GH & GHL Series Gas-Over-Oil Valve Actuators
|
|
- Brendan Scott
- 5 years ago
- Views:
Transcription
1 GH & GHL Series Gas-Over-Oil Valve Actuators Introduction Paladon s GH and GHL-Series use high pressure process gas to provide the energy required to power the actuator. To provide increased safety and reliability, the process gas acts upon hydraulic fluid stored in gas/hydraulic tanks, creating hydraulic pressure that is subsequently used to power the actuator. As standard, the gas-over-oil control system provides local open and close control using either the high pressure process gas, or via a hydraulic hand pump. Numerous additional control system options are available; including remote control and linebreak detection (high/low and rate-of-drop). Although gas-over-oil actuators and control systems are more complicated than direct gas type actuators, they offer many benefits including increased safety, reliability and operational lifespan
2 Key Features l Scotch-yoke and linear piston actuator configurations l Double-acting and spring-return actuator configurations l Low or high pressure control system packages available l Full enclosed manifold controls with lockable cover l Hydraulic manual override standard l Local operation using power gas standard l Speed control in both directions standard l PED or ASME approved gas/oil and power gas storage tanks l Actuators certified to IP66M l Actuators certified in accordance with PED 93/27/EC Performance Data l Supply Pressure Range 90 to 3,625 psig (13 to 250 Barg) l Torque Output Range l Thrust Output Range 1,770 to 4,425,000 lbs.in. (200 to 500,000 Nm) Up to 50,000 lbs (222,000 N) Total Valve Control
3 Control System Options In addition to custom gas-over-oil control systems, Paladon provides the following standard control system functionality: l Local manual control using a hydraulic handpump l Local control using power gas l Remote control using solenoid valves l Automatic high/low linebreak control using either a pressure pilot valve or electrical pressure transmitter l Automatic rate-of-drop linebreak control using either a mechanical or electrical linebreak sensor l Positional control using either 3-15 psig pneumatic positioners or 4-20 ma electrical positioners
4 Local Manual Control 1 Filter 9 Drain & Reducer 2 Ball Valve 10 Diffuser 3 Poppet Block 19 Pressure Relief Valve 4 Pressure Gauge 20 Flow Control Valve 5 Handpump Assembly 22 Pressure Regulator 6 Actuator 23 Pressure Relief Valve 7 Limit Switch 24 Pressure Vessel 8 Gas/Hydraulic Tanks 25 Non Return Valve Total Valve Control
5 Remote Control 1 Filter 12 Pressure Regulator 2 Ball Valve 13 Pressure Gauge 3 Poppet Block 14 Pressure Relief Valve 4 Pressure Gauge 17 Solenoid Valve 5 Handpump Assembly 19 Pressure Relief Valve 6 Actuator 20 Flow Control Valve 7 Limit Switch 22 Pressure Regulator 8 Gas/Hydraulic Tanks 23 Pressure Relief Valve 9 Drain & Reducer 24 Pressure Vessel 10 Diffuser 25 Non Return Valve 11 Ball Valve
6 Automatic High/Low Linebreak Control 1 Filter 13 Pressure Gauge 2 Ball Valve 14 Pressure Relief Valve 3 Poppet Block 15 Filter Unit 4 Pressure Gauge 17 Pneumatic Pressure Switch 5 Handpump Assembly 18 Cam Operated Valve 6 Actuator 19 Pressure Relief Valve 7 Limit Switch 20 Flow Control Valve 8 Gas/Hydraulic Tanks 22 Pressure Regulator (optional) 9 Drain & Reducer 23 Pressure Relief Valve (optional) 10 Diffuser 24 Pressure Vessel (optional) 11 Ball Valve 25 Non Return Valve (optional) 12 Pressure Regulator Total Valve Control
7 Automatic Rate-of-Drop Linebreak Control 1 Filter 14 Pressure Relief Valve 2 Ball Valve 18 Cam Operated Valve 3 Poppet Block 19 Pressure Relief Valve 4 Pressure Gauge 20 Flow Control Valve 5 Handpump Assembly 22 Pressure Regulator 6 Actuator 23 Pressure Relief Valve 7 Limit Switch 24 Pressure Vessel 8 Gas/Hydraulic Tanks 25 Non Return Valve 9 Drain & Reducer 26 Needle Valve 10 Diffuser 27 Pressure Sensing Pilot Valve 11 Ball Valve 28 Pilot Valve 12 Pressure Regulator 29 Reference Tank 13 Pressure Gauge
