AQUAFIX Separators. The water treatment range. Modern separation technology for sustainable preservation of vital resources.
|
|
- Tamsin Stafford
- 5 years ago
- Views:
Transcription
1 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators The water treatment range. Modern separation technoogy for sustainabe preservation of vita resources.
2 CIVILS LANDSCAPING AQUA SPORT The water treatment range. Modern separation technoogy for sustainabe preservation of vita resources. Living rivers and akes, intact groundwater resources, a secure and reiabe water suppy and efficient wastewater disposa are fundamenta requirements for environmentay sound economic deveopment. To avoid harming nature, contaminated water must be treated before it is aowed to fow directy or indirecty back into the natura water cyce. The mechanica separation process is designed to separate mixtures of substances. The aim is to remove one or more components of the mixture. The operating principe of the oi and ight iquid separator is based on the difference in density between the water and the components being separated from it. The ighter iquid rises to the top, coects on the surface of the water and can then be removed and disposed of. Coaescence separators are an enhancement of standard petroeum separators. These systems work on the coaescence principe, i.e. encouraging the merging of sma oi partices into arger ones. Even the smaest drops of oi wi then foat to the surface as a resut of gravity, where they can be separated off. AQUAFIX separators form part of a controed disposa concept and wi deiver many years of reiabe performance. The range consists of high quaity systems made of poyethyene, poypropyene, stee or concrete. Each system is individuay measured and customised to suit the construction project, thus guaranteeing many years of efficient water treatment. AQUAFIX separators are aways state of the art and compy with a reevant standards and reguations. 2
3 AQUAFIX Separators Series G made of stee 6 AQUAFIX Separators Series k made of stee 16 AQUAFIX Separators Series made of concrete (H/P) 30 AQUAFIX Separators Series 10 PE made of poyethyene 56 AQUAFIX Separators Series PP made of poypropyene 86 AQUAFIX Separators Instaation Instructions & Exampes 98 3
4 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators The water treatment range. Modern separation technoogy for sustainabe preservation of vita resources. Requirements Water is one of the most vauabe resources on Earth. Germany has one of the best deveoped sewage systems in the word. If both are to be protected and kept in good condition for our descendants, efficient ceansing systems are required. In fue stations, industria and coercia areas where surface water or effuents are pouted with hydrocarbon compounds, ight iquid separators are needed that satisfy the rigorous requirements of the norms and reguations governing groundwater protection. Effuents pouted with grease and fatty acids can cause enormous damage to drain systems and sewage pants. This is where AQUAFIX-Grease and Starch Separators make a vauabe contribution to protecting the environment. Appication areas Fue stations, car washes, car repair workshops, car showrooms, oi depots, car scrap yards, transformer stations, industria pants where ubricating oi is used, road hauage depots, poice, fire brigade, army, maintenance/servicing areas, parking areas, car customisers and importers, canteen kitchens, student refectories, cafés and restaurants, hotes, cafeterias, producers of ready-made meas, producers of tinned foods, sweet factories, potato processing pants, producers of frozen foods, coercia bakeries, abattoirs, butchers, anima product processing pants, soap and stearin factories, cosmetics industry, cat and dog food producers, fairground operators and many more. 4
5 AQUAFIX Separators Aarm devices. Security for the environment. Warning systems Warning system type 1 The W1 LAL-SRW-PF-01 warning system is an aarming device for ight iquid separators (petro, oi and coaescence separators) that is icensed for operation in potentiay exposive areas (Zone 0). It is used to detect the oi ayer thickness in a ight iquid separator. The warning system consists of a signaing unit with LED s for Power, System OK, Layer thickness aarm and Sensor error and an acoustic aarm. The acoustic aarm can be manuay disabed. The Sensor error diode cannot be acknowedged unti the cause of the aarm has actuay been rectified. A sensor that creates an eectrica fied is suspended in the separator. When the ight iquid ayer in a separator becomes thicker and the separating ayer between the water and the ight iquid is reocated downwards, the tip of the sensor is suspended in the ight iquid. This affects the eectrica fied and an aarm is triggered. Item no.: Warning system type 2 The W2 LAL-SRW-PF-08 warning system is an aarming device for ight iquid separators. It has the same signaing unit, but has negative switching. In warning system 2 an aarm is signaed when current is fowing. As soon as the iquid eve increases and the probe tips reach the surface of the water, an aarm is triggered. In this case the cause of the backup in the separator is irreevant. For exampe, if the coaescence materia is soied and preventing an adequate water fow, an aarm is signaed. An aarm is aso triggered if the pipeine behind the separator is bocked or the entire system is hydrauicay overoaded because of heavy rainfa. Item no.: Warning system type 3 Has a signaing unit with two pug-in units and two probes. It is a combination of warning systems 1 and 2. Item no.:
6 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series G made of stee Highest voume for biggest fow. 6
7 At a gance: Compact design Separator tank, continuousy chargeabe up to cass D 400 Gavanised inside and outside or coated with severa ayers of epoxy resin on pretreated surface 7
8 AQUAFIX Separators Series G made of stee Highest voume for biggest fow. Features Compact design Compies with standards EN 858/DIN 1999 Inets and outets made from 6-8 stee pate, same diameter as KG pipes Patented foat, easy to remove as required by the norm Easy to cean amear coaescence materia Maintenance-free coaescence bock Samping system can be integrated Increased ceaning performance possibe Warning systems can be integrated Additiona coaescence eement can be retrofited Shaft materias Extensions The 625 and 1000 diameter access openings are designed to be competed with DIN 4034/1 shaft materia. Shaft extensions can be suppied. 8
9 AQUAFIX Separator at Lego factory in Mexico AQUAFIX Stee G Largest project of separators overseas The foowing projects were deivered: AQUAFIX SKGBP metres, 6.1 tons AQUAFIX SKGBP metres, 8.7 tons AQUAFIX SKGBP metres, 10.5 tons AQUAFIX SKGBP metres, 13.5 tons AQUAFIX Stee k Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete 9
10 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series G AQUAFIX SKG Coaescence separator with sudge trap SKG 015 Length Width Height Externa diameter Fow performance /s SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG SKG
11 AQUAFIX Stee k AQUAFIX Stee G Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , , , , , , , , , , , , , , , , , , , , Item No. Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete 11
12 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series G AQUAFIX SKGBP Coaescence separator with sudge trap and bypass SKGBP 015 Length Width Height Externa diameter Fow performance /s SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP SKGBP
13 AQUAFIX Stee k AQUAFIX Stee G Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , , , , , , , , , , , , , , , , , , , , , Item No. Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete 13
14 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series G AQUAFIX SKG2BP Coaescence separator with sudge trap and bypass with increased performance SKG2BP 015 Length Width Height Externa diameter Fow performance /s SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP SKG2BP
15 AQUAFIX Stee k AQUAFIX Stee G Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , , , , , , , , , , , , , , , , , , , , , Item No. Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete 15
16 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series k sma made of stee Strong soutions for sma fows. 16
17 At a gance: At east 5-6 soid stee pates Separator tank, continuousy chargeabe up to cass D 400 Gavanised inside and outside or coated with severa ayers of epoxy resin on pretreated sur face 17
18 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series k sma made of stee Strong soutions for sma fows. Features At east 5-6 soid stee pates Entry and maintenance openings Size 1: 500 x 630 or 500 x 500 ; Size 2: 1000 x 630 or 1000 x 500 (Measurements depending on the pace of deivery/ country) Cass B 125 or C 250 extension covers with adjustabe height (Loading cass depending on the pace of deivery/country) Stop rings to hande the systems Separator tank, continuousy chargeabe up to cass D 400 Gavanised inside and outside or coated with severa ayers of epoxy resin on pretreated surface (Coating depending on the pace of deivery/country) Compact design Compies with standards EN 858 and EN 1825 Inets and outets made from 5-6 stee pate, same diameter as KG pipes Extensions A modes are equipped with 500 x 630 and 1000 x 630, or with 500 x 500 and 1000 x 500 covers. They are 200 or 100 high and are continuousy adjustabe by up to 40. They have been designed for cass B 125 or C 250. Severa units can be stacked on top of each other. For ight iquid separation systems: Easy to remove as required by the norm Easy to cean amear coaescence materia Maintenance-free coaescence bock Samping system can be integrated 18
19 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 19
20 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series k AQUAFIX Sk Sudge trap Sk 0100 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Sk , Item No. 20
21 AQUAFIX Kk Coaescence separator Kk 01,5 AQUAFIX Stee G Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg Kk 01, , Kk , Kk , Kk , Kk , Kk , Kk , Kk , Item No. Instaation Instructions AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP AQUAFIX Stee k 21
22 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series k AQUAFIX SKk Coaescence separator with sudge trap SKk 01,5/0150 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SKk 01,5/ , SKk 03/ , SKk 04/ , SKk 06/ , SKk 08/ , SKk 10/ , SKk 15/ , SKk 20/ , Item No. 22
23 AQUAFIX SKBPk Coaescence separator with sudge trap and bypass SKBPk 03/0300 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SKBPk 03/ , SKBPk 04/ , SKBPk 06/ , SKBPk 08/ , SKBPk 10/ , SKBPk 15/ , SKBPk 20/ , Item No. Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k 23
24 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series k AQUAFIX SKmPk Coaescence separator with sudge trap and pump chamber SKmPk 01,5/0150 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SKmPk 01,5/ , SKmPk 03/ , SKmPk 04/ , SKmPk 06/ , SKmPk 08/ , SKmPk 10/ , SKmPk 15/ , SKmPk 20/ , Item No. 24
25 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 25
26 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series k Grease Separator 26
27 AQUAFIX Grease separator with sudge trap for overground instaation GB 1 Instaation Instructions AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg GB , SFe 01/ , SFe 02/ , Item No. 27
28 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of stee, series k AQUAFIX Fk Grease separator Fk 01 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg Fk , Fk , Fk , Fk , Fk , Fk , Fk , Fk , Item No. 28
29 AQUAFIX SFk Grease separator with sudge trap SFk 01/0100 AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP Instaation Instructions AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SFk 01/ , SFk 02/ , SFk 04/ , SFk 07/ , SFk 10/ , SFk 15/ , SFk 20/ , SFk 25/ , Item No. 29
30 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series made of concrete Soid constructions for heavy duty. 30
