 Info SL A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Use of third party after-market piston kits in Rotax engines type 912 (series) and 914 (series) SL S n.a. ROTAX engine type 912 SFR - version for France SL , 377, 447, 462, 463, 501, 503, 505, 505 A, 508, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, n.a. Change of desig. of Tech. Bulletins and Service Information in acc. with the new ROTAX standard for ROTAX 2-stroke aircraft engines, ROTAX 912 (series) and ROTAX 914 (series) SL A, 912 F, 912 S, n.a. Standardization of the reduction gearbox for Rotax 912/ , 912 S, 914 F, 914 SL , 275, 277, n.a. List of documentation for ROTAX 2-Stroke Aircraft engines and all versions of engine Type 912 / , 447, 462, 463, 501, 503, 505, 505 A, 508, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL F, n.a. Documentations for ROTAX engine type 914 (series) 18 von / of 19

21 Info SL , 447, 462, 501, 503, 505, 505 A, 532, 535 A, 535 B, 535 C, 582, 618, 912 A, 912 F, 912 S, 912, 912 S, 914 F, 914 SL A, 912 F, 912 S, 912, 912 S, 914 F, 914 Anzahl der gefundenen Dokumente / Number of documents found: n.a. Change of layout for: Alert Service Bulletin (ASB), Service Bulletins (SB), Service Instructions (SI) and Service Letters (SL) n.a. Use of third party after-market piston kits in Rotax engines type 912 (series) and 914 (series) 19 von / of 19