8 Additional Products l PN & HY-Series Scotch-Yoke Actuators PN & HY-Series actuators are high performance pneumatic and hydraulic scotch-yoke actuators designed to operate any quarter-turn mechanism in both double-acting and spring-return configurations. l PNL & HYL-Series Linear Actuators PNL & HYL-Series are high performance pneumatic and hydraulic actuators designed to operate any linear valve or mechanism in both double-acting and spring-return configurations. l Electro-Hydraulic Control Systems These systems use electric pumps to pressurize hydraulic accumulators to provide hydraulic power. Stand-alone units using solar panels are also available when local utilities are unavailable or unreliable. l Electro Hydraulic Positional Control Systems Suitable for both Choke and Control Valve applications, operating from either existing ring main or self-contained power sources. Available for both Offshore Hazardous locations and Industrial Power Generation l DG-Series Direct Gas Actuators DG-Series actuators are typically used in gas pipeline applications in which the pipeline gas is used directly to power the actuators. l Subsea Actuators The rugged and flexible design does not require pressure compensation for depths down to 650 ft (200m). For deeper applications, a pressure compensated design is available for depths down to 6,500 ft (2,000m). l Autonomous Shutdown Valve (ASV) The ASV is designed to provide full automatic fail-safe operation of subsea valves to isolate pipelines from flexible risers Total Valve Control
Autonomous Shutdown Valve
Autonomous Shutdown Valve Introduction Paladon Systems Autonomous Shutdown Valve (ASV) provides operators of Calm Buoy SLS and similar onshore loading and offloading facilities with an innovative solution
More informationGas Hydraulic Valve Operator
A L o ng E xper ience in Energy Equipmen t and One G o al: T he C u sto mer s Sa tisfa c tion Gas Hydraulic Valve Operator Rugged, reliable controls are at the heart of any good actuator. In the pipeline
More informationAUTONOMOUS SHUTDOWN VALVE
AUTONOMOUS SHUTDOWN VALVE COMPANY For over 30 years Paladon Systems has been supplying valve actuators and control systems on a global basis. Since its inception in 1981, Paladon Systems has continuously
More informationPressureGuard. Self-Contained Hydraulic Emergency Shutdown Systems For Rotary or Non API 6A Linear Valves
PressureGuard Self-Contained Hydraulic Emergency Shutdown Systems For Rotary or Non API 6A Linear Valves Design and Construction Emerson Process Management - Valve Automation is a recognized leader in
More informationPLEM CONTROL SYSTEMS
Optimised PLEM Control Offspring International offers a range of PipeLine End Manifold (PLEM) control systems as part of its integrated CALM buoy and conventional buoy mooring and offloading systems. Available
More informationPLEM CONTROL SYSTEMS
PLEM CONTROL SYSTEMS Offspring International offers a range of PipeLine End Manifold (PLEM) control systems as part of its integrated CALM buoy and conventional buoy mooring and offloading systems. Available
More informationWellhead Safety Valve Control System (Wellhead Control Panel)
Wellhead Safety Valve Control System (Wellhead Control Panel) 1. Single Well Control Panel (Electric) Operating environment: onshore, including the harsh environment such as desert, or the fields that
More informationIndustrial Valves and Automation
Industrial Valves and Automation Prodim is the preferred supplier of over 20 leading European valve brands Our customers rely on Prodim for quality products, on-time delivery and product know-how 2 prodim.biz
More informationLiquid Level Controllers
Liquid Level Controllers ALL PUMPS LLC-2Y For both pump up and down control. Variable On/Off set points. NDP-15/20/25/32, DP-10/15 & *NDP-40/50/80 LLC-1 Pump up and down versions available. 6 to 12 differential
More informationhydro-pac, inc. Low-Pressure Gas Compressors 1500 to 6000 PSI
hydro-pac, inc. LX-SERIES Low-Pressure Gas Compressors 1500 to 6000 PSI hydro-pac, inc. LX-SERIES Features Hydro-Pac LX-SERIES Gas Compressors feature: Oil-free non lubricated gas pistons and cylinders
More informationCHE Well Testing Package/Service:
CHE Well Testing Package/Service: CHE delivers well testing package And services, trailer mounted well testing package and offshore/onshore well testing services with over 10 years experience. Our testing
More informationvalves and actuators SUBSEA ACTUATION
valves and actuators SUBSEA ACTUATION 100 C 55 M 20 Y 0 K 0 C 0 M 0 Y 80 K subsea PetrolValves offers a complete single-source integrated solution for manual or actuated high integrity ball, check, slab
More informationSeries 2G Diaphragm Actuators
Series 2G Diaphragm Actuators Precise Control: Operates valves in on/off, throttling or proportioning systems Series 2G diaphragm actuators are designed for on/off or throttling control of Norris angle-disc
More informationPhuel Portable Control Units
Phuel Portable PCE Control Unit Pressure Test Unit c/w Chart Recorder Triple Wireline BOP The Phuel range of Air Driven Portable provide all the control functions required for well intervention operations