31 At a gance: High quaity concrete Strong wa thickness Conforms to standards even down to the detais 31
32 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series made of concrete Soid constructions for heavy duty. Features high grade reinforced concrete C35/45 in accordance with Eurocode EC 206, DIN 1045 and 4281, wa thickness at east 120 coating consisting of three ayers of epoxy resin resistant to ight iquids and fatty acids conform to European standards EN 858 and
33 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 33
34 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P The foowing are products from Poand - series P 34
35 AQUAFIX S Sudge trap S 02000/0150 AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP Instaation Instructions AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg S 00300/ , P S 00600/ , P S 01000/0150 P , P S 01500/0200 P , P S 02000/ , P S 02000/ , P S / 0400 P , P S / 0200 P , P S / 0150 P , P S 04000/ , P S / 0200 P , P S / 0250 P , P S / 0250 P , P Item No. 35
36 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P AQUAFIX S Sudge trap, rectanguar version S 10000/0500 rectanguar P S 10000/0500 rectanguar P S 10000/0600 rectanguar P S 10000/0800 rectanguar P S 10000/1000 rectanguar P S 12000/0600 anguar P S 12000/1000 anguar P S 15000/0500 rectanguar P S 20000/0500 rectanguar P S 20000/0600 rectanguar P S 20000/0800 rectanguar P Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg , P , P , P , P , P , P , P , P , P , P Item No. 36
37 AQUAFIX K Coaescence separator K 10 P AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP Instaation Instructions AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg K 03 P , P K 06 P , P K 10 P , P K 15 P , P K 20 P , P K 30 P , P K 40 P , P K 50 P , P K 60 P , P K , P K 80 P , P K , P K 100 P , P Item No. 37
38 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P AQUAFIX K Coaescence separator - rectanguar shape K 150 rectanguar P K 150 rectanguar P K 200 rectanguar P Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg , P , P Item No. 38
39 AQUAFIX K2BP Coaescence separator with doube bypass K2BP 10 P AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP Instaation Instructions AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg K2BP 10 P , P K2BP 15 P , P K2BP 20 P , P K2BP 30 P , P K2BP 40 P , P K2BP 60 P , P K2BP 80 P , P K2BP 90 P , P Item No. 39
40 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P AQUAFIX SK Coaescence separator with sudge trap SK 10/1000 Length Width Height Externa dia- meter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SK 03/0650 P , P SK 06/ , P SK 10/ , P SK 10/ , P SK 10/2500 P , P SK 10/ , P SK 10/5000 P , P SK 15/ , P SK 15/3000 P , P SK 15/5000 P , P SK 20/4000 P , P SK 20/4000 P , P SK 30/3000 P , P SK 40/4000 P , P SK 50/5000 P , P Item No. 40
41 AQUAFIX K2BP Coaescence separator with doube bypass, rectanguar version K2BP100 oder K2BP120 AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE Instaation Instructions AQUAFIX PP AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg K2BP , P K2BP , P Item No. AQUAFIX SK2BP Coaescence separator with sudge trap and doube bypass SK2BP 15/1500 SK2BP 10/1000 ight Length Width Height Externa diameter Fow performance /s Sudge trap capa-city Separator capa-city DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg , P SK2BP 15/ , P SK2BP 20/ , P Item No. 41
42 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P Grease Separator 42
43 AQUAFIX Sf Sudge trap for grease Sf 0700/07 P Instaation Instructions AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg Sf 0700/07 P , P Sf 0700/07 P , P Sf 0800/04 P , P Item No. 43
44 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P AQUAFIX F Grease separator F 04 P Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg F 02 P , P F 04 P , P F 07 P , P F 10 P , P F 15 P , P Item No. 44
45 AQUAFIX SF Grease separator with sudge trap SF 04/0400 P AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP Instaation Instructions AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SF 02/0200 P , P SF 02/0400 P , P SF 04/0400 P , P SF 04/0800 P , P SF 04/0700 P , P SF 07/1400 P , P SF 10/1000 P , P SF 10/2000 P , P SF 20/2000 P , P Item No. 45
46 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series P Starch Separator 46
47 AQUAFIX Sa Starch separator SA 4,0 P Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SA 0,5 P , P SA 1,0 P , P SA 2,0 P , P SA 3,0 P , P SA 4,0 P , P SA 6,0 P , P Item No. Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k 47
48 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series H The foowing are products from Hungary - series H 48
49 AQUAFIX S Sudge trap S 10/02500 H Instaation Instructions AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg S 10/02500 H , H S 20/02500 H , H S 30/4000 H , H S 40/4000 H , H S 40/8000H , H S 50/06500 H , H Item No. 49
50 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series H AQUAFIX K Coaescence separator K 10 H Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg K 10 H , H K 20 H , H K 040 H , H K 050 H , H K 060 H , H Item No. 50
51 AQUAFIX SK Coaescence separator with sudge trap SK 04/0650 H AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP Instaation Instructions AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SK 04/0650 H , H SK 10/2500 H , H SK 06/0600 H , H SK 15/1500 H , H SK 20/2000 H , H SK 20/4000 H , H SK 25/2500 H , H SK 30/3000 H , H SK 40/4000 H , H SK 050/03000 H , H Item No. 51
52 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series H AQUAFIX SK Coaescence separator with sudge trap (more tanks S-K) H SK 150/15000 H Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SK 040/04000 H , H SK 040/08000 H , H SK 050/05000 H , H SK 060/06000 H , H SK 075/07500 H , H SK 080/08000 H , H SK 090/09000 H , H SK 100/10000 H , H SK 120/12000 H , H SK 120/13000 H , H SK 150/15000 H , H SK 180/18000 H , H Item No. 52
53 AQUAFIX SK2BP Coaescence separator with sudge trap and doube bypass SK2BP 10/3000 Instaation Instructions AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP AQUAFIX Stee k Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SK2BP 10/ , H SK2BP 15/ , H SK2BP 20/ , H Item No. 53
54 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of concrete, series H Grease Separator 54
55 AQUAFIX SF Grease separator with sudge trap SF 04/0400 H Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SF 04/0400 H , H SF 10/1000 H , H Item No. Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k 55
56 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series 10 PE made of poyethyene Light soutions for strong requirements. 56
57 At a gance: 10 wa thickness for highest security optimised construction after FE-anaysis pure, high quaity raw materia is used in the optimised production process 57
58 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series 10 PE made of poyethyene Light soutions for strong requirements. Features 10 wa thickness stop rings to hande computer aided design according to standards EN 858 or EN 1825 wide openings for ight iquid separators: automatic cosing device easy to remove coescence ce easy to remove sampe taking device can be integrated Extensions Extension pipes in every ength can be suppied. Covers in cass A or D avaiabe. The construction of AQUAFIX 10 PE separators was done according to detaied FE anaysis. The combination of high quaity materia, optimised production process and at east 10 wa thickness quarantuees highest stabiity. 58
59 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 59
60 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX SPE Sudge trap SPE 0800/0160 SPE 1000/0160 Length Width Height Externa diameter Fow performance /s SPE 0800/ SPE 1000/ SPE 1500/ SPE 2000/
61 SPE 1500/0200 SPE 2000/0200 Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , Item No. Instaation Instructions AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX PP AQUAFIX Stee k 61
62 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX KPE Coaescence separator KPE 03 KPE 06 KPE 08 Length Width Height Externa diameter Fow performance /s KPE KPE KPE KPE KPE
63 KPE 10 KPE 15 AQUAFIX PP AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX Stee k Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , Item No. Instaation Instructions 63
64 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX SKPE Coaescence separator with sudge trap SKPE 01,5/0150 SKPE 03/0300 SKPE 06/ Length Width Height Externa diameter Fow performance /s SKPE 01,5/ SKPE 03/ SKPE 06/ SKPE 08/ SKPE 10/ SKPE 15/
65 SKPE 08/0800 SKPE 10/1000 SKPE 15/1500 AQUAFIX Stee G AQUAFIX PP AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , , Item No. 65 Instaation Instructions
66 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX SKBPPE Coaescence separator with sudge trap and bypass SKBPPE 06/0600 SKBPPE 08/0800 Length Width Height Externa diameter Fow performance /s SKBPPE 06/ SKBPPE 08/ SKBPPE 10/
67 SKBPPE 10/1000 Sudge trap AQUAFIX Stee G Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , Item No. AQUAFIX PP Instaation Instructions AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 67
68 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX SKmPPE Coaescence separator with sudge trap and pump chamber SKmPPE 01,5/0150 SKmPPE 03/0300 SKmPPE 06/0600 Length Width Height Externa diameter Fow performance /s SKmPPE 01,5/ SKmPPE 03/ SKmPPE 06/ SKmPPE 08/ SKmPPE 10/ SKmPPE 15/
69 SKmPPE 08/0800 SKmPPE 10/1000 SKmPPE 15/1500 AQUAFIX Stee G AQUAFIX PP AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , , Item No. Instaation Instructions 69
70 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P 70
71 Grease Separator Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX Stee k 71
72 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX FPE Grease separator FPE 02 FPE 04 FPE 07 Length Width Height Externa diameter Fow performance /s FPE FPE FPE FPE FPE
73 FPE 10 FPE 15 AQUAFIX PP AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX Stee k Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , , Item No. Instaation Instructions 73
74 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX SFPE Grease separator with sudge trap SFPE 02/0200 SFPE 04/0400 Length Width Height Externa diameter Fow performance /s SFPE 02/ SFPE 04/ SFPE 07/ SFPE 10/
75 SFPE 07/0700 SFPE 10/1000 Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , Item No. Instaation Instructions AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX PP AQUAFIX Stee k 75
76 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P 76
77 Starch Separator Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX Stee k 77
78 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX SaPE Starch separator SaPE 01 SaPE 02 Length Width Height Externa diameter Fow performance /s SaPE SaPE SaPE SaPE
79 SaPE 03 SaPE 04 AQUAFIX Stee G Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , Item No. AQUAFIX PP Instaation Instructions AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 79
80 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P 80
81 Battery acid neutraiser Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX Stee G AQUAFIX concrete AQUAFIX Stee k 81
82 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PE, series P AQUAFIX NPE Battery acid neutraiser NPE 03 NPE 04 Length Width Height Externa diameter Fow performance /s NPE NPE NPE NPE
83 NPE 05 NPE 06 AQUAFIX Stee G Sudge trap Separator DN/OD in-/outet HE H inet HA H outet 1 2 Weight kg , , , , Item No. AQUAFIX PP Instaation Instructions AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 83
84 CIVILS LANDSCAPING AQUA SPORT Accessories for separators made of PE, series P AQUAFIX Covers Cover for muti-functiona shaft, PE, c. B 125 Length Width Height Weight kg Cover for muti-functiona shaft, PE, c. B , Item No. 84
85 AQUAFIX Extension parts Shaft extension PE, max. height 1000 Length Width Height Weight kg Frame for shaft cover PE, height , Shaft extension PE, max. height , Item No. Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k 85