More informationPhuel Modular Control Units
Phuel Modular Phuel Modular, like our market leading Modular BOPs, provide an efficient flexible solution to suit any customer s needs. Each unit is constructed from the best of materials and supportable,
More informationMWEA MAINTENANCE SEMINAR SPECIALTY VALVES POWER GLOBES
MWEA MAINTENANCE SEMINAR SPECIALTY VALVES POWER GLOBES J O H N G. H U N T E R Types of Valves P A U L M A R C H I Accessories Principals of Operation Maintenance Control Valve Types Common Problems Key
More informationFLUID POWER FLUID POWER EQUIPMENT TUTORIAL OTHER FLUID POWER VALVES. This work covers part of outcome 2 of the Edexcel standard module:
FLUID POWER FLUID POWER EQUIPMENT TUTORIAL OTHER FLUID POWER VALVES This work covers part of outcome 2 of the Edexcel standard module: UNIT 21746P APPLIED PNEUMATICS AND HYDRAULICS The material needed
More informationCVI Valve Line. Exceeds the industry s highest standards for reliability and performance
CVI Valve Line Exceeds the industry s highest standards for reliability and performance Available in the most standard models with the shortest lead times in the industry Exceptional quality every CVI
More informationUnit 24: Applications of Pneumatics and Hydraulics
Unit 24: Applications of Pneumatics and Hydraulics Unit code: J/601/1496 QCF level: 4 Credit value: 15 OUTCOME 2 TUTORIAL 9 ACCUMULATORS The material needed for outcome 2 is very extensive so there are
More informationSuitable for anyone who is required to maintain industrial pneumatic systems. No prior knowledge of pneumatic or electrical principles is necessary.
PNEUMATICS COURSE 660: 4 DAYS: Max 8 Candidates This course provides maintenance personnel and production operators etc with the skills and knowledge necessary to carry out maintenance tasks on pneumatic
More informationShafer Gas-Hydraulic Tanks Replacing Hydraulic Fluid Procedure on an Existing Actuator
MIS L10: Replacing Hydraulic Fluid Shafer Gas-Hydraulic Tanks Replacing Hydraulic Fluid Procedure on an Existing Actuator www.shafervalve.com The purpose of this procedure is to guide the operation of
More informationDIVERLESS SUBSEA HOT TAPPING OF PRODUCTION PIPELINES
DIVERLESS SUBSEA HOT TAPPING OF PRODUCTION PIPELINES Dale Calkins Senior Project Engineer, TD Williamson Inc Biography Dale Calkins joined TD Williamson Inc in November of 1999 after working as a consulting
More informationOPERATION MANUAL NTF-15
OPERATION MANUAL NTF-15 Nitrogen Tire Filling Valve Stem Caps (Qty=200) Order P/N 436075 RTI Technologies, Inc 10 Innovation Drive York, PA 17402 800-468-2321 www.rtitech.com 035-81235-00 (Rev B) TABLE
More informationFLUID POWER FLUID POWER EQUIPMENT TUTORIAL ACCUMULATORS. This work covers part of outcome 2 of the Edexcel standard module:
FLUID POWER FLUID POWER EQUIPMENT TUTORIAL ACCUMULATORS This work covers part of outcome 2 of the Edexcel standard module: UNIT 21746P APPLIED PNEUMATICS AND HYDRAULICS The material needed for outcome
More informationINSTALLATION, OPERATION, AND MAINTENANCE MANUAL WELKER CONSTANT PRESSURE SAMPLE CONTAINER
INSTALLATION, OPERATION, AND MAINTENANCE MANUAL WELKER CONSTANT PRESSURE SAMPLE CONTAINER MODEL LS-14 DRAWING NUMBERS AD245.HCRN AD245CRN AD245CV MANUAL NUMBER IOM-131 REVISION Rev. D, 9/6/2016 TABLE OF
More informationOPERATION MANUAL NTF-60 Plus
OPERATION MANUAL NTF-60 Plus Nitrogen Tire Filling Valve Stem Caps (Qty=200) Order P/N 436075 RTI Technologies, Inc 10 Innovation Drive York, PA 17402 800-468-2321 www.rtitech.com 035-81264-00 (Rev A)
More informationThe Discussion of this exercise covers the following points:
Exercise 5-3 Wet Reference Leg EXERCISE OBJECTIVE Learn to measure the level in a vessel using a wet reference leg. DISCUSSION OUTLINE The Discussion of this exercise covers the following points: Measuring
More informationPRESSURE SEQUENCE VALVE TYPE UZK
PRESSURE SEQUENCE VALVE TYPE UZK Size 10, 20, 30 31,5 MPa up to 450 dm 3 /min WK 450 414 04. 2000r. Pressure sequence valves type UZK are used for switching a system or part of a system off when a set
More informationSERVICE MANUAL No. I-0043
Bettis Canada Ltd. 4112 91A Street Edmonton, Alberta, Canada T6E 5V2 Tel: (403) 450-3600 Fax: (403) 450-1400 SERVICE MANUAL No. I-0043 Edmonton GAS/HYDRAULIC ADDITIONAL COMPONENTS CUSTOMER: P.O.#: W.O.#:
More informationL&T Valves Limited SAFETY INTEGRITY LEVEL (SIL) VERIFICATION FOR HIGH INTEGRITY PRESSURE PROTECTION SYSTEM (HIPPS) Report No.