86 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series PP made of poypropyene One system for a cases. 86
87 At a gance: 6 to 12 wa thickness ight instaation on site is possibe without crane high stabiity (sef standing construction) 87
88 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Series PP made of poypropyene One system for a cases. Features 6 to 12 wa thickness stop rings to hande in horizonta and vertica position buoyancy protection according to standards EN 858 or EN 1825 wide openings for ight iquid separators: automatic cosing device easy to remove coescence ce easy to remove sampe taking device can be integrated Extensions Extension 500 incuded, adjustment rings 500 can be suppied. Covers in cass A or D avaiabe. 88
89 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 89
90 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PP, series H AQUAFIX SPP Sudge trap SPP 0600/06 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SPP 0600/ , SPP 1000/ , SPP 2500/ , SPP 1500/ , SPP 2000/ , SPP 2500/ , Item No. 90
91 AQUAFIX KPP Coaescence separator KPP 04 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg KPP , KPP , KPP , KPP , KPP , Item No. Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k 91
92 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PP, series H AQUAFIX SKPP Coaescence separator with sudge trap SKPP 04/0400 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SKPP 04/ , SKPP 06/ , SKPP 06/ , SKPP 10/ , SKPP 10/ , SKPP 15/ , SKPP 15/ , SKPP 20/ , SKPP 20/ , Item No. 92
93 AQUAFIX SKBPPP Coaescence separator with sudge trap and bypass SKBPPP 10/1000 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SKBPPP 10/ , SKBPPP 15/ , Item No. Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX concrete AQUAFIX 10 PE AQUAFIX Stee k 93
94 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PP, series H AQUAFIX SK2BPPP Coaescence separator with sudge trap and doube bypass SK2BPPP 10/1000 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SK2BPPP 10/ , SK2BPPP 15/ , Item No. 94
95 Grease Separator Instaation Instructions AQUAFIX PP AQUAFIX Stee G AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 95
96 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separator made of PP, series H AQUAFIX FPP Grease separator FPP 02 Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg FPP , FPP , FPP , FPP , FPP 15/ , Item No. 96
97 AQUAFIX SFPP Grease separator with sudge trap SFPP 02/0200 AQUAFIX Stee G Length Width Height Externa diameter Fow performance /s Sudge trap Separator DN/ OD in-/ outet HE H inet HA H outet 1 2 Weight kg SFPP 02/ , SFPP 02/ , SFPP 04/ , SFPP 04/ , SFPP 07/ , SFPP 07/ , SFPP 10/ , SFPP 10/ , Item No. Instaation Instructions AQUAFIX concrete AQUAFIX 10 PE AQUAFIX PP AQUAFIX Stee k 97
98 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions & Exampes 98
99 99
100 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series G made of stee Instaation advice for AQUAFIX Separators series G made of stee 1. Pease check competeness of deivery and iediatey note any parts that are missing or were damaged in transit on the deivery note. Compaints received at a ater date wi not be accepted. Otherwise our genera business terms and conditions appy. 2. The separator must be instaed outside the washing areas where it wi not overfi or back up. It must aso be as cose as possibe to the source of the sewage, in the open but protected from the frost and easy to access with ceaning vehices. The outets and pipes must be abe to drain off. 3. The excavation base must be eve. If no suitabe soi is avaiabe a 10 thick compressed bed of sand or sma pebbes can be used. A foundation pate woud be even better. If the foundation soi is non-supporting, make a staticay dimensioned foundation pate. 4. Take thickness of base and correction ayer into consideration in height cacuations. Pay attention to height information in instaation drawing. 5. Tank must be instaed in a eve position. 6. The materia must be eve as it fows through the separator. Inets and outets must be correcty aigned. The inet and outet must not be the wrong way around! Use the correct gradient! Recoended tota gradient of system must be 2-5 %! 7. Insta system with top edge higher than ast inet point. 8. Pipeines must be connected without eaks. 9. After a tanks, tops, covers and connecting pipes have been correcty aigned, cean the system! 10. Before fiing up the system, fi a tanks with fresh water and check for eaks. The eak test is mandatory! 11. Do not modify tank or pipes again after fiing with sand and compressing. Pease refer to provided instaation drawing. 12. Attach concrete pate to provide buoyancy protection if necessary. 13. When fitting the dome shafts, ensure that the seas are correcty paced! Pease use an adequate quantity of ubricant. We recoend aying the shaft eements beneath each other in mortar. 14. With iquid separation systems: When fiing with fresh water, hod foat in raised position by hand unti it is abe to foat independenty. Report start-up to reevant authority. Aways foow accident prevention reguations during instaation! 100
101 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G Instaation Drawing 101
102 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 102
103 4 Abbidungen fogen Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 103
104 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 104
105 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 105
106 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series G made of stee Operation and maintenance of AQUAFIX ight iquid separators series G made of stee Before start-up 1. Cean entire system and remove residua mortar, soi etc. 2. Fi sudge trap and separator with fresh water.* Attention! Aways hod foat of sea in hand when fiing unti it can foat by itsef. Pease ensure that water eve is same in a chambers of tank, and fi in sequence! 3. Re-check joints of system for eaks. * Sudge trap in this type of system must be fied with fresh water. Operation As we as foowing the maintenance guide, the entire system must compy with the foowing reguations: DIN 1986 (estate drainage systems) EN 858 (ight iquid separators) Loca drainage reguations and other instructions Ony sewage that does not have a detrimenta effect on the intended operation of the separator must be ed into the system. Emusions and sovents (cod ceaners, driing and cutting oi, water-soube hydrocarbons etc.) must not be aowed to enter the separator. Dispose of these materias together with the specia waste. Rainwater from surfaces for which the separator was not intended and domestic sewage must not be ed into the separator. With coaescence separators: Do not remove coaescence insert during operation! The use of aarm systems with big stee AQUAFIX SKG, SKBP, SKGBP2 and SKGBPL separators is strongy recoended because of the arge quantity of ight iquid that is stored! Disposa Separator systems must be drained at east every six months, but shoud not be aowed to fi to more than 85% of their storage. Ceaning must occur more often if the storage of the separator or sudge trap is exceeded. Operation must not be interrupted. A separated materia must be drained, ceaned and taken away for disposa by an approved disposa company. Pease empty the separator and the sudge trap of this type of system at the same time if possibe. First extract the oi ayer from the system and then the ayer of water beneath it, into separate tanks if possibe. Cean foat and sea every time the system is emptied and check operation thereof. With coaescence separators: If the coaescence materia is soied, remove coaescence materia, cean above sudge trap, give damaged coaescence materia to disposa company and repace with new materia. Repace coaescence materia. The sudge trap has a coaescence chamber access fap for removing the coaescence materia. Refi system with fresh water whenever it is emptied and ceaned. Attention! Aways hod foat of sea by hand unti it is foating when fiing the system. Use mobie adder when entering the system. Extract air/vapour mixture beforehand. Take the reevant safety precautions! Foow the accident prevention reguations! In the event of torrentia rainfa, a sudden infux into the separator can occur with arge separators. When entering the system, prevent infux and pay attention to persona safety. 106
107 AQUAFIX Stee G Maintenance The separator must be serviced at east every 6 months. The system must be emptied to do this. Carefuy check that a system components are in good working order and undamaged. Then fi separator and sudge trap with water*, hod sea open by hand or insert ater. * Sudge trap in this type of system must be fied with fresh water. It is extremey important to foow the accident prevention reguations! Keep these instructions in a ceary visibe ocation in cose proximity to the separator! AQUAFIX Stee k AQUAFIX concrete Coaescence insert description and maintenance guide 1. Description: The coaescence insert consists of amear materia that is in the coaescence chamber. 2. Maintenance: The coaescence materia must be checked monthy for soiing. If the materia is difficut to rinse out, remove materia using the camp in the coaescence chamber that is accessibe from the sudge trap and cean. Repace materia with new materia if necessary. Then cose fap again. Do not remove coaescence materia during operation! Sea description and maintenance 1. Description: The separator outet is equipped with a sea. When the foat drops into the ight iquid ayer a seaing washer is pressed against the bottom end of the outet. When fiing the system with fresh water, hod foat in an eevated position by hand unti it can foat by itsef. 2. Maintenance: Important! The sea must be hed in an eevated position by hand by puing the foat unti the maximum water eve is reached. Do not reease foat unti it is foating in water, therefore reeasing the sea! AQUAFIX 10 PE AQUAFIX PP Instaation Instructions 107
108 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series k made of stee Instaation advice for AQUAFIX Separators series k made of stee 1. Pease check competeness of deivery and iediatey note any parts that are missing or were damaged in transit on the deivery note. Compaints received at a ater date wi not be accepted. Otherwise our genera business terms and conditions appy. 2. The separator shoud be instaed outside the washing areas where it wi not overfi or back up. It must aso be as cose as possibe to the source of the sewage, in the open but protected from the frost and easy to access with ceaning vehices. 3. The excavation base must be eve. If no suitabe soi is avaiabe a 10 thick compressed bed of sand or sma pebbes can be used. A foundation pate woud be even better. If the foundation soi is non-supporting, make a staticay dimensioned foundation pate. 4. Take thickness of base and correction ayer into consideration in height cacuations. Pay attention to height information in instaation drawing. 5. Tank must be instaed in a eve position. 6. The materia must be eve as it fows through the separator. The inet and outet must be correcty aigned. 7. Insta system with top edge higher than ast inet point. 8. Attach buoyancy protector if necessary and anchor it in the foundation pate. 9. Pipeines must be connected without eaks. 10. After correcty aigning a tanks, tops, covers and connecting pipes, cean the system! 11. Before fiing up the system, fi a tanks with fresh water and check for eaks. The eak test is mandatory! 12. Do not modify tank or pipes again after fiing with sand and compressing. Pease refer to provided instaation drawing. 13. Attach concrete pate to provide buoyancy protection if necessary. 14. With iquid separation systems: When fiing with fresh water, hod foat in raised position by hand unti it is abe to foat independenty. Report start-up to reevant authority. Aways foow accident prevention reguations during instaation! 108 The inet and outet must not be the wrong way around! Use the correct gradient! Recoended tota gradient of system must be 2-5 %!
109 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G Instaation Drawing 109
110 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 110
111 Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 111
112 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series k made of stee Operation and maintenance of AQUAFIX ight iquid separators series k made of stee Before start-up 1. Cean entire system and remove residua mortar, soi etc. 2. Fi sudge trap and separator with fresh water.* Attention! Aways hod foat of sea in hand when fiing unti it can foat by itsef. Pease ensure that water eve is same in a chambers of tank, and fi in sequence! 3. Re-check joints of system for eaks. * Sudge trap in this type of system must be fied with fresh water. Operation As we as foowing the maintenance guide, the entire system must compy with the foowing reguations DIN 1986 (estate drainage systems) EN 858 (ight iquid separators) Loca drainage reguations and other instructions Ony sewage that does not have a detrimenta effect on the intended operation of the separator must be ed into the system. Emusions and sovents (cod ceaners, driing and cutting oi, water-soube hydrocarbons etc.) must not be aowed to enter the separator. Dispose of these materias together with the specia waste. Rainwater from surfaces for which the separator was not intended and domestic sewage must not be ed into the separator. With coaescence separators: Do not remove coaescence insert during operation! Sea description and maintenance 1. Description: The separator outet is equipped with a sea. When the foat drops into the ight iquid ayer a seaing washer is pressed against the bottom end of the outet. When fiing the system with fresh water, hod foat in an eevated position by hand unti it can foat by itsef. 2. Maintenance: Important! The sea must be hed in an eevated position by hand by puing the foat unti the maximum water eve is reached. Do not reease foat unti it is foating in water, therefore reeasing the sea! Keep these instructions in cose proximity to the separator! Disposa Separator must be drained at east every six months, but shoud not be aowed to fi to more than 85% of its storage. Ceaning must occur more often if the storage of the separator or sudge trap is exceeded. Operation must not be interrupted. A separated materia must be drained, ceaned and taken away for disposa by an approved disposa company. Pease empty the separator and the sudge trap of this type of system at the same time if possibe. First extract the oi ayer from the system and then the ayer of water beneath it, into separate tanks if possibe. Cean foat and sea every time the system is emptied and check operation thereof. With coaescence separators: If the coaescence materia is soied, remove coaescence materia, cean above sudge trap, give damaged coaescence materia to disposa company and repace with new materia. Repace coaescence materia. Refi system with fresh water whenever it is emptied and ceaned. Attention! Aways hod foat of sea by hand unti it is foating when fiing the system. Use mobie adder when entering the system. Extract air/vapour mixture beforehand. Take the reevant safety precautions! Foow the accident prevention reguations! 112
113 AQUAFIX Stee G Maintenance Separator must be serviced at east every 6 months. System must be emptied to do this. Carefuy check that a system components are in good working order and undamaged. Then fi separator and sudge trap with water*, hod sea open by hand or insert ater. * Sudge trap of this type of system must be fied with fresh water. It is extremey important to foow the accident prevention reguations! Keep these instructions in cose proximity to the separator! Coaescence insert description and maintenance guide 1. Description: The coaescence insert consists of amear materia that is in the coaescence chamber. 2. Maintenance: The coaescence materia must be checked monthy for soiing. If it cannot be rinsed out easiy it must be removed and ceaned. Repace materia with new materia if necessary. Do not remove coaescence materia during operation! Operation and maintenance of AQUAFIX grease separators series k made of stee Before start-up Cean entire system and remove any residua mortar, soi etc. if necessary. Fi entire system with fresh water. Check joints of system for eaks. Operation As we as the maintenance guide, the foowing instructions must be foowed for the entire system: DIN 4040 (grease separation systems) DIN 1986 (estate drainage systems) Loca water remova reguations and other instructions Ony sewage that does not have a detrimenta effect on the intended operation of the separator must be ed to the separator. It is particuary important to prevent domestic sewage and ight minera iquids from entering the separator. Do not aow rainwater to enter the system. Keep these instructions in cose proximity to the separator! Disposa 1. Grease separators must be ceaned at east once per month, possiby more frequenty. Ceaning must take pace more frequenty if the separator or sudge trap storage is exceeded. The operation of the separator must not be affected. 2. Have a separated materia drained, ceaned and taken away by an approved disposa company. 3. Fi entire system with fresh water after it has been emptied and drained. 4. Use mobie adders when entering the system. Extract vapour/air mixture beforehand. Pay attention to accident prevention reguations! Maintenance The separator must be serviced at east once per month. The system must be drained and ceaned in order to do this. Carefuy check that a system components are in good working order and undamaged. Then refi system with fresh water. It is extremey important to observe the accident prevention reguations! Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 113
114 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series made of concrete (H/P) Instaation advice for AQUAFIX Separators series made of concrete (H/P) 1. Pease check competeness of deivery. Note any missing parts or transit damage that has occurred on the deivery note iediatey. Compaints that are received ater wi not be accepted. Otherwise our genera terms and conditions appy. 2. The separator system must be instaed in a ocation outside the washing areas where it wi not overfow or back up, as cose as possibe to the ocation where the waste water occurs. It must aso be in the open, frostfree and easiy accessibe for ceaning vehices. The drains and pipes must be abe to drain unti empty. 3. The base of the excavation must be eve. If no suitabe soi is avaiabe, create a 10 cm thick bed of sand and fine grave and compress. If the ground is non-oad bearing, make a staticay measured foundation sab. Put a 10 cm compensation ayer of sand onto the foundation sab. 4. Take thickness of foundation and compensation ayer into consideration during height measurements. Pay attention to height information in instaation drawing. 5. The tanks must be instaed in a eve position. Do not confuse the inet with the outet! Adhere to order of tanks! Maintain sope! Recoended tota incine of system 2-5%! 6. Insta system so that top edge is higher than fina admission point. 8. Arrange maintenance shaft at outet side such that a separator areas are accessibe and the foats and the coaescence insert can be removed if necessary. 9. Ensure that the seas are correcty paced! Pease use an adequate quantity of antiseize agent. It is advisabe to offset the reative positions of the shaft eements in mortar or using hose bearings. 10. The distance between the individua eements shoud be cm. 11. Ensure that pipeines are connected without eaks. 12. Fi a tanks with fresh water before fiing and check for eaks. This eak test is mandatory! 13. Do not ater positions of tanks and ines when fiing and compressing with sand. Pease pay attention to the provided drawing. 14. When a tanks, covering pates, tops and covers and connecting pipes have been correcty ocated, the system must be ceaned. 15. When fiing ight iquid separators with fresh water, hod foat in raised position unti it can foat independenty. Report start-up to the responsibe authority. Pay attention to accident prevention reguations during instaation! 7. Manua transport on side can be done easiy with stee bars which can be put through the hoes of the outer stop rings. 114
115 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G Instaation Drawing 115
116 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 116
117 Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 117
118 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 118
119 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 119
120 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series made of concrete (H/P) Operation and maintenance of AQUAFIX ight iquid separators series made of CONCRETE (H/P) Before start-up 1. Cean the entire system and remove mortar residue, soi etc. Remove ock during this operation and (if separator is a coaescence separator) remove the coaescence insert and repace them again afterwards. 2. Fi sudge trap and separator with fresh water. Attention! Aways hod ock in raised position when fiing, or repace when fiing is compete. 3. Re-check tightness of joints in the system. Operation As we as the maintenance guide, the foowing reguations must be observed for the entire system: DIN 1986 (Land drainage systems) DIN 1999 (Light iquid separating systems) EN 858 (Light iquid separating systems) Loca drainage statutes and other reguations Ony waste water that does not affect the intended operation of the separator must be ed to the separating system. Emusions and sovents (cod ceaners, driing and cutting ois, water-soube hydrocarbons etc.) must be kept away from the separating system and disposed of as specia waste. Rainwater from surfaces for which the separating system is not intended and domestic waste water must not be ed to the separating system. Do not remove coaescence insert during operation! The separated materia must ony be emptied, ceaned and taken away by authorised disposa companies. The oi ayer and water beneath it must be extracted first, preferaby into separate tanks. The foat and the ock must be ceaned and the operation thereof checked every time the equipment is emptied. Remove coaescence insert, cean the sudge trap, give damaged coaescence materia to the disposa company and repace with new materia. Re-insert the coaescence insert. Every time that the equipment is emptied and ceaned, refi system with fresh water. Hod ock open by hand when doing this or insert it again afterwards. Use mobie adders when cimbing into the system. Extract vapour/ air mixture beforehand. 120 Disposa Separating systems must be emptied at east every six months uness otherwise stipuated by the monitoring authority, but no ater than when 85% of the storage has been reached. The ceaning intervas must be shorter if the storage of the separator or the sudge trap is exceeded. The operation of the equipment must not be interrupted. Servicing The separator system must be serviced at east every 6 months. The system may need to be emptied to do this. Carefuy check operation of a parts of the system and inspect for damage. Then fi separator and sudge trap with fresh water, hod ock open by hand or insert afterwards. Pay attention to accident prevention reguations!