L&T Valves Limited TAMIL NADU SAFETY INTEGRITY LEVEL (SIL) VERIFICATION FOR HIGH INTEGRITY PRESSURE PROTECTION SYSTEM (HIPPS) MAY 2016 Report No. 8113245702-100-01 Submitted to L&T Valves Ltd. Report by
More informationElectro-hydraulic control valve - Calibrate - Remote valve calibration
Electro-hydraulic control valve - Calibrate - Remote valve calibration T9.390, T9.450, T9.505, T9.560, T9.615, T9.670 The CAN-based EHR valves need to be calibrated prior to use. Before calibrating the
More informationLifespan Improvements Available in the Industry
Refining Actuator Systems and Their Reliability, Lifespan Improvements Available in the Industry League City, TX, April 12-15, 2010 Philip Black, Director pbblack@earthlink.net 1 Extending the Lifespan
More informationBERMAD Fire Protection Hydraulic Control Valves
BERMAD Fire Protection Hydraulic Control Valves Control Solutions with the Power to Protect BERMAD - The Company Since its foundation in 1965, BERMAD has focused its efforts on innovation, quality and
More informationPriority (Swing) Motors Data and Specifications
s Data and Specifications Specifications HMF 55 HMF 75 HMF 105 cm 3/rev in 3/rev 55 3.36 75 4.57 105 6.40 Pressure Ratings Nominal 5000 PSIG Maximum 6090 PSIG Peak 7250 PSIG Operating Speed Maximum 4100
More informationPressure Calibrators. Series PC..., PM...
Pressure Calibrators Series PC..., PM... SIKA-Precision Pressure Calibrators, Series PC..., PM... We help you, if you are under pressure! Pneumatic pressure calibrators PM 25 A, PM 25 D, PM 110 PIC pressure
More informationSafety and Shut-off Block SAF/DSV
Safety and Shut-off Block SAF/DSV 1. DESCRIPTION 1.1. GENERAL The HYDAC safety and shut-off block is used to shut off and discharge hydraulic accumulators or consumers. It complies with the relevant safety
More information(Refer Slide Time: 0:26)
Fundamentals of Industrial Oil Hydraulics and Pneumatics By Professor R. Maiti Department of Mechanical Engineering Indian Institute of Technology, Kharagpur Module03 Lecture08 Different Types of Valves-
More informationXpress L90LS Directional Control Valve. Catalog HY /UK December, 2001
Xpress L90LS Directional Control Valve Catalog HY17-8525/UK December, 2001 Catalogue HY17-8525/UK Technical Information Xpress - general information Xpress is a valve-customization service that enables
More informationT e l N o : F a x N o : E m a i l : a i s h c m c - m e. c o m w w w. c m c - m e.