121 AQUAFIX Stee G Operation and maintenance of AQUAFIX ight iquid separators series made of CONCRETE (H/P) Before start-up Cean the entire system and remove mortar residue, soi etc. Fi entire system with fresh water. Check joints of system for eaks. Operation As we as the maintenance guide, the foowing reguations must be observed for the entire system: DIN 1986 (Land drainage systems) DIN 1999 (Light iquid separating systems) EN 858 (Light iquid separating systems) Loca drainage statutes and other reguations Ony waste water that does not affect the intended operation of the separator must be ed to the separating system. Particuary domestic waste water and minera ight iquids must be kept away from the separating system, nor must rainwater be ed to the separating system. Disposa 1. The separating systems must be ceaned at east every 14 days more frequenty if necessary. The ceaning intervas must be shorter if the storage of the separator or the sudge trap is exceeded. The operation of the equipment must not be interrupted. 2. The separated materia must ony be emptied, ceaned and taken away by authorised disposa companies. 3. Every time that the equipment is emptied and ceaned, refi system with fresh water. 4. Use mobie adders when cimbing into the system. Extract vapour/air mixture beforehand. Pay attention to accident prevention reguations! Servicing The separator system must be serviced at east every 14 days. The system must be emptied and ceaned to do this. Carefuy check operation of a parts of the system and inspect for damage. Then fi the system with fresh water. Pay attention to accident prevention reguations! Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 121
122 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series 10 PE made of poypropyene Instaation advice for AQUAFIX Separators series 10 PE made of poypropyene Instaation in frequented areas. 1. The system must be instaed beow ground. 2. Pace the system on a stabe base (concrete) in a horizonta position. 3. Connect the inet and the outet to the sewage system. 4. Connect the height adaptation equipment if necessary, and adjust the height thereof depending on the nature of the terrain. 5. Fi the system with cean water, packing ayers of sand around the equipment. 6. If the system is being instaed in a frequented area a 400 kn cast iron cover must be provided. The cast iron id is attached to the sef-supporting concrete base and seaed, whereby the edge of the foor (height and reinforcement must be cacuated) serves as a base. 7. Manua transport on side can be done easiy with stee bars which can be put through the hoes of the outer stop rings. 122 Instaation outside frequented areas. 1. The system must be instaed beow ground. 2. Pace the system on a compressed earth or concrete base in a horizonta position. 3. Connect the inet and the outet to the sewage system. 4. If necessary, attach the height adapter and adjust the height thereof depending on the nature of the top edge of the ground. 5. Fi the system with cean water, packing ayers of sand down around the system. 6. If severa height adapters are required, a sef-supporting concrete base must be made (base height and reinforcement must be cacuated). 7. Manua transport on side can be done easiy with stee bars which can be put through the hoes of the outer stop rings.
123 Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 123
124 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 124
125 Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 125
126 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 126
127 Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 127
128 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series 10 PE made of poypropyene Operation and maintenance of AQUAFIX ight iquid separators series 10 PE made of poypropyene Operation and maintenance of AQUAFIX grease separator series 10 PE made of poypropyene Before start-up 1. Cean entire system and remove residua mortar, soi etc. 2. Fi sudge trap and separator with fresh water. Pease ensure that water eve is same in a chambers of tank, and fi in sequence! 3. Re-check joints of system for eaks. Operation Separator must be drained at east every six months, but shoud not be aowed to fi to more than 85% of its storage. Ceaning must occur more often if the storage of the separator or sudge trap is exceded. Operation must not be interrupted. A separated materia must be drained, ceaned and taken away for disposa by an approved disposa company. Pease empty the separator and the sudge trap of this type of system at the same time if possibe. First extract the oi ayer from the system and then the ayer of water beneath it, into separate tanks if possibe. Cean foat and sea every time the system is emptied and check operation thereof. With coaescence separators: If the coaescence materia is soied, remove coaescence materia, cean above sudge trap, give damaged coaescence materia to disposa company and repace with new materia. Repace coaescence materia. Refi system with fresh water whenever it is emptied and ceaned. Before start-up Cean entire system and remove any residua mortar, soi etc. if necessary. Fi entire system with fresh water. Check joints of system for eaks. Operation As we as the maintenance guide, the foowing instructions must be foowed for the entire system: EN 1825 Grease separating systems Loca water remova reguations and other instructions Ony sewage that does not have a detrimenta effect on the intended operation of the separator must be ed to the separator. It is particuary important to prevent domestic sewage and ight minera iquids from entering the separator. Do not aow rainwater to enter the system. Disposa 1. Grease separators must be ceaned at east once per month, possiby more frequenty. Ceaning must take pace more frequenty if the separator or sudge trap storage is exceeded. The operation of the separator must not be affected. 2. Have a separated materia drained, ceaned and taken away by an approved disposa company. 3. Fi entire system with fresh water after it has been emptied and drained. 4. Use mobie adders when entering the system. Extract vapour/air mixture beforehand. Pay attention to accident prevention reguations! 128 Maintenance The separator must be serviced at east once per month. The system must be drained and ceaned in order to do this. Carefuy check that a system components are in good working order and undamaged. Then refi system with fresh water. It is extremey important to observe the accident prevention reguations!
129 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 129
130 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series PP made of poypropyene Instaation advice for AQUAFIX ight iquid separators series PP made of poypropyene Instaation in a frequented area 1. The system must be instaed beow ground. Instaation outside frequented areas. 1. The system must be instaed beow ground. 2. Pace the system on a stabe base (concrete) in a horizonta position. 2. Pace the system on a compressed earth or concrete base in a horizonta position. 3. Connect the inet and the outet to the sewage system. 3. Connect the inet and the outet to the sewage system. 4. Connect the height adaptation equipment if necessary, and adjust the height thereof depending on the nature of the terrain. 5. Fi the system with cean water, packing ayers of sand around the equipment. 6. If the system is being instaed in a frequented area a 400 kn cast iron cover must be provided. The cast iron id is attached to the sefsupporting concrete base and seaed, whereby the edge of the foor (height and reinforcement must be cacuated) serves as a base. 4. Connect the ventiation (diam. 50 ). 5. If necessary, attach the height adapter and adjust the height thereof depending on the nature of the top edge of the ground. 6. Fi the system with cean water, packing ayers of sand down around the system. 7. If severa height adapters are required, a sefsupporting concrete base must be made (base height and reinforcement must be cacuated). 130
131 Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G Instaation Drawing 131
132 CIVILS LANDSCAPING AQUA SPORT Instaation Drawing 132
133 Instaation Drawing Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k AQUAFIX Stee G 133
134 CIVILS LANDSCAPING AQUA SPORT AQUAFIX Separators Instaation Instructions Separators series PP made of poypropyene Operation and maintenance of AQUAFIX ight iquid separators series PP made of poypropyene Before start-up 1. Cean entire system and remove residua mortar, soi etc. 2. Fi sudge trap and separator with fresh water. Pease ensure that water eve is same in a chambers of tank, and fi in sequence! 3. Re-check joints of system for eaks. Operation As we as foowing the maintenance guide, the entire system must compy with the foowing reguations: EN 858 (Light iquid separating systems) Loca drainage statutes and other instructions Pease empty the separator and the sudge trap of this type of system at the same time if possibe. First extract the oi ayer from the system and then the ayer of water beneath it, into separate tanks if possibe. Cean foat and sea every time the system is emptied and check operation thereof. With coaescence separators: If the coaescence materia is soied, remove coaescence materia, cean above sudge trap, give damaged coaescence materia to disposa company and repace with new materia. Repace coaescence materia. Refi system with fresh water whenever it is emptied and ceaned. Ony sewage that does not have a detrimenta effect on the intended operation of the separator must be ed into the system. Emusions and sovents (cod ceaners, driing and cutting oi, water-soube hydrocarbons etc.) must not be aowed to enter the separator. Dispose of these materias together with the specia waste. Rainwater from surfaces for which the separator was not intended and domestic sewage must not be ed into the separator. With coaescence separators: Do not remove coaescence insert during operation! Disposa Separator must be drained at east every six months, but shoud not be aowed to fi to more than 85% of its storage. Ceaning must occur more often if the storage of the separator or sudge trap is exceeded. Operation must not be interrupted. A separated materia must be drained, ceaned and taken away for disposa by an approved disposa company. 134
135 AQUAFIX Stee G Operation and maintenance of AQUAFIX Separators series PP made of poypropyene Before start-up Cean entire system and remove any residua mortar, soi etc. if necessary. Fi entire system with fresh water. Check joints of system for eaks. Operation As we as the maintenance guide, the foowing instructions must be foowed for the entire system: EN 1825 Grease separating systems Loca water remova reguations and other instructions Ony sewage that does not have a detrimenta effect on the intended operation of the separator must be ed to the separator. It is particuary important to prevent domestic sewage and ight minera iquids from entering the separator. Do not aow rainwater to enter the system. Disposa 1. Grease separators must be ceaned at east once per month, possiby more frequenty. Ceaning must take pace more frequenty if the separator or sudge trap storage is exceeded. The operation of the separator must not be affected. 2. Have a separated materia drained, ceaned and taken away by an approved disposa company. 3. Fi entire system with fresh water after it has been emptied and drained. 4. Use mobie adders when entering the system. Extract vapour/air mixture beforehand. Pay attention to accident prevention reguations! Maintenance The separator must be serviced at east once per month. The system must be drained and ceaned in order to do this. Carefuy check that a system components are in good working order and undamaged. Then refi system with fresh water. It is extremey important to observe the accident prevention reguations! Instaation Instructions AQUAFIX PP AQUAFIX 10 PE AQUAFIX concrete AQUAFIX Stee k 135
136 HAURATON partner 07/2017 Printed in Germany A drawings, Measurements and weights are noncoitta! We reserve the right to do technica changes for improvement EN Hauraton HAURATON GmbH GmbH & Co. & Co. KG KG Werkstraße Werkstraße e Rastatt Rastatt Germany Germany Te Te Fax Fax info@hauraton.com export@hauraton.com aton.com
AUTOMATIC MARINE AND RV TOILETS
AUTOMATIC MARINE AND RV TOILETS 1 THE INVENTOR, DESIGNER AND MANUFACTURER SINCE 1958, SFA SANIFLO IS THE WORLD S LEADER OF MACERATING TOILETS FOR THE MARINE AND RECREATIONAL VEHICLE INDUSTRIES Speciay
More informationGas services renewal programme
Customer information Gas services renewa programme gasnetworks.ie Introduction Gas Networks Ireand constructs and extends the natura gas network in Ireand to the highest safety standards. We deiver natura
More informationPortable Compressors MOBILAIR M 52 / M 64 With the world-renowned SIGMA PROFILE Free air delivery 5.2 / 6.4 m³/min.