MU047: Practical Valve Technology: Selection, Installation, Upgrading, Inspection & Troubleshooting MU047 Rev.002 CMCT COURSE OUTLINE Page 1 of 7 Training Description: This five-day intensive course covers
More informationContents. Catalog HY /US Load and Motor Control Valves SERIES CAVITY DESCRIPTION FLOW PRESSURE PAGE NO. LPM/GPM BAR/PSI
Load and Motor Control Contents SERIES CAVITY DESCRIPTION FLOW PRESSURE PAGE NO. LPM/GPM BAR/PSI STANDARD PILOT ASSISTED CB101... C10-3... Load Control Cartridge Valve...45/12... 380/5500... 5-6 MHC-010-S***
More informationControl Valve : The Final Control Element. Nimish Shah
Control Valve : The Final Control Element Nimish Shah VALVES How to select Control Valve??? selection parameters for the valve : size, material of construction, pressure and temperature ratings, and End
More informationTECHNICAL DATA. Q = C v P S
January 6, 2012 Preaction 333a 1. Description Viking supervised Surefire Preaction Systems Utilize the Viking G-3000P Valve. The small profile, lightweight, pilot-operated Viking G-3000P Valve comes complete
More informationIWCF Equipment Sample Questions (Combination of Surface and Subsea Stack)
IWCF Equipment Sample Questions (Combination of Surface and Subsea Stack) 1. Given the volumes below, how much hydraulic fluid will be required to carry out the following operations (no safety margin)?
More informationWork Horses of the Breathing Air Industry
High Pressure Breathing Air Equipment Work Horses of the Breathing Air Industry Pegasus Compressor The Pegasus vertically enclosed compressor is a full-featured system that incorporates the latest technology
More informationProduct Data Sheet L-TRDD-D Rev. 1 November Shafer L-Series Linear Valve Actuators Thrust Ratings and Dimensional Data
Product Data Sheet L-TRDD-D-11097 Rev. 1 November 2017 Shafer L-Series Linear Valve Actuators Thrust Ratings and Dimensional Data Product Data Sheet L-TRDD-D-11097 Rev. 1 Shafer L-Series November 2017
More informationSafety and Shut-off Block SAF/DSV
1. DESCRIPTION 1.1. GENERAL The HYDAC safety and shut-off block is used to shut off and discharge hydraulic accumulators or user units. It complies with the relevant safety standards in accordance with
More informationTECHNICAL DATA 3 MODEL G-3000 DRY VALVE RISER ASSEMBLY
Page 1 of 13 1. DESCRIPTION The Viking 3 Model G-3000 Dry Valve Riser Assembly is equipped with a small profile, light weight, pilot operated valve that is used to separate the water supply from the dry
More informationIN-PLANT VALVES. Serving the Water & Waste Water Industry Since Clow Valve is a division of McWane, Inc.
Serving the Water & Waste Water Industry Since 1878 IN-PLANT VALVES Clow Valve is a division of McWane, Inc. www.clowvalve.com AUTOMATION MORIN ACTUATOR DESCRIPTION: The Morin Actuator is a heavy-duty,
More informationTECHNICAL DATA Q = C. v P S. 2 Model G-2000 Dry valve. Page 1 of 13
Page 1 of 13 1. Description The Viking 2 Model G-2000 Dry Valve Riser Assembly consists of a small profile, light weight, pilot operated valve that is used to separate the water supply from the dry sprinkler
More informationSEMPEO SQA Unit Code FP2P 04 Maintaining fluid power equipment
Overview This standard covers a broad range of basic fluid power maintenance competences which will prepare you for entry into the engineering or manufacturing sectors, creating a progression between education
More informationPneumatics. ZF Marine Pneumatics
St. Louis, MO 3137 Phone: 1-800-381-998 ZF Marine Designed for vessels with reverse reduction gears and diesel engines in the higher horsepower range, the ZF Marine Electronics AD12 pneumatic control systems,
More informationManual Actuated Boiler Blowdown Valves
Manual Actuated Boiler Blowdown Valves Installation and Maintenance Instructions 1. Safety information 2. General product information 3. Installation 4. Operation 5. Maintenance 6. Spare parts p.1 1. Safety
More informationBall valve-combinations 105 Shut-off blocks with integrated bypass and safety-lock 106 Sandwich plates 108 Accumulator safety blocks 114
able of contents Ball valve-combinations 105 hut-off blocks with integrated bypass and safety-lock 106 andwich plates 108 Accumulator safety blocks 114 with integrated 2-way ball valve type RA 114 with
More informationminibooster Hydraulics
minibooster Hydraulics The only full range of intensifying solutions! Company history Founded in 1994 as Iversen Hydraulics Aps minibooster A/S founded in 2001 as A/S Situated in Sønderborg, Denmark Owned
More informationTECHNICAL DATA. Q = C v P S
January 6, 2012 Preaction 347a 1. Description Viking supervised Double-Interlocked Electric/Pneumatic Release Preaction Systems utilize the Viking G-6000P Valve. The small profile, lightweight, pilot operated
More informationA versatile gas mixing system for blending LPG and air that is SAFE, RELIABLE, and EASY TO USE
A versatile gas mixing system for blending LPG and air that is SAFE, RELIABLE, and EASY TO USE A versatile gas mixing system for blending LPG and air that is SAFE, RELIABLE, and EASY TO USE Contents The
More informationPower Valve: Precision Regulator. High precision, large capacity relief regulator
Power Valve: Precision Regulator Series VEX High precision, large capacity relief regulator port large exhaust capacity pressure reducing valve which utilizes a nozzle flapper mechanism available as air
More informationLPG DRIVER ATTENDED TRANSPORT LOADING
November 1993 Prepared By: Ken A. Steward. P.E. Linco-Electromatic, Inc. 4580 West Wall Street Midland, Texas 78703 LPG DRIVER ATTENDED TRANSPORT LOADING INTRODUCTION The safest and most accurate method
More informationHydraulic Reliability & Preventive Maintenance Report
Hydraulic Reliability & Preventive Maintenance Report The following is a report of the test, procedures and recommendations for the in-plant press. This information was recorded on May 10 th and 11 th,
More informationModel DDX-LP Dry Pipe Valve System 8 (200mm) Features. Differential latching clapper-type, lighweight, dependable construction.