Portabe Compressors MOBILAIR M 52 / M 64 With the word-renowned SIGMA PROFILE Free air deivery / 6.4 m³/min www.kaeser.com Made in Germany KAESER s renowned MOBILAIR range of portabe compressors is manufactured
More informationBULLETIN ENERVAC CORPORATION. Engineers and Manufacturers of AND
BULLETIN ENERVAC CORPORATION Engineers and Manufacturers of -- AND ENERVAC SEAL OIL Vacuum Purification System Dehydrates Fiters Purifies De Aerates Degasifies Miions of gaons of good grade turbo-compressor
More informationPortable Compressors MOBILAIR M 52 / M 64 With the world-renowned SIGMA PROFILE Free air delivery 5.2 / 6.4 m³/min.
Portabe Compressors MOBILAIR M 52 / M 64 With the word-renowned SIGMA PROFILE Free air deivery / 6.4 m³/min www.kaeser.com Made in Germany KAESER s renowned MOBILAIR range of portabe compressors is manufactured
More informationThe Home of Control & Automation in Ireland. Monsoon
The Home of Contro & Automation in Ireand Monsoon Monsoon offers the most comprehensive range of premium quaity brass periphera pumps avaiabe on the market. Its wide range means that it is capabe of boosting
More informationSports & Recreation Products
Sports & Recreation Products This brochure gives a simpified overview of our products for sports and recreationa use. More detaied photos, drawings in pdf and CAD format, specifications and Q.40s are avaiabe
More informationPortable Compressors MOBILAIR M 36 / M 45 With the world-renowned SIGMA PROFILE Free air delivery 3.6 to 4.2 m³/min.
Portabe Compressors MOBILAIR M 36 / M 45 With the word-renowned SIGMA PROFILE Free air deivery 3.6 to m³/min www.kaeser.com Made in Germany KAESER s renowned MOBILAIR range of portabe compressors is manufactured
More informationGerman / British / Japanese Medical Gas Outlets
S o utio ns for Life German / British / Japanese Medica Gas Outets 38X6 / 38X7 / 38X8 Coor-coded for easy gas service identification Moduar structure, convenient maintenance German (DIN) Gas Outet is CE
More informationOperating Instructions OPTISWITCH 3000 C with two-wire output
Operating Instructions OPTISWITCH 3000 C with two-wire output Contents Contents 1 About this document 1.1 Function... 4 1.2 Target group... 4 1.3 Symboism used... 4 2 For your safety 2.1 Authorised personne...
More informationThe Plug-In Connector. BEULCONNECT. For water and gas A11. made in Germany 2018.
2018.1 The Pug-In Connector. BEULCONNECT. For water and gas. --------------------------------------------------------- made in Germany A11 MINIMUM EFFORT. MAXIMUM EFFECT. The Pug-In Connector - A11 For
More informationOperating Instructions OPTISWITCH 3100 C with two-wire output
Operating Instructions OPTISWITCH 3100 C with two-wire output Contents Contents 1 About this document 1.1 Function... 4 1.2 Target group... 4 1.3 Symboism used... 4 2 For your safety 2.1 Authorised personne...
More informationOperating Instructions OPTISWITCH 3300 C with two-wire output
Operating Instructions OPTISWITCH 3300 C with two-wire output Contents Contents 1 About this document 1.1 Function... 4 1.2 Target group... 4 1.3 Symboism used... 4 2 For your safety 2.1 Authorised personne...
More informationPRACTICAL APPLICATION OF STATIC HAZARD ASSESSMENT FOR DSEAR COMPLIANCE
PRACTICAL APPLICATION OF STATIC HAZARD ASSESSMENT FOR DSEAR COMPLIANCE Graeme R Eis, Senior Safety Consutant ABB Engineering Services, Daresbury Park, Daresbury, Warrington, Cheshire WA4 4BT, UK KEYWORDS:
More informationGas Hazard Solutions. Marine Industry. MED approved. Single gas & multigas options. Easy one-button operation. Compact & rugged
Gas Hazard Soutions Marine Industry MED approved Singe gas & mutigas options Easy one-button operation Compact & rugged MED Approved Portabe Detection When ives and property are at risk and you need gas
More information500 SERIES ADVANTAGES
K-FLO 00 SERIES Sizes -20 K-FL O B U T T E R F L Y V A L V E S 00 SERIES: SIZES -20 AWWA C0 Compiant he K-Fo 00 Series is a heavy-duty resiient seated butterfy vave ine in fu compiance with AWWA C0 for
More informationProduct Information. Hydrostatic Submersible pressure transmitter VEGABAR 86, 87 VEGAWELL 52
Product Information Hydrostatic Submersibe pressure transmitter VEGABAR 86, 87 VEGAWELL 5 Contents Contents Measuring principe.......................................................................................
More informationThe. Future of. Surfing
The Future of Surfing AMERICANWAVEMACHINES.COM LARGE SCALE WAVE AND SURF POOLS AWM s patented PerfectSwe is an entirey new approach to generating waves with the emphasis on the surfing experience: wave
More informationThermal-Links (Thermal Cutoffs)
Pb-Free Cd-Free New Product Circuit Components Business Unit 401 Sadamasa-cho, Fukui City 910-82, Japan A0408-1 freecd-free Axicia Lead Radia Lead in-type Form Eectrica rating E series 2V 0.5A F series
More informationZAXIS DASH-5 ultrashort-class EXcAVAtorS. ZX85uSB kw (56.9 net hp)
ZAXIS DASH-5 utrashort-cass EXcAVAtorS ZX85uSB-5 42.4 kw (56.9 net hp) ZX85uSB-5 ZAXIS DASH-5 utrashort-cass EXCAVAtorS Engine Manufacturer and Mode Yanmar 4TNV98C-WHBW Non-Road Emission Standard EPA Fina
More informationC-21 C-22. Gases and liquids ~0.4 ±5 Rc 1/ It is general data, and the maximum temperature may change by terms of use and environment.
TO MATA CONSTANT FOW C Series PURGE SET FOWMETER WITH CONSTANT FOW VAVE GENERA C series Constant Flow Valves keep flow rate of gases or liquids even when the supply or load pressure changes. Control valve
More informationOperation Guide 3283
MO1104-EA Operation Guide 3283 About This Manua (Light) Depending on the mode of your watch, dispay text appears either as dark figures on a ight background or ight figures on a dark background. A sampe
More informationUltimate Comfort Smart. Made by Ritter Germany
S M A R T S O L U T I O N S Utiate Cofort Sart Made by Ritter Gerany 2 S M A R T Q U A L I T Y Made by Ritter Gerany Cofort and Quaity The patient chair is synchronized and is eectric driven. An ergonoic
More informationOperating Instructions VEGAVIB 63 with relay output
Operating Instructions VEGAVIB 63 with reay output Contents Contents 1 About this document 1.1 Function... 4 1.2 Target group... 4 1.3 Symboism used... 4 2 For your safety 2.1 Authorised personne... 5
More informationFrequency of Regulatory Inspections. Hernández, D.G.; Tellería, D.M. and Jordan, O.D.
Frequency of Reguatory Inspections Hernández, D.G.; Teería, D.M. and Jordan, O.D. Presentado en: Internationa Conference on the Safety of Radiation Sources and the Security of Radioactive Materias. Dijon,
More informationKerk Lead-screw Assemblies: Lead-Screws Ø 1/8 to 15/16-in (3.2 to 23 mm)
Kerk -screw Assebies: -Screws Ø 1/8 to 15/16-in (3.2 to 23 ) Kerk -screws are anufactured fro 303 stainess stee and are produced with Kerk s excusive precision roing process. Kerk ead-screws are avaiabe
More informationVariable Displacement Pump (A)A10V Series-31
Variabe Dispacement Pump (A)A10V eries31 Industria & Mobie, inge & Thru haft Modes, A10V / AA10V 18, 28, 45, 71, 100 & 140 Variabe Dispacement Pump (A)A10V, eries 31 Features Axia piston pump A10V in swashpate
More informationOperating Instructions VEGABAR 64
Operating Instructions VEGABAR 64 4... 20 ma/hart p Process pressure/ Hydrostatic Contents Contents 1 About this document 1.1 Function............................. 5 1.2 Target group..........................
More informationPart Number Description Dimensions Shipping Weight Package Qty.
Fiber Optic Products Encosures...............................40-41 Adapter Panes..............................42 Fiber Spice Tray.............................42 Fiber Optic Cabe Assembies...................43
More informationOperating Instructions VEGAPULS 67 Foundation Fieldbus
Operating Instructions VEGAPULS 67 Foundation Fiedbus Radar Contents Contents 1 About this document 1.1 Function... 5 1.2 Target group... 5 1.3 Symboism used... 5 2 For your safety 2.1 Authorised personne...
More informationOperating Instructions VEGAPULS 67 Profibus PA
Operating Instructions VEGAPULS 67 Profibus PA Radar Contents Contents 1 About this document 1.1 Function... 5 1.2 Target group... 5 1.3 Symboism used... 5 2 For your safety 2.1 Authorised personne...
More informationOperating Instructions VEGASON 61
Operating Instructions VEGASON 61 4 20 ma/hart Utrasonic Contents Contents 1 About this document 1.1 Function............................. 5 1.2 Target group.......................... 5 1.3 Symboism used.......................
More informationROTAMAT Rotary Drum Fine Screen Ro 2 / RPPS
WASTE WATER Solutions ROTAMAT Rotary Drum Fine Screen Ro 2 / RPPS Reliable and well-proven inlet screen for municipal sewage treatment plants and industrial wastewater and process water screening with
More informationJackson Safety * Nemesis* Eyewear. Stylish Comfort. Lasting Protection.