Bulletin 335 Model DDX-LP Dry Pipe Valve System 8 (200mm) Bulletin 335 Features 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. Differential latching clapper-type, lighweight, dependable construction. Low Air Pressurized
More informationCompletion Workover Riser System. Enabling efficient operations by reducing interface complexities and minimizes operational risk
Completion Workover Riser System Enabling efficient operations by reducing interface complexities and minimizes operational risk Well integrity with fatigue management were key drivers for our system design
More informationHydraulics. Hydraulic Pressure Control
Hydraulics Hydraulic Pressure Control Direct Acting Pressure Relief Valve Normally Closed: Pilot Operated Relief Valve (Compound/ two stage) Small pilot relief valve + Main relief valve Pilot Operated
More informationXMO2. Panametrics Smart Oxygen Analyzer. Applications. Features. bhge.com. An oxygen transmitter for use in:
XMO2 Panametrics Smart Oxygen Analyzer Applications An oxygen transmitter for use in: Inerting/blanketing liquid storage tanks Reactor feed gases Centrifuge gases Catalyst regeneration Solvent recovery
More informationTraining Fees 4,000 US$ per participant for Public Training includes Materials/Handouts, tea/coffee breaks, refreshments & Buffet Lunch.
Training Title CONTROL & SAFETY RELIEF VALVES Training Duration 5 days Training Venue and Dates Control & Safety Relief Valves 5 06-10 May, 2018 $4,000 Dubai, UAE Trainings will be conducted in any of
More informationAssembling and testing fluid power systems
Unit 020 Assembling and testing fluid power systems Level: 2 Credit value: 14 NDAQ number: 500/9514/6 Unit aim This unit covers the skills and knowledge needed to prove the competences required to cover
More informationMotion and Flow Controls for Space Systems RELIABILITY WITHOUT COMPROMISE
Motion and Flow Controls for Space Systems RELIABILITY WITHOUT COMPROMISE When it comes to reliable, high-performance controls for space applications, manufacturers around the world rely on Marotta Controls.
More informationEnglish. Introduction. Safety Instructions. All Products. Inspection and Maintenance Schedules. Parts Ordering. Specifications WARNING WARNING
Contents All Products... Gb-1 Control Valves... Gb-2 Control Valve Actuators... Gb-3 Regulators... Gb-3 Relief Valves... Gb-4 Instruments, Switches, and Accessories... Gb-4 Products Covered by Battery
More informationTECHNICAL DATA. Q = C v P S
Page 1 of 13 1. DESCRIPTION The Viking 6 Model G-6000 Dry Valve Riser Assembly consists of a small profile, light weight, pilot operated valve that is used to separate the water supply from the dry sprinkler
More informationOPERATING AND MAINTENANCE MANUAL
Series 4300 Engineered Performance TABLE OF CONTENTS 0 INTRODUCTION 1 1 Scope 1 2 Description 1 3 Specifications 1 0 INSTALLATION 1 1 Mounting 1 2 Piping 1 1 Connecting Process Pressure 2 2 Vent Connections
More informationOperating Instructions Model and Hydrostatic Test Pump
Operating Instructions Model 39300 and 39301 Hydrostatic Test Pump Dimension Weight Pump Style Capacity Pressure Motor Lubrication Control Gauge Inlet Connection Outlet Connection Discharge Hose Hose Ends
More informationStandard Operating and Maintenance Instructions for Pumping System Model PS-90
Standard Operating and Maintenance Instructions for Pumping System Model PS-90 High Pressure Equipment Company 2955 West 17th Street, Suite 6 PO Box 8248 Erie, PA 16505 USA 814-838-2028 (phone) 814-838-6075
More informationEMERGENCY SHUT-DOWN RELIABILITY ADVANTAGE
Your partner in Fluid Control Solutions EMERGENCY SHUT-DOWN RELIABILITY ADVANTAGE George Cao 06 May, 2011 1. ESD Overview Why Do You Need ESD Solution? Safety! Safety!! Safety!!! Safety Is a Must! The
More informationFeatures. Model EX Low Pressure Dry Pipe Valve System 2 (DN50), 2½ (DN65), 3 (DN80), 76 mm, 4 (DN100 ), 6 (DN150), 165 mm & 8 (DN200)
Features 1. Differential latching clapper-type, lightweight, dependable construction. 2. Low Air Pressurized System, psi -to- 2 psi (0,6 bar -to- 1,9 bar) Max 3. Reset externally. Cover removal is not
More informationCopyright, 2005 GPM Hydraulic Consulting, Inc.