Jackson Safety * Nemesis* Eyewear Styish Comfort. Lasting Protection. Jackson Safety* Nemesis* Eyewear Styish Comfort. Lasting Protection. There s a reason why Jackson Safety* Nemesis* Eyewear is one of
More informationHUBER Rotary Drum Fine Screen ROTAMAT Ro2 / RPPS / STAR
WASTE WATER Solutions HUBER Rotary Drum Fine Screen ROTAMAT Ro2 / RPPS / STAR Reliable and well-proven inlet screen for municipal sewage treatment plants and industrial wastewater and process water screening
More informationDECISION OF THE ENDURANCE COMMITTEE
DECISION OF THE ENDURANCE COMMITTEE To: Teams Manufacturers Category: LM P1 LM P2 LM GTE Pro LM GTE Am Decision N : 15D0030LMP1 Date: 29/07/2015 Re: EoT Mission concerned Artice: Appendix B Decision 2015
More informationOperation Guide 3022
MO0912-EB Getting Acquainted Congratuations upon your seection of this CASIO watch. To get the most out of your purchase, be sure to read this manua carefuy. Appications The buit-in sensors of this watch
More informationKISS Polymers MegaGuard Ultra*
KISS Poymers MegaGuard Utra* Product Summary The Latest Technoogy in Non-Stick Protective Coatings MegaGuard Utra* is the atest technoogy in ow-drag protective surface coatings. MegaGuard Utra protects
More information15th EDBF EUROPEAN CLUB CREW CHAMPIONSHIPS INFORMATION BULLETIN No. 3
15th EDBF EUROPEAN CLUB CREW CHAMPIONSHIPS 2013 Hamburg, Germany 23, 24 and 25 August 2013 INFORMATION BULLETIN No. 3 This buetin contains additiona detais on the 15 th EDBF ECCC Hamburg, Germany, incuding
More informationChapter 11 Mass Transfer by Diffusion
Chapter 11 Mass Transfer by Diffusion Theory As with heat transfer, the rate of the transferred quantity in mass transfer is proportiona to the driving force and inversey proportiona to the resistance.
More informationQuick Reference. WARNING & l ALL RANGES CAN. Table of Contents:
@- A WARNING & ALL RANGES CAN TIP INJURY TO PERSONS COULD RESULT INSTALL ANTI-TIP DEVICE PACKED WITH RANGE SEE INSTALLATION INSTRUCTIONS Quick Reference Tabe of Contents: Pages 111 Before you start m piiziq
More informationOverview of the CONDUITS framework
Overview of the CONDUTS framework CONDUTS training workshop 26 November 2014 Madrid oannis Kaparias, City University London Niv Eden, Technion srae nstitute of Technoogy Outine CONDUTS KPs framework Requirements
More informationINDUSTRIAS IBAIONDO, HYDROPNEUMATIC TANKS
IBAIONDO, HYDROPNEUMATIC TANKS IBAIONDO, INTRODUCTION Hydropneumatic tanks are designed to be used in potable water supply installations as a part of the pressure booster set in order to ensure the adequate
More informationExpert Hydrostatic Level Transmitters
Expert Hydrostatic s General Features MJK Expert hydrostatic level transmitters are designed for level measurement by submerging the transmitter in open channels, drains and tanks. Expert hydrostatic level
More informationOperating Instructions VEGACAL 63 Profibus PA
Operating Instructions VEGACAL 63 Profibus PA Contents Contents 1 About this document 1.1 Function... 4 1.2 Target group... 4 1.3 Symboism used... 4 2 For your safety 2.1 Authorised personne... 5 2.2 Appropriate
More informationMarking Guidelines 2010 examination June series. Biology Unit 6T A2 Investigative Skills Assignment. General Certificate of Education BIO6T/P10/MG
Genera Certificate of Education Bioogy Unit 6T A2 Investigative Skis Assignment BIO6T/P10/MG Marking Guideines 2010 examination June series WMP/Jun10/BIO6T/P10/MG Bioogy - AQA GCE Unit 6T/P/Marking Guideines/2010
More informationTarget disk flowmeter Series DP. Instructions manual DP65 DP500. R-MI-DP Rev.: 4 English version
Target disk flowmeter Series DP Instructions manual DP65 DP500 R-MI-DP Rev.: 4 English version PREFACE Thank you for choosing the flowmeter series DP from Tecfluid S.A. This instruction manual allows the
More informationValves. Diaphragm shut-off valves, kidney-type
Valves Diaphragm shut-off valves, kidney-type Application When leakage of even the smallest quantities must be avoided with certainty For maximum requirements to operating safety For maximum requirements
More informationOperating Instructions VEGABAR 14
Operating Instructions VEGABAR 14 p Process pressure Contents Contents 1 About this document 1.1 Function............................. 4 1.2 Target group.......................... 4 1.3 Symboism used.......................
More informationø40, ø50, ø63, ø80, ø100, ø125, ø140, ø160
Lock-up Cyinder Doube Acting, Singe Rod Series ø, ø, ø, ø, ø, ø, ø1, ø The series ock-up cyinder is a sef-ocking type that contains a ring that is tited by a spring force, which is further tited by the
More informationInstallation and Operating Instructions Bypass Flow Meter DST
Installation and Operating Instructions Bypass Flow Meter DST DST_gb_A4_1.0.doc Version 1.0 1 von 10 Contents 1. Foreword... 3 2. Safety... 3 2.1. Symbol and meaning... 3 2.2. General safety directions
More informationHBI6X/PM1. General Certificate of Education Advanced Level Examination June A2 Externally Marked Practical Assignment.
Centre Number Surname Candidate Number For Examinerʼs Use Tota Task 1 Other Names Candidate Signature Genera Certificate of Education Advanced Leve Examination June 2013 Human Bioogy HBI6X/PM1 Unit 6X
More informationOperating Instructions VEGACAP 27 - double relay (DPDT)
Operating Instructions VEGACAP 27 - doube reay (DPDT) Capacitive Contents Contents 1 About this document 1.1 Function............................. 5 1.2 Target group.......................... 5 1.3 Symboism
More informationFOOD PAILS FOR INSTITUTIONAL AND COMMERCIAL APPLICATIONS
FOOD PAIS FOR INSTITUTIONA AND COMMERCIA APPICATIONS BECAUSE THERE IS NO ONE-SIZE-FITS-A! Your products and operations are unique, so IP offers a wide variety of pails and containers for every need no
More informationCruzPro WSD110. Wind Speed/Direction Display with Data Logging functions
CruzPro WSD110 O Wind Speed/Direction Dispay with Data Logging functions Tabe of Contents Introduction............................ 3 Specifications........................... 4 Instaation.............................
More informationThe Importance of Bicycling and Bicyclists Needs
Chapter 2 The Importance of Bicycing and Bicycists Needs The overa goa of the adopted regiona transportation pan is to provide an integrated, a-mode transportation system, which offers the efficient, effective,
More informationSPECIFICATION // DATA SHEET WATER DRAIN VALVE AM SENSORS LTD AMS-S-084/DS/ (ISSUE 1)
SPECIFICATION // DATA SHEET WATER DRAIN VALVE 1 Introduction The Water Drain Valve was developed for a major oil company to detect the presence of fuel when discharging water through the drain line of
More informationWastewater combination air valve in stainless steel AISI 316 Mod. SCS
Wastewater combination air valve in Mod. SCS The air valve guarantees the proper operation of sewage/industrial lines allowing the entrance of large quantity of air in case of pipe bursting or draining,
More informationPressure reducing valves Index
Index General information page Introduction 506 General introduction 507 for a steam plant 509 Product information BSP thread page Brass 510 ; BSP female thread 511 ; BSP male thread 513 Stainless steel
More informationBIMBAR INFLATABLE PACKERS AND ACCESSORIES
BIMBAR INFLATABLE PACKERS AND ACCESSORIES Geopro supplies a complete range of inflatable packers in nine different diameters from 28 up to 170mm. All our packers made of BIMBAR rubber technology are reinforced
More informationThe Pursuit of Excellence and an Active Lifestyle
The Pursuit of Exceence and an Active Lifestye s oo Water P Term g n o L o Guide t Ath ment p o e v e ete D OFFICIALS COACHES Long-Term Athete Deveopment COMPETITIONS BLUE Exceence ORANGE Competitive for
More informationPressure and Flow Control Valves DBGM, German and European Patents
Pressure and Flow Control Valves DBGM, German and European Patents Absolutely Reliable Pressure and Flow Control In water mains of sizes DN 50 to DN 150, ERHARD Control Valves in straight or angle pattern
More informationClassical style constructed roller skis and grip functionality
Avaiabe onine at www.sciencedirect.com Procedia Engineering 13 (2011) 4 9 5 th Asia-Pacific Congress on Sports Technoogy (APCST) Cassica stye constructed roer skis and grip functionaity Mats Ainegren *,
More informationOperating Instructions VEGAWELL 51
Operating Instructions VEGAWELL 51 4 20 ma p Process pressure/ Hydrostatic Contents Contents 1 About this document 1.1 Function............................. 4 1.2 Target group..........................
More informationDesign Data 22M. Flotation of Circular Concrete Pipe. w w I = w - x 1000 (3) (SG x 1000)
Design Data M Flotation of Circular Concrete Pipe There are several installation conditions where there is the possibility that concrete pipe may float even though the density of concrete is approximately.4
More informationDesiccant Air Breathers DBE. Section 3: TNK SCHROEDER INDUSTRIES ACCESSORIES 21
Desiccant Air Breathers DBE Section 3: SCHROEDER INDUSTRIES ACCESSORIES 21 Reservoir Accessories A hydraulic systems reservoir can play a significant role in the ingression of contamination into the system.
More informationOperation Guide 5497
MO1607-EA 2016 CASIO COMPUTER CO., LTD. Congratuations upon your seection of this CASIO watch. Appications The buit-in sensors of this watch measure direction, barometric pressure, temperature and atitude.