Troubleshooting and Preventive Maintenance of Hydraulic Systems Learning to Read the Signs of Future System Failures Instructed by: Al Smiley & Alan Dellinger Copyright, 2005 GPM Hydraulic Consulting,
More informationDirectional Controls
Vickers Directional Controls Directional Control Valves DG3V-3-*-60 Hydraulic Operated DG17V-3-*-60 Lever Operated DG18V-3-*-60 Air Operated DG20V-3-*-60 Cam Operated DG21V-3-*-60 Plunger Operated CETOP
More informationTECHNICAL DATA. Q = C v P S
January 6, 2012 Preaction 348a 1. Description Viking supervised Surefire Preaction Systems utilize the Viking G-6000P Valve. The small profile, lightweight, pilot operated Viking G-6000P Valve comes complete
More informationWelcome to the LESER Seminar, Taipei 28. June Design_of_safety_relief_valves_250804_Cal
Welcome to the LESER Seminar, Taipei 28. June 2006 1 Design of safety relief valves 2 Design of safety valves Target Classification of Pressure Relief Devices General design of Safety Relief valves 3 Design
More informationPressure and/or Temperature Pilot Operated Steam Regulators Series 2000
Hoffman Specialty Regulators Regulators Pressure and/or Temperature Operated Regulators Series 2000 The Hoffman Specialty Series 2000 consists of main valves, pilot valves, wells and hardware kits. They
More informationTECHNICAL DATA. Q= Cv S
Page 1 of 13 1. DESCRIPTION The Viking 4 inch Model G-4000 Dry Valve Riser Assembly consists of a small profile, light weight, pilot operated valve that is used to separate the water supply from the dry
More informationBETTIS J1-RT2 RATE OF DROP LINEBREAK DETECTION SYSTEM. FACTORY SET: psi/min psi P/L
Bettis Canada Ltd. 4112 91A Street Edmonton, Alberta, Canada T6E 5V2 Tel: (780) 450-3600 EDMONTON Fax: (780) 450-1400 Service Manual BETTIS J1-RT2 RATE OF DROP LINEBREAK DETECTION SYSTEM CUSTOMER: P.O.#:
More informationWaterous Relief Valve
Operating Instructions 1. Reduce pump discharge pressure with engine throttle. Make sure four way (On/Off) valve is OFF. 2. Open at least one discharge valve. Accelerate engine until pressure gage indicates
More informationTECHNICAL DATA OBSOLETE
April 9, 2009 Preaction 326a 1. DESCRIPTION Viking supervised Double-Interlocked Electric/Pneumatic Release Preaction Systems utilizing the Viking G-4000P Deluge Valve. The small profi le, lightweight,
More informationSINGLE VALVE WITH LOW-FLOW BYPASS
CONTROL VALVES Pressure Reducing Valve Sizing Guide Sizing pilot operated reducing valves is not a complicated process. It starts with determining requirements and following these guidelines in valve size
More informationACTUATORS AND INSTRUMENTS
ACTUATORS AND 03 ADVANCED ACTUATORS AND FOR A COMPLETE VALVE CONTROL SOLUTION Koso Kent Introl LIMITED (KKI) supplies a full range of advanced actuators and associated instrumentation to complement its
More informationTEST BENCH FOR SAFETY VALVES
TEST BENCH FOR SAFETY VALVES 1) Hydro panel : This Panel possesses This Bench Contains One Panel and One Reservoir. 1 No. Monobloc Version : Single Phase AC, 50 Hz Type of Duty :S1 (Continuous) Class of
More informationSubsea Safety Systems
Subsea Safety Systems The ELSA-HP has been developed to service the high pressure horizontal tree completion and intervention market. With systems designed and qualified up to 15,000 psi, 250 degf and
More informationTECHNICAL DATA. Low-Flow Foam Preaction System with Hydraulically Actuated Concentrate Control Valve.
Foam 302 a 1. DESCRIPTION (Refer to Figure 1 on page 302 e.) The Viking Low-Flow Foam/Water Proportioning System is a UL Listed and FM Approved system, for use with 3M and Viking brand foam concentrate.
More informationSafety and Shut-off Block SAF/DSV
Safety and Shut-off Block SAF/DSV 1. Description 1.1. GENERAL The HYDAC safety and shut-off block is used to shut off and discharge hydraulic accumulators or consumers. It complies with the relevant safety
More informationElectro-Pneumatic Converter YT-940 SERIES
Electro-Pneumatic Converter YT-940 SERIES PRODUCT MANUAL VERSION 1.00 Contents 1. Introduction 3 1.1 General information for the users. 3 1.2 Manufacturer Warranty 3 1.3 Explosion Proof Warning. 4 2. Product
More informationMEDICAL EQUIPMENT CATALOG
THE MOST TRUSTED MEDICAL EQUIPMENT IN NORTH AMERICA MEDICAL EQUIPMENT CATALOG Total Components Including Bulk Oxygen Supply, Back up and Delivery Equipment Designs for High Pressure, Liquid or Bulk Applications
More informationM-System s I/P and P/I Transducers
roduct introduction and application examples 6-0023 2017-12 EC-Z654 M-System s / and s Rev. 0 01 500523 Two-wire models available with no power supply required ower Chemical plants plants Actual Size M-System
More informationType ACE97. Introduction. Installation. P.E.D. Categories. Specifications. Overpressure Protection. Installation Guide English May 2002
Installation Guide English May 2002 Type ACE97 Introduction This installation guide provides instructions for installation, startup, and adjustment. To receive a copy of the instruction manual, contact
More informationTECHNICAL DATA. Q = C v P S
January 6, 2012 Preaction 331a 1. Description Viking supervised Double-Interlocked Electric/Pneumatic Release Preaction Systems utilize the Viking G-3000P Valve. The small profile, lightweight, pilot-operated
More information3-Way Safety Block DSV
3-Way Safety Block DSV DSV 10 - M DSV 10 - M - T-ball DSV 10 - EY 1. Description 1.1. GENERAL The 3-way safety block is used to shut off and discharge hydraulic accumulators or consumers. It complies with
More informationTRAINING SCHEDULE FLUID POWER TRAINING CUSTOM TRAINING PRODUCT TRAINING
TRAINING SCHEDULE 2018 FLUID POWER TRAINING CUSTOM TRAINING PRODUCT TRAINING Fluid Power Training CMA/Flodyne/Hydradyne offers economical four day hydraulic training classes in Basic Hydraulics, Advanced
More informationSafety and Shut-off Block SAF/DSV
Safety and Shut-off Block SAF/DSV 1.1.1 Key to the circuit diagram Circuit diagram The HYDAC safety and shut-off block is used to shut off and discharge hydraulic accumulators or consumers. It complies
More informationINSTALLATION OPERATION MAINTENANCE
Bermad Electrically Controlled On-Off Deluge Valve Model: 400E-3D INSTALLATION OPERATION MAINTENANCE Application Engineering BERMAD 1. Safety First BERMAD believes that the safety of personnel working
More informationHIGH PRESSURE DRILLING FLUID PUMP
1 HDF 200/250-280 HIGH PRESSURE DRILLING FLUID PUMP Dynaset HDF pump gives great water power with small amount of water in relation to its size. As self-priming it is productive in hard environment. Small
More informationInverse Proportional Pressure-Relief Cartridge, Size 10
Inverse Proportional Pressure-Relief Cartridge, Size 1 Q max = 12 l/min, p max = 3 bar Seated pilot, spool-type main stage, damped design 1 Description inverse-proportional pressure-relief valves are size
More informationDN300 DN2000 C Plunger Valve
ל DN300 DN2000 C Plunger Valve P.O.B 46 MOSHAV SHTULA WESTERN GALILEE 2286500 Tl. +972-(0)77-6656101, Fax. +972-(0)77-6656196 Website: www.saisanketvalves.com www.saisanket.com email: saisanket@saisanket.com
More information