More informationLiquid level glasses, type LLG REFRIGERATION AND AIR CONDITIONING. Technical leaflet
Liquid level glasses, type LLG 185-1550 REFRIGERATION AND AIR CONDITIONING Technical leaflet Introduction LLG are liquid level glasses in ductile steel which meets the strictest requirements on industrial
More informationAirless-Spraying Equipment. SuperFinish31. Fully equipped. More power. Innovative QLS technology
Airless-Spraying Equipment SuperFinish31 Fully equipped More power Innovative QLS technology New technology, fully equipped with even more power. This is the new SuperFinish 31 Airless spraying equipment,
More informationAirless-spraying equipment. SuperFinish 23. Solid. Profitable. Innovative QLS technology
Airless-spraying equipment SuperFinish 23 Solid Profitable Innovative QLS technology The easily transported Airless spraying equipment for flexible use on the building site Innovative QLS technology reliable
More informationPressure relief valve DHV 716 set range: 0,5-10,0 bar
Pressure relief valve DHV 7 set range: 0,5-0,0 bar Advantage pressure setting possible at any time, also during operation optimum monitoring valves high reproducibility of the set pressure high level of
More informationRRF DELTA TUBE FLOW ELEMENTS
RRF DELTA TUBE FLOW ELEMENTS CONTENTS Page No. 1. Theory and Principe of Operation... 1. Introduction to Deta Tube... 3. Sizing and Seection of Probes... 3 4. Quick Seection Guide Deta Tube Fow Eements...
More informationPipeline Emergency Response. First Responder Training By Michael Callan
Pipeine Emergency Response First Responder Training By Michae Caan 1 Course Objectives At the competion of this training, individuas wi possess the foowing knowedge, skis, and abiities: 1. Awareness of
More informationTechnical Service Training Global Fundamentals Curriculum Training TF S Shop Practices Student Information
Technica Service Training Goba Fundamentas Curricuum Training TF1010016S Shop Practices Student Information FCS-13202-REF CG7972/S en 12/2001 Copyright 2001 Ford Motor Company Introduction Preface Goba
More informationCentrifugal Gas Separator ZGA. Operating Manual. Dimensions, weights and other technical data are subject to changes.
Centrifugal Gas Separator ZGA Operating Manual Am Neuen Rheinhafen 4 - D-67346 Speyer Postfach 1709 - D-67327 Speyer Phone: +49 (6232) 657-0 Fax: +49 (6232) 657-505 Internet: http://www.burmt.de Email:
More informationSuperFinish 27. Available versions. Accessories. SuperFinish 27 Spraypack. Basic unit. Tip extensions / pole guns. Suction systems.
Available versions Spraypack Basic unit 0341 051 basic unit on trolley including pressure gauge system + QuickClean suction + 15 m high pressure hose + Airless gun G 12 + Wagner Tip holder with Airless
More informationDifferential Pressure Regulator Type Type 45-6 (0.1 to 1 bar, DN 15) Mounting and Operating Instructions EB 3226 EN
Differential Pressure Regulator Type 45-6 Type 45-6 (0.1 to 1 bar, DN 15) Mounting and Operating Instructions EB 3226 EN Edition March 2008 Contents Contents Page 1 Design and principle of operation...................
More informationMounting and Operating Instructions EB 3007 EN. Self-operated Pressure Regulators. Differential Pressure Regulators (opening) Type Type 42-25
Self-operated Pressure Regulators Differential Pressure Regulators (opening) Type 42-20 Type 42-25 Type 42-20 Differential Pressure Regulator Type 42-25 Differential Pressure Regulator Mounting and Operating
More informationSerie ECO 3F. Flanged back flow preventer with controllable reduced pressure zone. made in. Application fields. Protection
Flanged back flow preventer with controllable reduced pressure zone made in Application fields WATER FIRE FIGHTING DRINKING WATER 64 www.brandoni.it The ECO 3F flanged backflow preventers, which have a
More informationOperation Guide 5477
MO1705-E 2016 ASIO OMPUTER O., LTD. ongratuations upon your seection of this ASIO watch. Appications The buit-in sensors of this watch measure direction, barometric pressure, temperature and atitude. Measured
More informationHigh-performance submersible pressure transmitter For level measurement Model LH-10
Electronic pressure measurement High-performance submersible pressure transmitter For level measurement Model LH-10 WIKA data sheet PE 81.09 Applications Level measurement in rivers and lakes Deep well
More informationHigh-performance submersible pressure transmitter For level measurement Model LH-10
Electronic pressure measurement High-performance submersible pressure transmitter For level measurement Model LH-10 WIKA data sheet PE 81.09 Applications Level measurement in rivers and lakes Deep well
More informationContinental Industries TRANSITION FITTINGS or FAX Visit
Continental Industries TRANSITION FITTINGS 1-800-558-1373 or FAX 1-800-788-1668 Visit www.conind.com ABOUT US Our Company Continental Industries, headquartered in Tulsa, Oklahoma, was formed in 1958 and
More informationevoguard The valve series for aseptic applications
The valve series for aseptic applications Safety first Microbiologically sensitive products need to be treated with special care. The highest safety along the entire product handling chain is needed to
More informationGasMultiBloc Combined regulator and safety valve Infinitely variable air/ gas ratio control mode MBC-300-VEF MBC-700-VEF MBC-1200-VEF
GasMultiBloc Combined regulator and safety valve Infinitely variable air/ gas ratio control mode MBC-00-VEF 7.03 Max. operating pressure 30 mbar Compact design High flow values Low weight Low power consumption
More informationOperation Guide 5480
MO1803-EF 2016 CASIO COMPUTER CO., LTD. Operation Guide 5480 Congratuations upon your seection of this CASIO watch. Appications The buit-in sensors of this watch measure direction, barometric pressure,
More informationOperation Guide 5578
MO1804-EA 2018 CASIO COMPUTER CO., LTD. Operation Guide 5578 Congratuations upon your seection of this CASIO watch. To ensure that this watch provides you with the years of service for which it is designed,
More informationPremium Solutions for Gas and Biogas Handling
Premium Solutions for Gas and Biogas Handling Blower Solutions for Gas & Biogas Type of gas Applications Application requisites Specific characteristics of the blower unit Premium Solutions for Gas and
More information10.2. Basketball Single Post System
Basketball Basketball Single Post System The basketball single post is made from special aluminium profiles. The structure is supported by one post in the ground. The post measures a cross section of 120
More information104 Chamber System Ostendorf. Ostendorf. Chamber System ISO RV-Systém OSMA
104 Chamber System Ostendorf Ostendorf Chamber System ISO 9001 RV-Systém OSMA Ostendorf Chamber System 105 Ostendorf Chamber System The Ostendorf Chamber System is multifunctional enough to offer suitable
More informationMJK Expert 700 / 800 / 900 / 7070 / 7060 MJK Expert 1400 / 3400
MJK Expert 700 / 800 / 900 / 7070 / 7060 MJK Expert 1400 / 3400 Submersible Hydrostatic s Rugged and versatile 2.75 GB 2.75 Expert 090311 We reserve the right to continuously improve our products and make
More informationHEAVY DUTY KNIFE GATE VALVE
HEAVY DUTY KNIFE GATE VALVE The (SER.22) model knife gate is a bi-directional lug type valve designed according to MSS-SP-81 and TAPPI TIS 405-8 for industrial service applications. The completely new
More informationDepth Map Adjustment for the Improvement of Stereoscopic Image Perception
epth Map Adjustment for the Improvement of tereoscopic Image Perception Manbae Kim ept. of Computer and Communications Engineering Kangwon Nationa University Chunchon, Repubic of Korea, 2-71 E-mai: manbae@kangwon.ac.kr
More informationFocal&in A SERVICE PUBLICATION OF LOCKHEED-GEORGIA COMPANY A DIVISION OF LOCKHEED CORPORATION. Vol. 13, No. 3, July-September 1986 CONTENTS
Foca&in A SERVICE PUBLICATION OF LOCKHEED-GEORGIA COMPANY A DIVISION OF LOCKHEED CORPORATION Editor Chares 1. Gae Associate Editors James A. Loftin Robert J. R. Rockwood Art Direction & Production Teri
More informationWorkshop Compressors CLASSIC Series
www.kaeser.com Workshop Compressors CLASSIC Series Displacement: 210 to 40 l/min Pressure: 10 bar What do you expect from your Classic workshop compressor? Quality results can be achieved only by using
More informationDAV - WP DAV - WP. Wastewater Air Valves. Product Catalogue. (Wastewater Air Valves) DAV - WP
DAV - WP Wastewater Air Valves DAV - WP (Wastewater Air Valves) Product Catalogue DAV - WP DAV Series??? DAV-WP General DAV-WP Wastewater Air Valves The DAV-WP valve has been designed for efficient discharge
More informationJOS 15 JOS 25 JOS 40. Manual and semiautomatic test benches from DN 25 to DN 40. Characteristics. Basic characteristics. Test bench using balances
TEST BENCHES JOS 15 JOS 25 JOS 40 Manual and semiautomatic test benches from DN 25 to DN 40 02 Characteristics Compact test benches - all in one room Designation - for residential and apartment meters
More informationIMPORTANT: Read and save these instructions. 30 Sealed Burner Freestanding =Range WARNING
A WARNNG ALL RANGES CAN TP NJURY TO PERSONS COULD RESULT NSTALL ANT-TP DEVCE PACKED WTH RANGE SEE NSTALLATON NSTRUCTONS MPORTANT: Read and save these instructions. MPORTANT: nstaer: Leave nstaation nstructions
More informationThe mining industry is known for having some of the most diverse, difficut and demanding rope appications in the word. Usha Martin Limited can suppy a
MINING ROPES SURFACE AND UNDERGROUND ushamartin.com The mining industry is known for having some of the most diverse, difficut and demanding rope appications in the word. Usha Martin Limited can suppy
More informationUser Manual 1 P a g e Rev. V1.6-EN 11/08/2014
User Manual 1 P a g e Rev. V1.6-EN 11/08/2014 Copyright Disclaimer Trademarks and patents Intended use Contact info 2011 Inflotrolix, Inc. This document may not be copied in whole or in part or otherwise
More information